White Lightning WL60520 User Manual

WHITE LIGHTNING® 'One Step' Lightweight Spackling Compound White
Not available. Liquid.
(216) 566-2917
SAFETY DATA SHEET
Section 1. Identification
:
:::
:
White Lightning Products 101 W. Prospect Avenue Cleveland, OH 44115
Relevant identified uses of the substance or mixture and uses advised against
Not applicable.
WL60512-60526
WL60512-60526
:
:
(800) 241-5295
:
(216) 566-2902
:
(800) 424-9300
Section 2. Hazards identification
Not classified.
:
Signal word
:
No signal word.
Precautionary statements
Prevention
:
Not applicable.
Response
:
Not applicable.
Storage
:
Not applicable.
Disposal
Not applicable.
GHS label elements
General
:
Read label before use. Keep out of reach of children. If medical advice is needed, have product container or label at hand.
:
While this material is not considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200), this SDS contains valuable information critical to the safe handling and proper use of the product. This SDS should be retained and available for employees and other users of this product.
:
None known. No known significant effects or critical hazards.
:
Hazard statements
Please refer to the SDS for additional information. Keep out of reach of children. Do not transfer contents to other containers for storage.
Supplemental label elements
WARNING: This product contains a chemical known to the State of California to cause birth defects or other reproductive harm.
:
Date of issue/Date of revision
:
3/2/2018
Date of previous issue
:
1/17/2018
Version
:51/9
WL60512-60526
WHITE LIGHTNING® 'One Step' Lightweight Spackling Compound White
SHW-85-NA-GHS-US
Section 3. Composition/information on ingredients
Glass
≥10 - ≤25
65997-17-3
Ingredient name
CAS number
% by weight
There are no additional ingredients present which, within the current knowledge of the supplier and in the concentrations applicable, are classified as hazardous to health and hence require reporting in this section.
:
Not available.
CAS number/other identifiers
:
Occupational exposure limits, if available, are listed in Section 8.
Mixture
Any concentration shown as a range is to protect confidentiality or is due to batch variation.
Wash out mouth with water. Remove victim to fresh air and keep at rest in a position comfortable for breathing. If material has been swallowed and the exposed person is conscious, give small quantities of water to drink. Do not induce vomiting unless directed to do so by medical personnel. Get medical attention if symptoms occur.
Immediately flush eyes with plenty of water, occasionally lifting the upper and lower eyelids. Check for and remove any contact lenses. Get medical attention if irritation occurs.
Flush contaminated skin with plenty of water. Remove contaminated clothing and shoes. Get medical attention if symptoms occur.
Remove victim to fresh air and keep at rest in a position comfortable for breathing. Get medical attention if symptoms occur.
Section 4. First aid measures
Eye contact Skin contact
Inhalation
Ingestion
:
:
:
:
Protection of first-aiders
:
No action shall be taken involving any personal risk or without suitable training.
Notes to physician
:
Treat symptomatically. Contact poison treatment specialist immediately if large quantities have been ingested or inhaled.
Description of necessary first aid measures
Specific treatments
:
No specific treatment.
Most important symptoms/effects, acute and delayed
Inhalation
:
No known significant effects or critical hazards.
No known significant effects or critical hazards.
:
Ingestion
Skin contact
:
No known significant effects or critical hazards.
No known significant effects or critical hazards.
:
Eye contact
Over-exposure signs/symptoms
Skin contact
Ingestion
Inhalation
No specific data.
No specific data.
No specific data.
:::
Eye contact
:
No specific data.
Potential acute health effects
See toxicological information (Section 11)
Indication of immediate medical attention and special treatment needed, if necessary
Date of issue/Date of revision
:
3/2/2018
Date of previous issue
:
1/17/2018
Version
:52/9
WL60512-60526
WHITE LIGHTNING® 'One Step' Lightweight Spackling Compound White
SHW-85-NA-GHS-US
Section 5. Fire-fighting measures
Promptly isolate the scene by removing all persons from the vicinity of the incident if there is a fire. No action shall be taken involving any personal risk or without suitable training.
Hazardous thermal decomposition products
No specific data.
In a fire or if heated, a pressure increase will occur and the container may burst.
Fire-fighters should wear appropriate protective equipment and self-contained breathing apparatus (SCBA) with a full face-piece operated in positive pressure mode.
Use an extinguishing agent suitable for the surrounding fire.
Extinguishing media
:::
None known.
