Zanussi ZGF 692 C, ZGF 692 CT USER MANUAL

Instruction

booklet

Gas

hob

ZGF 642

ZGF 692 C

ZGF 692 CT

Thank you for selecting our applianceThank you for selecting our appliance

Thank you for selecting our appliance

Thank you for selecting our applianceThank you for selecting our appliance We wish you lots of enjoyment with your new appliance and we hope that

you will consider our brand again when purchasing household appliances. Please read this user manual carefully and keep it throughout the product life cycle as a reference document. The user manual should be passed on to any future owner of the appliance.

ContentsContents

Contents

ContentsContents

Important Safety InformationImportant Safety Information

Important Safety Information

Important Safety InformationImportant Safety Information

Description of the Hobs.........................................................................6

Instructions for the UserInstructions for the User

Instructions for the User

Instructions for the UserInstructions for the User

Operation ..............................................................................................8

Maintenance and Cleaning ................................................................. 10

Something Not Working? ....................................................................12

Guarantee/Customer Service ............................................................. 28

European Guarantee .......................................................................... 30

Instructions for the InstallerInstructions for the Installer

Instructions for the Installer

Instructions for the InstallerInstructions for the Installer

Engineer technical data....................................................................... 13

Important safety requirements ............................................................ 15

Installation ............................................................................................ 16

Gas Connection ................................................................................... 17

Location ............................................................................................... 18

Fitting the Hob into the Worktop......................................................... 19

Building In ............................................................................................ 20

Building over a cupboard or drawer ..................................................20

Building over a kitchen unit with door .................................................20

Electrical Connections.........................................................................21

Wiring diagram ...................................................................................22

Fault Finding ........................................................................................ 23

Commissioning.................................................................................... 26

Conversion from Natural Gas to LPG .................................................27

..................................................................................................................

.........................................................

..................................................................................................................

..................................................................................................................................

.................................................................

..................................................................................................................................

................................................................................................................

........................................................

................................................................................................................

1313

Guide to Use the instructionsGuide to Use the instructions

Guide to Use the instructions

Guide to Use the instructionsGuide to Use the instructions

The following symbols will be found in the text to guide you throughout the Instructions:

Safety Instructions

MANUFACTURER:

ELECTROLUX HOME PRODUCTS ITALY S.P.A. Viale Bologna, 298 - 47100 Forlì - Italy

Step by step instructions for an operation

Hints and Tips

Environmental information

Important Safety InformationImportant Safety Information

Important Safety Information

Important Safety InformationImportant Safety Information

ou MUST rou MUST r

ou MUST r

ou MUST rou MUST r

using the hob. If you need assistance, contact our Customerusing the hob. If you need assistance, contact our Customer

using the hob. If you need assistance, contact our Customer

using the hob. If you need assistance, contact our Customerusing the hob. If you need assistance, contact our Customer Care Department on 08705 727 727.Care Department on 08705 727 727.

Care Department on 08705 727 727.

Care Department on 08705 727 727.Care Department on 08705 727 727.

nstallationnstallation

nstallation

nstallationnstallation

# This appliance must be installed and serviced by a competent person as

ead these waread these war

ead these war

ead these waread these war

nings carnings car

nings car

nings carnings car

efully beforefully befor

efully befor

efully beforefully befor

e installing ore installing or

e installing or

e installing ore installing or

stated in the Gas Safety (Installation and Use) Regulations Current Editions and the IEE Wiring Regulations.

# For appliances installed in the Republic of Ireland please refer to NSAI-

Domestic Gas Installations I.S.813 Current Editions and the ETCI Rules for Electrical Installations.

# Remove all packaging before using the hob. # Ensure that the gas and electrical supply complies with the type stated on

the rating plate, located near the gas supply pipe.

# Do not attempt to modify the hob in any way.

People People

People

People People

# This hob is designed to be operated by adults. Do not allow children to play

SafetySafety

Safety

SafetySafety

near or with the hob.

# This appliance is not intended for use by children or other persons whose

physical, sensory or mental capabilities or lack of experience and knowledge prevents them from using the appliance safely without supervision or instruction by a responsible person to ensure that they can use the appliance safely.

# The hob gets hot when it is in use. Children should be kept away until it has

cooled.

# Children can also injure themselves by pulling pans or pots off the hob.

During UseDuring Use

During Use

During UseDuring Use

# This hob is intended for domestic cooking only. It is not designed for

commercial or industrial purposes.

