Zanussi ZNB4051S USER MANUAL

A/ZE/46. (06.)200370770

GB

FRIDGE - FREEZER

ZNB 4051S

ZZAANNUUSSSSII

INSTRUCTION BOOK

2

This instruction book contains safety precautions, information on use and helpful hints and tips.

To ensure you use this appliance effectively and safely, please read this instruction book carefully
before installing or using this appliance and retain for future reference.

The symbols below help you to find things more easily:

Safety precautions

Warnings and Safety information

Hints, useful information

Environmental information

The symbol on the product or on its packaging indicates that this product may not be treated
as household waste. Instead it shall be handed over to the applicable collection point for the
recycling of electrical and electronic equipment. By ensuring this product is disposed of
correctly, you will help prevent potential negative consequences for the environment and
human health, which could otherwise be caused by inappropriate waste handling of this
product. For more detailed information about recycling of this product, please contact your
local city office, your household waste disposal service or the shop where you purchased the
product.

3

Do not damage the refrigerant circuit.
Do not use electrical appliances inside the food
storage compartments of the appliance.

During Use

This appliance is designed for domestic use
only, specifically for the storage of edible
foodstuffs. It is not intended for commercial or
industrial use.
Containers with flammable gases or liquids can
leak at low temperatures. Do not store any
containers with flammable materials, such as
spray cans, fire extinguisher refill cartridges etc.
in the appliance.
Frozen food should not be refrozen once it has
thawed out.
Do not place carbonated or fizzy drinks in the
freezer compartment.
Ice lollies can cause 'frost/freezer burns' if
consumed straight from the freezer.
Do not remove items from the freezer
compartment if your hands are damp/wet, as
this could cause skin abrasions or frost/freezer
burns.
Bottles and cans must not be placed in the
freezer compartment they can burst when the
contents freeze.
Manufacturers' recommended storage times
should be adhered to. Refer to relevant
instructions.

Maintenance and Cleaning

Before cleaning, always switch off the appliance
and disconnect from the electrical supply.
When unplugging always pull the plug from the
mains socket, do not pull on the cable.

Servicing

This product should be serviced by an
authorised engineer and only genuine spare
parts should be used.
Under no circumstances should you attempt to
repair the appliance yourself. Repairs carried out
by inexperienced persons may cause injury or
serious malfunctioning. Contact your local
Service Force Centre.

At the end of the Appliance Life

When disposing of your appliance use an
authorised disposal site.
Remove the plug and ensure that any locks or
catches are removed, to prevent young children
being trapped inside.

The Appliance and the Environment

This appliance does not contain gases which could
damage the ozone layer.
Avoid damaging the cooling unit.
The packaging used on this appliance marked with
the symbol is recyclable.

Keep this instruction book for future reference
and ensure it is passed on to any new owner.

IMPOR

IMPORTT

ANT S

ANT S

AFET

AFET

Y INS

Y INS

TR

TR

UCTIONS

UCTIONS

These warnings are provided in the interests of your safety. Ensure that you understand them all
before installing or using this appliance. Your safety is of paramount importance. If you are unsure
about any of the meanings or these warnings contact the Customer Care Department.

Prior to installation

Check the appliance for transport damage. Under
no circumstances should a damaged appliance be
installed. In the event of damage please contact
your retailer.

Installation

This appliance is heavy. Care should be taken when
moving it.
It is dangerous to alter the specifications or attempt
to modify this product in any way.
Ensure that the appliance does not stand on the
electrical supply cable. If the supply cable is
damaged, it must be replaced by a cable available
from your local Service Force Centre.

Make sure that the power plug has not been
squashed or damaged during transit.

- A damaged power plug may overheat and cause a
fire.

As you unpack the appliance, check carefully
for any signs of transit damage.
Do not place heavy articles or the
fridge/freezer itself on the power cord.

- There is a risk of a short circuit and fire.

Do not remove the power cord by pulling on its
lead, particularly when the fridge/freezer is
being pulled out of its niche.

- Damage to the cord may cause a short-circuit, fire
and/or electric shock.

- If the power cord is damaged, it must be replaced
by a certified service agent or qualified service
personnel.

If the power plug socket is loose, do not insert
the power plug.

- There is a risk of electric shock or fire.

Any electrical work required to install this appliance
should be carried out by a qualified electrician or
competent person.
Parts which heat up should not be exposed.
Whenever possible, the back of the appliance
should be close to a wall, but leaving the required
distance for ventilation, as stated in the installation
instructions.
The appliance should be left for 2 hours after
installation before it is turned on, in order to allow
the refrigerant to settle.

Child Safety

Do not allow children to tamper with the controls or
play with the product.
Keep packaging materials away from children, to
prevent the risk of suffocation!