Suitable extinguishing media
:
Unsuitable extinguishing media
:
:
Section 6. Accidental release measures
Environmental precautions
Personal precautions, protective equipment and emergency procedures
Stop leak if without risk. Move containers from spill area. Prevent entry into sewers, water courses, basements or confined areas. Wash spillages into an effluent treatment plant or proceed as follows. Contain and collect spillage with non-combustible, absorbent material e.g. sand, earth, vermiculite or diatomaceous earth and place in container for disposal according to local regulations (see Section 13). Dispose of via a licensed waste disposal contractor. Note: see Section 1 for emergency contact information and Section 13 for waste disposal.
:
:
No action shall be taken involving any personal risk or without suitable training. Evacuate surrounding areas. Keep unnecessary and unprotected personnel from entering. Do not touch or walk through spilled material. Put on appropriate personal protective equipment.
Avoid dispersal of spilled material and runoff and contact with soil, waterways, drains and sewers. Inform the relevant authorities if the product has caused environmental pollution (sewers, waterways, soil or air).
Large spill
:
Stop leak if without risk. Move containers from spill area. Dilute with water and mop up if water-soluble. Alternatively, or if water-insoluble, absorb with an inert dry material and place in an appropriate waste disposal container. Dispose of via a licensed waste disposal contractor.
Small spill
:
Methods and materials for containment and cleaning up
For non-emergency personnel
For emergency responders
:
If specialized clothing is required to deal with the spillage, take note of any information in Section 8 on suitable and unsuitable materials. See also the information in "For non­emergency personnel".
Section 7. Handling and storage
Advice on general occupational hygiene
Eating, drinking and smoking should be prohibited in areas where this material is handled, stored and processed. Workers should wash hands and face before eating, drinking and smoking. Remove contaminated clothing and protective equipment before entering eating areas. See also Section 8 for additional information on hygiene measures.
:
Protective measures
Put on appropriate personal protective equipment (see Section 8).
:
Precautions for safe handling
Date of issue/Date of revision
:
3/2/2018
Date of previous issue
:
1/17/2018
Version
:53/9
WL60512-60526
WHITE LIGHTNING® 'One Step' Lightweight Spackling Compound White
SHW-85-NA-GHS-US
Section 7. Handling and storage
Store in accordance with local regulations. Store in original container protected from direct sunlight in a dry, cool and well-ventilated area, away from incompatible materials (see Section 10) and food and drink. Keep container tightly closed and sealed until ready for use. Containers that have been opened must be carefully resealed and kept upright to prevent leakage. Do not store in unlabeled containers. Use appropriate containment to avoid environmental contamination. See Section 10 for incompatible materials before handling or use.
:
Glass
NIOSH REL (United States, 10/2016).
TWA: 3 f/cc 10 hours. Form: Fibers of spec length TWA: 3 f/cc 10 hours. TWA: 5 mg/m³ 10 hours. Form: Total
ACGIH TLV (United States, 3/2016).
TWA: 5 mg/m³ 8 hours. Form: Inhalable fraction TWA: 1 f/cc 8 hours. Form: Respirable fibers: length greater than 5 uM; aspect ratio equal to or greater than 3:1 as determined by the membrane filter method at 400-450X magnification (4-mm objective) phase contrast illumination.
Section 8. Exposure controls/personal protection
Ingredient name
Exposure limits
Safety eyewear complying with an approved standard should be used when a risk assessment indicates this is necessary to avoid exposure to liquid splashes, mists, gases or dusts. If contact is possible, the following protection should be worn, unless the assessment indicates a higher degree of protection: safety glasses with side­shields.
Eye/face protection
:
Emissions from ventilation or work process equipment should be checked to ensure they comply with the requirements of environmental protection legislation. In some cases, fume scrubbers, filters or engineering modifications to the process equipment will be necessary to reduce emissions to acceptable levels.
:
Good general ventilation should be sufficient to control worker exposure to airborne contaminants.
Wash hands, forearms and face thoroughly after handling chemical products, before eating, smoking and using the lavatory and at the end of the working period. Appropriate techniques should be used to remove potentially contaminated clothing. Wash contaminated clothing before reusing. Ensure that eyewash stations and safety showers are close to the workstation location.
Hygiene measures
:
Control parameters
Individual protection measures
Occupational exposure limits (OSHA United States)
Skin protection
None.
Ingredient name
Exposure limits
Occupational exposure limits (Canada)
:
None.
Ingredient name
Exposure limits
Occupational exposure limits (Mexico)
Date of issue/Date of revision
:
3/2/2018
Date of previous issue
:
1/17/2018
Version
:54/9
WL60512-60526
WHITE LIGHTNING® 'One Step' Lightweight Spackling Compound White
SHW-85-NA-GHS-US
Section 8. Exposure controls/personal protection
Hand protection
Based on the hazard and potential for exposure, select a respirator that meets the appropriate standard or certification. Respirators must be used according to a respiratory protection program to ensure proper fitting, training, and other important aspects of use.
