Winnebago adventurer (2003) Owner's Manual

TO THE OWNER

Congratulations! We welcome you to the exciting world of motor home travel and camping. You will find it convenient and enjoyable to have all the comforts of home and still enjoy the great outdoors wherever you choose to go.

Your motor home has been carefully designed, engineered and manufactured to provide dependability as well as safety. Before sliding into the driver’s seat, take a few minutes to become familiar with operations and features. This manual was prepared to aid you in the proper care and operation of the vehicle and equipment. We urge you to read it completely. In addition, spend some time with the dealer when you take delivery, you will want to learn all you can about your new motor home.

Your new motor home is covered by a factory warranty against defects in material and workmanship. This warranty should be validated at once and returned to the factory by your dealer.

Read and understand all instructions and precautions in this manual before operating your new motor home. Throughout this manual, certain items are labeled NOTE, CAUTION and WARNING. These terms alert you to precautions that can involve risk to your vehicle or to your personal safety. Read and follow them carefully.

About Safety Messages Used in This Manual

Throughout this manual, certain items are labeled Note, Caution, Warning or Danger. These terms alert you to precautions that may involved damage to your vehicle or a risk to your personal safety. Read and follow them carefully.

This SAFETY ALERT SYMBOL is used to draw your attention to issues which could involved potential personal injury. This symbol is used throughout this manual and/or on labels affixed on or near various equipment in this motor home.

DANGER

DANGER indicates a directly hazardous situation which, if not avoided, will result in death or serious personal injury.

WARNING

WARNING indicates a potentially hazardous situation which, if not avoided, could result in death or serious personal injury.

132000-06-003October 2002

CAUTION

CAUTION indicates a potentially hazardous situation which, if not avoided, could result in damage mainly to equipment or property, but in some cases may also result in minor or moderate personal injury.

NOTE: A ‘Note’ is not necessarily safety related but indicates a recommendation or special point of information that could assist in understanding the use or care of a feature item.

OWNER’S NAME

STREET ADDRESS

CITY AND STATE (OR PROVINCE IN CANADA)

MOTOR HOME SERIAL NUMBER

VEHICLE CHASSIS IDENTIFICATION NO. (VIN)

DATE OF DELIVERY TO FIRST RETAIL PURCHASER

VEHICLE MILEAGE AT TIME OF DELIVERY

SELLING DEALER NAME AND ADDRESS

TANK CAPACITIES

Chassis Fuel Tank

All models .........................................................................................................75 gal.

LP Gas Tank

All Models.................................................................................23 gal.* (28 gal. w.c.)

Fresh Water Tank

All Models ........................................................................................................80 gal.

Water Heater....................................................................................................10 gal.

Black Water Holding Tank

Model 31Y (Toilet & Lavatory) ........................................................................45 gal.

Model 33V (Toilet)............................................................................................50 gal.

Model 35V (Toilet)............................................................................................40 gal.

Model 37C (Toilet) ...........................................................................................50 gal.

Model 38G (Toilet & Lavatory) .......................................................................53 gal.

Grey Water Holding Tank

Model 31Y (Galley & Shower) .........................................................................41 gal.

Model 33V (Galley, Shower & Lavatory).........................................................45 gal.

Model 35U (Galley, Shower & Lavatory)........................................................ 54 gal.

Model 37C (Galley, Shower & Lavatory) .........................................................45 gal.

Model 38G (Galley & Shower) .........................................................................55 gal.

*LP Gas tank capacity shown is the usable “full” LP gas capacity, which is 80% of the tank manufacturer’s listed water capacity (w.c. shown in parenthesis). An LP tank must have at least 20% of tank volume free to allow for expansion and proper vaporization of the liquid fuel. The tank is also equipped with mandatory safety shut-off equipment that prevents filling above this level.

