York XP036, XP060, XP048 Technical Manual
®
251933-YTG-J-1009
TECHNICAL GUIDE
R-410A
ZF / ZR / XP SERIES
3 - 5 TON
60 Hertz
Description
YORK® ZF/ZR/XP Series units are convertible single package
high efficiency rooftops with a common roof curb for the 3, 4
and 5 Ton sizes. Although the units are primarily designed for
curb mounting on a roof, they can also be slab-mounted at
ground level or set on steel beams above a finished roof.
All ZF/ZR/XP Series units are self-contained and assembled on
rigid full perimeter base rails allowing for overhead rigging.
Every unit is completely charged, wired, piped and tested at the
factory to provide a quick and easy field installation.
All models (including those with an economizer) are convertible
between bottom and horizontal duct connections.
ZF/ZR Series units are available in the following configurations:
cooling only, cooling with electric heat, and cooling with one or
two stage gas heat. Electric heaters are available as factoryinstalled option or field install e d accessory.
XP Series units are available in the following configurations:
cooling and heating only and cooling and heating with electric
heat.
Tested in accordance with:
FOR DISTRIBUTION USE ONLY - NOT TO BE USED AT POINT OF RETAIL SALE
251933-YTG-J-1009
3/4" PVC female
condensate drain
Knockout
for side
control entry
GFCI
convenience outlet
Smoke
detector
Slide-in
economizer
Economizer
hood
HACR
breaker
20 Gauge aluminized
steel tubular heat exchanger
Electric heat
accessory location
Power ventor motor with
post purge cycle
High efficiency
compressor
Knockout for side
gas supply entry
Simplicity® Lite™
control board
Highly Efficient
Enhanced Copper
Tube/Enhanced
Aluminum Fin
OR
Micro-Channel
Aluminum
Tube/Aluminum
Fin Condenser
Full perimeter baserails
with forklift slots and
lifting holes
Knockout
for side
power entry
Belt drive or
Direct drive
blower
Table of Contents
Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Component Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Nomenclature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Features and Benefits . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Guide Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Physical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Capacity Performance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Airflow Performance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Sound Performance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Electrical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Typical Field Power and Control Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Weights and Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Typical Wiring Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102
Component Location
Gas/Electric
2 Johnson Controls Unitary Products
Electric/Electric and Heat Pump
3/4" PVC female
condensate drain
Knockout
for side
control entry
GFCI
convenience outlet
Smoke
detector
Slide-in
economizer
Economizer
hood
HACR
breaker
Belt drive or
Direct drive
blower
High efficiency
compressor
Highly Efficient
Enhanced Copper
Tube/Enhanced
Aluminum Fin
OR
Micro-Channel
Aluminum
Tube/Aluminum
Fin Condenser
Full perimeter baserails
with forklift slots and
lifting holes
Knockout
for side
power entry
Electric Heat
accessory location
Simplicity® Lite™
control board
251933-YTG-J-1009
Johnson Controls Unitary Products 3
251933-YTG-J-1009
Z F 048 N04 A 2 A AA 1 0 1 2 4 A
Z = A/C, Single Pkg., R-410A
X = HP, Single Pkg., R-410A
Product Category
Airflow
A = Direct Drive
B = Direct Drive/Economizer
D = Direct Drive/Motorized Damper
N = Belt Drive
P = Belt Drive/Economizer
R = Belt Drive/Motorized Damper
T = Belt Drive High Static
U = Belt Drive High Static/Economizer
V = Belt Drive High Static/Motorized Damper
Product Generation
2 = Second Generation
C00 = Cooling Only. Suitable for Field
Installed Electric Heat
Heat Type and Nominal Heat Capacity
N04 = 40 MBH Output Aluminized Steel, 1 Stage (036)
N06 = 60 MBH Output Aluminized Steel, 1 Stage (048)
N08 = 80 MBH Output Aluminized Steel, 1 Stage
(036, 060)
N10 = 100 MBH Output Aluminized Steel, 1 Stage
(048, 060)
D06 = 60 MBH Output Aluminized Steel, 2 Stage
(036, 048, 060)
D10 = 100 MBH Output Aluminized Steel, 2 Stage
(036*, 048, 060)
S04 = 40 MBH Output Stainless Steel, 1 Stage (036)
S06 = 60 MBH Output Stainless Steel, 1 Stage (048)
S08 = 80 MBH Output Stainless Steel, 1 Stage
(036, 060)
S10 = 100 MBH Output Stainless Steel, 1 Stage
(048, 060)
T06 = 60 MBH Output Stainless Steel, 2 Stage
(036, 048, 060)
T10 = 100 MBH Output Sta
inless Steel, 2 Stage
(036*, 048, 060)
*(D, T)10 = 92 MBH Output on 036 Models
E05 = 5 KW
E07 = 7 KW
E10 = 10 KW
E15 = 15 KW
E20 = 20 KW
E30 = 30 KW
Gas Heat Options
Electric Heat Options
036 = 3.0 Ton
Nominal Cooling Capacity
048 = 4.0 Ton
060 = 5.0 Ton
Product Identifier
F = 13.0 SEER A/C
R = 13.0 SEER Reheat
P = 13.0 SEER HP
Voltage
1 = 208/230-1-60
2 = 208/230-3-60
4 = 460-3-60
5 = 575-3-60
Product Style
A = Style A
A = No Options Installed
Installation Options
B = Option 1
C = Option 2
D = Options 1 & 2
E = Option 3
F = Option 4
G = Options 1 & 3
H = Options 1 & 4
J = Options 1, 2 & 3
K = Options 1, 2, & 4
L = Options 1,3 & 4
M = Options 1, 2, 3, & 4
N = Options 2 & 3
P = Options 2 & 4
Q = Options 2, 3, & 4
R = Options 3 & 4
S = Option 5
T = Options 1 & 5
U = Options 1, 3, & 5
V = Options 1, 4, & 5
W = Options 1, 3, 4, & 5
X = Options 3 & 5
Y =
Options 4 & 5
Z = Options 3, 4 & 5
1 = Disconnect
2 = Non-Pwr'd Conv. Outlet
3 = Smoke Detector S.A.
4 = Smoke Detector R.A.
5 = Pwr'd Conv. Outlet
Options
SS Drain Pan
Configuration Options (not required for all units)
These four digits will not be assigned until a quote is requested, or an order placed.
CPC Controller, DFS, APS
Johnson Controller UNT 1126 (N2 protocol), DFS, APS
Honeywell Controller, DFS, APS
Novar Controller, DFS, APS
Simplicity IntelliComfort Controller
Simplicity IntelliComfort Controller w/ModLinc
2" Pleated filters
BAS Ready Economizer (2-10 V.D.C. Actuator Without a Controller)
Any Combination of Additional Options that Don’t Have an Option Code Pre-assigned
AA = None
Standard Cabinet
AB = Phase Monitor
AC = Coil Guard
AD = Dirty Filter Switch
AE = Phase Monitor & Coil Guard
AF = Phase Monitor & Dirty Filter Switch
AG = Coil Guard & Dirty Filter Switch
AH = Phase Monitor, Coil Guard & Dirty Filter Switch
AS = Bottom Drain Connection
RC = Coil Guard & American Flag
TA = Technicoat Condenser Coil
TJ = Technicoat Evaporator Coil
TS = Technicoat Evaporator and Condenser Coil
Additional Options
Hinged Filter Door & Toolless Access Cabinet
BA = Hinged Filter Door & Toolless Access Panels
BB = Phase Monitor, Hinged Filter Door & Toolless
Access Panels
BC = Coil Guard, Hinged Filter Door & Toolless
Access Panels
BD = Dirty Filter Switch, Hinged Filter Door &
Toolless Access Panels
BE = Phase Monitor & Coil Guard, Hinged Filter
Door & Toolless Access Panels
BF = Phase Monitor & Dirty Filter Switch, Hinged
Filter Door & Toolless Access Panels
BG = Coil Guard & Dirty Filter Switch, Hinged Filter
Door & Toolless Access Panels
BH =
Phase Monitor, Coil Guard & Dirty Filter Switch,
Hinged Filter Door & Toolless Access Panels
ZZ = If desired option combination is not listed above, ZZ will be assigned and configuration options will be
located in digits 15-18.
York Commercial Comfort System (YCCS) Rtu Controller
Nomenclature
4 Johnson Controls Unitary Products
251933-YTG-J-1009
Features and Benefits
Standard Features
• High Efficiency - High efficiency units reach 13.0 SEER.
Gas/electric units have electronic spark ignition and
power vented combustion with steady state efficiencies of
80%. High efficiency heat pumps reach 13 SEER and 7.7
H.S.P. F. These efficiencies exceed all legislated
minimum levels and provide low operating costs.
• Coil Technology – All ZF condensers utilize MicroChannel “all-aluminum” condensers which provide
improved heat transfer capabilities, superior corrosion
protection and reduced charge volume s. All evaporators
utilize a conventional copper tube/aluminum fin design for
proven reliability and performance.
• Convertible Airflow Design - All models (including those
with an economizer) are suitable for either bottom or
horizontal duct connections. For bottom duct, remove the
sheet metal panels from the supply and return air openings
through the base of the unit. For horizontal duct, remove
the supply and return air panels on the rear of the unit.
• System Protection - Suction line freezestats are supplied
on all units to protect against loss of charge and coil
frosting when the economizer operates at low outdoor air
temperatures while the compressors are running. Every
unit has solid-core liquid line filter-driers and high and lowpressure switches. Internal compressor protection is
standard on all compressors.
• Advanced Controls - The Simplicity
boards have standardized a number of features
previously available only as options or by utilizing
additional controls.
• Low Ambient - An integrated low-ambient control
allows all units to operate in the cooling mode down to
0F outdoor ambient without additional assistance.
Optionally, the control board can be pro g r a mme d to
lockout the compressors when the outdoor air
temperature is low or when free cooling is available.
The
Simplicity
will effectively operate the cooling system down to
0°F when this product is applied in a comfort cooling application for people. An economizer is typically included in this type of application. When
applying this product for process cooling applications (computer rooms, switchgear, etc.), please
reference applications bulletin AE-011-07 or call
the applications department for Unitary Products
@ 1-877-UPG-SERV for guidance. Additional
accessories may be needed for stable operation at
temperatures below 30° F.
• Anti-Short Cycle Protection - To aid compressor life,
an anti-short cycle delay is incorporated into the
® control board used in this product
®
Lite™ control
standard controls. Compressor reliability is further
ensured by programmable minimum run times. For
testing, the anti-short cycle delay can be temporarily
overridden with the push of a button.
• Fan Delays - Fan on and fan off delays are fully
programmable. Furthermore, the heating and cooling
fan delay times are independent of one another. All units
are programmed with default values based upon their
configuration of cooling and heat.
• Safety Monitoring - The control board monitors the
high and low-pressure switches, the freezestats, the gas
valve, if applicable, and the temperature limit switch on
gas and electric heat units. The unit control board will
alarm on ignition failures, compressor lockouts and
repeated limit switch trips.
• Nuisance Trip Protection and Strikes - To prevent
nuisance trouble calls, the control board uses a “three
times, you’re out” philosophy. The high and lowpressure switches and the freezestats must trip three
times within two hours before the unit control board will
lock out the associated compressor.
• On Board Diagnostics - Each alarm will energize a
trouble light on the thermostat, if so equipped, and flash
an alarm code on the control board LED. Each high and
low-pressure switch alarm as well as each freezestat
alarm has its own flash code. The control board saves the
five most recent alarms in memory, and these alarms can
be reviewed at any time. Alarms and programmed values
are retained through the loss of power.