Safety precautions for isobutane
Warning

The refrigerant isobutane (R 600a) is contained
within the refrigerant circuit of the appliance, a
natural gas with a high level of environmental
compatibility, which is nevertheless flammable.
Keep ventilation openings, in the appliance
enclosure or in the built-in structure, clear of
obstruction.
Do not use mechanical devices or other means to
accelerate the defrosting process, other than those
recommended by the manufacturer.

4

CCONTENT

ONTENTSS

Instructions for the User

Important Safety Instructions 3

General Information 5
Description of the Appliance 5

Switch and indicator set 6

Display background colour 7

Using the Appliance 7

Putting it into use 7
Controlling the temperature, seeting 7
How to use the refrigerator 7
Drawer 8
Shopping mode 8
The Refrigerator 8
Storage Shelves 8
Storage Times 8
The Freezer 9
Freezing Fresh Food 9
Frozen Food Storage 9
Thawing 10
To Make Ice Cubes 10

Hints and Tips 11

Normal Operating Sounds 11
Food Storage 11
Energy Saving Advice 11
In the Event of a Power Failure 11

Maintenance and Cleaning 12

Internal Cleaning 12
External Cleaning 12
When the Appliance is Not in Use 12

Defrosting 12

To Change the Light Bulb 13

Something Not Working 14

Service and Spare Parts 15

Customer Care Department 15

Guarantee Conditions 16

Instructions for the Installer

Technical Data 17

Installing the Appliance 17

Transportation, Unpacking 17
Cleaning 17
Location 17
Levelling the Appliance 18
Ventilation Requirements 18
Door Reversal 18

Electrical Connections 20

Storage Chart 21

5

INS

INS

TR

TR

UCTIONS F

UCTIONS F

OR THE USER

OR THE USER

A - Refrigerator
B - Freezer

1. Top with indicating switch

2. Air distributing and lighting box

3. Glass shelves

4. Bottle rack

5. Glass shelf

6. Fresh Box

7. D r a w e r

8. Data label

9. Air grid

10. Storing compartment(s)

11. Freezing compartment with drawer

12. Bottom plinth

13. Adjustable feet

14. Butter compartment lid

15. Egg tray

16. Door shelf

17. Door gasket

18. Bottle shelf

19. Handles

20. Ice tray

21. Condenser

22. Defrost water outlet tube

23. Spacer

24. Evaporator tray

25. Compressor

26. Rollers

Description of the appliance

General information

The official designation of the appliance is "frostfree
refrigerator-freezer combination with one motor
compressor and freezer placed in the lower part". The
appliance has - besides the general services - a freezer with
its own door and is completely separated from the other
unit.

According to this the appliance is suitable for storing frozen
and deep-frozen food, freezing products in quantity given in
the user's instructions at home and making ice.

The appliance can meet the requirements of standards
between different temperature limits according to the
climate class.

The letter symbol for climate class can be found on the
data label.

6

Switch and indicator set

The following components can be found under a cover in
the top frame:

A. Button ON/OFF

Switches the appliance on and off.

B. Fridge temperature display

By default it shows he medium temperature inside the
refrigerator. Should the temperature be higher than 9 °C,
a "-" sign is shown. Should the temperature be definitely
lower than 0 °C, a flashing "-" sign is shown.

It shows the desired fridge temperature by a flashing
number when one of the fridge temperature setting
buttons is pressed. After a while it returns to the actual
temperature.

It can show an "A" symbol when the appliance in action
cool mode. See also the chapter on using the
refrigerator.

It can show an "H" symbol when the appliance is in
holiday mode. See also the chapter on holiday mode.

C. Fridge temperature setting button (for colder
temperatures)

Press this button to make the desired fridge temperature
colder by 1 °C.

D. Fridge temperature setting button (for warmer
temperatures)

Press this button to make the desired fridge temperature
warmer by 1°C.

E. ACTION COOL button

Press this button to activate the action cool mode. See
also the chapter on using the refrigerator.

F. ACTION COOL function "on" indicator (yellow)

This indicator is lit when the appliance in action cool
mode. See also the chapter on using the refrigerator.

G. Freezer temperature display

By default it shows the highest temperature inside the
freezer.

It shows the desired fridge temperature by a flashing
number when one of the freezer temperature setting
buttons is pressed. After a while it returns to the actual
temperature.

It can show an "A" symbol when the appliance in action
freeze mode. See also the chapter on freezing.

H. Freezer temperature setting button (for colder

temperatures)

Press this button to make the desired freezer
temperature colder by 1 °C.

I. Freezer temperature setting button (for warmer

temperatures)

Press this button to make the desired freezer
temperature warmer by 1 °C.