TABLE OF CONTENTS

INTRODUCTION

About This Manual ....................................... 0- 1

Chassis Operating Guide .............................. 0- 1

Owner’s InfoCase ........................................ 0- 1

Options and Equipment ................................ 0- 2

Before Driving .............................................. 0- 2

Service and Assistance.................................. 0- 2

Warranty ....................................................... 0- 2

Drinking and Driving.................................... 0- 2

Reporting Safety Defects .............................. 0- 2

Vehicle Certification Label........................... 0- 4

Exterior Feature Identification...................... 0- 5

SECTION 1: SAFETY PRECAUTIONS

General Warnings ......................................... 1- 1

Driving .......................................................... 1- 2

Fuel & LP Gas .............................................. 1- 2

LP Gas Leaks ................................................ 1- 3

LP Gas Alarm ............................................... 1- 3

Electrical ....................................................... 1- 4

Loading ......................................................... 1- 4

Maintenance.................................................. 1- 5

Formaldehyde Information ........................... 1- 5

Carbon Monoxide Warning .......................... 1- 5

Carbon Monoxide Alarm .............................. 1- 6

Emergency Exits ........................................... 1- 6

Fire Extinguisher........................................... 1- 7

Smoke Alarm ................................................ 1- 7

SECTION 2: DRIVING YOUR MOTOR HOME

Before Entering Your Vehicle ..................... 2- 1

Before Driving Your Vehicle ...................... 2- 1

Key One Lock System .................................. 2- 2

Fuel Selection ............................................... 2- 2

Parking Brakes.............................................. 2- 3

Hazard Warning Lights................................. 2- 3

Entrance Door Lock and Handle................... 2- 3

Electric Entrance Step................................... 2- 4

Seats .............................................................. 2- 5

Child Restraints............................................. 2- 7

Mirrors .......................................................... 2- 7

Sony Rearview Monitor System ................... 2- 8

Comfort Controls ........................................ 2- 12

Heating........................................................ 2- 12

Defrosting ................................................... 2- 12

Ventilation .................................................. 2- 13

Air Conditioning......................................... 2- 13

Rear Coach Heater ...................................... 2- 13

Compact Disc Changer ............................... 2- 14

CB Radio Wiring ........................................ 2- 15

Coach Leveling Systems............................. 2- 16

Slideout Living Room................................. 2- 17

SECTION 3: IN CASE OF DRIVING EMERGENCY

Hazard Warning Flasher ............................... 3- 1

Safety Precautions......................................... 3- 2

Front Wheel .................................................. 3- 2

Dual Rear Wheels ......................................... 3- 3

Wheel Nuts ................................................... 3- 3

Recovery Towing.......................................... 3- 3

Jump Starting ................................................ 3- 4

Connecting Jumper Cables ........................... 3- 4

Connecting A Battery Charger ..................... 3- 5

Engine Overheat ........................................... 3- 5

SECTION 4: TRAVELING WITH YOUR MOTOR HOME

Loading the Vehicle...................................... 4- 1

Front Axle Tire Alignment ........................... 4- 1

Weighing Your Vehicle ................................ 4- 1

Maximum Occupancy................................... 4- 2

Roof Loading ................................................ 4- 2

Car or Trailer Towing ................................... 4- 2

Pre-Travel Checklist ..................................... 4- 3

Travel Tips.................................................... 4- 4

Severe Weather Information ......................... 4- 4

Nighttime Driving......................................... 4- 5

Mountain Driving ......................................... 4- 6

Campsite Selection ....................................... 4- 6

Leveling ........................................................ 4- 6

Blocking........................................................ 4- 6

Effects of Prolonged Occupancy .................. 4- 7

Humidity and Condensation ......................... 4- 7

SECTION 5: LP GAS SYSTEM

LP Gas Supply .............................................. 5- 1

Safe Use of the LP Gas System .................... 5- 1

TABLE OF CONTENTS

How LP Gas Works ...................................... 5- 1

Selecting LP Fuel Types ............................... 5- 2

LP Gas Output .............................................. 5- 2

LP Tank System............................................ 5- 2

LP Tank Capacity ......................................... 5- 2

Refilling LP Tank ......................................... 5- 3

Air in the LP Gas Tank ................................. 5- 3

Travel with LP Gas ....................................... 5- 3

Regulator....................................................... 5- 4

LP Gas Leaks ................................................ 5- 4

Winter use of LP Gas.................................... 5- 5

SECTION 6: ELECTRICAL SYSTEMS

110-Volt AC System..................................... 6- 1

External Power Cord..................................... 6- 1

Powerline Energy Management System

(EMS)........................................................ 6- 2

Power Converter System .............................. 6- 3

110-Volt Receptacles .................................... 6- 4

Ground Fault Circuit Interrupter................... 6- 4

Auxiliary 110-Volt Generator....................... 6- 5

12-Volt DC System....................................... 6- 7

12-Volt House Fuses..................................... 6- 7

Solar Charger Panel ...................................... 6- 8

Battery Access .............................................. 6- 8

Battery Maintenance ..................................... 6- 9

Trailer Wiring Connector............................ 6- 10

SECTION 7: PLUMBING SYSTEMS

Fresh Water System ...................................... 7- 1

Water Pump Switch ...................................... 7- 2

External Water Supply.................................. 7- 3

Water Purifier System................................... 7- 4

Shower Hose Vacuum Breaker..................... 7- 4

Exterior Shower ............................................ 7- 5

Waste Water System ..................................... 7- 5

Dumping Holding Tanks .............................. 7- 5

Holding Tank Capacities .............................. 7- 7

Water System Winterization Valve .............. 7- 7

Water Drain Valves....................................... 7- 8

Water System Drain Valve Locations......... 7- 10

SECTION 8: APPLIANCES AND INTERIOR FEATURES

Refrigerator................................................... 8- 1

Range and Oven............................................ 8- 6

Microwave Oven........................................... 8- 7

Range Hood .................................................. 8- 7

One Place Monitor Panel .............................. 8- 8

LP Gas Level ................................................ 8- 8

Water Pump Switch ...................................... 8- 8

Battery Voltage Meter .................................. 8- 9

Gas/Electric Water Heater ............................ 8- 9

Motor Aid ................................................... 8- 12

LP Gas Furnace........................................... 8- 12

Electronic Thermostat................................. 8- 13

Heat Pump................................................... 8- 14

Central Air Conditioning System ............... 8- 15

TV Antenna................................................. 8- 16

Antenna Check Light .................................. 8- 16

Signal Amplifier ......................................... 8- 17

Phone and Cable TV Hook-Ups ................. 8- 17

Video Selector System................................ 8- 17

Satellite Television System......................... 8- 18

DC-AC Electrical Voltage Inverter ............ 8- 19

Exterior Entertainment Center .................... 8- 19

Sleeping Facilities....................................... 8- 19

Couch Bed Conversion ............................... 8- 19

Dinette/Bed Conversion.............................. 8- 19

Rest Easy Multi-Position Lounge............... 8- 20

Swivel Glider Lounge Chair ....................... 8- 22

Fresh Water Toilet ...................................... 8- 22

Power Roof Vent ........................................ 8- 23

Crank-Out Side Windows........................... 8- 23

Slider Windows........................................... 8- 24

Day/Nighter Pleated Window Shades......... 8- 24

Quartz Wall Clock ...................................... 8- 24

SECTION 9: CARE AND MAINTENANCE

Roof .............................................................. 9- 1

Underbody .................................................... 9- 1

Exterior ......................................................... 9- 1

Care of Stripes and Decals............................ 9- 2

Compartment Doors...................................... 9- 3

Upholstery, Carpeting and Draperies............ 9- 3

Cabinetry....................................................... 9- 5

Vinyl Wallboard ........................................... 9- 6

Tables and Countertops ................................ 9- 6

Stainless Steel Sink....................................... 9- 7

Bathroom ...................................................... 9- 7

Doors and Windows...................................... 9- 7

Chassis Service & Maintenance ................... 9- 7

Hood.............................................................. 9- 8

Engine Cover ................................................ 9- 8

Engine Cooling Systems............................... 9- 9

Tires .............................................................. 9- 9

Front Air Springs .......................................... 9- 9

Suspension Alignment and Tire Balance...... 9- 9

Windshield Washers and Wipers ................ 9- 10

Lights .......................................................... 9- 10

Automotive 12-Volt Fuses and Circuit

Breakers .................................................. 9- 10

SECTION 10: STORING YOUR MOTOR HOME

Preparing Vehicle for Storage..................... 10- 1

Cold Weather Storage Procedure................ 10- 1

Removal from Storage ................................ 10- 5

TABLE OF CONTENTS

INTRODUCTION

Congratulations on the purchase of your new Adventurer motor home, which has been carefully designed, engineered and quality built by Winnebago Industries, Inc.