• Reliable - From the beginning - All units undergo
computer automated testing before they leave the factory.
Units are tested for refrigerant charge and pressure, unit
amperage, and 100% functionality. For the long term - All
ZF/ZR/XP Series units are painted with a long lasting,
powder paint that stands up over the life of the unit. The
paint used has been proven by a 1000 hour salt spray
test.
• Flexible Placement - All models and configurations share
the same cabinet/footprint and thus the same roof curb.
You have the flexibility to set one curb and choose the
correct tonnage size and heating option after the internal
loads have been determined.
• Full Perimeter Base Rails - The permanently attached
base rails provide a solid foundation for the entire unit and
protect the unit during shipment. The rails offer forklift
access from 3 sides, and rigging holes are available so that
an overhead crane can be used to place the units on a roof.
• Easy Installation - Gas and electric utility knockouts are
supplied in the unit underside as well as the side of the
unit. A clearly identified location is provided to mount a
field supplied electrical disconnect switch. Utility
connections can be made quickly and with a minimum
amount of field labor.
• Wide Range of Indoor Airflows - Indoor fan motors are
either direct-drive or belt-drive type providing maximum
flexibility to handle most airflow requirements.
• Gas Heat Operation - All single phase models with gas
heat have minimum annual fuel utilization efficiency
Johnson Controls Unitary Products 5
251933-YTG-J-1009
(AFUE) of 80%. All three phase models with gas heat
have minimum steady state efficiency of 80%. Each
section includes a durable heat exchanger with
aluminized steel or optional stainless steel tubes, a
redundant gas valve, spark ignition, power venting, an
ignition module for 100% shut-off and all of the safety
controls required to meet the latest ANSI standards.
The gas supply piping can be routed into the heating
compartment through a hole in the base pan of the unit or
through a knockout in the piping panel on the front of the
unit.
Electric Heat Operation - All electric heat models are
wired for a single power source and include a bank of
nickel chromium elements mounted at the discharge of
the supply air blower to provide a high velocity and
uniform distribution of air across the heating elements.
Every element is fully protected against excessive
temperature by thermal limit switches.
The power supply wiring can be routed into the control
box through a threaded pipe connection (field supplied) in
the base pan of the unit or through a knockout in the
wiring panel on the side of the unit.
• Warranty - All models include a 1-year limited warranty
on the complete unit. Compressors and electric heater
elements each carry a 5-year warranty. Aluminized steel
and stainless steel tubular heat exchangers carry a 10year warranty.
Factory Installed Options
• Single Input Electronic Enthalpy Economizers Includes a slide-in / plug-in damper assembly with fully
modulating spring-return motor actuator capable of
introducing up to 100% outdoor air with nominal 1%
leakage type dampers.
The enthalpy system contains one sensor that monitors
the outdoor air and determines when the air is cool
enough and dry enough to provide free cooling.
The rain hood is painted to match the basic unit and must
be field-assembled before installing.
• Motorized Outdoor Air Intake Damper -Includes a slidein / plug-in damper assembly with a 2-position, spring
return motor actuator which opens to a pre-set position
whenever the supply air blower is operating and will drive
fully closed when the blower unit shuts down.
The rain hood is painted to match the basic unit and must
be field assembled before installing.
• Phenolic Coated Evaporator And Condenser Coils Special coating process that utilizes Technicoat 10-1™
processes. Coating is applied by total immersion of the
complete coil for maximum protection.
• Electric Heaters - Wired for single point power supply.
These nickel chromium heater elements are provided with
limit and automatic reset capability to prevent operation at
excessive temperatures.
• Filter Options - Standard units are shipped with 1" throwaway filters installed. 2" pleated filters are offered as a
factory installed option.
• Convenience Outlet - This 110 volt outlet can be
“powered” by the unit with a stepdown transformer or the
unit may be ordered with a “non-powered” convenience
outlet that can be wired in the field.
• Disconnect Switch - For gas heat units and cooling units
with electric heat, a HACR breaker sized to the unit is
provided. For cooling only units, a switch sized to the
largest electric heat available for the particular unit is
provided. Factory installed option only.
• Smoke Detectors - (supply air & return air) The smoke
detectors stop operation of the unit by interrupting power
to the control board if smoke is detected within the air
compartment.
Factory installed smoke detectors in the return air, may
be subjected to freezing temperatures during “off” times
due to out side air infiltration. These smoke detectors
have an operational limit of 32°F to 131°F. Smoke
detectors installed in areas that could be out side those
limitations will have to be moved to prevent having false
alarms.
• Coil Guard - Customers can purchase a coil guard kit to
protect the condenser coil from damage. This is not a hail
guard kit.
• Stainless Steel Heat Exchanger - For applications in
corrosive environments, this option provides a full
stainless steel heat exchanger assembly.
• Stainless Steel Drain Pan - An optional rustproof
stainless steel drain pan is available to provide years of
trouble-free operation in corrosive environments.
• Bottom Drain Connection - An optional bottom drain
connection is available for inside the curb connections for
applications in cold environments to reduce freezing drain
lines.
• Phase Monitors - Designed to prevent unit damage. The
phase monitor will shut the unit down in an out-of phase
condition.
• Dirty Filter Switch - This kit includes a differential
pressure switch that energizes the fault light on the unit
thermostat, indicating that there is an abnormally high
pressure drop across the filters. Factory installed option or
field installed accessory.
• Hinged Filter Door/”Toolless” Blower And Access
Panels (Not Hinged) - This option allows for easy access
and maintenance.
NOTE: Knobs are shipped inside the unit to prevent shipping
damage. These must be field installed for tool-less
operation.
• High Static Drive - May include a belt, blower pulley,
motor pulley or a motor change to enhance blower
performance.
6 Johnson Controls Unitary Products
251933-YTG-J-1009
Control Options
• BAS - Building Automation System Controls Simplicity®
INTELLI-Comfort™ Control - The York® Simplicity®
INTELLI-Comfort™ control is factory installed. It includes a
supply air sensor, a return air sensor, and an outside air
sensor. There are provisions for a field installed dirty filter
indicator switch, an air-proving switch, an Outside Air
Humidity sensor, a Return Air Humidity sensor, an Inside
IAQ sensor, and an Outside Air IAQ sensor. Construction
mode operation, 365-day real time clock with 7 day
programming plus holiday scheduling is built-in. Two
different modes of demand ventilation are achieved through
the INTELLI-Comfort™ using CO
inside CO2 sensor to perform Demand Ventilation. It can
also use an Outside CO
sensor to perform Differential
2
Demand Ventilation. It uses a Patented Comfort Ventilation
algorithm to provide comfortable ventilation air
temperature. The patented economizer-loading algorithm
will protect the equipment when harsh operating conditions
exist. Humidity in the occupied space or return duct can be
monitored and controlled via humidity sensors and the onboard connection for hot gas re-heat system. It uses the
INTELLI-Start™ algorithm to maximize energy savings by
recovering the building from the Unoccupied Setpoints to
the Occupied Setpoints just in time for the Occupied Time
Period to begin. The Simplicity
balances space temperature, ventilation air temperature,
and humidity for ultimate comfort.
CO
2
• Simplicity
®
INTELLI-Comfort™ with ModLINC
Control - The York® Simplicity
ModLINC control is factory installed. It includes all the
features of the INTELLI-Comfo rt™ co ntrol with an
additional control to translate communications from
MODBUS to the BACnet MSTP protocol.
• Novar® BAS Control - The Novar® building automation
system controller is factory installed. Incudes supply air
sensor, return air sensor, dirty filter indicator switch, and
air proving switch.
• Johnson Controls BAS Control - The Johnson Control
YK-UNT-1126 building automation system controller is
factory installed. Includes supply air sensor, return air
sensor, dirty filter indicator switch, and air proving switch.
• CPC BAS Control - The Computer Process Controls
Model 810-3060 ARTC Advanced Rooftop building
automation system controller is factory installed. Includes
supply air sensor, return air sensor, dirty filter indicator
switch and air proving switch.
• Honeywell BAS Control - The Honeywell W7750C
building automation system controller is factory installed.
Includes air supply sensor, return air sensor, dirty filter
indicator switch, and air proving switch.
• York Commercial Comfort System (YCCS) - Provides
rooftop system integration for YCCS single zone and
change-over bypass systems.
sensors. It uses an
2
®
INTELLI-Comfort™
®
INTELLI-Comfort™ with
Field Installed Accessories
• Single Input Electronic Enthalpy Economizers -
Includes a slide-in / plug-in damper assembly with fully
modulating spring-return motor actuator capable of
introducing up to 100% outdoor air with nominal 1%
leakage type dampers.
The enthalpy system contains one sensor that monitors
the outdoor air and determines when the air is cool
enough and dry enough to provide free cooling.
The rain hood is painted to match the basic unit and must
be field-assembled before installing.
• Motorized Outdoor Air Intake Damper -Includes a slidein / plug-in damper assembly with a 2-position, spring
return motor actuator which opens to some pre-set
position whenever the supply air blower is operating and
will drive fully closed when the blower unit shuts down.
The rain hood is painted to match the basic unit and must
be field assembled before installing.
• Electric Heaters - wired for single point power supply.
These nickel chromium heater elements are provided with
limit and automatic reset capability to prevent operation at
excessive temperatures.
• Roof Curbs - Eight and fourteen-inch high roof curbs
provide a water-tight seal between the unit and the finished
roof. These full perimeter curbs meet the requirements of
the National Roofing Contractors Association (NRCA) and
are shipped knocked-down for field assembly.
Roof curbs are designed to fit inside the base rails of the
unit and include both a wood nailing strip and duct hanger
supports.
• High Altitude Natural Gas - Burner orifices and pilot
orifices are provided for proper furnace operation at
altitudes up to 6,000 feet.
• Propane - Burner orifices, pilot orifices and gas valve
parts are provided to convert a natural gas furnace to
propane.
• High Altitude Propane - Burner orifices and pilot orifices
are provided for proper furnace operation at altitudes up
to 6,000 feet. This accessory supplements the basi c
propane conversion kit.
• Low Nox Kit - Required to reduce the emission of
nitrogen oxides below 40 nano grams per joule.
• Power Exhaust - Our single input economizer options are
available with power exhaust. Whenever the outdoor air
intake dampers are opened for free cooling, the exhaust
fan will be energized to prevent the conditioned space from
being over-pressurized during economizer operation.
The power exhaust option can only be used on bottom
duct configurations.
Johnson Controls Unitary Products 7
251933-YTG-J-1009
• Barometric Relief Damper - This damper accessory can
be used to relieve internal building air pressure on units
with an economizer without power exhaust. This
accessory includes a rain hood, a bird screen and a fully
assembled damper. With bottom duct connections, the
damper should be mounted over the opening in the return
air panel. With horizontal ductwork, the accessory should
be mounted on the return air duct.
• Enthalpy Accessory Control Kit - This kit contains the
required components to convert a single enthalpy
economizer to dual enthalpy.
• Burglar Bars - Mount in the supply and return openings
to prevent entry into the duct work.
• Flue Exhaust Extension Kit - In locations with wind or
weather conditions which may interfere with proper
exhausting of furnace combustion products, this kit can be
installed to prevent the flue exhaust from entering nearby
fresh air intakes.