Chemical-resistant, impervious gloves complying with an approved standard should be worn at all times when handling chemical products if a risk assessment indicates this is necessary.
Respiratory protection
: :
Body protection
Personal protective equipment for the body should be selected based on the task being performed and the risks involved and should be approved by a specialist before handling this product.
:
Other skin protection
:
Appropriate footwear and any additional skin protection measures should be selected based on the task being performed and the risks involved and should be approved by a specialist before handling this product.
Section 9. Physical and chemical properties
Physical state
Liquid.
Not available.
0.52
1 [Air = 1]
2.3 kPa (17.5 mm Hg) [at 20°C]
Not available.
Not available.
Not available.
Color
0.09 (butyl acetate = 1)
Not available.
Closed cup: >93.3°C (>199.9°F)
Not available.
8.5
Kinematic (40°C (104°F)): >0.205 cm2/s (>20.5 cSt)
Not available.
:::
:
:
:
:
:
:::
:
:
:
:
Appearance
:
100°C (212°F)
:
Not available.
:
Not available.
:
Not available.
Heat of combustion
:
0.589 kJ/g
Aerosol product
:
Not applicable.
Section 10. Stability and reactivity
No specific data.
The product is stable.
No specific data.
:
:
Incompatible materials
:
:
Under normal conditions of storage and use, hazardous reactions will not occur.
:
No specific test data related to reactivity available for this product or its ingredients.
Date of issue/Date of revision
:
3/2/2018
Date of previous issue
:
1/17/2018
Version
:55/9
WL60512-60526
WHITE LIGHTNING® 'One Step' Lightweight Spackling Compound White
SHW-85-NA-GHS-US
Section 10. Stability and reactivity
Under normal conditions of storage and use, hazardous decomposition products should not be produced.
:
Section 11. Toxicological information
Acute toxicity
Not available.
Carcinogenicity
Not available.
Mutagenicity
Not available.
Teratogenicity
Not available.
Reproductive toxicity
Not available.
Irritation/Corrosion
Not available.
Sensitization
Not available.
Specific target organ toxicity (single exposure)
Specific target organ toxicity (repeated exposure)
Not available.
Not available.
Aspiration hazard
Not available.
Information on toxicological effects
Classification
Glass
-3-
Product/ingredient name
NTP
IARC
OSHA
Inhalation
:
No known significant effects or critical hazards.
No known significant effects or critical hazards.
:
Ingestion
Skin contact
:
No known significant effects or critical hazards.
No known significant effects or critical hazards.
:
Eye contact
Symptoms related to the physical, chemical and toxicological characteristics
Skin contact
Ingestion
Inhalation
No specific data.
No specific data.
No specific data.
:::
Eye contact
:
No specific data.
Delayed and immediate effects and also chronic effects from short and long term exposure
:
Not available.
Potential acute health effects
Date of issue/Date of revision
:
3/2/2018
Date of previous issue
:
1/17/2018
Version
:56/9
WL60512-60526
WHITE LIGHTNING® 'One Step' Lightweight Spackling Compound White
SHW-85-NA-GHS-US
Not available.
No known significant effects or critical hazards.
General
:
No known significant effects or critical hazards.
Carcinogenicity
:
No known significant effects or critical hazards.
Mutagenicity
:
No known significant effects or critical hazards.
Teratogenicity
:
Developmental effects
:
No known significant effects or critical hazards.
Fertility effects
:
No known significant effects or critical hazards.
Potential chronic health effects
Numerical measures of toxicity
Not available.
Acute toxicity estimates
Potential immediate effects
:
Not available.
Short term exposure
Potential delayed effects
:
Not available.
Potential immediate effects
:
Not available.
Long term exposure
Potential delayed effects
:
Not available.
Section 12. Ecological information
Bioaccumulative potential
:
No known significant effects or critical hazards.
Not available.
Toxicity
Not available.
Persistence and degradability
Soil/water partition coefficient (KOC)
:
Not available.
Mobility in soil
Not available.
Section 13. Disposal considerations
The generation of waste should be avoided or minimized wherever possible. Disposal of this product, solutions and any by-products should at all times comply with the requirements of environmental protection and waste disposal legislation and any regional local authority requirements. Dispose of surplus and non-recyclable products via a licensed waste disposal contractor. Waste should not be disposed of untreated to the sewer unless fully compliant with the requirements of all authorities with jurisdiction. Waste packaging should be recycled. Incineration or landfill should only be considered when recycling is not feasible. This material and its container must be disposed of in a safe way. Empty containers or liners may retain some product residues. Avoid dispersal of spilled material and runoff and contact with soil, waterways, drains and sewers.
