Zanussi ZGG642CW, ZGG642CS, ZGG642CN User Manual

GAS HOBS

ZGG642C

INSTRUCTION BOOKLET

Please read this instruction booklet before using the appliance

GB

Important Safety Information

You MUST read these warnings carefully before installing or using the hob. If you need
assistance, contact our Customer Care Department on 08705 727727

Installation

l This hob must be installed by qualified personnel,

according to the manufacturers instructions and to
the relevant British Standards.

l Any gas installation must be carried out by a

registered CORGI installer.

l Remove all packaging before using the hob.
l Ensure that the gas and electrical supply complies

with the type stated on the rating plate, located near
the gas supply pipe.

l Do not attempt to modify the hob in any way.

Child Safety

l This hob is designed to be operated by adults. Do

not allow children to play near or with the hob.

l The hob gets hot when it is in use.
l Children should be kept away until it has cooled.
l Children can also injure themselves by pulling pans

or pots off the hob.

During Use

l This hob is intended for domestic cooking only. It is

not designed for commercial or industrial purposes.

l When in use a gas cooking appliance will produce

heat and moisture in the room in which it has been
installed. Ensure there is a continuous air supply,
keeping air vents in good condition or installing a
cooker hood with a venting hose.

l When using the hob for a long period of time, the

ventilation should be improved, by opening a window
or increasing the extractor speed.

l Do not use this hob if it is in contact with water.

Do not operate the hob with wet hands.

l Ensure the control knobs are in the OFF position

when not in use.

l When using other electrical appliances, ensure the

cable does not come into contact with the hot surfaces
of the cooking appliance.

l Unstable or misshapen pans should not be used on

the hob as unstable pans can cause an accident by
tipping or spillage.

l Never leave the hob unattended when cooking with

oil and fats.

l Never use plastic or aluminium foil dishes on the hob.
l Perishable food, plastic items and areosols may be

affected by heat and should not be stored above or
below the hob unit.

Service

l This hob should only be repaired or serviced by an

authorised Service Engineer and only genuine
approved spare parts should be used.

Environmental Information

l After installation, please dispose of the packaging with

due regard to safety and the environment.

l When disposing of an old appliance, make it unusable,

by cutting off the cable.

Keep this instruction book for future reference

and ensure it is passed on to any new owner.

Guide to Use the instructions

The following symbols will be found in the text to guide
you throughout the Instructions:

Safety Instructions

Step by step instructions for an operation

F

Hints and Tips

Enviromental information

This appliance complies with the following

E.E.C. Directives:
* 73/23 - 90/683 (Low VoltageDirective);
* 93/68 (General Directives);
* 89/336 (Electromagnetical Compatibility

Directive);

* 90/396 (Gas Appliances),

and subsequent modifications

2

Contents

For the User

Important Safety Information 2

Description of the Hob 3

Operation 4

Maintenance and Cleaning 4

Something Not Working? 5

Service and Spare Parts 5

Guarantee conditions 6

For the Installer

Important safety requirements 10

Installation 10

Building In 11

Electrical connections 12

Wiring Diagram 13

Fault Finding 13

Commissioning 15

Conversion from Natural Gas to LPG 15

Description of the Hob

1. Semi-rapid Burners

2. Rapid Burner

1

1

4

3

2

3. Auxiliary Burner

4. Control knobs

3

Operation

Hob burners

To light a burner:

F

l push in the relevant control and turn it to maximum

position;

l then adjust the flame as required.

l If the burner does not ignite, turn the control knob to

zero, and try again.

If you use a saucepan which is smaller than the
recommended size, the flame will spread beyond
the bottom of the vessel, causing the handle to
overheat.

Take care when frying food in hot oil or fat, as
the overheated splashes could easily ignite.

As soon as a liquid starts boiling, turn down the
flame so that it will barely keep the liquid
simmering.

If the control knobs become difficult to turn, please
contact your local Zanussi Service Centre.

To ensure maximum burner efficiency, you should only
use pots and pans with a flat bottom fitting the size of
the burner used (see table).

Burner minimum maximum

diameter diameter

Large (rapid) 180 mm. 260 mm.
Medium (semi-rapid) 120 mm. 220 mm.
Small (Auxiliary) 80 mm. 160 mm.

Maintenance and Cleaning

Before any maintenance or cleaning can be carried
out, you must DISCONNECT the hob from the
electricity supply.

The hob is best cleaned whilst it is still warm, as
spillage can be removed more easily than if it is
left to cool.

The Hob Top

Regularly wipe over the hob top and the aluminium frame
using a soft cloth well wrung out in warm water to which
a little washing up liquid has been added. Avoid the use
of the following:

- household detergent and bleaches;

- impregnated pads unsuitable for non-stick saucepans;

- steel wool pads;

- bath/sink stain removers.
Should the hob top become heavily soiled, it is
recommended that a cleaning product such as Hob Brite
or Bar Keepers Friend is used.

The Burners

Pan Supports

The pan supports are dishwasher proof.
If necessary, remove stubborn stains using a paste
cleaner. Never use steel wool pads or acids.

