WILDWOOD OVENS &BBQ’S MILANO Installation Instructions

MILANO OVEN

INSTALLATION INSTRUCTIONS 4.0

WILDWOOD

5020 EAGLE ROCK BLVD.
LOS ANGELES, CA 90041

TEL. [phone]
FAX. [phone]

www.wildwoodovens.com
info@wildwo

SAVE THESE INSTRUCTIONS!

READ AL
NOT PROPERLY INSTALLED, A FIRE MAY RESULT. TO REDUCE THE RISK OF FIRE, FOLLOW THE
INSTRUCTIONS. A MAJOR CAUSE OF OVEN RELATED FIRES IS FAILURE TO MAINTAIN REQUIRED
CLEARANCES (AIR SPACES) TO COMBUSTIBLE MATERIALS. IT IS OF UTMOST IMPORTANCE THAT
THIS OVEN BE INSTALLED ONLY IN ACCORDANCE WITH THESE INSTRUCTIONS.

WE RECOMMEND THAT YOU CONTACT A LOCAL BUILDING OR FIRE OFFICIAL CONCERNING
ANY INSTALLATION RESTRICTIONS OR NEED FOR INSPECTION OF THE OVEN INSTALLATION
PRIOR TO CONSTRUCTION. THIS OVEN IS TO BE INSTALLED BY A QUALIFIED PERSONNELL ONLY.

OBTAIN THE NECESSARY PERMIT TO CONSTRUCT. IN MOST AREAS THIS WILL INCLUDE A PERMIT
TO CONSTRUCT THE OVEN AND A PERMIT FOR THE EXHAUST SYSTEM. ALL CONSTRUCITON
MUST COMPLY WITH LOCAL BUILDING CODES. WHICHEVER IS MOST RESTRICTIVE MUST BE
FOLLOWED.

TO MAINTAIN THE U.L. LISTING OF THE OVEN THE VENTING APPLICATION MUST BE INSTALLED
PER UL-103 STANDARD AND NEEDS TO BE INSTALLED IN ACCORDANCE WITH THE GUIDELINES
SPECIFIED IN THIS INSTALLATION INSTRUCTION GUIDE.

L INSTUCTIONS BEFORE INSTALLING AND USING THE APPLIANCE. WHEN THIS OVEN IS

OVENS &BBQ’S

odovens.com

TABLE OF

CONTENTS

MILANO O

Oven Base and Enclosure Material List 2

Minimum Clearances 3

Minimum Footprint Requirements 4

Wood-Fired Oven Operating Tips 5

Wood-Fired Oven Maintenance Tips 7

Pre-Construction Checklist 8

ven Kit Parts List 1

Building Foundation and Base 9

Oven Assembly Instructions 11

Roofing and Finishing the Exterior 15

Adapter Plate Installation Diagram 15

Commercial Application 17

Curing the Oven 18

Cooking Pizza in the Oven 19

Using Your Oven 20

Milano

Wood F

Installation Instructions

INSTALLATION INSTRUCTIONS: Failure to follow instructions may result in significant oven damage
and may

void your warranty.

Before you Begin

Oven must

be installed by a licensed contractor knowledgeable of wood fired appliances. This
installation manual is for reference only. Please read this entire manual before installing the oven.
Failure to follow instructions may result in property damage, bodily injury, or even death. Be sure
to place orders early for any items that are necessary to complete your project. It is best to have
everything you need prior to beginning construction.

MILANO OVEN KIT PARTS LIST

ired Oven

Version 4.0

A 2-Pre-cas

t hearth sections

B 4-Pre-cast dome sections and center cap

C 1-Steel oven door (available in stainless steel)

D 4-Tubes Fireplace Mortar *

E 1-Fiber insulation blanket (12 ft roll, 24 in wide)

ADDITIONAL RECOMMENDED MATERIALS:

G 2-1” Thick Heat stopper board (48”x48”)

H 1 Roll of Diamond Lath Mesh (8 ft roll, 27 in wide) ***

• Chimney System customized to fit the oven application (see pg 16

for contact information)

• 1-Tube of high temperature sealant for anchor plate

• 4 concrete screws: ¼” diameter and 2-1/4” long. Use 3/16” drill bit.

• 24-48 Alcohol Can Heat (used for buffet tray warmers) Available at Wildwood!

*Oven has to reach 350 degrees on first initial curing. Never cure an un-insulated oven.

*Fireplace Mortar provided by Wildwood is tested and approved to meet safety standards and therefore must be

the only sealant/adhesive used in oven assembly. Do not use an alternate sealant/adhesive.