ABOUT THIS MANUAL

Please read this operator’s manual completely to understand how everything in your coach works before taking it on its “maiden voyage.”

This manual is a guide to safe operation of the features, equipment and controls in this coach. Some equipment, such as the vehicle chassis and certain electronic systems or appliances, have their own comprehensive, manufacturer supplied manuals or information sheets which describe operation of these products in great detail. This manual will refer you to the manufacturer’s information included in your Owner I whenever necessary.

SUBJECT ICONS - To make it easier for you to find information you’re looking for, we have placed convenient, pictorial symbols called “icons” beside many of the subject headings in this manual. The icons correspond to the subject matter of the section. These icons were designed similar to the familiar international symbols which identify public facilities such as restrooms and handicap access. There are several examples of icons on this page.

PAGE ICONS - The icons at the upper corners of each page correspond to the primary content of each main section of the manual, such as LP Gas, Electrical, Plumbing, etc. This means you can flip through the manual either forward or backward and know exactly which main section you are looking for just by watching the icons at the top of the page. This means less paging back and forth.

We also urge you to read the complete Chassis Operating Guide provided by the chassis maker and all other operating information provided by our equipment suppliers and manufacturers. This is contained in your

Owner I

NFOCASE.

NFOCASE

This manual should be kept in the vehicle at

all times for personal reference. The operator’s manual, I are to be considered permanent components of this vehicle. They should remain in the vehicle when sold to provide the next owner with important safety, operating and maintenance information.

NOTE: The descriptions, illustrations, and spec-

NFOCASE and chassis operating guide

ifications in this manual were correct at the time of printing. We reserve the right to change specifications or design without notice, and without incurring obligation to install the same on products previously manufactured.

CHASSIS OPERATING GUIDE

Throughout this manual, frequent reference is made to the vehicle chassis operating guide. The chassis guide is the operator’s manual provided by the manufacturer of the chassis on which this motor home is built (i.e., Ford, Workhorse, etc.). Consult the chassis guide for operating safety and maintenance instructions pertaining to the chassis section of the motor home.

OWNER’S INFOCASE

Your InfoCase contains information supplied by manufacturers of individual appliances and equipment installed in your motor home.

Consult this information regarding the operation and care of appliances, accessories and special equipment.

0-1

INTRODUCTION

OPTIONS AND EQUIPMENT

This model is available in several sizes and floorplans, so accessories and components may differ slightly between models. Some equipment described in this manual may not apply to your coach.

BEFORE DRIVING

Before sitting in the driver’s seat, always check around your vehicle to be sure you have proper clearance for maneuvering. If necessary, have a passenger help guide you out of a difficult parking space.

Although your coach features automotive conveniences like power steering and power brakes, driving a motor home is different from driving a car. A motor home is larger and heavier than an automobile, so it requires more stopping and passing distance, and more parking and maneuvering space than a car does.

Always be mindful of the size of your motor home. The added height of roof accessories, TV antennas or luggage boxes may cause clearance problems around some tunnels, canopies and hanging signs. Know the height of your unit so you can observe posted clearance limits. Also, remember that some bridges, old ones in particular, may not support the weight of your motor home. Know the weight of your unit and observe any posted weight limits.

Remember: Alway use your seat belt and be sure your passengers do so as well. We also advise making frequent rest stops while traveling to relieve stress on yourself, your passengers and your vehicle.

Your dealer will provide quality maintenance and any other assistance that you may require during your ownership of this vehicle.

If you need warranty repairs while traveling, however you may take your motor home to any Winnebago or Itasca dealership and they will assist you.

WARRANTY

Your new vehicle is covered by a factory warranty against defects in material and workmanship. This warranty should be validated immediately and returned to the factory by your dealer. For additional information, see your “New Vehicle Limited Warranty” included with this vehicle.

DRINKING AND DRIVING

Winnebago Industries supports the recommendations of the Presidential Commission on Drunk Driving.

· Exercise your good judgment and encourage

others to do the same.

· Know the legal limits and do not exceed

them.

· Also know your personal limits, which may

be lower than the legal limits.

· Should you ever exceed your limits, find al-

ternative transportation; call a cab, ask a

friend to drive you home or call a family

member to come and get you.

SERVICE AND ASSISTANCE

Your dealer will be glad to provide any additional information you need, as well as answer any questions you might have about operating the equipment in your motor home. When it comes to service, remember that your dealer knows your vehicle best and is interested in your satisfaction.

0-2

The presence of alcohol in significant levels in the blood increases the probability that the driver will be involved in an accident.

REPORTING SAFETY DEFECTS

If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration

(NHTSA) in addition to notifying Winnebago Industries, Inc.

If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Winnebago Industries.

To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800-424-9393 (or 366-0123 in Washington, D.C. area) or write to: NHTSA, U.S. Department of Transportation, Washington, D.C. 20590. You can also obtain other information about motor vehicle safety from the Hotline.

INTRODUCTION

0-3

INTRODUCTION

VEHICLE CERTIFICATION LABEL

This label contains vehicle identification and other important reference information. The vehicle certification label is located on the sidewall to the left of the steering wheel, or on the driver’s door. Never remove or destroy this label.

MANUFACTURED BY

GAWR:

FRT______ LB______ KG________________ ________________ ______ PSI______ KPA SINGLE RR. _______ LB______ KG________________ ________________ ______ PSI______ KPA______

THIS VEHICLE CONFORMS TO ALL APPLICABLE FEDERAL MOTOR VEHICLE SAFETY STANDARDS IN EFFECT ON THE DATE OF MANUFACTURE SHOWN ABOVE.

SERIAL NO. _________________________ VIN______________________________ TYPE ____________________ MODEL ____________________ COLOR__________

SUITABLE TIRE AND RIM CHOICE COLD INFLATION

EXPLANATION OF DATA

1. Chassis manufacturer.

2. Chassis manufacture date.

3. Month and year of manufacture at Win-

nebago Industries.

4. Gross Vehicle Weight Rating: Total permis-

sible weight of the vehicle, including driver,

passengers, total cargo carried (including all

liquids) and equipped with all options.