Sensor - Senses CO2 levels and automatically
• CO
2
overrides the economizer when levels rise above the
present limits.
• Coil Guard - Customers can purchase a coil guard kit to
protect the condenser coil from damage. This is not a hail
guard kit.
• Hail Guard - Hail Guard kit is available to prevent unit
from hail damage. This is a sloped hood that fits above
the coil.
• Gas Piping Kit - This kit supplies all necessary fittings
and shut off valve.
circuit includes a liquid line filter-drier, a discharge line high
pressure switch and a suction line with a freezestat and low
pressure/loss of charge switch.The unit control circuit includes
a 75 VA transformer, a 24-volt circuit breaker and a relay board
with a compressor lockout circuit, a terminal strip for thermostat
wiring, plus an additional set of pin connectors to simplify the
interface of additional field controls. All models are CSA listed.
All models include a 1-year limited warranty on the complete
unit. Compressors and electric heater elements carry a 5-year
warranty. Aluminized steel and Stainless steel tubular heat
exchangers carry a 10-year warranty.
Description
Units shall be factory-assembled, single packaged, Electric
Cooling/Gas Heat, Electric Cooling/Optional Electric Heat, Heat
Pump/Optional Electric Heat and are designed for outdoor
mounted installation.
The 3 ton, 4 ton and 5 ton units shall have minimum SEER rating of 13.0 with heat pumps having a 7.7 H.S.P.F. They shall
have built-in field convertible duct connections for down dis
charge supply/return or horizontal discharge supply/return, and
be available with factory installed options or field installed
accessories. The units shall be factory wired, piped, charged
with R-410A refrigerant and factory tested prior to shipment. All
unit wiring shall be both numbered and color coded. All units the
cooling performance shall be rated in accordance with DOE
and ARI test procedures. Units shall be CSA listed, classified to
ANSI Z21.47, UL 1995/CSA No. 236 standards.
Unit Cabinet
-
Guide Specifications
General
Units shall be manufactured by Johnson Controls Unitary
Products in an ISO 9001 certified facility.
York's ZF/ZR/XP units are convertible single package units.
Although the units are primarily designed for curb mounting on
a roof, they can also be slab-mounted at ground level or set on
steel beams above a finished roof. Cooling only, cooling with
gas heat and cooling with electric heat models are available
with a wide variety of factory-mounted options and fieldinstalled accessories to make them suitable for almost every
application. All units are self-contained and assembled on full
perimeter base rails with holes in the four corners for overhead
rigging. Every unit is completely piped, wired, charged and
tested at the factory to simplify the field installation and to
provide years of dependable operation. All models (including
those with an economizer) are suitable for either bottom or
horizontal duct connections. Models with power exhaust are
suitable for bottom duct connections only. For bottom duct,
remove the sheet metal panels from the supply and return air
openings through the base of the unit. For horizontal duct,
remove the supply and return air panels on the rear of the unit.
All non-Scroll compressors include crankcase heaters and all
compressors have internal pressure relief. Every refrigerant
Unit cabinet shall be constructed of galvanized steel, with
exterior surfaces coated with a non-chalking, powdered paint
finish, certified at 1000 hours salt spray test per ASTMB117
standards. Indoor blower section shall be insulated with a
minimum 1/2” thick insulation, coated on the airside. Aluminum
foil faced insulation shall be used in the furnace compartment
and be fastened with ridged fasteners to prevent insulation from
entering the air stream. Cabinet panels shall be “large” size,
easily removable for servicing and maintenance. Full perimeter
base rails shall be provided to assure reliable transit of
equipment, overhead rigging and proper sealing on roof curb
applications. Disposable 1" filters shall be furnished and be
accessible through a removable access door, sealed airtight.
Units filter track shall be designed to accommodate either 1" or
2" filters. Fan performance measuring ports shall be provided
on the outside of the cabinet to allow accurate air
measurements of evaporator fan performance without removing
panels or creating air by-pass of the coils. Condensate pan
shall be internally sloped and conform to ASHRAE 62-89 selfdraining standards. Condensate connection shall be a minimum
of 3/4” I.D. female and be a ridged mount connection.
Indoor (Evaporator) Fan Assembly
The indoor fan shall be a factory installed direct-drive or beltdrive assembly that includes an adjustable pitch motor pulley.
Job site selected (B.H.P.) brake horsepower shall not exceed
the motors nameplate horsepower rating, plus the service
8 Johnson Controls Unitary Products
251933-YTG-J-1009
factor. Units shall be designed not to operate above service
factor. Fan wheel shall be double-inlet type with forward-curved
blades, dynamically balanced to operate smoothly throughout
the entire range of operation. Airflow design shall be constant
air volume. Bearings shall be sealed and permanently
lubricated for longer life and no maintenance.
Outdoor (Condenser) Fan Assembly
The outdoor fan shall be of the direct-driven propeller type,
discharge air vertically, have aluminum blades riveted to a
corrosion resistant steel spider bracket and shall be
dynamically balanced for smooth operation. The outdoor fan
motor shall be totally enclosed with permanently lubricated
bearings, internally protected against overload conditions and
staged independently.
Refrigerant Components
Compressor:
a. Shall be internally protected with internal high-pressure
relief and over temperature protection.
b. Shall have internal spring isolation and sound muffling to
minimize vibration and noise, and be externally isolated
on a dedicated, independent mounting.
Coils:
a. Evaporator coils shall have aluminum plate fins
mechanically bonded to seamless internally enhanced
copper tubes with all joints brazed. Special Phenolic
coating shall be available as a factory option.
b. Evaporator coils shall be of the direct expansion, draw-
thru design.
c. Condenser coils shall have aluminum plate fins
mechanically bonded to seamless internally enhanced
copper tubes with all joints brazed or Micro-Channel
aluminum tube, aluminum fins.
d. Condenser coils shall be of the direct expansion, draw-
thru design.
Refrigerant Circuit and Refrigerant Safety Components shall
include:
a. Independent fixed-orifice or thermally operated
expansion devices.
b. Filter drier/strainer to eliminate any moisture or foreign
matter.
c. Accessible service gage connections on both suction
and liquid lines to charge, evacuate, and measure
refrigerant pressure during any necessary servicing or
troubleshooting, without losing charge.
d. The refrigeration system shall provide at least 15°F of
sub-cooling at design conditions.
Unit Controls
a. Unit shall be complete with self-contained low-voltage
control circuit protected by a resettable circuit breaker on
the 24-volt transformer side.
b. Unit shall incorporate a lockout circuit which provides
reset capability at the space thermostat or base unit,
should any of the following standard safety devi ces trip
and shut off compressor.
c. Loss-of-charge/Low-pressure switch.
d. High-pressure switch.
e. Freeze-protection thermostat, evaporator coil.
f. Unit shall incorporate “AUTO RESET” compressor over
temperature, over current protection.
g. Unit shall operate with conventional thermostat designs
and have a low voltage terminal strip for easy hook-up.
h. Unit control board shall have on-board diagnostics and
fault code display.
i. Standard controls shall include anti-short cycle and low
voltage protection, and permit cooling operation down to
0°F.
j. Control board shall monitor each refrigerant safety switch
independently.
k. Control board shall retain last 5 fault codes in non volatile
memory which will not be lost in the event of a power loss.
Gas Heating Section (Single Or 2 Stage)
Shall be designed with induced draft combustion with post
purge logic, energy saving direct spark ignition, and redundant
main gas valve. Venter wheel shall be constructed of stainless
steel for corrosion resistance. The heat exchanger shall be of
the tubular type, constructed of T1-40 aluminized steel for
corrosion resistance and allowing minimum mixed air entering
temperature of 25°F. Burners shall be of the inshot type,
constructed of aluminum coated steel and contain air mixture
adjustments. All gas piping shall enter the unit cabinet at a
single location through either the side or curb without any field
modifications. Integrated control boards shall provide timed
control of evaporator fan functioning and burner ignition.
Heating section shall be provided with the following minimum
protection:
a. Primary and auxiliary high-temperature limit switches.
b. Induced draft motor speed sensor.
c. Flame roll out switch.
d. Flame proving controls.
e. If any of the above safety devices trip, a LED (light-
emitting diode) indicator shall flash a diagnostic code that
indicates which safety switch has tripped.
st
NOTE: All 2 Stage Gas Heat, 60% Capacity 1
Capacity 2
nd
Stage.
Stage, 40%
Johnson Controls Unitary Products 9
251933-YTG-J-1009
Electric Heating Section
An electric heating section, with nickel chromium elements,
shall be provided in a range of 5 thru 30 KW, offering two
stages of capacity - 16 KW and above on 208/230 volt heaters
and 20 KW and above on 460 and 575 volt heaters. The
heating section shall have a primary limit control(s) and
automatic reset to prevent the heating element system from
operating at an excessive temperature. The heating section
assembly shall slide out of the unit for easy maintenance and
service. Units with Electric Heating shall be wired for a single
point power supply with branch circuit fusing (where required).
Unit Operating Characteristics
Unit shall be capable of starting and running at 125°F outdoor
temperature, exceeding maximum load criteria of ARI Standard
210/240. The compressor, with standard controls, shall be
capable of operation down to 0°F outdoor temperature. Unit
shall be provided with fan time delay to prevent cold air delivery
before heat exchanger warms up (Gas heat only).
Electrical Requirements
All unit power wiring shall enter unit cabinet at a single factory
provided location and be capable of side or bottom entry, to
minimize roof penetrations and avoid unit field modifications.
Separate side and bottom openings shall be provided for the
control wiring.
Standard Limited Warranties
• Compressor 5 Years
• Heat Exchanger 10 Years
• Electric Heat Element 5 Years
• Other Parts 1 Year
Optional Outdoor Air
Shall be made available by either/or:
• Electronic Enthalpy Automatic Economizer - Outdoor
and return air dampers that are interlocked and positioned
by a fully-modulating, spring return damper actuator. The
maximum leakage rate for the outdoor air intake dampers
shall not exceed 2% when dampers are fully closed and
operating against a pressure differential of 0.5 IWG. A unitmounted potentiometer shall be provided to adjust the
outdoor and return air damper assembly to take in CFM of
outdoor air to meet the minimum ventilation requirement of
the conditioned space during normal operation. During
economizer operation, a mixed-air temperature control
shall modulate the outdoor and return air damper assembly
to prevent the supply air temperature from dropping below
55°F. Changeover from compressor to economizer
operation shall be provided by an integral electronic
enthalpy control that feeds input into the basic module. The
outdoor intake opening shall be covered with a rain hood
that matches the exterior of the unit. Water eliminator/filters
shall be provided. Simultaneous economizer/compressor
operation is also possible. Dampers shall fully close on
power loss.
• Motorized Outdoor Air Dampers - Outdoor air dampers
are positioned by a 2-position, spring-return damper
actuator. The maximum leakage rate for the outdoor air
intake dampers shall not exceed 2% when dampers are
fully closed and operating against a pressure differential
of 0.5 IWG. A unit-mounted potentiometer shall be
provided to adjust the outdoor damper assembly to take in
the design CFM of outdoor air to meet the ventilation
requirements of the conditioned space during normal
operation. Whenever the indoor fan motor is energized,
the dampers open up to one of two pre-selected positions
- regardless of the outdoor air enthalpy. Dampers return to
the fully closed position when the indoor fan motor is deenergized. Dampers shall fully close on power loss.