J. ACTION FREEZE button

Press this button to activate the action freeze mode. See
also the chapter on freezing.

K. ACTION FREEZE function "on" indicator (yellow)

This indicator is lit when the appliance in action freeze
mode. See also the chapter on freezing.

L. Alarm reset button

7

M. Alarm light (red)

In the event of an abnormal temperature rise inside the
freezer (e.g. power cut) this warning light will start to
flash and a buzzer will sound.

After the temperature has returned to normal, the
warning light will continue to flash, although the buzzer
has stopped.

If the alarm button is pressed, the freezer temperature
display shows for a few seconds the warmest
temperature reached in the section. The buzzer, if
sounding, will switch off.

This warning light will start to flash and a buzzer will
sound in case of a door left open. To stop the alarm light
simply close the door.

Using the Appliance

Putting it into use

Place the accessories into the appliance then plug to the
mains socket.

To start the appliance, press the ON/OFF button ("A"). The
fridge temperature display ("B") and freezer temperature
display ("G") will go on. The alarm light ("M") flashes since
the temperature is high. The buzzer sounds. To stop the
buzzer, press the alarm reset button ("L").

Note:

The appliance cannot be switched on or off if unplugged, or
if there is no power being supplied to it. Following
connection to the mains power supply, the appliance
returns to the same operating state as before the
interruption of main power.

Controlling the temperature, setting

The electronic control interrupts the cooling automatically
for more or less time depending on the set ting then restarts
it assuring the required temperature.

Temperature of the refrigerator and freezer can by set by
buttons "C"-"D" and "H"-"I", respectively. The desired
temperature is seen blinking on the respective display.

For everyday use medium setting, i.e. +5 °C in the
refrigerator and colder than -18 °C is the freezer is
recommended.

Allow the appliance to run for a period of 24 hours
whenever the temperature setting is changed. This will
allow the temperature to stabilize inside the appliance.

The temperature coming about in the refrigerator is effected
by not only the position of the thermostat but the ambient
temperature, frequency of door openings and the quantity
of food put into it newly, etc.

When the coldest temperature possible is set - in
case of increased demand e.g. during heatwaves

- the compressor may operate continually. This does
not cause damages to the appliance.

How to use the refrigerator

For adequate cooling developing interior air

circulation is necessary. For this reason you are
asked not to cover the air circulation gaps behind the
shelves (e.g. with tray etc.).

Do not put hot food into the refrigerator. Allow

it to reach room temperature naturally. In this
way the unnnecessary frost building up can be
avoided.

Foods can take over odours from each other.

So it is essential to put foods in closed dishes
or wrap them in cellophane, aluminium foil, grease­proof paper or cling film before placing them into
the refrigerator. This way foods will keep their
moisture e.g. vegetables will not dry out after some
days.

8

The Refrigerator

Below is the recommended storage positions for various
food types:

1. Ready-cooked foods, fresh meat, cold cuts.

2. Milk, dairy products.

3. Fruits, vegetables, salads.

4. Cheese, butter.

5. Eggs.

6. Yoghurt, sour cream.

7. Small bottles, drinks.

8. Large bottles, drinks.

9. Fish, meat, seafood

Drawer

The drawer is suitable for storing fruit and vegetables.

There is a separator inside the drawer that can be placed in
different position to allow for the subdivision best suited to
personal needs.

ACTION COOL mode

The ACTION COOL function is suited for quick cooling of
large quantities of goods in the refrigerator.

The ACTION COOL function is switched on by pressing the
ACTION COOL button ("E").

The yellow light ("F") illuminates. During the time of ACTION
COOL the display ("B") shows an "A" letter.

The ACTION COOL function now provides for intensive
cooling. A desired temperature of +2 °C is automatically
selected.

To exit from the ACTION COOL mode press the "E" button
again. Should you not do so, after a while the refrigerator
returns to automatic mode.

Air Filter

Your appliance is equipped with a carbon filter behind a flap
in the rear wall of the air distributing box.

The filter purifies the air from unwanted odours in the fridge
compartment meaning that the storage quality will be
further improved.

Note: Always keep the air ventilation flap closed.

Fresh Box

The product equipped with this feature in the fridge part.
This compartment is indicated for the best conservation of
fresh food like fish, meat, seafood because the temperature
is lower here than in the rest of the fridge. It is placed in the
lower part, directly above of the vegetable drawer.

9

The Freezer

Freezing fresh food

The appliance can be used to freeze fresh food of quantity
specified on the data label. Freezing different products
should always be done after proper preparing as follows.