# This appliance is not connected to a combustion products evacuation device.

It must be installed and connected in accordance with current installation regulations. Particular attention shall be given to the relevant requirements regarding ventilation.

# When in use a gas cooking hob will produce heat and moisture in the room

in which it has been installed. Ensure there is a continuous air supply, keeping air vents in good condition or installing a cooker hood with a venting hose.

# Ensure a good ventilation around the appliance. A poor air supply could cause

lack of oxygen.

# When using the hob for a long period time, the ventilation should be

improved, by opening a window or increasing the extractor speed.

# Do not use this hob if it is in contact with water. Do not operate the hob with

wet hands.

# Ensure the control knobs are in the ‘OFF’ position when not in use. # When using other electrical appliances, ensure the cable does not come

into contact with the hot surfaces of the cooking appliance.

# Unstable or misshapen pans should not be used on the hob as unstable

pans can cause an accident by tipping or spillage.

# Never leave the hob unattended when cooking with oil and fats. # Never use plastic or aluminium foil dishes on the hob. # Perishable food, plastic items and areosols may be affected by heat and

should not be stored above or below the hob unit.

# This appliance cannot be cleaned with steam or with a steam cleaning

machine.

ServiceService

Service

ServiceService

# This hob should only be repaired or serviced by an authorised Service

Engineer and only genuine approved spare parts should be used.

Environmental InformationEnvironmental Information

Environmental Information

Environmental InformationEnvironmental Information

# After installation, please dispose of the packaging with due regard to

safety and the environment.

# When disposing of an old appliance, make it unusable, by cutting off the

cable.

# The symbol on the product or on its packaging indicates that this

product may not be treated as household waste. Instead it shall be handed over to the applicable collection point for the recycling of electrical and

electronic equipment. By ensuring this product is disposed of correctly, you will help prevent potential negative consequences for the environment and human health, which could otherwise be caused by inappropriate waste handling of this product. For more detailed information about recycling of this product, please contact your local city office, your household waste disposal service or the shop where you purchased the product.

These instructions are only valid for countries whose identification symbols are shown on the cover of this instruction booklet and on the appliance itself.

Keep this instruction book for future reference and ensure it isKeep this instruction book for future reference and ensure it is

Keep this instruction book for future reference and ensure it is

Keep this instruction book for future reference and ensure it isKeep this instruction book for future reference and ensure it is

passed on to any new ownerpassed on to any new owner

passed on to any new owner

passed on to any new ownerpassed on to any new owner

Description of the HobsDescription of the Hobs

Description of the Hobs

Description of the HobsDescription of the Hobs

Model ZGF 642

Model ZGF 692 C-

ZGF 692 CT

1. Hob Top

2. Auxiliary Burner

3. Semi-rapid Burner

4. Rapid Burner

5. Triple crown Burner

6. Control knobs

Instructions for the UserInstructions for the User

Instructions for the User

Instructions for the UserInstructions for the User

Installation

Any gas installation must be carried out by a registered competent person, and in accordance with existing rules and regulations.

The relevant instructions are to be found in the second section of this manual. Please, ensure that, once the hob is installed, it is easily accessible for the engineer in the event of a breakdown.

WHEN THE HOB IS FIRST INSTALLED

Once the hob has been installed, it is important to remove any protective materials, which were put on in the factory. The manufacturer will not accept liability, should the above instructions or any of the other safety instructions incorporated in this book be ignored.

OperationOperation

Operation

OperationOperation

Lighting the burnersLighting the burners

Lighting the burners

Lighting the burnersLighting the burners

For easier lighting, proceed before puttingFor easier lighting, proceed before putting

For easier lighting, proceed before putting

For easier lighting, proceed before puttingFor easier lighting, proceed before putting a pan on the pan support.a pan on the pan support.

a pan on the pan support.

a pan on the pan support.a pan on the pan support.

To light a burner:

# turn the relevant knob anti-clockwise to maximum

position ( burner.

Only for model ZGF 692 CT

# Upon ignition, keep the knob pushed down

about "thermocouple" (see diagram - letter D) to be heated and the safety device to be switched off, otherwise the gas supply would be interrupted.

# Then adjust the flame as required.

If the burner does not ignite, turn the control knob to zero, and try again.

If you cannot light the flame even after severalattempts, check the "cap" (see diagram

- letter BB

B) are in the correct position.