Other Pre-engineered Accessories Available
• Roof Curb - 14"and 8” high, full perimeter curb with wood
nailer (shipped knocked-down).
• Barometric Relief Damper - Contains a rain hood, air
inlet screen, exhaust damper and mounting hardware.
Used to relieve internal air pressure through the unit.
• Propane Conversion Kit
valve parts to convert from natural to L.P. gas. One per
unit required.
• High Altitude - Natural Gas - Contains orifices required
for applications between 2000 and 6000 feet altitude.
• High Altitude - Propane Gas - Contains orifice s requ ired
for applications between 2000 and 6000 feet altitude.
Must be used with propane conversion kit.
• Low Nox - Required to reduce the emission of nitrogen
oxides below 40 nanograms per joule.
• Gas Piping - Contains 1/2” pipe nipples, fittings and gas
cock (including panel assess gaskets) required for bottom
gas supply connection with external shut off.
• Power Exhaust Option - To work in conjunction with
economizers.
• Electric Heaters
• Economizer/motorized Damper Rain Hood - Contains
all hood panels and the hardware for assembling.
• Manual Outdoor Air Damper
• Coil Guard Kit - Guard for cooling coil.
• Hail Guard
• Flue Exhaust Extension
OTHER FACTORY INSTALLED OPTIONS
• Power Exhaust Option - To work in conjunction with
economizers.
• Stainless Steel Heat Exchanger
• Stainless Steel Drain Pan
• Bottom Drain Connection
- Contains new orifices and gas
10 Johnson Controls Unitary Products
251933-YTG-J-1009
• Technicoat Phenolic Coated Condenser And
Evaporator Coil
• Electronic Single Enthalpy Economizer
• Dirty Filter Switch
• Phase Monitor
•Coil Guard
• Powered GFI Convenience Outlet
• Non-powered GFI Convenience Outlet
• BAS Controls (Simplicity
®
INTELLI-Comfort™, CPC,
Johnson, Honeywell, Novar, York Commercial
Comfort System (YCCS))
• Bas Ready Economizer (2-10 V.D.C. Actuator Without
a Controller)
• Hinged Filter Door Access And Toolless Access
Panels
• 2" Pleated Filters
• Disconnect Switch
• Supply Air Smoke Detector
• Return Air Smoke Detector
• Direct Drive Or Belt Drive Blower With High Static
Drive Option
• Hot Gas Reheat with Hot Gas Bypass
Johnson Controls Unitary Products 11
251933-YTG-J-1009
XP036-060 Physical Data
Component
Nominal Tonnage 3.0 4.0 5.0
ARI COOLING PERFORMANCE
Gross Capacity @ ARI A point (Btu) 36200 48500 60100
ARI net capacity (Btu) 35000 46500 57500
EER 11.0 10.8 10.6
SEER 13.0 13.0 13.0
Nominal CFM 1200 1600 1850
System power (KW) 3.25 4.26 5.42
Refrigerant type R-410A R-410A R-410A
Refrigerant charge (lb-oz) 13-0 13-0 12-10
ARI HEATING PERFORMANCE
47°F capacity rating (MBH) 34800 45000 56500
System power (KW) / COP 3.29 (kW) / 3.10 4.06 (kW) / 3.25 5.4 (kW) / 3.10
17°F capacity rating (MBH 19000 27000 34400
System power (KW) / COP 2.60 (kW) / 2.15 3.86 (kW) / 2.06 4.75 (kW) / 2.10
HSPF (Btu/Watts-hr) 7.70 7.70 7.70
DIMENSIONS (inches)
Length 82-1/4 82-1/4 82-1/4
Width 44-7/8 44-7/8 44-7/8
Height 32-5/8 32-5/8 32-5/8
OPERATING WT. (lbs.) 575 585 590
COMPRESSORS
Type Scroll Scroll Scroll
Quantity 1 1 1
CONDENSER COIL DATA
Face area (Sq. Ft.) 16.88 16.88 16.88
Rows 222
Fins per inch 18 18 18
Tube diameter 3/8 3/8 3/8
Circuitry Type Split-face Split-face Split-face
EVAPORATOR COIL DATA
Face area (Sq. Ft.) 5.06 5.06 5.06
Rows 444
Fins per inch 13 13 13
Tube diameter 0.375 0.375 0.375
Circuitry Type Split-face Split-face Split-face
Refrigerant control TXV TXV TXV
XP036 XP048 XP060
Models
16 Johnson Controls Unitary Products
XP036-060 Physical Data (Continued)
251933-YTG-J-1009
Component
Nominal Tonnage 3.0 4.0 5.0
CONDENSER FAN DATA
Quantity 1 1 1
Fan diameter (Inch) 24 24 24
Type Prop Prop Prop
Drive type Direct Drive Direct Drive Direct Drive
No. speeds 1 1 1
Number of motors 1 1 1
Motor HP each 1/4 1/2 1/2
RPM 850 1090 1090
Nominal total CFM 3275 4200 4200
BELT DRIVE EVAP FAN DATA
Quantity 1 1 1
Fan Size (Inch) 12 x 10 12 x 10 12 x 10
Type Centrifugal Centrifugal Centrifugal
Motor Sheave 1VL44 1VP56 1VL44 1VP56 1VL44 1VP56
Blower Sheave AK64 AK66 AK56 AK61 AK56 AK56
Belt A37 A39 A36 A38 A36 A38
Motor HP each 1-1/2 1-1/2 1-1/2 1-1/2 1-1/2 2
RPM 1725 1725 1725
Frame size 56 56 56
DIRECT DRIVE EVAP FAN DATA
Quantity 1 1 1
Fan Size (Inch) 12 x 10 12 x 10 12 x 10
Type Centrifugal Centrifugal Centrifugal
Motor HP each 3/4 1 1
RPM 1050 1050 1050
FILTERS
15” x 20” x 1” or 2” 2 2 2
14” x 25” x 1” or 2” 1 1 1
XP036 XP048 XP060
Models
Johnson Controls Unitary Products 17
251933-YTG-J-1009
ZF/ZR/XP036-060 Unit Limitations
Size
(Tons)
ZF/ZR/XP036
(3.0)
ZF/ZR/XP048
(4.0)
ZR/XP060
(5.0)
ZF060
(5.0)
Unit Limitations
Unit Voltage
208/230-1-60 187 252 125
208/230-3-60 187 252 125
460-3-60 432 504 125
575-3-60 540 630 125
208/230-1-60 187 252 125
208/230-3-60 187 252 125
460-3-60 432 504 125
575-3-60 540 630 125
208/230-1-60 187 252 125
208/230-3-60 187 252 125
460-3-60 432 504 125
575-3-60 540 630 125
208/230-1-60 187 252 125
208/230-3-60 187 252 125
460-3-60 432 504 125
575-3-60 540 630 125
Applied Voltage Outdoor DB Temp
Min Max Max (°F)
18 Johnson Controls Unitary Products
XP036-060 Cooling Capacities
XP036 (3.0 Ton)
Air on
Evaporator Coil
CFM
750
900
1050
1200
1350
1500
750
900
1050
1200
1350
1500
WB
(°F)
77 43.4 2.1 20.2 17.0 13.8 - - - 41.3 2.4 18.4 15.3 12.2 - - 72 40.8 2.1 25.0 21.8 18.6 15.4 - - 38.5 2.4 23.2 20.2 17.1 14.0 - 67 38.2 2.1 29.9 26.7 23.5 20.3 17.1 - 35.6 2.4 28.1 25.0 21.9 18.9 15.8 62 32.1 2.1 32.1 34.4 29.0 25.8 22.6 19.4 32.0 2.4 32.0 32.0 27.1 24.1 21.0 17.9
77 45.5 2.1 22.4 18.7 15.0 - - - 42.9 2.4 20.6 17.0 13.3 - - 72 42.8 2.1 27.7 24.0 20.2 16.5 - - 40.0 2.4 25.9 22.3 18.6 15.0 - 67 40.0 2.1 32.9 29.2 25.5 21.7 18.0 - 37.0 2.4 31.2 27.6 24.0 20.3 16.7 62 33.7 2.1 33.7 35.2 31.5 27.7 24.0 20.2 33.3 2.4 33.3 33.3 29.6 26.0 22.4 18.8
57 31.0 2.1 31.0 31.0 29.4 25.6 21.9 18.1 31.2 2.4 31.2 31.2 28.7 25.1 21.5 17.9
77 47.6 2.1 24.7 20.4 16.1 - - - 44.5 2.4 22.8 18.6 14.5 - - 72 44.7 2.1 30.4 26.1 21.8 17.5 - - 41.5 2.4 28.5 24.4 20.2 16.1 - 67 41.9 2.1 36.0 31.7 27.5 23.2 18.9 - 38.4 2.4 34.3 30.1 26.0 21.8 17.7 62 35.3 2.1 35.3 36.0 33.9 29.6 25.3 21.1 34.5 2.4 34.5 34.5 32.1 28.0 23.8 19.7
