Wyott FT-1000-240, FT-1000H User Manual
R
INSTALLATION
AND
OPERATING
INSTRUCTIONS
Model: FT 1000H
TM
FASTRAC HORIZONTAL CONVEYOR TOASTER
UNIT MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES
INTENDED FOR OTHER THAN HOUSEHOLD USE
RETAIN THIS MANUAL FOR FUTURE REFERENCE
TABLE OF CONTENTS
Safety Precautions
Important Safety Instructions
General Information
Installation Instructions
Operation Instructions
Cleaning Instructions
Warranty Procedure
Troubleshooting
Replacement Parts List
Wiring Diagram
Warranty
WARNING: Improper installation, adjustment, alteration, service or maintenance can
cause property damage, injury or death. Read the Installation, Operating and
Maintenance Instructions thoroughly before installing or servicing this equipment.
This equipment has been engineered to provide you with year-round dependable service when used
according to the instructions in this manual and standard commercial kitchen practices.
Phone: +1 (214) 421-7366
Fax: +1 (214) 565-0976
Toll Free: +1 (800) 527-2100
Website: www.apwwyott.com
E-mail: info@apwwyott.com
APW WYOTT
729 Third Avenue
Dallas, TX 75226
2
3
4
4
5
5
6
6
8
10
11
!!
P/N 67193 9/06
1
Notes:
IMPORTANT FOR FUTURE REFERENCE
Please complete this information and retain this manual for the life of the equipment. For
Warranty Service and/or Parts, this information is required.
Model Number Serial Number Date Purchased
SAFETY PRECAUTIONS
Before installing and operating this equipment be sure everyone involved in its operation are fully trained
and are aware of all precautions. Accidents and problems can result by a failure to follow fundamental rules
and precautions.
The following words and symbols, found in this manual, alert you to hazards to the operator, service
personnel or the equipment. The words are defined as follows:
DANGER: This symbol warns of imminent hazard which will result in serious injury or death.
!
APW Wyott takes pride in the design and quality of our products. When used as intended and with proper
care and maintenance, you will experience years of reliable operation from this equipment. To ensure best
results, it is important that you read and follow the instructions in this manual carefully.
Installation and start-up should be performed by a qualified installer who thoroughly read, understands and
follows these instruction.
If you have questions concerning the installation, operation, maintenance or service of this product, contact
APW Wyott Foodservice Equipment Company’s “ Technical Service Department”.
WARNING: This symbol refers to a potential hazard or unsafe practice, which could result in
!
serious injury or death.
CAUTION: This symbol refers to a potential hazard or unsafe practice, which may result in minor or
moderate injury or product or property damage.
!
NOTICE: This symbol refers to information that needs special attention or must be fully understood
even though not dangerous.
!
!
!
!
!
2
1. IMPORTANT SAFETY INSTRUCTIONS
IMPORTANT: Read the following important safety instructions to avoid personal injury or
!
!
!
!
!
!
death, and to avoid damage to the equipment or property.
WARNING: Do not allow untrained personnel to operate the toaster.
NOTICE: Do not use toppings (butter, etc.) on product as product is inverted during normal
operation.
WARNING: To avoid any injury, turn the power switch off at the fuse disconnect switch/circuit
breaker or unplug the unit from the power source and allow to cool completely before performing
any maintenance or cleaning.
WARNING: Unit is not waterproof. DO NOT submerge in water. Do not operate if it has been
submerged in water. Do not clean the unit with a water jet.
WARNING: Operating toaster without legs invalidates any warranty claims.
!
!
!
!
!
!
WARNING: Neglecting to keep the fan opening clean could result in toaster failure.
!
!
!
!
!
!
!
!
!
!
!
WARNING: Operating the toaster without the Reflector Tray reduces the toasting capabilities.
WARNING: Neglecting to keep fan opening clean could result in toaster failure.
WARNING: APW Wyott toasters are designed, built, and sold for commercial use. If positioned
where the general public can usethem, make sure that all cautions, warnings, and operating
instructions are clearly posted near each unit to insureproper operation, reduce the chance of
personal injury and/or equipment damage.