Push the ACTION FREEZE button ("J") 4 hours before
placing fresh food in smaller quantity or 24 hours before
placing fresh food in bigger quantity into the appliance. The
yellow light ("K") lit and the freezer temperature display ("G")
shows an "A" symbol.

Put the previously frozen food - or some of it - to another
basket or baskets. Put the fresh food into the lower basket,
leaving enough space for airflow.

Run the appliance this way for 24 hours.

To exit from action freeze mode press the ACTION FREEZE
button again. Should you not do so, after a while the freezer
returns to automatic mode.

Never freeze food in bigger quantity than given in

the 'Technical data' at the same time, otherwise
freezing will not be thorough and after dissolving
various deterioration may take place (losing taste and
aroma, lysing, etc.).

Do not make ice during freezing preferably, because

making ice reduces freezing capacity.

The freezing tray is suitable for freezing smaller fruits

(raspberry, strawberry, currant, etc.).Fruits should be
put in the tray in thin layers without packaging. After freezing
they can be packed and sorted out then placed into the
storing compartments.

Storage Shelves

The shelves in the refrigerator compartment are adjustable
to allow for the storage of large items.

To re-arrange the shelves, open the door to 90°.

Storage Times

The storage chart at the end of the instruction book gives
information on storage times in the refrigerator
compartment. The storage times quoted are intended as a
guide only.

Do not cover the shelves with paper or trays etc. as this
will affect the air circulation within the refrigerator
compartment.

Do not put hot foods in the refrigerator, allow hot foods
to reach room temperature naturally before placing in the
refrigerator.

Cover foods, or place in closed dishes before placing
them in the refrigerator, this prevents any transference of
food smells.

10

Thawing

Deep frozen or frozen food, prior to being used, can
be thawed in the fridge or at room temperature,
depending on the time available. Small food items may
even be cooked from frozen, in this case cooking will
take longer.

Any frozen food which is allowed to thaw accidentally
should either be eaten as soon as possible, or thrown
away. Alternatively, if the food is uncooked and has not
been completely defrosted it can be cooked and then
refrozen.

Defrosted cooked food must never be
refrozen.

)

To Make Ice Cubes

1. Fill the ice cube tray ¾ full with cold water, place in

the freezing compartment and leave to freeze.

2. To remove the cubes twist the tray or hold it under

running water for a few seconds.

Never try to free an ice tray that is frozen to
the freezer compartment by using pointed or

sharp edged objects.

Frozen Food Storage

When first starting the freezer or if the freezer has been out
of use for some time, we advise you to run your appliance
for at least 2 hours before storing frozen food.

Do not exceed the storage period indicated by the
manufacturer.

Do not open the door frequently or leave it open longer than
is necessary.

It is practical to replace frozen products into the basket(s)
after freezing has finished. Doing this you could make room
in the freezing compartment for furtner freezing.
Intermediate freezing does not deteriorate foods already
stored.

In large quantities of food are to be stored, remove the
baskets except the lowest one from appliance and place
food on the shelves.

Important

Do not put carbonated liquids in the freezer.

Ice lollies, if consumed immediately after removal from
the freezer can cause a low temperature skin burn.

In the event of a power cut the food in the freezer will not
be affected if the power cut is short and the freezer is full.
Do not open the door. Should the food begin to thaw it
must be consumed quickly and must not be re-frozen.
(See Hints and Tips)

Do not remove items from the freezer if your hands are
damp/wet, as this could cause skin abrasions or
frost/freezer burns.

11

Hints & T

Hints & T

ips

ips

Normal Operating Sounds

You may hear faint gurgling or bubbling sounds
when the refrigerant is pumped through the coils or
tubing.

When the compressor is on, the refrigerant is being
pumped round and you will hear a whirring sound or
pulsating noise from the compressor.

A thermostat controls the compressor and you will
hear a faint 'click' when the thermostat cuts in and
out.

Food Storage

To obtain the best performance from your freezer:

Do not store warm food or evaporating liquid.

Avoid buying frozen food if you cannot store it
straight away. The use of an insulated container is
advisable. When you arrive home, place the frozen
food in the freezer immediately.

Do not push food together too much, try to allow air
to circulate around each item.

Do not store food uncovered.

Ensure that food placed in the freezer is dated and
labelled and used in date order to ensure that food
is consumed at its best.

Lean food keeps better and longer than fatty food,
salt reduces the storage time.

Wrap the food in polythene or aluminium freezing
bags or foil so that they adhere to the food and
provide an airtight seal.

Packaging which is swollen or has traces of
refrozen water droplets on the pack could indicate
that the product has not been kept at a suitable
temperature and that it may have lost its original
quality. Partially thawed food must not be refrozen,
it must be consumed within 24 hours. Never
exceed the storage times indicated by the
manufacturer.