57 32.5 2.1 32.5 32.5 31.6 27.4 23.1 18.8 32.4 2.4 32.4 32.4 31.1 27.0 22.8 18.7
77 49.6 2.1 27.0 22.1 17.3 - - - 46.1 2.4 25.0 20.3 15.6 - - 72 46.7 2.1 33.0 28.2 23.4 18.6 - - 43.0 2.4 31.1 26.5 21.8 17.1 - 67 43.7 2.1 39.1 34.3 29.4 24.6 19.8 - 39.8 2.4 37.3 32.7 28.0 23.3 18.6 62 36.8 2.1 36.8 36.8 36.4 31.6 26.7 21.9 35.8 2.4 35.8 35.8 34.6 29.9 25.3 20.6
57 33.9 2.1 33.9 33.9 33.9 29.1 24.3 19.5 33.5 2.4 33.5 33.5 33.5 28.9 24.2 19.5
72 46.9 2.1 35.4 30.1 24.8 19.5 - - 43.3 2.4 33.4 28.3 23.2 18.0 - 67 43.9 2.1 41.6 36.6 31.3 26.0 20.7 - 40.1 2.4 38.8 34.9 29.8 24.6 19.5 62 37.0 2.1 37.0 37.0 36.8 31.5 26.2 20.9 36.0 2.4 36.0 36.0 35.4 30.3 25.2 20.0
57 34.1 2.1 34.1 34.1 34.1 28.8 23.5 18.2 33.8 2.4 33.8 33.8 33.8 28.6 23.5 18.4
72 47.1 2.1 37.8 32.0 26.3 20.5 - - 43.6 2.4 35.7 30.2 24.6 19.0 - 67 44.1 2.1 44.1 38.8 33.1 27.3 21.5 - 40.3 2.4 40.3 37.1 31.6 26.0 20.4 62 37.1 2.1 37.1 37.1 37.1 31.4 25.6 19.8 36.3 2.4 36.3 36.3 36.3 30.7 25.1 19.5
57 34.2 2.1 34.2 34.2 34.2 28.4 22.7 16.9 34.0 2.4 34.0 34.0 34.0 28.4 22.8 17.2
77 39.2 2.8 16.5 13.6 10.7 - - - 35.6 3.1 14.8 12.4 9.5 - - 72 36.1 2.7 21.4 18.5 15.5 12.6 - - 32.9 3.1 20.2 17.2 14.3 11.4 - 67 33.0 2.7 26.3 23.3 20.4 17.5 14.5 - 30.2 3.1 25.5 22.1 19.1 16.2 13.3 62 31.9 2.6 31.9 29.6 25.3 22.4 19.4 16.5 28.4 3.0 28.4 27.3 23.2 20.3 17.3 14.4
77 40.3 2.8 18.7 15.2 11.7 - - - 36.8 3.1 17.4 13.9 10.5 - - 72 37.2 2.7 24.0 20.6 17.1 13.6 - - 34.0 3.1 22.7 19.3 15.8 12.3 - 67 34.0 2.7 29.4 25.9 22.4 19.0 15.5 - 31.2 3.1 28.1 24.6 21.1 17.7 14.2 62 32.9 2.6 32.9 31.3 27.8 24.4 20.9 17.4 29.4 3.0 29.4 28.6 25.6 22.2 18.7 15.2
57 31.4 2.6 31.4 31.4 28.1 24.6 21.1 17.6 28.7 3.1 28.7 28.7 25.7 22.3 18.8 15.4
77 41.5 2.8 20.8 16.8 12.8 - - - 38.0 3.1 19.9 15.4 11.5 - - 72 38.2 2.7 26.7 22.6 18.6 14.6 - - 35.1 3.1 25.3 21.3 17.3 13.3 - 67 35.0 2.7 32.5 28.5 24.5 20.5 16.5 - 32.3 3.1 30.6 27.1 23.2 19.2 15.2 62 33.8 2.6 33.8 33.0 30.4 26.4 22.3 18.3 30.4 3.0 30.4 30.0 28.0 24.1 20.1 16.1
57 32.3 2.7 32.3 32.3 30.6 26.6 22.6 18.6 29.7 3.1 29.7 29.7 28.2 24.2 20.2 16.2
77 42.6 2.8 22.9 18.4 13.9 - - - 39.3 3.1 22.5 17.0 12.4 - - 72 39.3 2.7 29.3 24.7 20.2 15.6 - - 36.3 3.1 27.8 23.3 18.8 14.3 - 67 35.9 2.7 35.6 31.1 26.5 22.0 17.4 - 33.3 3.0 33.2 29.7 25.2 20.6 16.1 62 34.7 2.6 34.7 34.7 32.9 28.3 23.8 19.3 31.4 3.0 31.4 31.4 30.5 26.0 21.4 16.9
57 33.2 2.7 33.2 33.2 33.2 28.6 24.1 19.5 30.6 3.1 30.6 30.6 30.6 26.1 21.6 17.1
72 39.7 2.8 31.5 26.5 21.5 16.6 - - 36.3 3.1 30.0 25.0 20.1 15.1 - 67 36.3 2.7 36.1 33.3 28.3 23.3 18.3 - 33.4 3.1 33.3 31.2 26.9 21.9 17.0 62 35.1 2.7 35.1 35.1 34.1 29.2 24.2 19.2 31.4 3.0 31.4 31.4 31.0 26.0 21.1 16.1
57 33.5 2.7 33.5 33.5 33.5 28.5 23.5 18.5 30.7 3.1 30.7 30.7 30.7 25.7 20.7 15.8
72 40.0 2.8 33.7 28.3 22.9 17.5 - - 36.4 3.1 32.2 26.8 21.4 16.0 - 67 36.6 2.7 36.6 35.4 30.0 24.6 19.2 - 33.4 3.1 33.4 32.8 28.6 23.2 17.8 62 35.4 2.7 35.4 35.4 35.4 30.0 24.6 19.2 31.5 3.0 31.5 31.5 31.5 26.1 20.7 15.3
57 33.8 2.7 33.8 33.8 33.8 28.4 23.0 17.6 30.7 3.1 30.7 30.7 30.7 25.3 19.9 14.5
Total
Capacity
(MBh)
Total
1
Input
2
(kW)
251933-YTG-J-1009
Sensible Capacity (MBh)
Return Dry Bulb (°F) Return Dry Bulb (°F)
90 85 80 75 70 65 90 85 80 75 70 65
75°F 85°F
95°F 105°F
Temperature of Air on Condenser Coil
Total
Capacity
(MBh)
Total
1
Input
(kW)
Sensible Capacity (MBh)
2
Johnson Controls Unitary Products 37
251933-YTG-J-1009
XP036 (3.0 Ton) (Continued)
Air on
Evaporator Coil
CFM
750
900
1050
1200
1350
1500
WB
(°F)
77 31.9 3.5 13.1 11.2 8.3 - - - 28.3 3.8 11.3 10.0 7.1 - - 72 29.6 3.5 18.9 16.0 13.1 10.1 - - 26.4 3.8 17.7 14.8 11.9 8.9 - 67 27.3 3.4 24.8 20.8 17.9 14.9 12.0 - 24.4 3.8 24.0 19.5 16.6 13.7 10.7 62 25.0 3.5 25.0 25.0 21.1 18.1 15.2 12.3 21.5 3.9 21.5 21.5 19.0 16.0 13.1 10.2
77 33.2 3.5 16.1 12.7 9.2 - - - 29.7 3.8 14.8 11.4 7.9 - - 72 30.8 3.4 21.4 18.0 14.5 11.1 - - 27.7 3.8 20.1 16.7 13.2 9.8 - 67 28.4 3.4 26.7 23.3 19.8 16.4 12.9 - 25.7 3.8 25.4 22.0 18.5 15.1 11.7 62 26.0 3.4 26.0 26.0 23.4 20.0 16.5 13.1 22.6 3.8 22.6 22.6 21.2 17.8 14.3 10.9
57 26.0 3.5 26.0 26.0 23.4 20.0 16.5 13.1 23.3 3.9 23.3 23.3 21.1 17.7 14.2 10.8
77 34.6 3.4 19.1 14.1 10.1 - - - 31.1 3.8 18.3 12.7 8.8 - - 72 32.1 3.4 23.9 19.9 16.0 12.0 - - 29.0 3.8 22.5 18.6 14.6 10.7 - 67 29.6 3.4 28.7 25.8 21.8 17.9 13.9 - 26.9 3.8 26.8 24.4 20.5 16.5 12.6 62 27.0 3.4 27.0 27.0 25.7 21.8 17.8 13.8 23.6 3.8 23.6 23.6 23.4 19.5 15.5 11.6
57 27.0 3.5 27.0 27.0 25.8 21.8 17.8 13.8 24.4 3.9 24.4 24.4 23.3 19.4 15.4 11.5
77 35.9 3.4 22.1 15.5 11.0 - - - 32.5 3.7 21.8 14.1 9.6 - - 72 33.3 3.4 26.4 21.9 17.4 12.9 - - 30.3 3.7 24.9 20.5 16.0 11.6 - 67 30.7 3.4 30.7 28.3 23.8 19.3 14.8 - 28.1 3.7 28.1 26.9 22.4 18.0 13.5 62 28.1 3.4 28.1 28.1 28.1 23.6 19.1 14.6 24.7 3.8 24.7 24.7 24.7 21.2 16.7 12.3
57 28.1 3.4 28.1 28.1 28.1 23.6 19.1 14.6 25.5 3.8 25.5 25.5 25.5 21.1 16.6 12.2
72 33.0 3.4 28.5 23.6 18.6 13.7 - - 29.7 3.8 27.0 22.1 17.2 12.3 - 67 30.4 3.4 30.4 29.2 25.5 20.5 15.6 - 27.5 3.8 27.5 27.2 24.1 19.1 14.2 62 27.8 3.4 27.8 27.8 27.8 22.9 17.9 13.0 24.2 3.8 24.2 24.2 24.2 19.7 14.8 9.9
57 27.8 3.5 27.8 27.8 27.8 22.9 17.9 13.0 25.0 3.8 25.0 25.0 25.0 20.1 15.2 10.2
72 32.7 3.4 30.7 25.3 19.9 14.5 - - 29.0 3.8 29.0 23.7 18.4 13.0 - 67 30.1 3.4 30.1 30.1 27.1 21.7 16.3 - 26.9 3.8 26.9 26.9 25.7 20.3 14.9 62 27.6 3.4 27.6 27.6 27.6 22.2 16.8 11.4 23.6 3.8 23.6 23.6 23.6 18.2 12.9 7.5
57 27.6 3.5 27.6 27.6 27.6 22.2 16.8 11.4 24.5 3.9 24.5 24.5 24.5 19.1 13.7 8.3
Total
Capacity
(MBh)
Total
1
Input
2
(kW)
Sensible Capacity (MBh)
Return Dry Bulb (°F) Return Dry Bulb (°F)
90 85 80 75 70 65 90 85 80 75 70 65
115°F 125°F
1. These capacities are gross ratings. For net capacity, deduct air blower motor, MBh = 3.415 x kW. Refer to the appropriate Blower
Performance Table for the kW of the supply air blower motor.
2. These ratings include the condenser fan motors (total 1 kW) and the compressor motors but not the supply air blower motor.