5 seconds 5 seconds

5 seconds. This will allow the

5 seconds 5 seconds

A) and the"crown" (see diagram - letter

), then push it down to ignite the

Triple crown burner

(mod. ZGF 692 C/CT)

A - Burner cap

B - Burner crown

BB CC

C - Ignition electrode

CC DD

D - Thermocouple (only in

DD model ZGF 692 CT)

Do not keep the control knob pressed for more than 15 seconds. If the burner does not light even after 15 seconds, release the control knob, turn it the "off" position and wait for at least one minute before trying to light the burner again.

When switching on the mains, after installation or a power cut, it is quite normal for the spark generator to be activated automatically.

In the absence of electricityIn the absence of electricity

In the absence of electricity, ignition can occur without the electrical

In the absence of electricityIn the absence of electricity device; in this case, approach the burner with a flame, push the relevant knob down and turn it anti-clockwise until it reaches the maximum position.

If the control knobs become difficult to turn, please contact your local Service Force Centre.

Using the Wok Stand (only forUsing the Wok Stand (only for

Using the Wok Stand (only for

Using the Wok Stand (only forUsing the Wok Stand (only for model ZGF 692 C, ZGF 692 CT)model ZGF 692 C, ZGF 692 CT)

model ZGF 692 C, ZGF 692 CT)

model ZGF 692 C, ZGF 692 CT)model ZGF 692 C, ZGF 692 CT)

A wok stand is provided to enable you to use a round bottomed wok on the hob. The wok stand must only be used on the triple crown burner, and should not be used with any other type of wok or pan. When fitting the wok stand, ensure the recesses in the frame fit securely onto the bars of the pan supports, as shown in the picture.

Using the hob correctlyUsing the hob correctly

Using the hob correctly

Using the hob correctlyUsing the hob correctly

To ensure maximum burner efficiency, it is strongly recommended that you use only pots and pans with a so that flame will not spread beyond the bottom of the vessel (see the table below).

Burner minimum maximum

Triple crown 180 mm 260 mm Large (rapid) 180 mm 260 mm Medium (semi-rapid) 120 mm 220 mm Small (auxiliary) 80 mm 160 mm

flat flat

flat bottom fitting the size of the burner used,

flat flat

diameter diameter

As soon as a liquid starts boiling, turn down the flame so that it will barely keep the liquid simmering.

Use only pans or pots with flatUse only pans or pots with flat

Use only pans or pots with flat

Use only pans or pots with flatUse only pans or pots with flat bottom.bottom.

bottom.

bottom.bottom. If you use a saucepan which is smallerIf you use a saucepan which is smaller

If you use a saucepan which is smaller

If you use a saucepan which is smallerIf you use a saucepan which is smaller than the recommended size, thethan the recommended size, the

than the recommended size, the

than the recommended size, thethan the recommended size, the flame will spread beyond the bottomflame will spread beyond the bottom

flame will spread beyond the bottom

flame will spread beyond the bottomflame will spread beyond the bottom of the vessel, causing the handle toof the vessel, causing the handle to

of the vessel, causing the handle to

of the vessel, causing the handle toof the vessel, causing the handle to overheat.overheat.

overheat.

overheat.overheat. Carefully supervise cooking with

fat or oilfat or oil

fat or oil,

fat or oilfat or oil since these types of foodstuff can result in a fire, if over-heated.

The stainless steel can become tarnished if excessivelyThe stainless steel can become tarnished if excessively

The stainless steel can become tarnished if excessively

The stainless steel can become tarnished if excessivelyThe stainless steel can become tarnished if excessively heated. Therefore prolonged cooking with potstones,heated. Therefore prolonged cooking with potstones,

heated. Therefore prolonged cooking with potstones,

heated. Therefore prolonged cooking with potstones,heated. Therefore prolonged cooking with potstones, earthenware pans or cast-iron plates is inadvisable. Also,earthenware pans or cast-iron plates is inadvisable. Also,

earthenware pans or cast-iron plates is inadvisable. Also,

earthenware pans or cast-iron plates is inadvisable. Also,earthenware pans or cast-iron plates is inadvisable. Also, do not use aluminium foil to protect the top during use.do not use aluminium foil to protect the top during use.

do not use aluminium foil to protect the top during use.

do not use aluminium foil to protect the top during use.do not use aluminium foil to protect the top during use. Make sure pots do not protrude over the edges of the cooktopMake sure pots do not protrude over the edges of the cooktop

Make sure pots do not protrude over the edges of the cooktop

Make sure pots do not protrude over the edges of the cooktopMake sure pots do not protrude over the edges of the cooktop and that they are centrally positioned on the rings in order toand that they are centrally positioned on the rings in order to

and that they are centrally positioned on the rings in order to

and that they are centrally positioned on the rings in order toand that they are centrally positioned on the rings in order to obtain lower gas consumption.obtain lower gas consumption.

obtain lower gas consumption.

obtain lower gas consumption.obtain lower gas consumption.