Energy Saving Advice

Do not install the appliance close to sources of
heat, such as a boiler or radiator.

Locate the appliance in a cool well ventilated
room and make sure that the air openings of the
appliance are not obstructed.

Avoid unnecessary frosting in the cabinet by
packing all foodstuffs into airtight packages
before placing them in the freezer.

Food which is to be frozen (when cool) should
be placed in the fridge before being transferred
to the freezer.

Try to avoid keeping the door open for long
periods or opening the door too frequently as
warm air will enter the cabinet and cause the
compressor to switch on unnecessarily often.

Ensure there are no obstructions preventing the
door from closing properly.

In the Event of a Power Failure

If there is a power failure during the storage of
frozen foods, keep the door closed. If the
temperature within your freezer should rise, do not
refreeze the food without checking its condition.
The following guidelines should assist you:

Ice Cream: Once thawed should be discarded.

Fruits & Vegetables: If soft should be cooked and

used up.

Breads & Cakes: Can be refrozen without danger.

Shellfish: Should be refrigerated and used up

quickly.

Cooked Dishes: i.e. casseroles should be
refrigerated and used up.

Large Pieces of Meat: Can be refrozen providing
there are still ice crystals remaining within them.

Small Joints: Should be cooked and can then be
refrozen as cooked dishes.

Chicken: Should also be cooked and refrozen as a
fresh dish.

12

Maint

Maint

enance and Cleaning

enance and Cleaning

Before any maintenance or cleaning is carried out
you must DISCONNECT the appliance from the

electricity supply.

Internal Cleaning

Clean the inside and accessories with warm water and
bicarbonate of soda (5 ml to 0.5 litre of water).

Rinse and dry thoroughly.

NEVER use detergents, abrasive powders,

highly perfumed cleaning products or wax
polishes to clean the interior as these will damage
the surface and leave a strong odour.

External Cleaning

Wash the outer cabinet with warm soapy water.

Once or twice a year dust the condenser (black grille) and
the compressor at the back of the appliance with a brush or
vacuum cleaner, as an accumulation of dust will affect the
performance of the appliance and cause excessive
electricity consumption.

Changing the Carbon Filter

To maintain the best performance the carbon filter should
be changed every year.

New carbon filters can be purchased from your local dealer.

1. Pull the flap outwards. (1)

2. Remove the filter from the plastic bag.

3. Insert the filter in the slot found in the back of the flap

cover (2).

4. Close the flap cover.

Note: the carbon filter is a consumable accessory and as
such is not covered by the guarantee.

During operation, always keep the air ventilation flap
closed.

The filter should be handled carefully so fragments do
not loosen from the surface.

When the Appliance is not in Use

When the appliance is not in use for long periods,
disconnect from the electricity supply, empty all foods and
clean the appliance, leaving the door open to prevent
unpleasant smells.

HOLIDAY mode

The HOLIDAY mode is suitable when the refrigerator part is
empty but there is foodstuff stored in the freezer.

The HOLIDAY mode is switched on by pressing the "D"
fridge temperature setting button several times. The display
("B") shows an "H" letter.

To exit from the HOLIDAY mode press the "C" fridge
temperature setting button.

13

Important: If the fridge compartment is off, the door must be
closed in order that the freezer is working properly.

In this condition, the electronic control of the appliance
functions automatically and periodically circulating the air to
prevent unpleasant smells and humidity.

Defrosting

Defrosting is automatic in this model.

)

To Change the Light Bulb

Should the light fail to work you can change it as
below:

Break the circuit of the appliance.

Press the rear hook (1) of the lampcover by a
screwdriver and at the same time pull and rotate the
cover in the direction indicated by the arrow (2). So
the bulb can be replaced. (Bulb type: T25 230-240 V,
25 W, E 14 thread)

After changing the bulb replace the cover, snap it in
place and apply voltage to the appliance.

14

If after the above checks your appliance still does not
operate correctly, contact your local Service Force
Centre.

Please note that it will be necessary to provide proof
of purchase for any in-guarantee service calls.

In-guarantee customers should ensure that the
above checks have been made, as the
engineer will make a charge if the fault is not a
mechanical or electrical breakdown.

Something N

Something N

ot W

ot W

orking

orking

If the appliance is not working correctly, please carry out the following checks before contacting your local
Service Force Centre.

Problem

No power to the appliance

The temperature in the
fridge or freezer is too high

The compressor runs
continuously

The temperature in the
fridge or freezer is too low

Excessive frost and ice has
built up

The appliance is noisy.

Possible Cause

No power at the socket.

There is a power cut.

The fuse has blown.

Thermostat control knob is set at „0”.