The burner caps and crowns can be removed for cleaning.
The cap and crown of each burner are secured with two
screws. To separate the two pieces, lift the crown, turn it
upside down, then undo the two fixing screws as shown
in fig. 1.
After cleaning, reassemble the two parts and refit the
cap on its correct position on the burner.
Wash the burner caps and crowns using hot soapy water,
and remove marks with a mild paste cleaner. A well
moistened soap impregnated steel wool pad can be used
with caution, if the marks are particularly difficult to
remove.
After cleaning, be sure to wipe dry with a soft cloth.

4

Fig. 1

FO 2265

Something Not Working?

If the hob is not working correctly, please carry out the following checks before contacting your local Service Force
Centre.

IMPORTANT:
installation, a charge will be made even if the appliance is under guarantee.

If you call out an engineer to a fault listed below, or to repair a fault caused by incorrect use or

SYMPTOM

n There is no spark when lighting the gas

n The gas ring burns unevenly

If after all these checks, your hob still does not operate
correctly, contact your local Service Force Centre.

Please note that it will be necessary to provide proof of
purchase for any in-guarantee service calls.

SOLUTION

u Check that the unit is plugged in and the electrical

supply is switched on

u Check that the RCCB has not tripped (if fitted)

u Check the mains fuse has not blown

u Check the burner cap and crown have been

replaced correctly, e.g. after cleaning.

u Check the main jet is not blocked and the burner

crown is clear of food particles.

u Check the burner cap and crown have been

replaced correctly, e.g. after cleaning.

In-guarantee customers should ensure that the
above checks have been made as the engineer will
make a charge if the fault is not a mechanical or
electrical breakdown.

Service and Spare Parts

In the event of your appliance requiring service, or if you
wish to purchase spare parts, please contact your local
Zanussi Service Force Centre by telephoning:

0870 5 929929

Your telephone call will be automatically routed to the
Service Force Centre covering your post code area. The
addresses are listed on the following pages.
Before calling out an engineer, please ensure you have
read the details under the heading Something Not
Working.
When you contact the Service Force Centre you will need
to give the following details:

1. Your name, address and post code

2. Your telephone number

3. Clear and concise details of the fault

4. The model and serial number of the appliance (found
on the rating plate)

5. The purchase date

5

Customer Care Department

For general enquiries concerning your Zanussi appliance
or for further information on Zanussi products, please
contact our Customer Care Department by letter or
telephone at the address below or visit our website at
www.zanussi.co.uk

Customer Care Department

Zanussi
55-77 High Street
Slough
Berkshire
SL1 1DZ
08705 727727 (*)

* calls to this number may be recorded for training
purposes.

Guarantee Conditions

Zanussi Guarantee conditions

We, Zanussi, undertake that if, within 24 months of the
date of the purchase, this Zanussi appliance or any part
thereof is proved to be defective by any reason only of
faulty workmanship or materials, we will, at our option,
repair or replace the same FREE OF ANY CHARGE for
labour, materials or carriage on condition that:

* The appliance has been correctly installed and used

only on the gas and electricity supply stated on the
rating plate.

* The appliance has been used for normal domestic

purpose only, and in accordance with the
manufacturer's instructions.

* The appliance has not been serviced, maintained,

repaired, taken apart or tampered with by any person
not authorised by us.

* All service work under this guarantee must be

undertaken by a Zanussi Service Centre.

* Any appliance or defective part replaced shall

become the Company's property.

* This guarantee is in addition to your statutory and

other legal rights.

Home visits are made between 8.30am and 5.30pm
Monday to Friday. Visits may be available outside these
hours, in which case a premium will be charged.

Exclusions

This guarantee does not cover:

* Damage or calls resulting from transportation,

improper use or neglect, the replacement of any light
bulbs or removable parts of glass or plastic.

* Costs incurred for calls to put right an appliance

which is improperly installed or calls to appliance
outside the United Kingdom.

* Appliances found to be in use within a commercial

or similar environment, plus those which are the
subject to rental agreements.

* Products of Zanussi manufacture which are not

marketed by Zanussi.

European Guarantee

If you should move to another country within Europe then

your guarantee moves with you to your new home
subject to the following qualifications:

* The guarantee starts from the date you first

purchased your product.

* The guarantee is for the same period and to the same

extent for labour and parts as exist in the new country
of use for this brand or range of products.

* This guarantee relates to you and cannot be

transferred to another user.

* Your new home is within the European Community

(EC) or European Free Trade Area.

* The product is installed and used in accordance with

our instructions and is only used domestically, i.e. a
normal household

* The product is installed taking into account

regulations in your new country.

Before you move, please contact your nearest Customer
Care centre, listed below, to give them details of your
new home. They will then ensure that the local Service
Organisation is aware of your move and able to look after
you and your appliances.

France Senlis [phone]
Germany Nürnberg [phone]
Italy Pordenone [phone]
Sweden Stockholm [phone]
UK Slough [phone]

6