5. Gross Axle Weight Rating: Total permissible

weight allowed for the front, and rear axles

(listed in pounds and kilograms).

6. Suitable Tire Choice: Tires recommended to

meet handling and safety requirements.

When replacing any of the tires on your

vehicle, always replace with a tire that meets

these specifications.

7. Suitable Rim Choice: Wheel rims recom-

INCOMPLETE VEHICLE MANUFACTURED

BY MOTOR CORP.

MONTH AND YEAR OF MANUFACTURE:________ GVWR_______LB _________KG

TIRE RIM PRESSURE

10. Serial Number: This is the serial number assigned to the completed vehicle by Winnebago Industries.

11. Vehicle Identification Number (VIN): This number identifies the chassis on which the motor home is built. The 10th digit of the VIN designates the chassis model year. (1=2001, 2=2002, 3=2003) This information is useful when ordering chassis repair parts.

12. Type: States the NHTSA designated usage classification for your motor home. MPV signifies a Multi-purpose Passenger Vehicle.

13. Model: Lists the Winnebago product model number of your vehicle.

14. Color: Signifies the color code number of the decor used throughout the vehicle. This number is necessary for ordering replacement cushions, curtains, carpet, etc.

mended to meet handling and safety requirements. When replacing any of the rims on your vehicle, always replace with a rim that meets these specifications.

8. Cold Inflation Pressure: Inflation pressures recommended (while Cold) for the tires originally equipped on your vehicle. These pressure levels must be maintained to assure proper handling, safety and fuel economy.

9. Rear Axle Wheel Configuration: Single or Dual.

0-4

Vehicle Certification Label

INTRODUCTION

EXTERIOR FEATURE IDENTIFICATION

Composite model shown for illustration purposes only.

Actual locations of features depends on coach model and options.

0-5

SECTION 1

SAFETY PRECAUTIONS

Read and understand all instructions and precautions in this manual before operating your new motor home.

About Safety Messages Used in This Manual

DANGER

DANGER indicates a directly hazardous situation which, if not avoided, will result in death or serious personal injury.

NOTE: A ‘Note’ is not necessarily safety related but indicates a recommendation or special point of information that could assist in understanding the use or care of a feature item.

The following pages provide safety precautions that must be adhered to. These precautions as well as others that involve possible injury or damage to equipment are also displayed in the appropriate areas in this manual.

GENERAL WARNINGS

· Only seats equipped with seat belts are to be

occupied while the vehicle is moving.

· Make sure all passengers have seat belts

fastened in a low and snug position so the force exerted by the belt in a collision will be spread across the strong hip area. Pregnant women should wear a lap-shoulder belt whenever possible, with the lap belt portion worn low and snug throughout the pregnancy.

WARNING

WARNING indicates a potentially hazardous situation which, if not avoided, could result in death or serious personal injury.

CAUTION

· All moveable or swiveling seats should be

placed and locked in forward facing positions while the vehicle is moving.

· Never let passengers stand or kneel on seats

while the vehicle is moving.

· Sleeping facilities are not to be utilized while

vehicle is moving.

· Examine the escape window and be familiar

with its operation, but do not use except in an emergency.

• Inspect the fire extinguisher monthly for

proper charge and operating condition. This should also be done before beginning a vacation or any extended trip.

1-1

SECTION 1

SAFETY PRECAUTIONS

DRIVING

heater. They contain carbon monoxide, which is an odorless, colorless and poisonous gas.

· Do not attempt to adjust the driver’s seat while the vehicle is moving.

· Do not adjust tilt steering in a moving vehicle.

· Do not operate the cruise control on icy or extremely wet roads, winding roads, in heavy traffic, or in any other traffic situation where a constant speed cannot be maintained.

· Use care when accelerating or decelerating on a slippery surface. Abrupt speed changes can cause skidding and loss of control.

· Driving through water deep enough to wet the brakes may affect stopping distance or cause the vehicle to pull to one side. Check brake operation in a safe area to be sure they have not been affected. Never operate any vehicle if a difference in braking efficiency is noticeable.

· Adverse weather conditions and extremes in terrain may affect handling and/or performance of your vehicle. Refer to your chassis manual for related information.

FUEL & LP GAS

· Do not bring or store LP gas containers, gasoline or other flammable liquids inside the vehicle because a fire or explosion may result. LP gas containers are equipped with safety valves which relieve excessive pressure by discharging gas to the atmosphere.

· Do not fill LP gas container(s) above 80 percent of capacity. Overfilling the LP gas container can result in uncontrolled gas flow which can cause fire or explosion. A properly filled container will contain approximately 80 percent of its volume as liquid LP gas.

· Never use an open flame to test for LP gas leaks. Replace all protective covers and caps on LP system after filling. Make sure valve is closed and door latched securely.

· Never connect natural gas to the LP gas system.

· When lighting range burners do not turn burner controls to “On” and allow gas to escape before lighting match.

· Portable fuel-burning equipment, including wood and charcoal grills and stoves, shall not be used inside the recreational vehicle. The use of this equipment inside the recreational vehicle may cause fires or asphyxiation.

· All pilot lights must be extinguished and appliances turned off while refilling the fuel tank or LP tank.

· Never smoke while refilling vehicle fuel tank or LP gas tank.

· Avoid inhaling exhaust gases produced by burned gasoline, diesel fuel or LP gas in items such as the range, chassis engine, generator engine, refrigerator, furnace and water

1-2

· LP gas regulators must always be installed with the diaphragm vent facing downward. Regulators are equipped with a protective cover. Make sure that the regulator vent faces downward and that the cover is kept in place to minimize vent blockage which could result in excessive gas pressure causing fire or explosion.

· The following warning label is located in the cooking area to remind you to provide an adequate supply of fresh air for combustion.

WARNING

IT IS NOT SAFE TO USE COOKING APPLIANCES

FOR COMFORT HEATING

Cooking appliances need fresh air for safe

operation. Before operation

1. Open overhead vent or turn on exhaust fan.

2. Open window

FAILURE TO COMPLY COULD RESULT IN

DEATH OR SERIOUS INJURY.