The appliance is located in an unsuitable position.

The thermostat control knob is set too low.

The thermostat control knob is set at the wrong
temperature.

The door is open.

Large quantities of food have been placed in the
cabinet.

The door has been opened too frequently.

The air ventilation is obstructed.

The thermostat control knob is set too cold.

The door has been left open.

Something is obstructing the door.

The door gasket is dirty.

The appliance is not level.

Solution

Check there is power at the socket.

Check there is not a power cut by checking the
household lights.

Check the fuse has not blown.

Check the thermostat setting.

Check the ambient temperature is within the
appliances operating limits of 10 °C to 32 °C.

Check that the thermostat control knob is turned to
the correct setting relative to ambient conditions.

Adjust the thermostat control knob.

Close the door.

Do not leave the door open longer than necessary.

Check that the air ventilation is not obstructed.

Set the thermostat control knob to a warmer
position.

Check the door has not been left open.

Check nothing is preventing the door from closing.

Check the door gasket is intact and clean.

Check if the appliance stands stable on the floor.

15

For Customer Service in Ireland please
contact us at the address below:

Zanussi - Electrolux
Electrolux Group (Irl) Ltd
Long Mile Road
Doublin 12
Republic of Ireland

Tel: [phone]

Email: [e-mail]

Ser

Ser

vice and Spar

vice and Spar

e P

e P

ar

ar

ts

ts

In the event of your appliance requiring service, or if you wish to purchase spare parts, please contact your
local Service Force Centre by telephoning:-

08705 929929

Your telephone call will be automatically routed to the Service Force Centre covering your post code area.

For the address of your local Service Force Centre and further information about Service Force, please visit
the website at www

.servicef

orce.co.uk

Before calling out an engineer, please ensure you have read the details under the heading "Something Not
Working."

When you contact the Service Force Centre you will need to give the following details:

1. Your name, address and post code

2. Your telephone number

3. Clear and concise details of the fault

4. The model and serial number of the appliance (found on the rating plate)

5. The purchase date

Please note that a valid purchase receipt or guarantee documentation is required for in-guarantee
service calls.

Cus

Custt

omer Car

omer Car

e Depar

e Depar

tment

tment

For general enquiries concerning your Zanussi - Electrolux appliance or for further information on
Zanussi - Electrolux products, please contact our Customer Care Department by letter or telephone at the
adresses below or visit our website at www.zanussi-electrolux.co.uk

Major Appliances - Customer Care Department
Zanussi-Electrolux
101 Oakley Road
Luton
Bedfordshire
LU4 9QQ
08705 727727 (*)
*calls to this number may be recorded for training purposes.

16

Guar

Guar

ant

ant

ee Conditions

ee Conditions

We Zanussi - Electrolux undertake that if within 12
months of the date of the purchase this
ZANUSSI - ELECTROLUX appliance or any part
thereof is proved to be defective by reason only of
faulty workmanship or materials, the company will, at
our option repair or replace the same FREE OF
CHARGE for labour, materials or carriage on condition
that:

The appliance has been correctly installed and
used only on the electrical supply stated on the
rating plate.

The appliance has been used for normal domestic
purposes only, and in accordance with the
manufacturer's instructions.

The appliance has not been serviced, maintained,
repaired, taken apart or tampered with by any
person not authorised by us.

All service work under this guarantee must be
undertaken by a Service Force Centre.

Any appliance or defective part replaced shall
become the Company's property.

Home visits are made between 8.30am and 5.30pm
Monday to Friday. Visits may be available outside
these hours in which case a premium will be charged.

EXCLUSIONS

This Guarantee does not cover:

Damage or calls resulting from transportation,
improper use or neglect, the replacemet of any light
bulbs or removable parts of glass or plastic.

Costs incurred for calls to put right an appliance
improperly installed or calls to appliances outside
the United Kingdom.

Appliances found to be in use within a commercial
environment, plus those which are the subject of
rental agreements.

Products of Zanussi - Electrolux manufacture
which are not marketed by Zanussi - Electrolux.

The guarantee is in addition to your statutory and legal
rights.

EUROPEAN GUARANTEE

If you should move to another country within
Europe then your guarantee moves with you to your
new home subject to the following qualifications:

The guarantee starts from the date you first
purchased your product.

The guarantee is for the same period and to the
same extent for labour and parts as exists in the
new country of use for this brand or range of
products.

This guarantee relates to you and cannot be
transferred to another user.

Your new home is within the European
Community (EC) or European Free Trade Area.

The product is installed and used in accordance
with our instructions and is only used
domestically, i.e. a normal household.

The product is installed taking into account
regulations in your new country.

