Winco PGS-1K Operating Instructions Manual

Page 1
PORTABLE SINGLE-RANGE
GAS STOVE
Operating Instruction Manual
Model
Input
Rating
PGS-1K 9500 BTU /h 155 g / H Butane
BEFORE OPERATING ANY EQUIPMENT, READ AND FAMILIARIZE YOURSELF WITH THESE USE AND SAFETY INSTRUCTIONS
Congratulations on your purchase of this WINCO commercial gas range. WINCO takes pride in the quality of its products. When used as intended and with proper care and maintenance, you will experience years of reliable operation from this equipment. To ensure best results, it is important that you read and follow the instructions in this manual carefully. It’s important to save these instructions for future reference.
Power
(g/H)
Gas
PGS-1K
ermal
Flux
2.5 KW 13"
Width Depth Height
330mm
Dimensions
11"
280mm
4.33"
110mm
Page 2
Portable Single-Range Gas Stove
Important For Future Reference
Please complete this information and retain this manual for the life of the product. For Warranty Service and/or parts, this information is required. Please see page 8 for more information on your Warranty and how to register.
PGS-1K
Model Number Serial Number Date Purchased
WARNING: IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR MAINTENANCE CAN C AUSE
!
PROPERTY DAMAGE, INJURY, OR DEATH. READ THE INSTALLATION, OPERATION, AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERVICING THIS EQUIPMENT.
CAUTION: THESE MODELS ARE DESIGNED, BUILT, AND SOLD FOR COMMERCIAL USE ONLY. IF THESE MODELS
!
ARE POSITIONED SO THE GENERAL PUBLIC CAN USE THE EQUIPMENT, MAKE SURE THAT CAUTION SIGNS, WARNINGS, AND OPERATING INSTRUCTIONS ARE CLEARLY POSTED NEAR EACH UNIT SO THAT ANYONE USING THE EQUIPMENT WILL USE IT CORRECTLY AND NOT INJURE THEMSELVES OR HARM THE EQUIPMENT.
WARNING: A FACTORY AUTHORIZED SERVICE PROVIDER SHOULD HANDLE ALL MAINTENANCE
!
AND REPAIR. FOLLOW THE SERVICE SETUP ARRANGEMENTS BEFORE ATTEMPTING ANY REPAIR OR MAINTENANCE.
AVERTISSEMENT: TouTE INSTAllATIoN, RéglAgE, ModIfIcATIoN, RépARATIoN ou ENTRETIEN INcoRREcT pEuT occASIoNNER dES doMMAgES MATéRIElS, dES blESSuRES gRAVES ou lA MoRT. lIRE lES INTRucTIoNS d'INSTAllATIoN, d'uTIlISATIoN ET d'ENTRETIEN ATTENTIVEMENT AVANT d'INSTAllER ou dE RépARER cET AppAREIl.
ATTENTIoN: cES ModèlES SoNT coNçuS, fAbRIquéS, ET VENduS pouR uN uSAgE coMMERcIAl SEulEMENT. SI cES ModèlES SoNT plAcéS pouR quE lE gRANd publIc puISSE lES uTIlISER, ASSuREz-VouS quE lES coNSIgNES d’ATTENTIoN, d'AVERTISSEMENT, ET lES INSTRucTIoNS d'uTIlISATIoN SoIENT clAIREMENT AffIchéES pRèS dE chAquE uNITé dE SoRTE quE N'IMpoRTE quEl uTIlISATEuR dE l'AppAREIl l'EMploIE coRREcTEMENT ET NE SE blESSE pAS ou N'ENdoMMAgE pAS l'AppAREIl.
AVERTISSEMENT: uN TEchNIcIEN AuToRISé pAR l'uSINE dEVRA EffEcTuER TouT l'ENTRETIEN ET lES RépARATIoNS. AVANT dE fAIRE TouT ENTRETIEN ou RépARATIoN, VEuIllEz coNTAcTER WINco.
!
!
!
Introduction
Congratulations on the purchase of your WINCO machine. Please take the time to carefully read through this manual to ensure the machine is operated and maintained properly, to ensure the best possible performance from this product for many years.
WINCO will not accept liability if:
• The instructions in this manual have not been followed correctly.
• Non-authorized personnel have tampered with the machine.
• Non-original spare parts are used.
• The machine has not been handled and cleaned correctly.
• There is any use damage to the unit.
