White Lightning WL1111100 User Manual
WHITE LIGHTNING® STOP GAP!™ Minimal Expanding Insulating Foam
Not available.
Spray
(216) 566-2917
SAFETY DATA SHEET
Product name
Other means of
identification
Product type
Emergency telephone
number of the company
Section 1. Identification
:
:::
Manufacturer
:
White Lightning Products
101 W. Prospect Avenue
Cleveland, OH 44115
Relevant identified uses of the substance or mixture and uses advised against
Not applicable.
WL1111100
WL1111100
Product code
:
Product Information
Telephone Number
:
(800) 241-5295
Regulatory Information
Telephone Number
:
(216) 566-2902
Transportation Emergency
Telephone Number
:
(800) 424-9300
Section 2. Hazards identification
FLAMMABLE AEROSOLS - Category 1
GASES UNDER PRESSURE - Compressed gas
ACUTE TOXICITY (inhalation) - Category 4
SKIN CORROSION/IRRITATION - Category 2
SERIOUS EYE DAMAGE/ EYE IRRITATION - Category 2A
RESPIRATORY SENSITIZATION - Category 1
SKIN SENSITIZATION - Category 1
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE) (Respiratory tract
irritation) - Category 3
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE) (Narcotic effects) Category 3
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE) - Category 2
Classification of the
substance or mixture
:
Signal word
:
Danger
Hazard pictograms
:
GHS label elements
Percentage of the mixture consisting of ingredient(s) of unknown oral toxicity: 24%
Percentage of the mixture consisting of ingredient(s) of unknown dermal toxicity: 24%
Percentage of the mixture consisting of ingredient(s) of unknown inhalation toxicity: 10%
OSHA/HCS status
:
This material is considered hazardous by the OSHA Hazard Communication Standard
(29 CFR 1910.1200).
Date of issue/Date of revision
:
9/6/2017
Date of previous issue
:
7/26/2016
Version
:41/13
Section 2. Hazards identification
Precautionary statements
Prevention
:
Wear protective gloves. Wear eye or face protection. Wear respiratory protection.
Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No
smoking. Do not spray on an open flame or other ignition source. Use only outdoors or
in a well-ventilated area. Do not breathe vapor. Wash hands thoroughly after handling.
Contaminated work clothing must not be allowed out of the workplace. Pressurized
container: Do not pierce or burn, even after use.
Response
:
Get medical attention if you feel unwell. IF INHALED: If breathing is difficult, remove
person to fresh air and keep comfortable for breathing. Call a POISON CENTER or
physician if you feel unwell. If experiencing respiratory symptoms: Call a POISON
CENTER or physician. IF ON SKIN: Wash with plenty of soap and water. Wash
contaminated clothing before reuse. If skin irritation or rash occurs: Get medical
attention. IF IN EYES: Rinse cautiously with water for several minutes. Remove
contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get
medical attention.
Storage
:
Store locked up. Protect from sunlight. Do not expose to temperatures exceeding 50
°C/122 °F. Store in a well-ventilated place.
Disposal
Dispose of contents and container in accordance with all local, regional, national and
international regulations.
General
:
Read label before use. Keep out of reach of children. If medical advice is needed, have
product container or label at hand.
Hazards not otherwise
classified
:
None known.
Extremely flammable aerosol.
Contains gas under pressure; may explode if heated.
Harmful if inhaled.
Causes serious eye irritation.
Causes skin irritation.
May cause allergy or asthma symptoms or breathing difficulties if inhaled.
May cause an allergic skin reaction.
May cause respiratory irritation.
May cause drowsiness or dizziness.
May cause damage to organs through prolonged or repeated exposure.
:
Hazard statements
Please refer to the SDS for additional information. Keep out of reach of children. Keep
upright in a cool, dry place. Do not discard empty can in trash compactor.
Supplemental label
elements
DELAYED EFFECTS FROM LONG TERM OVEREXPOSURE. Contains solvents which
can cause permanent brain and nervous system damage. Intentional misuse by
deliberately concentrating and inhaling the contents can be harmful or fatal. VAPOR
AND SPRAY MIST HARMFUL. Gives off harmful vapor of solvents and isocyanates.
DO NOT USE IF YOU HAVE CHRONIC (LONG-TERM) LUNG OR BREATHING
PROBLEMS, OR IF YOU HAVE EVER HAD A REACTION TO ISOCYANATES. USE
ONLY WITH ADEQUATE VENTILATION. WHERE OVERSPRAY IS PRESENT, A
POSITIVE PRESSURE AIR SUPPLIED RESPIRATOR (NIOSH approved) SHOULD BE
WORN TO PREVENT EXPOSURE. IF UNAVAILABLE, AN APPROPRIATE
PROPERLY FITTED APPROVED NIOSH VAPOR/PARTICULATE RESPIRATOR MAY
BE EFFECTIVE. Follow directions for respirator use. Wear the respirator for the whole
time of spraying and until all vapors and mists are gone. If you have any breathing
problems during use, LEAVE THE AREA and get fresh air. If problems remain or
happen later, IMMEDIATELY call a doctor - If not available get emergency medical
treatment. Have this label with you. Reacts with water in closed container to produce
pressure which may cause container to burst.