Temperature of Air on Condenser Coil
Total
Capacity
(MBh)
Total
1
Input
(kW)
Sensible Capacity (MBh)
2
38 Johnson Controls Unitary Products
XP048 (4.0 Ton)
Air on
Evaporator Coil
CFM
1000
1200
1400
1600
1800
2000
1000
1200
1400
1600
1800
2000
WB
(°F)
77 60.0 2.8 26.9 22.4 18.0 - - - 54.8 3.2 22.8 18.7 14.6 - - 72 55.2 2.8 33.0 28.6 24.2 19.8 - - 50.4 3.2 29.4 25.4 21.3 17.2 - 67 50.3 2.8 39.2 34.9 30.5 26.1 21.7 - 46.0 3.2 36.1 32.0 27.9 23.8 19.8 62 45.1 2.8 45.1 43.9 37.8 33.4 29.0 24.6 40.8 3.2 40.8 39.6 33.4 29.3 25.2 21.1
77 61.8 2.8 29.3 24.4 19.5 - - - 57.0 3.2 25.6 20.9 16.2 - - 72 56.8 2.8 35.9 31.0 26.1 21.3 - - 52.5 3.2 33.0 28.3 23.6 18.8 - 67 51.7 2.8 42.6 37.7 32.8 27.9 23.0 - 47.9 3.2 40.4 35.7 30.9 26.2 21.5 62 46.5 2.8 46.5 45.6 40.7 35.9 31.0 26.1 42.5 3.2 42.5 41.7 37.0 32.3 27.5 22.8
57 46.8 2.8 46.8 46.8 43.2 38.3 33.4 28.5 42.3 3.2 42.3 42.3 38.2 33.5 28.8 24.0
77 63.6 2.8 31.6 26.4 21.0 - - - 59.3 3.2 28.5 23.1 17.8 - - 72 58.4 2.8 38.8 33.4 28.0 22.7 - - 54.6 3.2 36.6 31.2 25.9 20.5 - 67 53.2 2.8 46.0 40.5 35.1 29.7 24.4 - 49.8 3.2 44.7 39.3 34.0 28.6 23.2 62 47.8 2.8 47.8 47.4 43.7 38.3 32.9 27.5 44.2 3.2 44.2 43.8 40.6 35.2 29.9 24.5
57 48.2 2.8 48.2 48.2 46.3 41.0 35.6 30.2 44.0 3.2 44.0 44.0 41.9 36.6 31.2 25.8
77 65.4 2.8 34.0 28.3 22.5 - - - 61.6 3.2 31.4 25.4 19.3 - - 72 60.0 2.8 41.7 35.8 29.9 24.1 - - 56.6 3.2 40.2 34.2 28.2 22.1 - 67 54.7 2.8 49.3 43.3 37.4 31.5 25.7 - 51.7 3.2 49.0 43.0 37.0 31.0 24.9 62 49.2 2.8 49.2 49.2 46.6 40.8 34.9 29.0 45.9 3.2 45.9 45.9 44.2 38.2 32.2 26.1
57 49.5 2.8 49.5 49.5 49.5 43.7 37.8 31.9 45.7 3.2 45.7 45.7 45.7 39.6 33.6 27.6
72 61.4 2.8 45.7 39.0 32.3 25.6 - - 57.1 3.2 43.0 36.4 29.7 23.1 - 67 56.0 2.8 53.3 47.2 40.5 33.8 27.1 - 52.1 3.2 50.8 45.7 39.1 32.4 25.8 62 50.3 2.8 50.3 50.3 49.0 42.3 35.6 28.9 46.3 3.2 46.3 46.3 45.4 38.8 32.2 25.5
57 50.6 2.8 50.6 50.6 50.6 43.9 37.2 30.5 46.0 3.2 46.0 46.0 46.0 39.4 32.7 26.1
72 62.8 2.8 49.8 42.3 34.7 27.2 - - 57.5 3.2 45.8 38.5 31.3 24.1 - 67 57.2 2.8 57.2 51.1 43.6 36.1 28.5 - 52.5 3.2 52.5 48.4 41.1 33.9 26.7 62 51.4 2.8 51.4 51.4 51.4 43.9 36.4 28.8 46.6 3.2 46.6 46.6 46.6 39.4 32.1 24.9
57 51.7 2.8 51.7 51.7 51.7 44.2 36.7 29.2 46.3 3.2 46.3 46.3 46.3 39.1 31.9 24.7
77 49.5 3.6 18.7 15.0 11.2 - - - 45.8 3.9 17.2 14.4 10.7 - - 72 45.6 3.6 25.8 22.1 18.3 14.5 - - 42.3 4.0 24.8 21.1 17.4 13.7 - 67 41.7 3.6 33.0 29.1 25.4 21.6 17.8 - 38.7 4.0 32.4 27.9 24.2 20.5 16.8 62 36.5 3.6 36.5 35.4 29.0 25.2 21.5 17.7 34.2 4.0 34.2 33.7 27.7 24.0 20.3 16.6
77 52.3 3.6 22.0 17.5 12.9 - - - 48.0 4.0 21.0 16.6 12.1 - - 72 48.2 3.6 30.1 25.6 21.0 16.4 - - 44.3 4.0 28.7 24.2 19.7 15.3 - 67 44.1 3.6 38.2 33.7 29.1 24.5 19.9 - 40.6 4.0 36.4 31.9 27.4 22.9 18.5 62 38.6 3.6 38.6 37.8 33.3 28.7 24.1 19.5 35.9 4.0 35.9 35.5 31.4 26.9 22.4 18.0
57 37.8 3.5 37.8 37.8 33.3 28.7 24.1 19.5 35.6 4.0 35.6 35.6 31.4 27.0 22.5 18.0
77 55.0 3.6 25.4 19.9 14.5 - - - 50.3 4.0 24.9 18.8 13.5 - - 72 50.7 3.6 34.4 29.1 23.7 18.3 - - 46.4 4.0 32.6 27.3 22.1 16.8 - 67 46.4 3.6 43.5 38.2 32.8 27.4 22.1 - 42.5 4.0 40.4 35.9 30.6 25.4 20.1 62 40.6 3.6 40.6 40.3 37.5 32.2 26.8 21.4 37.6 4.0 37.6 37.4 35.1 29.8 24.6 19.3
57 39.8 3.5 39.8 39.8 37.5 32.2 26.8 21.4 37.2 4.0 37.2 37.2 35.1 29.9 24.6 19.3
77 57.8 3.6 28.7 22.4 16.2 - - - 52.5 4.0 28.7 21.0 14.9 - - 72 53.3 3.6 38.7 32.6 26.4 20.2 - - 48.4 4.0 36.5 30.5 24.4 18.3 - 67 48.7 3.6 48.7 42.7 36.6 30.4 24.2 - 44.4 4.0 44.4 39.9 33.9 27.8 21.8 62 42.7 3.6 42.7 42.7 41.8 35.6 29.4 23.3 39.2 4.0 39.2 39.2 38.8 32.7 26.7 20.6
57 41.8 3.5 41.8 41.8 41.8 35.6 29.4 23.3 38.8 4.0 38.8 38.8 38.8 32.8 26.7 20.7
72 52.7 3.6 40.3 33.7 27.1 20.6 - - 48.0 4.0 38.1 31.5 24.9 18.3 - 67 48.2 3.6 48.2 44.2 37.6 31.1 24.5 - 43.9 4.0 43.9 41.2 34.6 28.0 21.4 62 42.2 3.6 42.2 42.2 41.8 35.2 28.7 22.1 38.8 4.0 38.8 38.8 38.6 32.0 25.4 18.8
57 41.4 3.6 41.4 41.4 41.4 34.8 28.3 21.7 38.5 4.0 38.5 38.5 38.5 31.9 25.3 18.7
72 52.2 3.6 41.8 34.8 27.9 21.0 - - 47.5 4.0 39.7 32.6 25.4 18.3 - 67 47.7 3.6 47.7 45.6 38.7 31.8 24.9 - 43.5 4.0 43.5 42.4 35.3 28.1 21.0 62 41.8 3.6 41.8 41.8 41.8 34.9 27.9 21.0 38.5 4.0 38.5 38.5 38.5 31.3 24.2 17.0
57 40.9 3.6 40.9 40.9 40.9 34.0 27.1 20.2 38.1 4.0 38.1 38.1 38.1 30.9 23.8 16.7
Total
Capacity
(MBh)
251933-YTG-J-1009
Total
1
Input
2
(kW)
Sensible Capacity (MBh)
Return Dry Bulb (°F) Return Dry Bulb (°F)
90 85 80 75 70 65 90 85 80 75 70 65
75°F 85°F
95°F 105°F
Temperature of Air on Condenser Coil
Total
Capacity
(MBh)
Total
1
Input
(kW)
Sensible Capacity (MBh)
2
Johnson Controls Unitary Products 39
251933-YTG-J-1009
XP048 (4.0 Ton) (Continued)
Air on
Evaporator Coil
CFM
1000
1200
1400
1600
1800
2000
WB
(°F)
77 42.1 4.3 15.8 13.7 10.1 - - - 38.5 4.7 14.4 13.1 9.6 - - 72 38.9 4.3 23.8 20.2 16.6 13.0 - - 35.6 4.7 22.7 19.2 15.7 12.2 - 67 35.7 4.4 31.7 26.6 23.0 19.4 15.8 - 32.7 4.7 31.1 25.3 21.8 18.3 14.8 62 31.9 4.3 31.9 31.9 26.4 22.8 19.2 15.6 29.6 4.7 29.6 29.6 25.1 21.6 18.0 14.5
77 43.8 4.4 20.1 15.7 11.3 - - - 39.6 4.7 19.1 14.8 10.5 - - 72 40.5 4.4 27.3 22.9 18.5 14.1 - - 36.6 4.8 25.8 21.6 17.3 13.0 - 67 37.1 4.4 34.5 30.1 25.7 21.3 17.0 - 33.7 4.8 32.6 28.3 24.0 19.8 15.5 62 33.2 4.4 33.2 33.2 29.5 25.1 20.8 16.4 30.5 4.8 30.5 30.5 27.6 23.3 19.1 14.8
57 33.3 4.4 33.3 33.3 29.6 25.2 20.8 16.5 31.0 4.8 31.0 31.0 27.7 23.5 19.2 14.9
77 45.5 4.4 24.3 17.7 12.5 - - - 40.7 4.8 23.8 16.5 11.5 - - 72 42.0 4.4 30.8 25.6 20.5 15.3 - - 37.7 4.8 29.0 23.9 18.9 13.8 - 67 38.5 4.4 37.2 33.6 28.5 23.3 18.1 - 34.6 4.9 34.1 31.3 26.3 21.2 16.2 62 34.5 4.4 34.5 34.5 32.6 27.5 22.3 17.2 31.4 4.9 31.4 31.4 30.2 25.1 20.1 15.1
57 34.6 4.4 34.6 34.6 32.7 27.6 22.4 17.3 32.0 4.8 32.0 32.0 30.3 25.3 20.2 15.2
77 47.2 4.4 28.6 19.6 13.7 - - - 41.9 4.9 28.5 18.3 12.5 - - 72 43.6 4.4 34.3 28.4 22.4 16.5 - - 38.7 4.9 32.1 26.3 20.5 14.7 - 67 40.0 4.5 40.0 37.1 31.2 25.2 19.3 - 35.6 4.9 35.6 34.3 28.5 22.7 16.9 62 35.8 4.5 35.8 35.8 35.8 29.8 23.9 18.0 32.3 4.9 32.3 32.3 32.3 26.9 21.1 15.3
57 35.8 4.4 35.8 35.8 35.8 29.9 24.0 18.1 32.9 4.9 32.9 32.9 32.9 27.1 21.3 15.5
72 43.2 4.4 36.0 29.3 22.7 16.0 - - 38.4 4.9 33.8 27.2 20.5 13.8 - 67 39.6 4.5 39.6 38.2 31.5 24.9 18.2 - 35.3 4.9 35.3 35.2 28.5 21.8 15.1 62 35.5 4.5 35.5 35.5 35.5 28.8 22.2 15.5 32.1 4.9 32.1 32.1 32.1 25.6 18.9 12.2
57 35.5 4.4 35.5 35.5 35.5 28.9 22.3 15.6 32.6 4.9 32.6 32.6 32.6 25.9 19.2 12.6
72 42.8 4.4 37.7 30.3 22.9 15.6 - - 38.2 4.9 35.6 28.0 20.4 12.9 - 67 39.3 4.5 39.3 39.2 31.9 24.5 17.1 - 35.1 4.9 35.1 35.1 28.4 20.9 13.3 62 35.1 4.4 35.1 35.1 35.1 27.8 20.4 13.0 31.8 4.9 31.8 31.8 31.8 24.2 16.7 9.1
57 35.2 4.4 35.2 35.2 35.2 27.9 20.5 13.1 32.4 4.9 32.4 32.4 32.4 24.8 17.2 9.6
Total
Capacity
(MBh)
Total
1
Input
2
(kW)
Sensible Capacity (MBh)
Return Dry Bulb (°F) Return Dry Bulb (°F)
90 85 80 75 70 65 90 85 80 75 70 65
115°F 125°F
1. These capacities are gross ratings. For net capacity, deduct air blower motor, MBh = 3.415 x kW. Refer to the appropriate Blower
Performance Table for the kW of the supply air blower motor.
2. These ratings include the condenser fan motors (total 1 kW) and the compressor motors but not the supply air blower motor.
