Zanussi ZGF648IX User Manual [ru]

User Pуководство

Manual по эксплуатации

Gas

Газовая

варочная

Hob поверхность

ZGF 643 ITXC

ZGF 648 IR

ZGF 648 IX

RU

2

Thank you for selecting our appliance

We wish you lots of enjoyment with your new appliance and we hope that you will consider our brand again when purchasing household appliances. Please read this user manual carefully and keep it throughout the product life cycle as a reference document. The user manual should be passed on to any future owner of the appliance.

3

Contents
For the User
Important safety information ..............................................................................	5
Operation ..........................................................................................................	7
Using the hob correctly .....................................................................................	8
Cleaning and Maintenance ................................................................................	9
Service and original spare parts .......................................................................	20
European guarantee ........................................................................................	20
For the Installer
Technical data .................................................................................................	11
Installation .......................................................................................................	13
Adaptation to different types of gas .................................................................	15
Electrical connection .......................................................................................	16
Building in .......................................................................................................	17
Possibilities for insertion ..................................................................................	19
Guide to Use the instructions
The following symbols will be found in the text to guide you throughout the
Instructions:

Safety Instructions

!Step by step instructions for an operation

Hints and Tips

Environmental information

This appliance complies with the following E.E.C. Directives:

•2006/95 (Low Voltage Directive);

•89/336 (Electromagnetical Compatibility Directive);

•90/396 (Gas Appliances);

•93/68 (General Directives)

and subsequent modifications.

MANUFACTURER:

ELECTROLUX HOME PRODUCTS ITALY S.p.A.

Viale Bologna, 298

47100 FORLÌ (Italy)

4

English

Important safety information

This warnings has been given for the safety of you and others. We therefore ask you to carefully read the procedures of installing and using this appliance.

Installation

"The work of installation must be carried out by competent and qualified installers according to the regulations in force.

•Any modifications to the domestic electrical mains which may be necessary for the installation of the appliance should be carried out only by competent personnel.

During Operation

•This appliance has been designed for non professional purpose in private houses only. It is meant to cook edible foodstuff only and must not be used for any other purposes.

•It is dangerous to alter the specification in any way.

•For hygiene and safety reasons, this appliance should be kept clean at all times. A build-up of fats or other foodstuff could result in a fire.

•Under no circumstances should you attempt to repair the appliance yourself. Repairs carried out by unexperienced persons may cause injury or serious malfunctioning. Refer to your local Service Centre. Always insist on genuine spare parts.

•Ensure that all control knobs are in the OFF position when not in use.

•Should you connect any electrical tool to a plug near this cooking appliance, ensure that electric cables are not in

contact with it and keep them far enough from the heated parts of this appliance.

•If the appliance is out of order, disconnect it from the electric supply.

People Safety

•This appliance has been designed to be operated by adults and children under supervision. Young children must not be allowed to tamper with the controls or play near or with the oven.

•This appliance is not intended for use by children or other persons whose physical, sensory or mental capabilities or lack of experience and knowledge prevents them from using the appliance safely without supervision or instruction by a responsible person to ensure that they can use the appliance safely.

•Accessible parts of this appliance may become hot when it is in use. Children should be kept away until it has cooled.

About Installation, Cleaning and

Manteinance

"It is mandatory that all operations required for the installation are carried out by a qualified or competent person, in accordance with existing rules and regulations.

•Disconnect the appliance from the electrical supply, before carrying out any cleaning or manteinance work.

•Ensure a good ventilation around the

5

appliance. A poor air supply could cause lack of oxygen.

•Ensure that the gas supply complies with the gas type stated on the identification label, placed near the gas supply pipe.

•This appliance is not connected to a combustion products evacuation device. It must be installed and connected in accordance with current installation regulations. Particular attention shall be given to the relevant requirements regarding ventilation.

•The use of a gas cooking appliance results in the production of heat and moisture in the room in which it is installed. Ensure that the kitchen is well ventilated: keep natural ventilation holes open or install a mechanical ventilation device (mechanical extractor hood).

Environmental Information

"After installation, please dispose of the packaging with due regard to safety and the environment.

