Winco TFLC User Manual

INSTALLATION, OPERATION, and MAINTENANCE INSTRUCTIONS

PORTABLE GENERATORS

LC SERIES

DLC SERIES

LLC SERIES

TFLC SERIES

Read and understand all instructions in the manual before starting and

operating the generator set.

USING THIS MANUAL

Congratulations on your choice of a DYNA generator set. You have selected a high-quality, precisionengineered generator set designed and tested to give you years of satisfactory portable service. To get the best performance from your new engine generator set, it is important that you carefully read and follow the operating instructions in this manual. Should you experience a problem please follow the “Things To Check” near the end of this manual. The warranty listed in this manual describes what you can expect from DYNA should you need service assistance in the future.

PROPER USE AND INSTALLATION

You must be sure your new engine generator set is: * Properly serviced before starting * Operated in a well ventilated area * Operated so that exhaust gases are dispersed safely * Wired by a qualified electrician * Operated only for its designed purposes * Used only by operators who understand its operation * Properly maintained

COPY YOUR MODEL AND SERIAL

NUMBER HERE

No other DYNA generator has the same serial number as

yours. It is important that you record the number and other vital information here. If you should ever need to contact us on this unit it will help us to respond to your needs faster.

TABLE OF CONTENTS

INTRODUCTION i FEATURES BY MODEL 1 GUIDE TO PRODUCT SAFETY 2 BASIC INFORMATION 3 Intended Uses 3 Restricted Uses 3 Unit Capabilities 3 PREPARING THE UNIT 4 Unpacking the unit 4 Unit Preparation 4 BASIC OPERATION 5 Battery Charging 5 Low Oil Level Shutdown System 5 Initial Starting 6 Starting 6 Starting Hints 6 Stopping And Storage 6 Operating Speed 6 Connecting The Loads 7 OPERATOR CARE AND MAINTENANCE 8 Engine Care 8 Generator Care 8 Cleaning 8 Troubleshooting - Things To Check BEFORE You Call For Service 9 Schematic Wiring Diagram 10 24 MONTH WARRANTY 1 0

MODEL______________________________________ SERIAL NUMBER _____________________________ PURCHASE DATE_____________________________ DEALER_____________________________________

Page i

SIZE ONLY CONTROL OPERATION AVAILABLE

FEATURES BY MODEL

ENGINE LOW OIL BATTERY FUEL 120 120/240 ELECTRIC AUTOMATIC LP/NG

TYPE SHUTDOWN CHARGER TANK VOLT VOLT START IDLE FUEL CSA

MODEL PAGE 5 PAGE 5 PAGE 4 PAGE 5 NOTE 1 NOTE 2

LC1500 B&S STD NO YES 2 QT Y E S NO NO NO NO NO

LC3000 B&S STD NO NO 3 QT YE S NO NO NO NO YES

LC3000I B&S I/C Y ES NO 3 QT YES NO NO NO NO YES

LC3000H HONDA YES NO 4 QT YES NO NO NO NO YES

LC4500 B&S STD NO NO 4 QT NO Y E S NO NO NO YES

LC4500I B&S I/C Y ES NO 6 QT NO YES NO NO NO YES

LC5000H HONDA YES NO 6 QT NO YES NO NO NO YES

LLC4500 B&S STD YES NO 4.5 GAL NO YE S NO NO NO YES

LLC4500E B&S STD YES YE S 4.5 GAL NO YES YE S NO NO YES

LLC5000H HONDA YES NO 4.5 GAL NO YE S NO NO NO YES

LLC6000 B&S STD YES NO 4.5 GAL NO YE S NO NO NO YES

LLC6000H HONDA YES NO 4.5 GAL NO YE S NO NO NO NO

LLC6000HE HONDA YE S NO 4.5 GAL NO YE S YES NO NO NO

LLC9000E B&S VGD YE S YES 4.5 GAL NO YES YES NO NO NO

LLC9500HE HONDA YE S YES 4.5 GAL NO YES YE S NO NO NO

LLC15000KE KOHLER YES YES 4.5 GAL NO YES YES NO NO NO

DLC4500 B&S I/C Y ES NO 4.5 GAL NO YES NO YES NO YES

DLC6000E B&S I/C YES YES 4.5 GAL NO YE S YE S YES NO YES

TFLC6000E B&S I/C YES YES 4.5 GAL NO YES YES NO YES NO

TFLC9000E B&S VGD YE S YES 4.5 GAL NO YES YES NO YES NO

NOTE 1: SUPPLEMENTAL INSTRUCTION SHEET 60707-201 DETAILS INSTALLATION AND OPERATION OF UNITS WITH LP/NG FUEL.