Temperature of Air on Condenser Coil
Total
Capacity
(MBh)
Total
1
Input
(kW)
Sensible Capacity (MBh)
2
40 Johnson Controls Unitary Products
XP060 (5.0 Ton)
Air on
Evaporator Coil
CFM
1250
1500
1750
2000
2250
2500
1250
1500
1750
2000
2250
2500
WB
(°F)
77 69.7 3.8 25.8 21.7 17.7 - - - 67.7 4.3 26.6 21.9 17.2 - - 72 64.2 3.7 34.2 30.1 26.0 22.0 - - 62.6 4.3 35.2 30.6 25.9 21.2 - 67 58.7 3.7 42.6 38.5 34.4 30.3 26.3 - 57.5 4.2 43.9 39.2 34.5 29.9 25.2 62 52.8 3.6 52.8 47.5 41.2 37.1 33.1 29.0 52.0 4.2 52.0 49.4 42.1 37.4 32.7 28.0
77 74.1 3.8 30.6 25.3 20.0 - - - 70.7 4.3 30.5 24.9 19.2 - - 72 68.3 3.8 40.1 34.8 29.5 24.2 - - 65.4 4.3 40.2 34.5 28.8 23.1 - 67 62.4 3.7 49.6 44.3 39.0 33.7 28.4 - 60.1 4.2 49.9 44.2 38.5 32.8 27.1 62 56.2 3.7 56.2 52.6 46.8 41.5 36.2 30.9 54.4 4.2 54.4 52.6 46.9 41.2 35.5 29.9
57 54.6 3.7 54.6 54.6 49.3 44.0 38.7 33.4 53.5 4.2 53.5 53.5 48.1 42.4 36.7 31.0
77 78.6 3.9 35.4 28.9 22.3 - - - 73.8 4.4 34.5 27.8 21.1 - - 72 72.3 3.8 46.0 39.5 33.0 26.5 - - 68.2 4.3 45.2 38.5 31.8 25.1 - 67 66.1 3.7 56.7 50.1 43.6 37.1 30.6 - 62.7 4.2 55.9 49.2 42.5 35.8 29.1 62 59.6 3.7 59.6 57.8 52.3 45.8 39.3 32.7 56.8 4.2 56.8 55.9 51.8 45.1 38.4 31.7
57 57.9 3.7 57.9 57.9 55.1 48.6 42.1 35.5 55.8 4.2 55.8 55.8 53.0 46.3 39.6 32.9
77 83.0 3.9 40.2 32.4 24.7 - - - 76.9 4.4 38.5 30.8 23.1 - - 72 76.4 3.8 51.9 44.2 36.4 28.7 - - 71.1 4.3 50.2 42.5 34.8 27.1 - 67 69.9 3.7 63.7 56.0 48.2 40.5 32.7 - 65.3 4.2 61.8 54.1 46.4 38.7 31.0 62 62.9 3.7 62.9 62.9 57.8 50.1 42.4 34.6 59.1 4.2 59.1 59.1 56.6 48.9 41.2 33.5
57 61.2 3.7 61.2 61.2 60.9 53.2 45.4 37.7 58.1 4.2 58.1 58.1 58.0 50.3 42.5 34.8
72 77.0 3.8 54.6 46.4 38.3 30.2 - - 71.7 4.3 52.8 44.7 36.6 28.5 - 67 70.4 3.8 67.3 58.8 50.7 42.5 34.4 - 65.9 4.3 64.1 57.0 48.9 40.8 32.7 62 63.4 3.7 63.4 63.4 60.9 52.7 44.6 36.4 59.6 4.2 59.6 59.6 58.4 50.3 42.1 34.0
57 61.7 3.7 61.7 61.7 61.5 53.4 45.2 37.1 58.6 4.2 58.6 58.6 58.5 50.4 42.3 34.2
72 77.6 3.8 57.2 48.7 40.2 31.6 - - 72.3 4.3 55.5 47.0 38.5 30.0 - 67 70.9 3.8 70.9 61.7 53.1 44.6 36.0 - 66.4 4.3 66.4 59.9 51.4 42.9 34.4 62 63.9 3.7 63.9 63.9 63.9 55.3 46.8 38.2 60.1 4.2 60.1 60.1 60.1 51.6 43.1 34.6
57 62.1 3.7 62.1 62.1 62.1 53.6 45.0 36.5 59.1 4.2 59.1 59.1 59.1 50.6 42.1 33.6
77 65.6 4.8 27.3 22.0 16.7 - - - 61.6 5.4 25.0 20.8 15.6 - - 72 60.9 4.8 36.3 31.0 25.7 20.4 - - 56.8 5.4 34.5 29.3 24.2 19.0 - 67 56.3 4.7 45.3 40.0 34.7 29.4 24.1 - 52.0 5.3 44.1 37.9 32.7 27.6 22.4 62 51.3 4.7 51.3 51.3 43.0 37.7 32.4 27.1 48.0 5.3 48.0 48.0 39.8 34.6 29.5 24.3
77 67.3 4.8 30.5 24.4 18.3 - - - 63.1 5.4 29.1 23.1 17.1 - - 72 62.5 4.8 40.3 34.3 28.2 22.1 - - 58.2 5.4 38.5 32.5 26.6 20.6 - 67 57.7 4.7 50.2 44.1 38.0 31.9 25.8 - 53.3 5.3 47.9 41.9 36.0 30.0 24.0 62 52.6 4.7 52.6 52.6 47.1 41.0 34.9 28.8 49.2 5.3 49.2 49.2 43.7 37.8 31.8 25.8
57 52.4 4.7 52.4 52.4 46.8 40.8 34.7 28.6 49.1 5.3 49.1 49.1 43.6 37.7 31.7 25.8
77 69.0 4.9 33.7 26.8 19.9 - - - 64.7 5.4 33.2 25.4 18.7 - - 72 64.1 4.8 44.4 37.5 30.6 23.7 - - 59.6 5.4 42.5 35.7 28.9 22.2 - 67 59.2 4.7 55.1 48.2 41.3 34.4 27.5 - 54.6 5.3 51.7 46.0 39.2 32.5 25.7 62 54.0 4.7 54.0 54.0 51.2 44.3 37.4 30.6 50.4 5.3 50.4 50.4 47.7 40.9 34.1 27.4
57 53.7 4.7 53.7 53.7 50.9 44.1 37.2 30.3 50.3 5.3 50.3 50.3 47.6 40.8 34.1 27.3
77 70.8 4.9 36.9 29.2 21.5 - - - 66.2 5.5 37.3 27.8 20.2 - - 72 65.8 4.8 48.4 40.8 33.1 25.4 - - 61.1 5.4 46.4 38.9 31.3 23.8 - 67 60.7 4.7 60.0 52.3 44.6 37.0 29.3 - 55.9 5.3 55.5 50.0 42.4 34.9 27.3 62 55.3 4.7 55.3 55.3 55.3 47.6 40.0 32.3 51.6 5.3 51.6 51.6 51.6 44.0 36.5 29.0
57 55.1 4.7 55.1 55.1 55.0 47.3 39.7 32.0 51.5 5.3 51.5 51.5 51.5 43.9 36.4 28.9
72 66.4 4.8 51.1 43.0 35.0 26.9 - - 61.7 5.4 49.6 41.5 33.4 25.3 - 67 61.3 4.7 60.9 55.2 47.2 39.1 31.0 - 56.5 5.3 56.3 52.6 45.3 37.2 29.1 62 55.9 4.7 55.9 55.9 55.9 47.8 39.7 31.6 52.1 5.3 52.1 52.1 52.1 44.1 36.0 27.9
57 55.6 4.7 55.6 55.6 55.6 47.5 39.4 31.4 52.1 5.3 52.1 52.1 52.1 44.0 35.9 27.8
72 67.0 4.8 53.8 45.3 36.8 28.4 - - 62.4 5.4 52.7 44.1 35.5 26.9 - 67 61.9 4.7 61.9 58.2 49.7 41.2 32.7 - 57.1 5.3 57.1 55.3 48.1 39.5 30.9 62 56.4 4.7 56.4 56.4 56.4 47.9 39.4 31.0 52.7 5.3 52.7 52.7 52.7 44.1 35.5 26.9
57 56.1 4.7 56.1 56.1 56.1 47.7 39.2 30.7 52.6 5.3 52.6 52.6 52.6 44.0 35.4 26.8
Total
Capacity
(MBh)
251933-YTG-J-1009
Total
1
Input
2
(kW)
Sensible Capacity (MBh)
Return Dry Bulb (°F) Return Dry Bulb (°F)
90 85 80 75 70 65 90 85 80 75 70 65
75°F 85°F
95°F 105°F
Temperature of Air on Condenser Coil
Total
1
Capacity
(MBh)
Total
Input
(kW)
Sensible Capacity (MBh)
2
Johnson Controls Unitary Products 41
251933-YTG-J-1009
XP060 (5.0 Ton) (Continued)
Air on
Evaporator Coil
CFM
1250
1500
1750
2000
2250
2500
WB
(°F)
77 57.6 6.0 22.6 19.5 14.5 - - - 53.6 6.6 20.0 18.3 13.4 - - 72 52.7 5.9 32.7 27.7 22.6 17.6 - - 48.5 6.5 31.0 26.0 21.1 16.2 - 67 47.7 5.9 42.9 35.8 30.8 25.7 20.7 - 43.5 6.5 41.7 33.8 28.8 23.9 19.0 62 44.7 5.9 44.7 44.7 36.6 31.6 26.5 21.5 41.4 6.4 41.4 41.4 33.4 28.5 23.6 18.7
77 59.0 6.0 27.6 21.8 16.0 - - - 54.8 6.6 26.2 20.5 14.8 - - 72 53.9 6.0 36.6 30.8 25.0 19.1 - - 49.6 6.5 34.8 29.1 23.4 17.7 - 67 48.8 5.9 45.6 39.8 33.9 28.1 22.3 - 44.4 6.5 43.3 37.6 31.9 26.2 20.5 62 45.8 5.9 45.8 45.8 40.4 34.5 28.7 22.9 42.3 6.5 42.3 42.3 37.0 31.3 25.6 19.9
57 45.8 5.9 45.8 45.8 40.4 34.6 28.8 22.9 42.6 6.4 42.6 42.6 37.2 31.5 25.8 20.1
77 60.3 6.0 32.7 24.1 17.5 - - - 56.0 6.6 32.4 22.7 16.2 - - 72 55.1 6.0 40.5 33.9 27.3 20.7 - - 50.6 6.6 38.6 32.1 25.6 19.1 - 67 50.0 5.9 48.3 43.7 37.1 30.5 23.8 - 45.3 6.5 45.0 41.5 35.0 28.5 22.0 62 46.8 5.9 46.8 46.8 44.1 37.5 30.9 24.2 43.2 6.5 43.2 43.2 40.5 34.1 27.6 21.1
57 46.9 5.9 46.9 46.9 44.2 37.6 30.9 24.3 43.5 6.5 43.5 43.5 40.8 34.3 27.8 21.3
77 61.7 6.0 37.8 26.4 18.9 - - - 57.1 6.6 38.6 24.9 17.7 - - 72 56.4 6.0 44.4 37.0 29.6 22.2 - - 51.7 6.6 42.4 35.1 27.9 20.6 - 67 51.1 5.9 51.1 47.7 40.2 32.8 25.4 - 46.2 6.5 46.2 45.3 38.1 30.8 23.5 62 47.8 5.9 47.8 47.8 47.8 40.4 33.0 25.6 44.1 6.5 44.1 44.1 44.1 36.8 29.6 22.3
57 47.9 5.9 47.9 47.9 47.9 40.5 33.1 25.7 44.4 6.5 44.4 44.4 44.4 37.1 29.8 22.6
72 57.1 6.0 48.1 40.0 31.9 23.8 - - 52.4 6.6 46.5 38.5 30.4 22.3 - 67 51.7 5.9 51.7 50.0 43.4 35.3 27.2 - 46.9 6.5 46.9 46.9 41.5 33.4 25.3 62 48.4 5.9 48.4 48.4 48.4 40.4 32.3 24.2 44.7 6.5 44.7 44.7 44.7 36.6 28.6 20.5
57 48.5 5.9 48.5 48.5 48.5 40.5 32.4 24.3 45.0 6.5 45.0 45.0 45.0 36.9 28.8 20.8
72 57.7 6.0 51.7 43.0 34.2 25.5 - - 53.1 6.6 50.6 41.8 32.9 24.0 - 67 52.3 5.9 52.3 52.3 46.5 37.8 29.0 - 47.5 6.5 47.5 47.5 44.9 36.0 27.2 62 49.0 5.9 49.0 49.0 49.0 40.3 31.5 22.8 45.3 6.5 45.3 45.3 45.3 36.4 27.6 18.7
57 49.1 5.9 49.1 49.1 49.1 40.4 31.6 22.9 45.6 6.5 45.6 45.6 45.6 36.7 27.8 19.0
Total
Capacity
(MBh)
Total
1
Input
2
(kW)
Sensible Capacity (MBh)
Return Dry Bulb (°F) Return Dry Bulb (°F)
90 85 80 75 70 65 90 85 80 75 70 65
115°F 125°F
1. These capacities are gross ratings. For net capacity, deduct air blower motor, MBh = 3.415 x kW. Refer to the appropriate Blower
Performance Table for the kW of the supply air blower motor.