2
Page 3
Table of Contents
Specications .............................................................................. 1
Warnings ..................................................................................... 2
Introduction ................................................................................ 2
Table of Contents ....................................................................... 3
Packaging .................................................................................... 3
Important Safeguards ................................................................ 4
Cleaning, Care & Maintenance ................................................. 4
Part Identication ....................................................................... 5
Operation .................................................................................... 6
Safety ........................................................................................... 7
Portable Single-Range Gas Stove
Service & Repair .......................................................................... 7
Troubleshooting ......................................................................... 7
Limited Warranty ....................................................................... 8
Package Contents
All units come with an Operating Instruction Manual and the following:
• PGS-1K Portable Single-Range Gas Stove
WINCO prides itself on quality and service, ensuring that at the time of packing, all products are supplied fully functional and free of damage. Should you nd any damage as result of freight, please contact your WINCO dealer immediately.
Unpacking the Equipment
DISPOSE OF ALL PACKAGING MATERIALS IN AN ENVIRONMENTALLY RESPONSIBLE MANNER.
1. Remove all packing materials and tape, as well as any protective plastic and cardboard, from the unit.
2. Clean any glue residue left over from the plastic or tape.
3. Place the unit in the desired position and height.
SAVE THE ORIGINAL BOX AND PACKAGING FOR USE IN PACKAGING AND SHIPPING THE EQUIPMENT IF SERVICES ARENEEDED.
Function and Purpose
This unit is intended to be used for cooking food in commercial food-service operations only. It is not intended for household, industrial or laboratory use.
NOTE
Please remember that this manual and the warning labels do not replace the need to be alert, to properly train and supervise operators, and to use common sense when using this equipment.
3
Page 4
Important Safeguards
Cleaning, Care, Maintenance & Storage
To ensure safe installation and operation, please carefully read and understand the following statements.
Unless the operator is adequately trained and supervised there is a possibility of serious injury. Owners of this equipment bear the responsibility to make certain that this equipment is used properly and safely, and to strictly follow all of the instructions contained in this manual and the requirements of local, state or federal law.
Owners should not permit anyone to touch this equipment unless they are over 18 years old, are adequately trained and supervised, and have read and understood this manual.
Owners should also ensure that no customers, visitors or other unauthorized personnel come in contact with this equipment. It is the responsibility of the owner and the operator to remain alert to any hazards posed by the function of this equipment.
If there is ever uncertainty about a particular task or the proper method of operating this equipment, ask an experienced supervisor.
Warnings
This manual contains a number of precautions to follow to promote safety while using this equipment.
Before using this equipment it must be cleaned and dried thoroughly. Clean all surfaces before use. Failure to clean surfaces before using the unit could cause food contamination.
Turn o and remove the gas canister from the unit and allow all surfaces to cool prior to cleaning and storing. Wipe with a damp cloth with cleanser, dry with a dry cloth.
Avoid using harsh or abrasive chemicals, metal tools or scouring agents as they may cause damage to the appliance or scratch the surfaces.
Never immerse the appliance in water.
Store the gas canister separately from the appliance and it should be kept in a cool, dry place when not in use.
NOTE: Proper cleaning instructions must be followed; otherwise, operation of the unit may be seriously impaired. Do not wash parts in an automatic dishwasher.
Keep the appliance and gas canister away from children.
WARNING AVERTISSEMENT
USE CAUTION WHEN TOUCHING THE UNIT.
HOT
Ne touchez pas le liquide c haud ou les sur faces de chauage lorsque l’appareil chaue ou en fonctionnement.
FOR YOUR SAFETY
Do not store or use gasoline or other ammable vapors and liquids in the vicinity of this or any other appliance.
WARNING
Improper installation, adjustment, alteration, service or
maintenance can cause property damage, injury or death.
Read this installation, operating and maintenance instructions
thoroughly before installing or servicing this equipment.
TO PURCHASER
Contact your local gas supplier and ask instructions in the event
the user smells gas. This information should be posted in a
prominent location.
4
ESURE DE SECURITE
Ne pas entreposer ni utiliser de'essence ni autres vapeurs ou liquides
inammables a proximte de cet appareil ou de tout autre apparel!
AVERTISSEMENT
Linstallation,le reglage,la modication,la reparation ou I'entretien incorrect de cet appareil peut causer des dommages materiels,des
blessures ou la mort.Lire attentivement les instructions
d'installation,de fonctionnement et d'entretien avant de proceder
a son installation ou entretien.
À L'ACHETEU R
CommunIquez avec votre distributeur de gaz et informez vous
quant aux procédés a suivre si vous détectez une odeur de gaz. Cette
information doit etre achée a un endroit facile d'acces et tres visible.