Before you move please contact your nearest
Customer Care Centre, listed below, to give them
details of your new home. They will then ensure that
the local Service Organisation is aware of your
move and able to look after you and your
appliances.

France Senlis [phone]
Germany Nurenberg [phone]
Italy Pordenone [phone]
Sweden Stockholm [phone]
UK Luton [phone]

Ireland Dublin [phone]

17

Ins

Instrtr

uctions f

uctions f

or the Ins

or the Instt

aller

aller

Technical data

Model

Gross capacity (l)

Net capacity (l)

Width (mm)

Height (mm)

Depth (mm)

Energy consumption (kWh/24h)

(kWh/year)

Energy class, according to EU standards

Freezing capacity (kg/24h)

Rising time (h)

Rated current (A)

Noise Lc (dB)

Weight (kg)

Number of compressors

ZNB 4051S

Refrigerator: 251

Freezer: 122

Refrigerator: 240

Freezer: 109

595

2010

632

1,12

409

A

10

16

0,6

42

77

1

Installing the appliance

Transportation, unpacking

The appliance and the interior fittings are protected for
transport.

Remove all packaging and any adhesive tape.

Any remnants of adhesive can be removed using
white spirit.

After transportation the appliance must not be
switched on for 2 hours. This is to allow the
refrigerant to settle.

Cleaning

Clean the accessories and the inside of the appliance
with warm water and bicarbonate of soda (5 ml
to 0.5 litres of water). Rinse and dry thoroughly.

Do not use detergents, abrasive powders, highly
perfumed cleaning products, wax polishes or
cleaning products containing bleach or alcohol.

Location

The appliance should be positioned in a well
ventilated, dry room.

Energy use is affected by the ambient temperature.

The appliance should therefore:

not be installed next to radiators, cookers or
other sources of heat

only be installed at a location where the ambient
temperature corresponds to the climate
classification, for which the appliance is
designed.

The climate classification can be found on the
rating plate.

The following table shows which ambient
temperature is correct for each climate
classification:

Climate Classification Ambient Temperature

SN +10 to +32 °C

N +16 to +32 °C

ST +18 to +38 °C

18

In the bag of the accessories there are two spacers
which must be fitted in the two top corners.

Slacken the screws and insert the spacer under the
screw head, the re-tighten the screws.

Levelling the Appliance

When placing the appliance ensure that it stands level.
This can be achieved by two adjustable feet at the
bottom in front.

Do not stand the appliance next to a source of heat
such as a radiator or cooker.

Ventilation Requirements

The appliance must have adequate ventilation to
ensure correct operation.

Diagram shows the ventilation requirements when
installed:

A Under a cupboard.

B When freestanding

Door Reversal

Should the location demand it, door-opening direction
can be refitted from right-handed to left-handed.

Appliances are supplied right-handed.
Following operations are to be done on the basis of

figures and explanations:

1. To perform the operations listed below it is
recommended to ask another person for help who
safely can keep the doors while performing the
operations.

2.Disconnect the appliance from the electricity
supply.

3. Open the doors and dismount the double door
hinge (a,b) by removing the screws (2 pieces) (c).
(fig. 2)

4. Take off the double door hinge (a,b,c) by gradually

fig. 1.

19

removing it from the cabinet, slightly tilting both
doors. Do not forget to remove the plastic spacer
(b) under the hinge. (fig. 2)

5. Take off the refrigerator door by pulling it slightly
downwards.

6. Take off the freezer door by pulling it slightly
upwards.

7. Unscrew the top door hinge pin (d) of the
refrigerator then screw it back on the other side.
(fig. 1)

8.Remove the insert of the plinth (e) by a
screwdriver. (fig. 4)

9. Unmount the lower hinge pin (f) and its washer (h)
and mount them on the other side. (fig. 4)

10.Replace the insert of the plinth (e) on the other
side.

11. Remove the covering nails (3 pieces) (n,k) of the
double door holder on the left side and put them
to the other side. (fig. 2)

12. Remove the (t, z) plugs from both doors. (fig. 3)

13. Remove the (u, v) door closing devices by
unscrewing the (s) screw.

14. Replace the (u, v) door devices on the opposite
side of the other door after turning them, then fix
them by screwing the (s) screw.

15. Replace the (t, z) plugs on the opposite side.

16. Fit the pin of the double door hinge (m) into the left
hole of the freezer door. (fig. 2)

17. Fit the freezer door to the lower door hinge pin (f).
(fig. 4)

18. Fit the refrigerator door to the upper door hinge
pin (d) then slightly tilting both doors fit the pin of
the double door hinge (m) into the left hole of the
refrigerator door.