*** DIAMOND LATH MESH can be purchased from any local home improvement/hardware store.

©Wildwood Ovens and BBQs LLC 2009 WWW.WILDWOODOVENS.COM 323.255.6587 All specifications subject to change without notice

1

Milano

Wood F

Installation Instructions

OVEN BASE AND ENCLOSURE MATERIAL LIST

ired Oven

Version 4.0

The followi

ng list is provided for your convenience only; the materials are not part of the oven kit.

List may vary depending on construction method.

MASONARY CONSTRUCTION METHOD

FOUNDATION

AND SLAB

 Stakes and forms (for smooth finish melamine can be used to build forms)

 1500 Lb or higher strength concrete mix

 #4 Rebar

WALLS & SHELF

 Forms

 6” x 8” x 16” masonry blocks

 Masonry mortar

 #4 Rebar

 1500 Lb or higher strength concrete mix

 Optional alternative metal stand (contact a wildwood representative for prices)

ROOF

 Non-flam

mable roofing material

CHIMNEY SYSTEM *

 1 Anchor plate for 6” pipe

 1 Double or triple wall chimney pipe (exact length will depend on individual installation

needs)

 1 Chimney cap with spark arrestor

 1 Tube high temperature sealant for anchor plate (withstanding up to 2000 degrees F)

 4 concrete screws. ¼” diameter and 2-1/4” long. Use 3/16” drill bit.

IMPORTANT:

Oven sha

ll only be installed with exhaust hoods constructed in accordance with NFPA 96 or

LISTED building heating appliance chimneys also LISTED as grease ducts.

* Material list for chimney system may vary depending on oven application. Interior installations may require

addition

©Wildwood Ovens and BBQs LLC 2009 WWW.WILDWOODOVENS.COM 323.255.6587 All specifications subject to change without notice

al parts.

2

Milano

Wood F

Installation Instructions

WOOD-FIRED OVEN OPERATING TIPS

WARNING-KEEP THESE INSTRUCTIONS FOR FUTURE REFERENCE

 WOOD-FIRED

PERSONNEL ONLY. INQUIRE ABOUT OUR OVEN OPERATION/COOKING CLASSES AT

WILDWOOD!

 THIS OVEN IS A HIGH HEAT PRODUCING APPLIANCE AND MAY CAUSE SEVERE BURNS IF

TOUCHED DURING OPERATION.

 DO NOT OVERFIRE THE OVEN. IF FLAME SPILLS OUT OR TEMPERATURE EXCEEDS 7

FAHRENHEIT, YOU ARE OVERFIRING. OVER-FIRING CAN CAUSE OVEN DAMAGE AND IS NOT

RECOMMENDED. SPILLAGE OCCURS WHEN FLAME PERMEATES THE CHIMNEY AND THE
OPENING-PHYSICALLY COMING BEYOND THE OPENING FOR THE OVEN DOOR.

 IMPORTANT! A WOOD-FIRE RATED FIRE EXTINGUISHER MUST BE KEPT IN CLOSE

PROXIMITY TO THE OVEN AT ALL TIMES. NOTIFY ALL OVEN OPERATORS ABOUT THE
LOCATION AND USE DURING EMERGENCIES.

 IN CASE OF OVERFIRING THE OVEN, CLOSE DOOR TIGHTLY.

 CAUTION: NEVER USE GASOLINE, GASOLINE-TYPE LANTERN FUEL, KEROSENE,

CHARCOAL LIGHTER FLUID, OR SIMILAR LIQUIDS TO START OR ‘FRESHEN UP’ A FIRE IN
THIS OVEN. KEEP ALL SUCH LIQUIDS WELL AWAY FROM THE OVEN WHEN IN USE.

 WHEN USED INDOORS, PROVISIONS MUST BE MADE TO SUPPLY SUFFICIENT

COMBUSTION MAKE-UP AIR INTO STRUCTURE, WHEN USING THIS OVEN.
COMBUSTION AIR MUST BE SUPPLIED IN ACCORDANCE WITH LOCAL BUILDING
CODES.

 DO NOT ELEVATE THE FIRE. BUILD THE FIRE DIRECTLY ON THE HEARTH.

 DO NOT LEAVE A FIRE UNATTENDED. YOU MUST CLOSE THE OVEN DOOR TIGHTLY TO

EXTINGUISH THE FIRE BEFORE LEAVING OVEN UNATTENED.

OVEN IS INTENDED FOR OPERATION BY TRAINED AND QUALIFIED

ired Oven

Version 4.0

00 DEGREES

©Wildwood Ovens and BBQs LLC 2009 WWW.WILDWOODOVENS.COM 323.255.6587 All specifications subject to change without notice

5