Page 5
Specifications
TYPE Portable Single Range Gas Stove MODEL PGS-1K WEIGHT 3.1 LBS FUEL Direct Pressure Butane Gas GAS CONSUMPTION 155 g/hr SAFETY DEVICE Automatic Gas Shut-O HEAT OUTPUT RATING 9,500 BTU/hr
Part Identification
1. Brass Burner
2. Drip-pan
3. Body
4. Electronic Ceramic Needle
5. Pressure Sensor-Lock Lever
2
3
6. Temperature Control Dial
7. Auto Gas Shut-o Safety Device
8. Valve
9. Side Lid to Canister Compartment
1
9
4
5
8
7
6
5
Page 6
Warning
Improper installation, adjustment, alteration, service, or maintenance can cause property damage, injury, or death. Read the installation, operation, and maintenance instructions thoroughly before installing or servicing this equipment.
IF YOU SMELL GAS: DO NOT ATTEMPT TO LIGHT THIS APPLIANCE AND REMOVE GAS CANISTER.
DANGER : CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide which is a colorless and odorless, potentially deadly gas. DO NOT Operate this appliance in an enclosed space or poorly ventilated space.
Caution Before Using Appliance
1. Read All instructions carefully
2. Inspect the product carefully upon unpacking. Should any part of the gas line or gas can be damaged, please notify the vendor and replace before use. Do not operate with damaged components. A factory authorized service provider should handle all maintenance and repair.
3. Do not touch hot surfaces, particularly ones marked “CAUTION: HOT.” ALWAYS use caution when moving or operating the unit if its containers are holding hot liquid.
4. To protect against re, do not place unit on combustible surface, and do not place ammable materials close to the burner.
5. Do not attempt to disassemble the gas stove; this will void the warranty.
6. Always unlatch the gas can when not in use and turn gas dial to o.
7. Remove gas can and allow to cool before cleaning.
8. When using the product indoors, provide proper ventilation to avoid Carbon Monoxide build up.
9. Do not heat empty containers on this unit.
Operation
10. Place the unit on a at, stable surface. Do not place in, on, or near a hot burner, stove, oven, or any surface that can reach exceedingly hot temperatures.
11. Individuals unfamiliar with or unqualied to operate this machine, such as children, should not operate it without close and proper supervision.
12. Proper cleaning and care of the unit are necessary for the longevity and durability of the machine. Should proper procedures not be undertaken, it may void the warranty.
13. Improper use, handling, or adherence to these instructions or common sense may result in scalding or other injury.
14. When in use, the unit shall have a clearance of 8 inches from any side, and at least 5 feet from the top to any ceiling or covering.
15. Pots/pans shall be a minimum of 6 inches in diameter to be used on this unit.
16. For use with butane gas canisters, Types 2P or 2Q, which have been approved by the D.O.T.
17. Butane canisters are not reusable. Do Not try to rell them. Read the gas canisters caution labels before use.
1. Prior to rst use, carefully unpack the gas stove and inspect it for damage.
2. Place on a level surface away from any other heated surfaces.
3. Flip the burner drip pan so the legs will support a pot/pan above the burner.
4. Open the gas compartment lid and place a butane can with the notch of the upper rim facing up. This notch will t into the spring loaded latch to keep it in place.
5. Press the lock lever down until it locks in place. If the lock lever will not press down, the gas canister is either installed wrong or the gas dial is not in the OFF position.
6
6. If you smell gas or hear leaking gas, do not attempt to light the stove and remove the gas can.
7. Turn the gas dial switch to max and beyond until the dial ‘clicks’ to activate the electric igniter. If the igniter does not light the gas after several attempts, the igniter may be broken or the gas is empty. Turn o immediately to avoid the possibility of releasing excess gas.
8. Ensure to turn the gas dial to “OFF” and the lock lever is in the upward ‘Release’ position when the unit is not in use.
Page 7
Safety
Service and Repair
A WINCO Approved Service Technician should carry out repairs if necessary. Do not remove any components or service panels on this product.
If the power cord is damaged, it must be replaced by a WINCO Approved Service Technician in order to avoid a hazard.
There are no user serviceable parts within this appliance. To avoid serious injury or damage, NEVER attempt to repair the unit yourself.
To initiate warranty service contact: support@wincous.com or call: 973-295-3899
DO NOT send unit to WINCO without rst contacting our customer service department.
See "Limited Warranty" section on page 8 for details.
Troubleshooting
If your WINCO Portable Gas Stove does not operate, please check the following prior to placing a service call.