• When disposing of an old appliance, make it unusable, by cutting off the

cable.
The symbol	on the product or

on its packaging indicates that this product may not be treated as household waste. Instead it shall be handed over to the applicable collection point for the recycling of electrical and electronic equipment. By ensuring this product is disposed of correctly, you will help prevent potential negative consequences for the environment and human health, which could otherwise be caused by inappropriate waste handling of this

•Prolonged intensive use of the product. For more detailed information appliance may call for additional about recycling of this product, please

	ventilation, for example opening of	contact your local city office, your
	a window, or more effective	household waste disposal service or the
	ventilation, for example increasing	shop where you purchased the product.
	the level of mechanical ventilation
	where present.	It is very important that this
	• Once you removed all packaging from
		instruction book should be kept
	the appliance, ensure that it is not
		safely for future consultation. If the
	damaged and the electric cable is in
		appliance should be sold or given to
	perfect conditions. Otherwise, contact
	your dealer before proceeding with the	another person, please ensure that
	installation.	the booklet goes together with it, so
	• The manufacturer disclaims any	that the new owner can know of the
		functions of the machine and also be
	responsability should all the safety
		aware of the warnings.
	measures not be carried out.
		These instructions are only for the
	Service
		countries stated by the symbol printed
	• Under no circumstances should you	on the front cover of this instruction
	attempt to repair the appliance	book.
	yourself. Repairs carried out by
	unexperienced persons may cause
	injury or serious malfunctioning. Refer
	to your local Service Centre. Always
	insist on genuine spare parts.

6

Operation

Hob burner control knobs

The symbols on the knobs mean:

"= no gas supply

= maximum gas supply

= minimum gas supply

For easier lighting, proceed before putting a pan on the pan support.

! Lighting the burners

Mod. ZGF 648 IX

Push the relevant knob down and turn it anti-clockwise until it reaches the "maximum" position.

Mod. ZGF 648 IR / ZGF 643 ITXC

After lighting the flame, keep the knob pushed down for about 5 seconds. This will allow the "thermocouple" (see figure - lett. D) to be heated and the safety device to be switched off, otherwise the gas supply would be interrupted.

Then, check the flame is regular and adjust it as required.

If you cannot light the flame even after several attempts, check the "cap" and “crown” (see figure - lett. A, B) are in the correct position.

When switching on the mains, after installation or a power cut, it is quite normal for the spark generator to be activated automatically.

In the absence of electricity, ignition can occur without the electrical device; in this case approach the burner with a flame, push the relevant knob down and turn it anti-clockwise until it reaches the "maximum" position.

A - Burner cap

B - Burner crown

C - Ignition candle

D - Thermocouple

7

Do not keep the control knob pressed for more than 15 seconds.

If the burner does not light even after 15 seconds, release the control knob, turn it the

"off" position and wait for at least one minute before trying to light the burner again.

! To switch off burners

To put the flame out, turn the knob to the symbol (").

The Hob Lid (available only for model ZGF 648 IX)

In order to make the appliance match with the kitchen design, a lid (not provided) can be fitted on the hob.

•The lid is meant to avoid dust to settle on the hob, when it is closed, and to collect splashes of oil or fat, when it is open. Do not use it for any other purpose.

•Always wipe off any splash of liquid before opening the lid.

•Always clean the lid from cooking residues before opening it or taking it off.

WARNING! The crystal lid can splinter when o v e r h e a t e d . Always ensure all the burners are off before closing it.

Using the hob correctly

Practical hints

The burners

To ensure maximum burner efficiency, you should only use pots and pans with a flat bottom fitting the size of the burner used.

Rapid Burner	diameter 16-26 cm
Semi-rapid Burner	diameter 12-22 cm
Auxiliary Burner	diameter 8-16 cm

•For easier lighting, proceed before putting a pan on the pan support.

•Use only pans or pots with flat bottom.

8

•Take care when frying food in hot oil or fat, as the overheated splashes could easily ignite.

•If you use a saucepan which is smaller than the recommended size, the flame will spread beyond the bottom of the vessel, causing the handle to overheat.

•Prolonged cooking with potstones, earthenware pans or cast-iron plates is inadvisable.

Also, do not use aluminium foil to protect the top during use.

•Make sure pots do not protrude over the edges of the cooktop and that they are centrally positioned on the rings in order to obtain lower gas consumption.

•Do not place unstable or deformed pots on the rings: they could tip over or spill their contents, causing accidents.

•Pots must not enter the control zone.

•If the control knobs become difficult to turn, please contact your local Service Force Centre.

•As soon as a liquid starts boiling, turn down the flame so that it will barely keep the liquid simmering.

Cleaning and Mainteinance

Disconnect the appliance from the electrical supply, before carrying out any cleaning or manteinance work.

The hob is best cleaned whilst it is still warm, as spillage can be removed more easily than if it is left to cool.

This appliance cannot be cleaned with steam or with a steam cleaning machine.

The burners

"The burner caps and crowns can be removed for cleaning.

"Wash the burners taps and crowns using hot soapy water, and remove marks with a mild paste cleaner. A well moistened soap impregnated steel wool pad can be used with caution, if the marks are particularly difficult to remove.

"After cleaning, be sure to wipe dry with a soft cloth.

"Frequently wash the "caps" and the "crowns" with hot soapy water, carefully taking away any built-up of food.