Unlike large homes, the oxygen supply inside a recreational vehicle is limited due to its size. To avoid danger of axphyxiation, provide proper ventilation when using the gas rangetop or gas oven. It is especially important that the gas oven and range top not be used for comfort heating. Danger of asphyxiation is greater when these appliances are used for long periods of time.

SECTION 1

SAFETY PRECAUTIONS

LP gas is present inside the coach. Because LP gas is heavier than air, the detector is located on a cabinet face near the floor of the coach.

A green light on the face of the alarm shows

when the unit is active.

If the detector senses LP gas, the alarm will make a loud, pulsating sound and the red light will come on. Pressing the “MUTE” button will stop the alarm for 60 seconds. If there is no more detectable LP gas, the alarm will stay off. If the detector still senses LP gas by the end of the 60 second mute mode, the alarm will sound again.

Press to stop alarm

LP GAS LEAKS

The following label is located in the vehicle near the range area. If you smell gas within the vehicle, quickly and carefully perform the procedures listed.

DANGER

IF YOU SMELL GAS

1. EXTINGUISH ANY OPEN FLAME, PILOT LIGHTS AND ALL SMOKING MATERIALS.

2. DO NOT TOUCH ELECTRICAL SWITCHES.

3. SHUT OFF THE GAS SUPPLY AT THE TANK VALVE(S) OR GAS SUPPLY CONNECTIONS.

4. OPEN DOORS AND OTHER VENTILATING OPENINGS.

5. LEAVE THE AREA UNTIL ODOR CLEARS.

6. HAVE THE GAS SYSTEM CHECKED AND LEAKAGE SOURCE CORRECTED BEFORE USING AGAIN.

FAILURE TO COMPLY COULD RESULT IN

EXPLOSION RESULTING IN DEATH OR

SERIOUS INJURY.

LP GAS ALARM

Your coach is equipped with an LP gas detec-

tor which sounds an alarm if an unsafe amount of

Green

(Active)

Red

(Alarm)

Amber

(Low Batt.)

If the Alarm Sounds

If the alarm sounds, do not touch any electrical switches. Immediately turn off the main LP tank valve and all LP appliances, open all windows and roof vents, and leave the coach until the alarm stops sounding.

If the alarm keeps sounding at regular intervals, a leak may be present. Contact your dealer or an LP gas service center to have the problem corrected before using the LP system again.

WARNING

Never use an open flame to test for gas leaks. When testing for gas line leaks with a soapy water solution, DO NOT use a detergent containing ammonia or chlorine. These substances may generate a chemical reaction causing corrosion to gas lines, resulting in dangerous leak conditions.

1-3

SECTION 1

SAFETY PRECAUTIONS

Power Connection

The gas alarm is powered by the coach batteries. If the battery cable is disconnected from the batteries, auxiliary battery switch is shut off, or the fuse is blown, the alarm will not work. The LP gas alarm breaker is located on the house 12volt panel shown on page 6-7 and 6-8.

Because the LP gas alarm is connected directly to the auxiliary battery, it is always drawing a small amount of current. Even though this current draw is slight, it could drain the coach battery during storage periods of 30 days or longer. We recommend turning the auxiliary battery switch off or disconnecting the battery cables from the auxiliary battery during extended storage periods to avoid discharge.

If the coach batteries become extremely drained (8.5 volts or less), the amber Low Voltage/FAULT light on the face of the alarm will come on, and in some rare cases the LP alarm may begin to sound on its own. This condition is not likely to occur except during storage situations when coach battery charge is not being restored by the converter charger or solar charger.

Other Combustible Fumes or Vapors

This alarm is designed to detect the presence of LP gas, however there are other combustible fumes or vapors which may be detected by the sensor. These include: alcohol, liquor, deodorants, colognes, perfumes, wine, adhesives, lacquer, kerosene, gasoline, glues, most all cleaning agents and the propellants of aerosol cans. Most are lighter than air in their vapor state and will only be detected when the area is closed up. Glues and adhesives may exhaust hydrocarbon vapors for months after they are applied. They are easily activated by high temperatures. If you close up an RV coach on a hot day, the chemicals used in its construction may be detected for months after the coach was manufactured.

Further Information

See the manufacturer’s information entitled “Your LP Gas Detector” in the Owner InfoCase for further instructions on nuisance alarms and care and testing of the LP gas detector.

ELECTRICAL

· Careless handling of electrical components can be fatal. Never touch or use electrical components or appliances while feet are bare, while hands are wet, or while standing in water or on wet ground.

· Improper grounding of the vehicle can cause personal injury. Do not plug the utility power cord into an outlet which is not grounded and do not adapt the plug to connect to a receptacle for which it is not designed.

· Do not attach an extension cord to the utility power cord.

· Be sure that all electrical appliances to be used contain 3-prong plugs for proper grounding.

· Avoid overloading electrical circuits. Replace fuses or circuit breakers with those of the same size and amperage rating only. Never use a higher rated fuse or breaker.

· Use caution when handling or working near electrical storage batteries. Always remove jewelry and wear protective clothing and eye covering. Avoid creating sparks.

· Store or secure all loose items inside the motor home before traveling. Possible overlooked items such as canned goods or small appliances on the countertop, cooking pans on the range, or free-standing furniture items can become dangerous projectiles during a sudden stop.

· Be aware of GVWR, GAWR and individual load limit on each tire or set of duals. (See “Loading the Motor Home” in Section 4.)

1-4

· Never load the motor home in excess of the gross vehicle weight rating or the gross axle weight rating for either axle.

SECTION 1

SAFETY PRECAUTIONS

NOTE: Your motor home’s load capacity is des-

ignated by weight, not by volume, so you cannot necessarily use all available space when loading your motor home.

MAINTENANCE

· Do not remove the radiator cap while engine and radiator are still hot. Always check coolant level visually at the see-through coolant reservoir.

· Never get beneath a vehicle that is held up by a jack.

· Do not mix different construction types of tires on the vehicle such as radial, bias or belted tires, as vehicle handling may be affected. Replace tires with exact size, type and load range.

· Do not attempt to start the vehicle by hot wiring.

NOTE: To aid in dissipation, ventilate the vehi-

cle by opening all windows and circulating the air with a fan.

CARBON MONOXIDE WARNING

WARNING

Avoid inhaling exhaust gases, as they contain carbon monoxide, which is a colorless, odorless and poisonous gas.