PROBLEM POSSIBLE CAUSE RECOMMENDED SOLUTION
The gas dial is not in the o position Turn the dial to the o position
Drip pan has not been ipped over Flip the drip pan over
The lock lever won't push down to the LOCK position
The gas canister is incorrect size Only 8oz. butane cans can be used
The gas canister is installed incorrectly The gas can has a small cut along the rim that
needs to be facing upward to align with a spring clip
The gas can is damaged Replace gas can
The gas is leaking after locking (sound or smell). Wiping soapy water on the suspected area(s) will cause bubbles and help determine where the gas is escaping
The burner is not lighting all the way around
Fire looks low or weak
The electric igniter is not working
The ame is too weak
The seal or gas line is damaged Contact your retailer
The gas has been turned on Turn gas dial to the OFF position until ready
for use. DO NOT try starting the gas burner if you can smell or hear gas escaping. Remove butane canister and ventilate the area. Evacuate the immediate area and call for professional help.
The burner may have debris in it After the unit has been turned o and cooled,
try using a toothpick to remove any debris from the burner holes.
Gas is low or almost empty Change gas canister
Debris is blocking the burner or nozzles, or the nozzle is not aligned.
Debris could be blocking the igniter Try cleaning the igniter pin next to the burner.
The igniter has disconnected or is broken The igniter may have moved and is no longer
After the unit has been turned o and cooled, try cleaning the burner and nozzle. The nozzle can be found at the copper tube leading to the bottom of the burner.
sparking the burner. If possible, place in the correct position. Contact your retailer if it has broken.
7
Page 8
Limited Warranty
WINCO warrants to the original purchaser of new equipment that said equipment, when installed in accordance with our instructions within North America and subjected to normal use, is free from defects in material or workmanship for a period of 1 year. The labor warranty is one year from original installation or 18 months from actual factory shipment date, whichever date occurs rst.
THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES, WHETHER EXPRESSED OR IMPLIED. WINCO EXPRESSLY DISCLAIMS ANY IMPLIED WARRANTY OF MERCHANTABILITY OR EXPRESSED OR IMPLIED WARRANTY OF FITNESS FOR A PARTICULAR PURPOSE.
WINCO’S OBLIGATION AND LIABILITY UNDER THIS WARRANTY IS EXPRESSLY LIMITED TO REPAIRING AND REPLACING EQUIPMENT THAT PROVES TO BE DEFECTIVE IN MATERIAL OR WORKMANSHIP WITHIN THE APPLICABLE WARRANTY PERIOD.
IN NO EVENT SHALL WINCO BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES TO BUYER OR ANY THIRD PARTY, INCLUDING, WITHOUT LIMITATION, LOSS OF PROPERTY, PERSONAL INJURY, LOSS OF BUSINESS OR PROFITS OR OTHER ECONOMIC LOSSES, OR STATUTORY OR EXEMPLARY DAMAGES, WHETHER IN NEGLIGENCE, WARRANTY, STRICT LIABILITY, OR OTHERWISE.
This warranty is given only to the rst purchaser from a retail dealer. No warranty is given to subsequent transferees.
Warranty does not cover product failures caused by: failure to maintain, neglect, abuse, damage due to excess water, re, normal wear, improper set up and use. Periodic maintenance is not covered.
REGISTER ONLINE AT:
http://support.wincous.com
Proof of purchase is required to extend warranty more than 1 year from date of shipment from the factory.
THE FOREGOING WARRANTY PROVISIONS ARE A COMPLETE AND EXCLUSIVE STATEMENT BETWEEN THE BUYER AND SELLER. WINCO NEITHER ASSUMES NOR AUTHORIZES ANY PERSONS TO ASSUME FOR IT ANY OTHER OBLIGATION OR LIABILITY IN CONNECTION WITH SAID EQUIPMENT.
Examples of items not covered under warranty, but not limited to just these items:
1. Acts of God, re, water damage, burglary, accident, theft.
2. Freight damage.
3. Improper installation or alteration of equipment.
4. Use of generic or after market parts.
5. Repairs made by anyone other than a WINCO designated service provider.
6. Lubrication.
7. Expendable wear parts, adjustable feet, blown fuses, lamps, etc.
8. Cleaning of equipment.
9. Misuse or abuse.
WARRANTY REGISTRATION
This warranty is not in force until such time as a properly completed and digitally signed Installation/Warranty Registration has been received by WINCO within 30 days from the date of installation.
WARRANTY SERVICE
To initiate warranty service contact: support@wincous.com or call: 973-295-3899
DO NOT send unit to WINCO without rst contacting our customer service department.
Please keep this manual in a safe place for future use!
8
SCAN THE QR CODE WITH YOUR MOBILE DEVICE
or go to
http://support.wincous.com
TO FILL OUT AND SUBMIT YOUR WARRANTY REGISTRATION.
Loading...