:
Date of issue/Date of revision
:
3/2/2018
Date of previous issue
:
1/17/2018
Version
:57/9
WL60512-60526
WHITE LIGHTNING® 'One Step' Lightweight Spackling Compound White
SHW-85-NA-GHS-US
Section 14. Transport information
-
-
-
-
-
-
Not regulated.
Not regulated.
-
-
DOT
Classification
IMDG
UN number
UN proper shipping name
Transport hazard class(es)
Packing group
Additional information
Environmental hazards
No.
No. Not available.
:
Proper shipping name
:
Ship type
:
Not available.
Pollution category
:
Not available.
Not available.
:
TDG
Classification
Not regulated.
-
-
-
No.
-
Mexico
Classification
Not regulated.
-
-
-
No.
-
Multi-modal shipping descriptions are provided for informational purposes and do not consider container sizes. The presence of a shipping description for a particular mode of transport (sea, air, etc.), does not indicate that the product is packaged suitably for that mode of transport. All packaging must be reviewed for suitability prior to shipment, and compliance with the applicable regulations is the sole responsibility of the person offering the product for transport. People loading and unloading dangerous goods must be trained on all of the risks deriving from the substances and on all actions in case of emergency situations.
IATA
Not regulated.
-
-
-
No.
-
Section 15. Regulatory information
SARA 313
SARA 313 (40 CFR 372.45) supplier notification can be found on the Environmental Data Sheet.
WARNING: This product contains a chemical known to the State of California to cause birth defects or other reproductive harm.
California Prop. 65
Section 16. Other information
Hazardous Material Information System (U.S.A.)
0
0
0
/
Health
Flammability
Physical hazards
Caution: HMIS® ratings are based on a 0-4 rating scale, with 0 representing minimal hazards or risks, and 4 representing significant hazards or risks. Although HMIS® ratings and the associated label are not required on SDSs or products leaving a facility under 29 CFR 1910.1200, the preparer may choose to provide them. HMIS® ratings are to be used with a fully implemented HMIS® program. HMIS® is a registered trademark and service mark of the American Coatings Association, Inc.
The customer is responsible for determining the PPE code for this material. For more information on HMIS® Personal Protective Equipment (PPE) codes, consult the HMIS® Implementation Manual.
Date of issue/Date of revision
:
3/2/2018
Date of previous issue
:
1/17/2018
Version
:58/9
WL60512-60526
WHITE LIGHTNING® 'One Step' Lightweight Spackling Compound White
SHW-85-NA-GHS-US
Section 16. Other information
3/2/2018
History
Date of printing
Date of issue/Date of revision
Version
It is recommended that each customer or recipient of this Safety Data Sheet (SDS) study it carefully and consult resources, as necessary or appropriate, to become aware of and understand the data contained in this SDS and any hazards associated with the product. This information is provided in good faith and believed to be accurate as of the effective date herein. However, no warranty, express or implied, is given. The information presented here applies only to the product as shipped. The addition of any material can change the composition, hazards and risks of the product. Products shall not be repackaged, modified, or tinted except as specifically instructed by Sherwin-Williams, including but not limited to the incorporation of non Sherwin-Williams products or the use or addition of products in proportions not specified by Sherwin-Williams. Regulatory requirements are subject to change and may differ between various locations and jurisdictions. The customer/buyer/user is responsible to ensure that his activities comply with all country, federal, state, provincial or local laws. The conditions for use of the product are not under the control of the manufacturer; the customer/buyer/user is responsible to determine the conditions necessary for the safe use of this product. The customer/buyer/user should not use the product for any purpose other than the purpose shown in the applicable section of this SDS without first referring to the supplier and obtaining written handling instructions. Due to the proliferation of sources for information such as manufacturer-specific SDS, the manufacturer cannot be responsible for SDSs obtained from any other source.
Notice to reader
Date of previous issue
:::
:
Key to abbreviations
:
ATE = Acute Toxicity Estimate BCF = Bioconcentration Factor GHS = Globally Harmonized System of Classification and Labelling of Chemicals IATA = International Air Transport Association IBC = Intermediate Bulk Container IMDG = International Maritime Dangerous Goods LogPow = logarithm of the octanol/water partition coefficient MARPOL = International Convention for the Prevention of Pollution From Ships, 1973 as modified by the Protocol of 1978. ("Marpol" = marine pollution) UN = United Nations
3/2/2018
1/17/2018
5
Not classified.
Procedure used to derive the classification
Classification
Justification
Date of issue/Date of revision
:
3/2/2018
Date of previous issue
:
1/17/2018
Version
:59/9
WL60512-60526
WHITE LIGHTNING® 'One Step' Lightweight Spackling Compound White
SHW-85-NA-GHS-US
Loading...