If your suspect that exhaust fumes are entering the passenger compartment, have the cause determined and corrected as soon as possible. If you must drive under these conditions, drive only with ALL WINDOWS FULLY OPENED.

The best protection against carbon monoxide entry into the vehicle body is a properly maintained engine exhaust and ventilation system. It is recommended that the exhaust system and body be inspected by a qualified motor home service center.

FORMALDEHYDE INFORMATION

WARNING

Some components in this vehicle contain formaldehyde based adhesives which may release formaldehyde fumes into the air for an unknown period of time until total dissipation occurs. Individuals who are allergic to formaldehyde gas fumes may experience irritation to eyes, ears, nose and throat. Reaction in infants may be more severe. Although long range effects are not well understood, testing to date has not revealed any serious health effects in humans at the level of emission from these products.

· Each time the vehicle is raised for an oil

change.

· Whenever a change in the sound of the ex-

haust system is noticed.

· Whenever the exhaust system, underbody or

rear of the vehicle is damaged.

To allow proper operation of the vehicle’s ventilation system, keep front ventilation inlet grill clear of snow, leaves or other obstructions at all times. DO NOT OCCUPY A PARKED VEHICLE WITH ENGINE RUNNING FOR AN EXTENDED PERIOD.

Do not run engine in confined areas, such as a garage, except to move vehicle in or out of area. When vehicle is stopped in an UNCONFINED area with the engine running for any more than a short period, adjust heating or cooling system to force outside air into the vehicle as follows:

1. Set fan to medium or high speed and vent

control to air.

1-5

SECTION 1

SAFETY PRECAUTIONS

2. On vehicles equipped with air conditioning, set fan to medium or high speed and set control to obtain maximum vent air.

Rear windows should be closed while driving to avoid drawing dangerous exhaust gases into the vehicle.

CARBON MONOXIDE ALARM

Your coach is equipped with a carbon monoxide (CO) alarm, it will be located on the ceiling in the bedroom area. The CO alarm is powered by a 9-volt battery and contains a sensor that is designed to detect toxic carbon monoxide gas fumes resulting from incomplete combustion of fuel. It will detect CO gas from any combustion source such as the furnace, gas range/oven, water heater, refrigerator, chassis engine, and electric generator engine.

· Patented biomimetic sensor mimics the hu-

man response to Carbon Monoxide.

· Test/Reset provides for one time alarm si-

lence and multiple warning silence. Also tests alarm circuitry, microprocessor, battery and horn.

· Red light flashes once every thirty seconds in

normal operation

.· Continuous yellow light with a beep every

three seconds indicates an unhealthy CO level.

· Continuous red light and pulsating alarm sig-

nal a dangerous CO condition.

· Battery operation provides protection 100%

of the time. Low battery signal alerts consumer of need to replace battery.

· 85 decibel alarm assures waking during

sleeping hours.

Red Light

(Press to Test Alarm)

Monthly Testing

Press the TEST button on the face of the alarm periodically (at least monthly) to check the function of the alarm and condition of the battery. If the alarm begins to beep every few seconds, the battery may be weak and need replacement. (Press the TEST button to be sure before replacing the battery. If the alarm sounds, the battery may still be okay. If the alarm still beeps every few seconds, check the smoke detector also. The “low battery” warning beep is similar on many alarm devices, so the origin of this electronic sound can be deceiving.)

FURTHER INFORMATION

Please read the information provided by the manufacturer, which is included in your Owner InfoCase. It includes information on precautions, operational testing, and battery/sensor replacement.

Yellow Light

(Warning)

EMERGENCY EXITS Emergency Exit Windows

Your motor home is equipped with an emergency exit window in the side of the vehicle which functions as an escape exit in an emergency situation.

1-6

WARNING

Use care when exiting emergency window, as broken glass may be present in the exit area.

Side Escape Window

The side mounted escape window is secured by two safety latches and can be opened by first releasing these two latches and then pushing outward on the lower part of the window.

Instructions for removal are also located near the latches for quick reference and for passengers who may not be familiar with the exit. Never remove or destroy this label.

SECTION 1

SAFETY PRECAUTIONS

familiar with the operating instructions displayed on the side of the fire extinguisher or in the information supplied in your Owner InfoCase.

We also recommend that you inspect the fire extinguisher for proper charge at least once a month in accordance with National Fire Protection Association (NFPA) recommendations as stated on the label.

If the charge is insufficient, the fire extinguisher must be replaced.

Lift Both Handles Up Push Out on Bottom of Window

Using Slider Windows As An Emergency Exit

Most single and double slider windows along the side of the motor home can also be used as emergency exits, should the need arise. To use the windows as exits, slide the window glass and screen open.

FIRE EXTINGUISHER

A dry chemical fire extinguisher is located near the floor by the side entrance door.

We recommend that you become thoroughly

WARNING

Do not test the fire extinguisher by discharging it. Partial discharge can cause leakage of pressure or contents which would render the unit inoperative when needed. When using the fire extinguisher, aim the spray at the base of the fire.

SMOKE ALARM

Your motor home is equipped with a smoke alarm located on the ceiling in the galley area. This alarm meets U.L. Standard 217 and NFPA Standard 74 for operation of smoke detection devices.

1. The smoke alarm should be tested for correct

operation each time the vehicle is brought out of storage, before each trip, and at least once a week during motor home use. To test

1-7

SECTION 1

SAFETY PRECAUTIONS

the electronics, firmly depress the button. To test that smoke reaches the sensor, blow smoke in a careful, fire-safe manner into your smoke alarm.

Press to Test

Smoke Alarm

2. Your smoke alarm will not work without power. Never remove the battery to quiet the alarm. When your smoke alarm “beeps” about once a minute the battery is weak. Install a new battery immediately. Be sure to use only batteries specified in manual or on unit. Test unit after installing a new battery.

3. Clean and vacuum the openings on your smoke alarm once a month.

4. Do not open the smoke alarm or try to repair it. For replacement information see warranty in Owner’s Manual.

5. Smoke alarms have technical limitations and may not respond in all situations. FIRE PREVENTION is your best safeguard.

See your InfoCase for further information.

