Wincor Nixdorf iCASH 15 Cleaning Instruction Manual

iCASH 15 Cleaning Instruction

Edition November 2010

All product names mentioned in this document are registered trademarks.

Copyright ©Wincor Nixdorf International GmbH, 2010

All rights including the rights to the translation, reprinting, transmission or copying by any means, in whole or in part are

reserved. Offenders will be liable for damages. All rights including rights resulting from a patent grant or registration of a utility

or design are reserved.

iCASH 15 – Cleaning Instruction

1

General Informations

The device must be switched off for service and maintenance work.

You should service and clean the parts of the device listed below at the specified intervals.
In addition, please note the following:

 Take care not to drop any cleaning liquids into the device.
 Only use the cleaning material listed in this manual. Do not use thinners.

Information where to order the listed cleaning materials is given in the chapter "Cleaning materials".

Maintenance

 Check the dust box once a day and empty it if necessary.
 Perform a visual inspection of the coin hoppers and coin paths.
 Clean the coin paths.

Cleaning the housing

Cleaning interval: as needed
Cleaning material: Wet cleaning cloths
for stainless steel surfaces Ballistol oil for cleaning stainless steel
for varnished surfaces Wincor Nixdorf cleaning set
for plastic surfaces Wincor Nixdorf cleaning set

Cleaning the coin paths

The conveyer belts must not come into contact with alcohol.

Clean the coin paths with compressed air.
Cleaning interval: when necessary, at least once a month
Cleaning material: Wincor Nixdorf air duster

Cleaning the coin validator

Clean the coin validator with cleaning swabs.
Cleaning interval: when necessary, at least once a month

Cleaning material: Cleaning swabs

Except for the Coin Validator all components of the iCASH 15E must be cleaned
and maintained by trained and authorized Service personnel only! Unauthorized or
inexpert cleaning or maintenance will in va lidate your warr ant y and liabil ity protection.

iCash 15 – Cleaning Instruction

2

Coin Validator (User and Service Staff)

 Unlock the iCASH 15 (1) and pull out the unit (2).

 Swing the front cover open (1).

2

1 2 2

iCASH 15 – Cleaning Instruction

3

 Unlock the green levers (arrows) and open the cover to the right.

i

Always use a commercially available hard toothbrush to clean the device. F ina lly, clean the

area with a slightly moistened (Isopropylalkohol) cloth and then dry it.

To clean the whole area (shaded area) turn the green wheel (1) to bring the rotor (2) to a different
position. Pay special attention to the thickly white marked area (3).

 Mount the device in logically reverse order.

2

3

1