WARNING: Plug unit into a properly grounded electrical outlet of the correct voltage, size and plug
configuration. If the plug and receptacle do not match, contact a qualified electrician to determine
the proper voltage and size and install the proper electrical outlet.
WARNING: To avoid electrical shock, always unplug the unit before performing cleaning or
maintenance.
WARNING: For safe and proper operation, the unit must be located a reasonable distance from
combustible walls and materials. If safe distances are not maintained, discoloration or combustion
could occur.
WARNING: To avoid electrical shock or personal injury, do not steam clean or use excessive water
on the unit.
WARNING: If service is required on this unit, contact your authorized APW Wyott Service Agent, or
contact the APW Wyott Service Department directly at (214) 421-7366 or (800) 527-2100; fax (214)
565-0976.
WARNING: This product has no “user” serviceable parts. To avoid damage to the unit or injury to
personnel, use only Authorized APW Wyott Service Agents and genuine APW Wyott Parts when
service is required..
CAUTION: Some exterior surfaces on the unit will get hot. Use caution when touching these areas
to avoid injury.
!
!
!
!
!
!
!
!
!
!
!
CAUTION: Use only non-abrasive cleaners. Abrasive cleaners could scratch the finish of your unit,
!
marring it’s appearance and making it susceptible to dirt accumulation.
WARNING: An earthing cable must connect the appliance to all other units in the complete
installation and from there to an independent earth connection.
!
WARNING: In Europe, appliance must be connected by an earthing cable to all other units
in the complete installation and thence to an independent earth connection in compliance
!
with EN 60335-1 and/or local codes
3
!
!
!
CAUTION: The National Sanitation Foundation (NSF) requires that units over 36” (91 cm) in length
or weighing more than 80 lbs. (36 kg) to be either sealed or raised on the installation surface. If this
!
unit cannot be sealed at the point of use, 4” (10 cm) legs are included to allow for proper cleaning
access below unit.
WARNING: Genuine APW Wyott Replacement Parts are specified to operate safely in the
environments in which they are used. Some aftermarket or generic replacement parts do not have
the characteristics that will allow them to operate safely in APW Wyott equipment. It is essential to
!
!
!
use APW Wyott Replacement Parts when repairing APW Wyott equipment. Failure to use APW
Wyott Replacement Parts may subject operators of the equipment to hazardous electrical voltage,
resulting in electrical shock or burn.
CAUTION: Locate the unit at the proper counter height, in an area that is convenient for use. The
location should be level to prevent the unit or it’s contents from accidentally falling, and strong
enough to support the weight of the unit and food.
WARNING: Failure to provide clearances will cause unit failure and invalidate warranty claims
(see installation instructions).
!
!
!
!
I. Consult the rating label for model and serial number. Write this information below before
proceeding:
A. Model # __________________ B. Serial # __________________
II. Overall Dimensions w/Wire Feeder - 16.1" H (409mm) x 16.2" W (411 mm) x 26.5" 0 (674mm)
III. Product Opening - 3.0" H (76mm) x 10.50" W (267mm)
IV. Productivity (per hour) - results will vary depending on line voltage and bread dryness.
V. Electrical Requirements
A. Single phase, 208-240 volts, 3330 watts, 15.9 amps.
B. Cordset configuration
1. Each toaster is equipped with a three-wire grounded cordset and standard three-prong
plug.
2. In the United States, a four foot cordset with NEMA 6-20P plug.
3. In Canada, a six foot cordset with NEMA 6-20P plug.
Net/Shipping Weight - 54Ib.(24.5kg) /62Ib.(28.2kg)
GENERAL INFORMATION
INSTALLATION INSTRUCTIONS
I. Check Contents - refer to Figure 1, account for the following parts:
A. Toast Drawer - shipped in place
B. Reflector Tray - shipped in place
C. Wire Feeder - inside Reflector Tray
D. Instruction Manual - shipped loose
NOTE: DO NOT OPERATE THE TOASTER WITH THE REFLECTOR TRAY REMOVED FROM
ITS POSITION
II. Position Wire Feeder - refer to Figure 2
A. Pull out Reflector Tray
B. Rotate Wire Feeder
C. Slide Reflector Tray back
D. WARNING: Operating the toaster without the Reflector Tray reduces toasting capabilities.
figure 2
4
Loading...