1-8

DRIVING YOUR MOTORHOME

(See also Safety Precautions, Section 1 of this

manual.)

SECTION 2

WARNING

NOTE: See your Ford or Workhorse chassis

operator's guide for information on starting the engine, operating the transmission, steering column controls descriptions of instrument gauges and other chassis related information.

Some items described in this section may be optional or unavailable on your coach.

BEFORE ENTERING YOUR VEHICLE

Before entering your vehicle, there are a few recommended procedures that will aid in your driving safety and equipment.

1. Be sure that the windows, mirrors and light

lenses are clean and unobstructed.

2. Make sure all exterior lights operate prop-

erly.

3. Check tires for proper cold inflation pres-

sures.

4. Check wheel lug nuts for tightness.

5. Look beneath the vehicle for noticeable fluid

leakage.

6. Check fluid levels and fill if necessary. This

includes engine oil, transmission fluid, coolant, brake fluid, power steering fluid and windshield washer solvent.

The engine should be shut off unless specifically required for a certain procedure.

Workhorse/Ford: Transmission must be in P (Park) and park brake applied while performing any checks or adjustments.

7. Unhook and store sewer and water supply hoses.

8. Retract step.

9. Be sure that all of your cargo is secured in event of a sudden stop or an accident.

10. Check around your vehicle in all directions to assure that you have proper clearance.

11. Lower TV antenna.

12. Disconnect and store shoreline.

WARNING

Before driving your vehicle, be sure you have read the entire operator’s manual and that you understand your vehicle’s equipment completely and how to use the equipment safely.

BEFORE DRIVING YOUR VEHICLE

Before preparing to drive your vehicle, here are a few recommended procedures that will add to your driving safety and enjoyment.

1. Be sure that you adjust the interior and exte-

rior rear view mirrors to your driving preference.

2. Adjust the driver's seat for proper distance

from foot pedals and steering wheel to allow for safety and ease in controlling your vehicle.

2-1

SECTION 2

DRIVING YOUR MOTOR HOME

3. Place front seats in the forward facing position.

4. Be sure to fasten all safety belts to fit you comfortably, but tight enough to obtain the full safety of the belts.

5. Make sure all doors are completely shut and locked. When the doors are shut and locked, there is less chance of the doors flying open in event of an accident. It also prevents unintentional opening of doors and keeps intruders out of your vehicle.

6. Check to see that all gauges are operating properly.

7. Check the fuel level in the vehicle.

8. Be certain that the fire extinguisher is fully charged and secure in its mounting bracket.

CAUTION

Be sure hood and all compartment doors are latched securely before driving vehicle

“KEY ONE” LOCK SYSTEM

Your coach is equipped with the new Key

One door lock in the entire motor home (except the security deadbolt lock on the entrance door). This means you don’t have to sort through a handful of keys to find the right one for the water fill door or the luggage doors or the entrance door or the driver’s door.

tered in our factory database, so if you ever lose your keys, any Winnebago Industries dealership can easily order a new key for you. They are also equipped with special master keys and can unlock your coach for you if needed.

lock system. A single key will open every

The number of the key for your coach is regis-

WARNING

Modern fuel systems may build up pressure within the tank as the gasoline warms during use or in hot weather.

Under certain conditions, sudden release of this pressure when removing the gasoline cap can spray gasoline from the fuel fill opening, causing a possible hazard.

GASOLINE FUEL FILL

REMOVING THE FUEL CAP

When removing the gasoline cap, slowly rotate it only far enough to allow pressure to re- lease. After any "hissing" sounds stop, continue removing the cap.

FILLING THE TANK

Do not overfill the fuel tank. Allow gasoline

to pump into the tank until the auto-shutoff valve in the fuel pump nozzle stops the flow of fuel, indicating a full tank. This provides a pre-determined vapor space at the top of the tank to allow for expansion of the gasoline.

CAUTION

Continuing to fill above this level may cause damage to the fuel/evaporative emission system.

Fuel Tank Capacity: ............................75 gal.

REPLACEMENT FUEL CAPS

To protect gasoline system from excessive pressure or vacuum, or from sudden pressure, replace lost caps with caps of the same design available from your dealer.

FUEL SELECTION

Refer to your chassis operating guide for the manufacturer's recommendations on proper fuel selection.

2-2

STARTING AND STOPPING ENGINE

Refer to your chassis operating guide for the manufacturer's recommendations on starting and stopping the engine.

SECTION 2

DRIVING YOUR MOTOR HOME

Brake-Shift Interlock (Workhorse and Ford Chassis)

Workhorse and Ford chassis are equipped with a brake-shift interlock safety feature. The shift lever cannot be moved from the Park position unless the ignition is ON and the service brake pedal is pressed.

NOTE: On Ford chassis, if the brake light fuse is

blown, the interlock feature will not work properly and an alternate method must be used. See your Ford Owners Guide for detailed instructions on what to do in this situation.

PARKING BRAKES Ford or Workhorse Chassis:

The parking brake pedal is located to the left of the foot service brake.

To set the parking brake, press the service brake pedal firmly with your right foot while you apply the parking brake with your left foot. The BRAKE warning light will go on as soon as you start to press the parking brake pedal. The brake will not prevent the vehicle from moving unless you push it down firmly and fully. Remove your

foot from the service brake pedal and make

sure there is no vehicle movement.

To release the parking brake, apply the service brake with your right foot and hold the parking brake pedal down with your left foot while you pull the release lever. The release lever is located above the brake pedal.

Never drive your vehicle with the parking brake set as this will reduce parking brake effectiveness and cause excessive wear.

pump in the event of collision. This switch must be manually reset to resume the fuel supply to the engine.

See your Ford chassis operating guide for lo-

cation and reset procedures for this switch.

NOTE: It is possible to accidentally trigger the

fuel pump shut-off switch by abruptly striking an object such as a curb or parking block. If your vehicle exhibits symptoms of running out of fuel immediately after such an occurrence, the fuel pump shut-off switch may need to be reset. Consult your chassis operating guide for additional information.

ENTRANCE DOOR LOCK AND HANDLE

The entrance door may be opened by pulling the door handle outward. When the door is locked, neither the inside nor the outside door handle can be operated. It can be locked and unlocked from the outside of the vehicle by inserting the key into the lock and turning.