19. Opening both doors fix the double door hinge
onto the left side using the screws (2 pieces) (c).
Do not forget to replace the plastic spacer (b)
under the hinge. Be careful that the door edges
are parallel with the edge of the mantle.

20.Put over the handles (r) on the other side and put
the plastic covering pins (p) supplied in the plastic
bag of this instruction book into the vacant holes.
(fig. 5)

21. Put the appliance to its place, ensure it is level,
and apply to voltage it.

In case you do not want to perform the procedures
above, call the nearest Service Force Centre.

Technicians will make a charge for door reversal.

Important

After completion of the door reversing operation,
check that the door gasket adheres to the cabinet. If
the ambient temperature is cold (i.e. in Winter), the
gasket may not fit perfectly to the cabinet. In that case,
wait for the natural fitting of the gasket or accelerate
this process by heating the part involved with a normal
hairdryer on a low setting.

fig. 2.

fig. 3.

fig. 4.

fig. 5.

20

Electrical Connection

Electrical Connection

Any electrical work required to install this
appliance should be carried out by a
qualified electrician or competent person.

This appliance must be earthed.

The manufacturer declines any liability should
these safety measures not be observed.

Electrical Requirements

Before switching on, make sure the electricity supply
voltage is the same as that indicated on the appliance
rating plate.

The appliance is supplied with a 13 amp plug fitted. In
the event of having to change the fuse in the plug
supplied, a 13 amp ASTA approved (BS 1362) fuse
must be used. Should the plug need to be replaced
for any reason. The wires in the mains lead are
coloured in accordance with the following code:

Green and Yellow: Earth
Blue: Neutral
Brown: Live
The wire coloured green and yellow must be

connected to the terminal marked with the letter “E“ or
by the earth symbol or coloured green and yellow.

The wire coloured blue must be connected to the
terminal “N“ or coloured black.

The wire coloured brown must be connected to the
terminal marked “L“ or coloured red.

Upon completion there must be no cut, or stray
strands of wire present and the cord clamp must
be secure over the outer sheath.

Important!

The plug must still be accessible after the
appliance has been installed.

The appliance should not be connected to the
electrical supply by means of an extension cable.

In case that the electrical cable has to be
replaced, please contact your local Service Force
Centre.

Warning!

A cut off plug inserted into a 13 amp socket is a
serious safety (shock) hazard. Ensure that it is
disposed of safely.

This appliance complies with the following
E.E.C. Directives:

73/23 EEC of 19.02.73 (Low Voltage Directive)
and subsequent modifications,

89/336 EEC of 03.05.89 (Electromagnetic
Compatibility Directive) and subsequent
modifications.

21

SSttor

or

age time char

age time chartt

Time and method of storage of fresh foods in the refrigerator

Foods Storage time in days Method of packaging

1234567

Raw meat XXx x x cling film, airtight
Cooked meat XXXx x x dish covered
Roasted meat XXXx x dish covered
Raw minced meat X dish covered
Cooked minced meat XXx x dish covered
Cold cuts XXx x cling film, cellophane, grease-

proof paper
Fresh fish X x x cling film, airtight
Cooked fish XXx x dish covered
Tinned fish, open X x x dish covered
Fresh chicken XXXx x x cling film, airtight
Fried chicken XXXx x x dish covered
Fresh duck, goose XXXx x x cling film, airtight
Roasted duck, goose XXXXx x x dish covered
Butter unopened XXXXXXXoriginal packaging
Butter opened XXx x x x x original packaging
Milk XXXx x original packaging
Cream XXx x plastic box
Sour cream XXXX x x x plastic box
Cheese (hard) XXXXXXXaluminium foil
Cheese (soft) XXXX x x x cling film
Egg XXXXXXX
Spinach, sorrel XXx x cling film
Green peas, green beans XXXXx x x cling film
Mushroom XXx x x cling film
Carrot XXXXXXXcling film
Tomato XXXXXXXcling film
Cabbage XXXXXx x cling film
Fruits (Strawberry,
raspberry, etc.) XXXx x cling film
Tinned fruits opened XXXx x dish covered
Cakes filled with cream XXx x dish covered

Notation:

X recommended storage time

x maximum recommended storage time

22

A/ZE/46. (06.)

23

2006. 06. 15.Printed by Océ Hungária Kft.

From the Electrolux Group. The world’s No.1 choice.

The Electrolux Group is the world's largest producer of powered appliances for kitchen, cleaning and outdoor use. More than 55 million Electrolux
Group products (such as refrigerators, cookers, washing machines, vacuum cleaners, chain saws and lawn mowers) are sold each year to a value of
approx. USD 14 billion in more than 150 countries around the world.

ELECTROLUX HOME PRODUCTS OPERATIONS EUROPE

© Electrolux plc 2006