:
Date of issue/Date of revision
:
9/6/2017
Date of previous issue
:
7/26/2016
Version
:42/13
Section 3. Composition/information on ingredients
Diphenylmethane Diisocyanate Polymer
37.5
9016-87-9
4, 4'-Diphenylmethane Diisocyanate
13.5
101-68-8
Propane
10
74-98-6
2-Methylpropane
10
75-28-5
Dimethyl Ether
4
115-10-6
Ingredient name
CAS number
% by weight
There are no additional ingredients present which, within the current knowledge of the supplier and in the
concentrations applicable, are classified as hazardous to health and hence require reporting in this section.
Other means of
identification
:
Not available.
Substance/mixture
CAS number/other identifiers
:
Occupational exposure limits, if available, are listed in Section 8.
Mixture
Any concentration shown as a range is to protect confidentiality or is due to batch variation.
Get medical attention. If necessary, call a poison center or physician.
Get medical attention.
Wash with plenty of soap and water. Wash contaminated clothing thoroughly with water
before removing it, or wear gloves. Continue to rinse for at least 10 minutes. Get
medical attention. In the event of any complaints or symptoms, avoid further exposure.
If it is suspected that fumes are still present, the rescuer should wear an appropriate
mask or self-contained breathing apparatus. It may be dangerous to the person
providing aid to give mouth-to-mouth resuscitation. Get medical attention. If necessary,
call a poison center or physician. In case of inhalation of decomposition products in a
fire, symptoms may be delayed. The exposed person may need to be kept under
medical surveillance for 48 hours. In the event of any complaints or symptoms, avoid
further exposure.
Section 4. First aid measures
Eye contact
Skin contact
Inhalation
Ingestion
:
:
:
:
Description of necessary first aid measures
Most important symptoms/effects, acute and delayed
Inhalation
:
Harmful if inhaled. Can cause central nervous system (CNS) depression. May cause
drowsiness or dizziness. May cause respiratory irritation. May cause allergy or asthma
symptoms or breathing difficulties if inhaled.
Can cause central nervous system (CNS) depression.
:
Ingestion
Skin contact
:
Causes skin irritation. May cause an allergic skin reaction.
Causes serious eye irritation.
:
Eye contact
Over-exposure signs/symptoms
Inhalation
Adverse symptoms may include the following:
respiratory tract irritation
coughing
wheezing and breathing difficulties
asthma
nausea or vomiting
headache
drowsiness/fatigue
:
Eye contact
:
Adverse symptoms may include the following:
pain or irritation
watering
redness
Potential acute health effects
Date of issue/Date of revision
:
9/6/2017
Date of previous issue
:
7/26/2016
Version
:43/13
Section 4. First aid measures
Protection of first-aiders
:
No action shall be taken involving any personal risk or without suitable training. If it is
suspected that fumes are still present, the rescuer should wear an appropriate mask or
self-contained breathing apparatus. It may be dangerous to the person providing aid to
give mouth-to-mouth resuscitation. Wash contaminated clothing thoroughly with water
before removing it, or wear gloves.
Notes to physician
:
In case of inhalation of decomposition products in a fire, symptoms may be delayed.
The exposed person may need to be kept under medical surveillance for 48 hours.
Specific treatments
:
No specific treatment.
Skin contact
Ingestion
dizziness/vertigo
unconsciousness
No specific data.
Adverse symptoms may include the following:
irritation
redness
:
:
See toxicological information (Section 11)
Indication of immediate medical attention and special treatment needed, if necessary
Section 5. Fire-fighting measures
Promptly isolate the scene by removing all persons from the vicinity of the incident if
there is a fire. No action shall be taken involving any personal risk or without suitable
training. Move containers from fire area if this can be done without risk. Use water
spray to keep fire-exposed containers cool.
Hazardous thermal
decomposition products
Specific hazards arising
from the chemical
Decomposition products may include the following materials:
carbon dioxide
carbon monoxide
nitrogen oxides
Extremely flammable aerosol. Runoff to sewer may create fire or explosion hazard. In
a fire or if heated, a pressure increase will occur and the container may burst, with the
risk of a subsequent explosion. Gas may accumulate in low or confined areas or travel
a considerable distance to a source of ignition and flash back, causing fire or explosion.
Bursting aerosol containers may be propelled from a fire at high speed.
Special protective
equipment for fire-fighters
Use an extinguishing agent suitable for the surrounding fire.
Extinguishing media
:
:
:
None known.
Suitable extinguishing
media
:
Unsuitable extinguishing
media
:
Special protective actions
for fire-fighters
:
Section 6. Accidental release measures
Personal precautions, protective equipment and emergency procedures
:
In the case of aerosols being ruptured, care should be taken due to the rapid escape of
the pressurized contents and propellant. If a large number of containers are ruptured,
treat as a bulk material spillage according to the instructions in the clean-up section.
Shut off all ignition sources. No flares, smoking or flames in hazard area.
For non-emergency
personnel
For emergency responders
:
If specialized clothing is required to deal with the spillage, take note of any information in
Section 8 on suitable and unsuitable materials. See also the information in "For nonemergency personnel".
Date of issue/Date of revision
:
9/6/2017
Date of previous issue
:
7/26/2016
Version
:44/13
Loading...