HAZARD WARNING LIGHTS

See chassis manual or "Instrument Panels" in this section for location of hazard flasher switch. See also Section 3 for further operating information.

FUEL PUMP SHUT-OFF SWITCH (Ford Chassis Only)

Vehicles built on Ford chassis are equipped with an inertial type switch that shuts off the fuel

Door Handle LockBolt Lock

To lock the door from inside, rotate the lock levers as indicated. The deadbolt lock is for added security and should be used as a security night lock.

2-3

SECTION 2

DRIVING YOUR MOTOR HOME

Door Handle Lock

Door Handle Bolt Lock

Screen Door Latch

Lubricate the locks periodically with graphite

to maintain good working condition.

CAUTION

When releasing security night lock, be sure to retract bolt before opening door latch to prevent drag on bolt pin. Instruct all passengers in operation of this door catch system as well as emergency exit window.

NOTE: Keys should always be removed when

leaving the vehicle. Since doors can be locked without keys, make sure they have been removed from the ignition before locking the driver's compartment.

Luggage Compartment Doors

To ensure that compartment doors are latched properly, press the bottom edge of the door with the palms of your hands.

Automatic Mode (Operates with Door)

With the Power Switch in the On position the step is in Automatic Mode. This means it will extend and retract automatically whenever the door is opened or closed. This is done by means of a magnetic door switch attached to the lower hinged edge of the screen door section of the entrance doors. The steps will extend when the screen door is opened, and retract when the screen door is closed. With the power switch in the Off position the step can be kept in the extended or retracted position as described below.

Stationary Extended Mode

To keep the step in the extended position:

• turn the Power Switch to On,

• open the screen door to extend the step,

• then turn the Power Switch to Off.

The step will now stay extended whether the door is opened or closed. This position is normally used when parked at a campsite or whenever people are going to be entering and exiting the vehicle frequently.

ELECTRIC ENTRANCE STEP

The power switch for the electric entrance step is located to the left of the main entry door as you enter the coach.

2-4

Stationary Retracted Mode

To keep the step in the retracted position:

• turn the Power Switch to On,

• close the screen door to extend the step,

• then turn the Power Switch to Off. The step will now stay retracted when the

screen door is open or closed. This position is

SECTION 2

DRIVING YOUR MOTOR HOME

normally used where an exterior step is not required or to avoid damage to the step, such as when parked near a high curb or similar object.

Automatic Retraction Feature

The coach is equipped with a step retraction feature that retracts the step automatically when the Ignition Switch key is turned to either the On or Start position regardless of whether the Step Power Switch is On or Off. This feature is standard and is installed to prevent injury or damage which may be caused by an extended step when the vehicle is moving. An associated feature is the “Last Out Feature”. This feature extends the step when the screen door is opened after the ignition switch has been turned to either the On or Start position.

WARNING

the seats on some models to be turned toward the living area for additional seating while the unit is parked.

To swivel the seats: Lift the release lever, located on the side of the seat, and rotate seat. The seats are designed to lock only when returned to the forward facing position.

To recline the seats: Lift the reclining lever, lean back to desired incline and release the lever. To return to the upright position, lift the lever and lean body forward. Allow the seat to return to the desired position and release the lever.

Do not use steps unless it is fully extended.

Do Not Stand on step when vehicles ignition switch is turned to either the “On” or “Start” position. The step will automatically retract, which may cause personal injury. Always remember to retract the step before moving the vehicle.

For additional information on the step, see the

step manufacturer’s operators manual included in your Owners InfoCase.

SEATS

The driver and co-pilot seats may be independently adjusted to suit individual preference. To move the seat forward or backward, lift the slide release paddle, located on the side of the seat, and exert slight body pressure in the direction desired.

The seats may be swiveled to provide easy entrance and exit. The swivel feature also allows

Lift to

Swivel

Lift to

Swivel

Lift to

Slide

Lift to

Recline

Slide

2-5

SECTION 2

DRIVING YOUR MOTOR HOME

WARNING

Do not adjust driver’s seat while vehicle is in motion.

After adjusting seat, always use body pressure to make sure slide and swivel locking mechanism have engaged.

ARM REST ADJUSTMENT

The driver and co-pilot seat armrests may be adjusted to rest at two different positions as shown.

Position 1 - Raise armrest, push in toward seat, and lower into position. This position would generally be used when the seat is in the upright position.

Position 2 - Raise armrest, pull outward from seat, and lower into position. You may wish to use this position when you recline the seat.

tection of the safety belt, never let more than one person use the same safety belt at any one time, and do not let the safety belts become damaged by pinching them in the doors or in the seat mechanism. After any serious accident, any seat belts which were in use at the time should be replaced.

1. PULL TO TIGHTEN.

2. TONGUE.

3. PUSH TO RELEASE.

Adjustment: To lengthen belt, turn tongue at a right angle to belt and pull to desired length. To shorten, pull loose end of belt. To Fasten: Be sure belt is not twisted. Grasp each part of the belt assembly and push tongue into buckle. Adjust to a snug fit by pulling the loose end away from the tongue. To Release: Press button in center of buckle and slide tongue out of buckle.

SEAT BELTS

Seats intended for occupancy while the vehicle is in motion are equipped with seat belts for the protection of the driver and passengers.

Lap Belts

The lap belts must be worn as low as possible and fit snugly across the hip area. Always sit erect and well back into the seat. To gain full pro-

WARNING

Snug and low belt positions are essential. This will ensure that the force exerted by the lap belt in a collision is spread over the strong hip area and not across the abdomen, which could result in serious injury.

Only seats equipped with seat belts are to be occupied while vehicle is in motion.

THREE-POINT LAP-SHOULDER BELTS

The driver and co-pilot seat belts in your coach are equipped with automatic locking retractors that let you easily adjust your seat belt to the proper length for passenger safety.

Fastening:

· Grasp the belt just behind the tongue using

the hand nearest the door or sidewall. Be sure the belt is not twisted before fastening.

· Pull the belt smoothly outward from the wall

and across your body, then insert the tongue

2-6

+ 108 hidden pages

Winnebago adventurer (2003) Owner's Manual

Specifications and Main Features

Frequently Asked Questions

User Manual