Do not place unstable or deformed pots on the rings: theyDo not place unstable or deformed pots on the rings: they

Do not place unstable or deformed pots on the rings: they

Do not place unstable or deformed pots on the rings: theyDo not place unstable or deformed pots on the rings: they could tip over or spill their contents, causing accidents.could tip over or spill their contents, causing accidents.

could tip over or spill their contents, causing accidents.

could tip over or spill their contents, causing accidents.could tip over or spill their contents, causing accidents.

Pots must not enter the control zone.Pots must not enter the control zone.

Pots must not enter the control zone.

Pots must not enter the control zone.Pots must not enter the control zone.

Maintenance and CleaningMaintenance and Cleaning

Maintenance and Cleaning

Maintenance and CleaningMaintenance and Cleaning

Before any maintenance or cleaning can be carried out, youBefore any maintenance or cleaning can be carried out, you

Before any maintenance or cleaning can be carried out, you

Before any maintenance or cleaning can be carried out, youBefore any maintenance or cleaning can be carried out, you must DISCONNECT the hob frmust DISCONNECT the hob fr

must DISCONNECT the hob fr

must DISCONNECT the hob frmust DISCONNECT the hob fr The hob is best cleaned whilst it is still warm, as spillage canThe hob is best cleaned whilst it is still warm, as spillage can

The hob is best cleaned whilst it is still warm, as spillage can

The hob is best cleaned whilst it is still warm, as spillage canThe hob is best cleaned whilst it is still warm, as spillage can be removed more easily than if it is left to cool.be removed more easily than if it is left to cool.

be removed more easily than if it is left to cool.

be removed more easily than if it is left to cool.be removed more easily than if it is left to cool. This appliance cannot be cleaned with steam or with a steamThis appliance cannot be cleaned with steam or with a steam

This appliance cannot be cleaned with steam or with a steam

This appliance cannot be cleaned with steam or with a steamThis appliance cannot be cleaned with steam or with a steam cleaning machine.cleaning machine.

cleaning machine.

cleaning machine.cleaning machine.

om the electricity supplyom the electricity supply

om the electricity supply

om the electricity supplyom the electricity supply

The Hob TThe Hob T

The Hob T

The Hob TThe Hob T

Regularly wipe over the hob top using a soft cloth well wrung out in warm water to which a little wasing up liquid has been added. Avoid the use of the following:

- household detergent and bleaches;

- impregnated pads unsuitable for non-stick saucepans;

- steel wool pads;

- bath/sink stain removers. Should the hob top become heavily soiled, the following products are

recommended:

- For stainless steel hobs use a proprietary stainless steel cleaner.

- For other hobs use Hob Brite or Bar Keepers Friend.

Do not leave acid or alkalineDo not leave acid or alkaline

Do not leave acid or alkaline

Do not leave acid or alkalineDo not leave acid or alkaline substances (e.g. vinegarsubstances (e.g. vinegar

substances (e.g. vinegar

substances (e.g. vinegarsubstances (e.g. vinegar lemon juice, etc.) on the cooktop.lemon juice, etc.) on the cooktop.

lemon juice, etc.) on the cooktop.

lemon juice, etc.) on the cooktop.lemon juice, etc.) on the cooktop.

Pan SupportsPan Supports

Pan Supports

Pan SupportsPan Supports

To keep the pan supports in the correct position, they are hooked into hinges at the back of the hob.

Model ZGF 642Model ZGF 642

Model ZGF 642: The pan supports can

Model ZGF 642Model ZGF 642 be lifted for easier cleaning, as shown in Fig.

1. To remove the pan supports completely, proceed as shown in Fig. 2.

Model ZGF 692 C, ZGF 692 CTModel ZGF 692 C, ZGF 692 CT

Model ZGF 692 C, ZGF 692 CT: The

Model ZGF 692 C, ZGF 692 CTModel ZGF 692 C, ZGF 692 CT hob has two cast iron pan supports.

opop

, salt,, salt,

, salt,

, salt,, salt,

Fig. 1

YES

Fig. 2

+ 22 hidden pages