The Hob Top

"Regularly wipe over the hob top using a soft cloth well wrung out in warm water to which a little wasing up liquid has been added. Avoid the use of the following:

-household detergent and bleaches;

-impregnated pads unsuitable for non-stick saucepans;

-steel wool pads;

-bath/sink stain removers.

"Should the hob top become heavily soiled, the following products are recommended:

-For stainless steel hobs use a

9

proprietary stainless steel cleaner.
- For other hobs use Hob Brite or Bar
Keepers Friend.
" Do not leave acid or alkaline
substances (e.g. vinegar, salt,
lemon juice, etc.) on the cooktop.
Pan supports
To keep the pan supports in the right
position, they are hooked to a couple of
special hinges in the back of the hob.
Thanks to these hooks, you can lift the pan
supports for easier cleaning, as shown in
the picture.
To take the pan supports completely off the
hob, proceed as shown in the picture.
The Ignition electrode
The electric ignition is obtained
through a ceramic electrode with a				NO
metal	electrode.	Keep	these
components very clean, to avoid difficult
lighting, and check that the burner
crown holes are not obstructed.
Cast iron pan supports (ZGF
643 ITXC / ZGF 648 IR)
	Caution!
	When removing the cast iron pan
	supports, lift them up. Never turn
	the pan supports on the hinges
	since this could damage them.			YES
Periodic Maintenance
Periodically ask your local Service Centre
to check the conditions of the gas supply
pipe and the pressure adjuster, if fitted.

10

Technical data

Burner gas power (natural gas G20-20 mbar)

Rapid burner	3,0 kW
Semi-rapid burner	2,0 kW
Auxiliary burner	1,0 kW
Category	II2H3B/P
Gas supply	natural gas G20 (2H) / 20 mbar
Gas connection	G 1/2"
Electric supply	230 V~ 50 Hz
Appliance class	3

Hob dimensions

Width	580 mm
Depth	510 mm

Cut out dimensions

Width		560 mm
Depth		480 mm
	By-pass diameters
	Burner	Ø By-pass in 1/100 mm.
	Auxiliary	28
	Semi-rapid	32
	Rapid	42

11

Gas burners

	NORMAL	REDUCED		NORMAL
				POWER
	POWER	POWER
BURNER			NATURAL GAS			LPG
			G20 (2H) - 20 mbar		(Butane/Propane) 30 mbar
	kW	kW				g/h
			inj.	m3/h	inj.	G30	G31
			100/mm		100/mm
Auxiliary
burner	1,0	0,33	70	0,095	50	73	71
Semi-rapid
burner	2,0	0,45	96	0,190	71	145	143
Rapid	3,0
burner	(natural gas)	0,75	119	0,285	86	204	200
	2,8
	(LPG)

Gas burners G20 13 mbar - only for Russia

	NORMAL	REDUCED		NORMAL
				POWER
	POWER	POWER
BURNER			NATURAL GAS
			G20 - 13 mbar
	kW	kW	inj.	m3/h
			100/mm
Auxiliary
burner	0,9	0,33	80	0,095
Semi-rapid
burner	1,4	0,45	105	0,148
Rapid
burner	1,9	0,75	120	0,20

12

Installation

l

l

l

l

The following instructions about installation and maintenance must be carried out by qualified personnel in compliance with the regulation in force.

The appliance must be electrically disconnected before all interventions. If any electric supply to the appliance is required to carry out the work, ensure all the necessary precautions are followed.

The side walls of the unit in which the hob is going to be installed, must not exceed the height of the working top.

Avoid installing the appliance in the proximity of inflammable materials (e.g. curtains, tea towels etc.).

THE MANUFACTURER WILL NOT

ACCEPT LIABILITY, SHOULD ANY OF THE OTHER SAFETY INSTRUCTIONS INCORPORATED IN THIS BOOKLET OR THE REGULATION IN FORCE BE IGNORED.

Gas connection

Choose fixed connections or use a flexible pipe in stainless steel in compliance with the regulation in force. If using flexible metallic pipes, be careful they do not come in contact with mobile parts or they are not squeezed. Use the same attention when the hob is combinated with an oven.

13

IMPORTANT - To ensure a correct operation, a savingof energy and the long life of the appliance, the voltage pressure of the appliance must correspond to the recommended values. The adjustable connection is fixed to the comprehensive ramp by means of a threaded nut G 1/2". Interpose the sealing between the components as shown in the picture. Screw the parts without forcing, adjust the connection in the required direction and tighten everything.

IMPORTANT

Once installation is complete, check the perfectseal of every pipe fitting, using a soapy solution, never a flame.

A)Ramp with ending nut

B)Seal

C)Adjustable connection

14