NOTE 2: SUPPLEMENTAL INSTRUCTION SHEET 60710-096 DETAILS ADDITIONAL INFORMATION FOR CSA UNITS.

60707-101

------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------

Page 1

DYNA SERIES

GUIDE TO PRODUCT SAFETY

This engine generator set has been designed and

manufactured to allow safe, reliable performance. Poor maintenance, improper or careless use can result in potential deadly hazards; from electrical shock, exhaust gas asphyxiation, or fire. Please read all safety instructions carefully before installation or use. Keep these instructions handy for future reference. Take special note and follow all warnings on the unit labels and in the manuals.

ANSI SAFETY DEFINITIONS

______________________________________________________ DANGER: DANGER indicates an imminently hazardous situation which,

if not avoided, will result in death or serious injury. This

signal word is to be limited to the most extreme situations. ______________________________________________________ ______________________________________________________ WARNING: WARNING indicates a potentially hazardous situation which,

if not avoided, could result in death or serious injury. ______________________________________________________ ______________________________________________________ CAUTION:

CAUTION indicates a potentially hazardous situation which,

if not avoided, may result in minor or moderate injury. It may

also be used to alert against unsafe practices. ______________________________________________________ NOTE:

CAUTION is also used on the unit labels and in this

manual to indicate a situation that could result in serious

damage or destruction of the equipment and possible

personal injury. ______________________________________________________

1.ELECTRIC SHOCK- The output voltage present in this

equipment can cause a fatal electric shock. This

equipment must be operated by a responsible person.

a. Do not allow anyone to operate the generator without

proper instruction.

b. Guard against electric shock.

c. Avoid contact with live terminals or receptacles.

d. Use extreme care if operating this unit in rain or snow.

e. Use only three-prong grounded plugs and extension

cords.

f. Be sure the unit is properly grounded to an external

ground rod driven into the earth.

2.FIRE HAZARD- Gasoline and other fuels always present a

hazard of possible explosion and/or fire.

a. Do not refuel when the engine is running or hot. Allow

the engine to cool at least two minutes before refueling.

b. Keep fuel containers out of reach of children.

c. Do not smoke or use open flame near the generator set

or fuel tank.

d. Keep a fire extinguisher nearby and know its proper

use. Fire extinguishers rated ABC by NFPA are appropriate.

e. Store fuel only in an approved container, and only in a

well-ventilated area.

3.DEADLY EXHAUST GAS - Exhaust fumes from any gasoline engine contain carbon monoxide, an invisible, odorless and deadly gas that must be mixed with fresh air.

a. Operate only in well ventilated areas. b. Never operate indoors. c. Never operate the unit in such a way as to allow exhaust gases to seep back into closed rooms (i.e. through windows, walls or floors).

4.NOISE HAZARD - Excessive noise is not only tiring, but continual exposure can lead to loss of hearing.

a. Use hearing protection equipment when working around this equipment for long periods of time. b. Keep your neighbors in mind when permanently installing this equipment.

5.CLEANLINESS- Keep the generator and surrounding area clean.

a. Remove all grease, ice, snow or materials that create slippery conditions around the unit. b. Remove any rags or other material that could create potential fire hazards. c. Carefully wipe up any gas or oil spills before starting the unit. d. Never allow leaves or other flammable material to build up around the engine exhaust area.

6.SERVICING EQUIPMENT- All service, including the installation or replacement of service parts, should be performed only by a qualified technician.

a. Use only factory approved repair parts. b. Do not work on this equipment when fatigued. c. Never remove the protective guards, cover, or receptacle panels while the engine is running. d. Use extreme caution when working on electrical components. High output voltages from this equipment can cause serious injury or death. e. Always avoid hot mufflers, exhaust manifolds, and engine parts. They all can cause severe burns instantly. f. Installing a home-standby generator is not a “do-ityourself” project. Consult a qualified, licensed electrician or contractor. The installation must comply with all national, state, and local codes.

INTENDED USES

These engine generator sets have been designed primarily

for portable use. Both 120 and 240 volt AC receptacles are provided in the 'control panel' to plug in your loads (lights, portable tools, and small appliances). These units are dual wound generators, therefore the 120 Volt loads must be equally split with 1/2 of the rated capacity available on each of the two 120 Volt circuits. See unit capabilities for further explanation.

DYNA SERIES

Page 2 60707-101

+ 8 hidden pages

Winco TFLC User Manual

Specifications and Main Features

Frequently Asked Questions

User Manual