2. These ratings include the condenser fan motors (total 1 kW) and the compressor motors but not the supply air blower motor.
Temperature of Air on Condenser Coil
Total
1
Capacity
(MBh)
Total
Input
(kW)
Sensible Capacity (MBh)
2
42 Johnson Controls Unitary Products
XP036-060 Heating Capacities
251933-YTG-J-1009
Size
(Tons)
036
(3.0)
048
(4.0)
060
(5.0)
Model
XP
XP
XP
Air Over Evaporator
Coil
Capacity
CFM DB (°F) -10 0 10 20 30 40 50 60
55
900
1200
1500
1200
1600
2000
1500
2000
2500
70
80
55
70
80
55
70
80
55
70
80
55
70
80
55
70
80
55
70
80
55
70
80
55
70
80
1
&
Outdoor Temperature (°F @ 72% RH)
kW
MBH 8.8 13.0 17.3 21.5 25.7 29.9 34.1 38.3
KW 1.61.61.71.71.81.91.92.0
MBH 5.5 9.8 14.0 18.2 22.4 26.6 30.8 35.0
KW 1.92.02.12.12.22.22.32.4
MBH 5.1 9.3 13.5 17.7 21.9 26.2 30.4 34.6
KW 2.22.22.32.42.42.52.62.6
MBH 10.3 14.5 18.7 22.9 27.1 31.3 35.5 39.8
KW 1.21.31.41.41.51.61.61.7
MBH 7.0 11.2 15.4 19.6 23.8 28.0 32.2 36.4
KW 1.61.71.71.81.91.92.02.1
MBH 6.5 10.8 15.0 19.2 23.4 27.6 31.8 36.0
KW 1.81.92.02.02.12.22.22.3
MBH 9.5 13.7 17.9 22.1 26.3 30.5 34.8 39.0
KW 0.50.60.70.70.80.90.91.0
MBH 6.2 10.4 14.6 18.8 23.0 27.3 31.5 35.7
KW 0.91.01.01.11.21.21.31.4
MBH 5.8 10.0 14.2 18.4 22.6 26.8 31.0 35.2
KW 1.21.21.31.41.41.51.51.6
MBH 11.8 17.1 22.5 27.9 33.3 38.6 44.0 49.4
KW 2.72.72.82.82.92.93.03.0
MBH 9.1 14.5 19.9 25.2 30.6 36.0 41.3 46.7
KW 3.23.23.33.33.43.43.53.5
MBH 8.6 14.0 19.4 24.7 30.1 35.5 40.8 46.2
KW 3.73.73.83.83.93.94.04.0
MBH 13.5 18.9 24.2 29.6 35.0 40.3 45.7 51.1
KW 2.32.32.42.42.52.52.62.6
MBH 10.8 16.2 21.6 26.9 32.3 37.7 43.0 48.4
KW 2.82.82.92.92.93.03.03.1
MBH 10.3 15.7 21.1 26.4 31.8 37.2 42.6 47.9
KW 3.33.33.43.43.53.53.63.6
MBH 12.1 17.5 22.9 28.3 33.6 39.0 44.4 49.7
KW 1.51.61.61.61.71.71.81.8
MBH 9.5 14.9 20.2 25.6 31.0 36.3 41.7 47.1
KW 2.02.02.12.12.22.22.32.3
MBH 9.0 14.4 19.7 25.1 30.5 35.8 41.2 46.6
KW 2.52.62.62.72.72.72.82.8
MBH 18.1 24.6 31.1 37.7 44.2 50.8 57.3 63.8
KW 3.53.63.73.94.04.14.24.4
MBH 17.5 24.0 30.6 37.1 43.6 50.2 56.7 63.3
KW 4.44.54.64.84.95.05.15.3
MBH 17.5 24.0 30.5 37.1 43.6 50.2 56.7 63.2
KW 4.95.05.25.35.45.55.75.8
MBH 20.8 27.4 33.9 40.4 47.0 53.5 60.0 66.6
KW 3.73.83.94.04.24.34.44.6
MBH 20.2 26.8 33.3 39.9 46.4 52.9 59.5 66.0
KW 4.64.74.84.95.15.25.35.5
MBH 20.2 26.8 33.3 39.8 46.4 52.9 59.4 66.0
KW 5.15.25.35.55.65.75.96.0
MBH 23.1 29.6 36.2 42.7 49.2 55.8 62.3 68.9
KW 3.94.04.14.34.44.54.64.8
MBH 22.5 29.1 35.6 42.1 48.7 55.2 61.7 68.3
KW 4.84.95.05.25.35.45.55.7
MBH 22.5 29.0 35.6 42.1 48.6 55.2 61.7 68.3
KW 5.35.45.55.75.85.96.16.2
1. These capacities do not include the supply air blower motor heat. For net capacity, add motor heat,
MBh = 3.415 x kW.
Johnson Controls Unitary Products 43
ZR036 - 060 (3-5 Ton Direct Drive) Bottom Duct
WATTS
2
CFM
WATTS
CFM
AVAILABLE EXTERNAL STATIC PRESSURE - IWG
0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1.0
UNIT
TONNAGE
3
3
3
4
3
5
1
MOTOR
SPEED
CFM
HI 1520 320 1478 335 1438 349 1401 363 1363 376 1327 390 1286 403 1248 417 1207 430
MED/HI 1430 263 1384 276 1342 290 1302 303 1259 316 1215 329 1168 343 1114 358 1044 374
MED 1287 208 1242 221 1199 234 1155 246 1108 258 1060 272 997 288 930 303 889 313
MED/LOW 1185 171 1138 183 1091 195 1041 207 987 220 921 235 862 248 - - - -
LOW 1040 130 959 134 900 145 - - - - - - - - - - - -
HI - - 1995 696 1957 714 1922 734 1885 749 1844 764 1795 769 1709 743 1566 685
MED/HI 1846 539 1812 557 1776 571 1736 585 1704 602 1662 619 1619 638 1566 653 1492 639
MED 1662 408 1624 426 1577 438 1542 455 1501 472 1454 490 1400 505 1356 521 1323 536
MED/LOW 1566 362 1526 380 1480 391 1450 406 1411 423 1363 440 1312 455 1279 469 1235 485
LOW 1287 223 1246 237 1190 247 - - - - - - - - - - - -
HI 2166 883 2169 931 2158 950 2134 964 2095 979 2040 971 1963 940 1881 898 1791 854
MED/HI 2060 771 2042 784 2035 808 2006 826 1970 844 1934 859 1888 861 1821 843 1730 806
MED 1940 637 1920 656 1907 675 1870 696 1834 715 1802 730 1759 740 1722 756 1657 748
MED/LOW 1688 413 1645 432 1611 451 1575 468 1534 479 1498 497 1461 513 - - - -
LOW 1509 327 1477 339 - - - - - - - - - - - - - -
WATTS
CFM
WATTS
CFM
WATTS
CFM
WATTS
CFM
WATTS
CFM
1. Factory set on medium speed tap.
2. Includes allowances for a wet evaporator coil, 1” filters, and the heat exchangers. Refer to STATIC RESISTANCES Table for
resistance values.
3. Bottom Duct application (230 Volts)
251933-YTG-J-1009
CFM
WATTS
WATTS
XP036-060 Side Duct Application
XP036 (3 Ton Belt Drive) Side Duct
Air Flow
(CFM)
800 678 0.37 761 0.44 840 0.52 917 0.60 991 0.69 1062 0.77 1130 0.87 1195 0.96 1259 1.06 1320 1.17
1000 699 0.42 782 0.49 862 0.56 939 0.64 1012 0.73 1083 0.82 1151 0.91 1217 1.01 1280 1.11 1341 1.21
1200 727 0.45 810 0.52 889 0.60 966 0.68 1040 0.76 1110 0.85 1179 0.95 1244 1.04 1308 1.14 1369 1.24
1400 759 0.51 842 0.58 922 0.65 998 0.73 1072 0.82 1143 0.91 1211 1.00 1276 1.10 1340 1.20 1401 1.30
1600 795 0.60 878 0.67 958 0.74 1035 0.82 1108 0.91 1179 1.00 1247 1.09 1313 1.19 1376 1.28 1438 1.39
0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0
RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP
Field Supplied Drive Standard Drive Option HIgh Static Drive Option
Available External Static Pressure - IWG
1. Blower performance includes 1” filters. See STATIC RESISTANCE table for additional applications.
2. See RPM SELECTION table to determine desired motor sheave setting and to determine the maximum continuous BHP.
3. kW = BHP x 0.932.
4. Field Supplied Drive.
XP048 (4 Ton Belt Drive) Side Duct
Air Flow
(CFM)
1000 699 0.42 782 0.49 862 0.56 939 0.64 1012 0.73 1083 0.82 1151 0.91 1217 1.01 1280 1.11 1341 1.21
1200 727 0.45 810 0.52 889 0.60 966 0.68 1040 0.76 1110 0.85 1179 0.95 1244 1.04 1308 1.14 1369 1.24
1400 759 0.51 842 0.58 922 0.65 998 0.73 1072 0.82 1143 0.91 1211 1.00 1276 1.10 1340 1.20 1401 1.30
1600 795 0.60 878 0.67 958 0.74 1035 0.82 1108 0.91 1179 1.00 1247 1.09 1313 1.19 1376 1.28 1438 1.39
1800 836 0.72 919 0.79 999 0.87 1075 0.95 1149 1.03 1220 1.12 1288 1.22 1353 1.31 1417 1.41 1478 1.51
2000 880 0.89 963 0.96 1042 1.04 1119 1.12 1193 1.20 1263 1.29 1331 1.39 1397 1.48 1460 1.58 1522 1.68
0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0
RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP
Field Supplied Drive Standard Drive Option HIgh Static Drive Option
Available External Static Pressure - IWG
1
1
FS
4
1. Blower performance includes 1” filters. See STATIC RESISTANCE table for additional applications.
2. See RPM SELECTION table to determine desired motor sheave setting and to determine the maximum continuous BHP.
3. kW = BHP x 0.932.
Johnson Controls Unitary Products 49
Loading...