White Z-165 User Manual

Page 1
Parts Manual
Model
Z-165
IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLY
Warning: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-
WHITE OUTDOOR PRODUCTS COMPANY P.O. BOX 361131 CLEVELAND, OHIO 44136-9722
PRINTED IN U.S.A.
FORM NO. 770-10103A
(5/99)
Page 2
Model Z-165
1
29
23
2
3
20
21
6
24
25
26
22
6
27
6
7
12
28
13
14
4
8
5
9
10
11
16
15
17
18
19
30
31
32
24
37
38
39
6
36
35
33
34
6
25
2
Page 3
REF.
NO.
1 731-3263 Control Handle 2 712-3004A Flange Lock Nut 5/16-18 3 710-0451 Carriage Bolt 5/16-18 4 731-3185 Bellow 5 735-0251 Foot Pad 6 710-0642 Hex Washer Screw 1/4-20 x .75 7 703-2648 Bellow Retainer Bracket 8 712-0431 Flange Lock Nut 3/8-16
9 703-2807B Foot Pad Mounting Bracket 10 710-3168 Carriage Bolt 3/8-16 11 749-3081 Cruise Control Tube 12 703-3288 Control Tube Mounting Bracket 13 710-0276 Carriage Screw 5/16-18 x 1.0 14 731-3283 Consol 15 726-0289 Plug 16 731-3128A Lens 17 736-0242 Bell Washer .340 ID x .872 OD 18 720-0241 Wingnut Knob 19 738-0754 Shoulder Screw 20 720-0302 Knob
PART
NO. DESCRIPTION
REF.
NO.
21 731-3195A LH Control Panel Cover 22 603-0424 LH Control Panel Assembly 23 723-3042 Snap Bushing 24 712-0453 Retainer Nut 1/4-20 25 726-3047 Push Nut 26 728-0117 PopRivet 27 726-0197 Cable Tie 28 703-1345A Key 29 731-3309 Rear Body 30 738-3163A Shoulder Screw 3/8-16 31 736-3039 Flat Washer .406 ID x 1.5 OD 32 731-3318 Floor Body 33 603-0578 Body Plate Assembly 34 703-3474 Body Clip 35 710-0376 Hex Cap Screw 5/16-18 x 1.0 36 703-1345A Key 37 725-3233 Electric PTO Switch 38 731-3196 RH Control Panel Cover 39 603-0425 RH Control Panel Assembly
PART
NO. DESCRIPTION
3
Page 4
Model Z-165
11
5
10
1
3
2
4
6
9
8
12
7
13
14
15
25
7
4
19
20
7
21
22
24
23
9
16
17
18
4
Page 5
REF.
NO.
1 603-0649 Parking Brake Shift Ass’y 2 714-3004 Cotter Pin 3 710-3178 Carriage Bolt 3/8-16 x .75 4 741-0324 Hex Flange Bearing .506 ID x .590 5 703-3400 Brake Mounting Bracket 6 747-3404 Connecting Brake Rod 7 714-0104 Cotter Pin 8 710-0134 Carriage Screw 1/4-20 x .62
9 712-3027 Hex Flange Lock Nut 1/4-20 10 703-3405 Support Plate 11 714-0101 Cotter Pin 12 703-2857 Retaining Rod Bracket 13 732-0827 Torsion Spring 5/16 14 747-3397 Parking Brake Retaining Rod 15 735-0664 Parking Brake Pad 16 603-0683 Brake Rod Ass’y 17 711-3357 Ferrule 18 712-0314 Jam Nut 1/4-28 19 736-0258 Flat Washer .385 ID x 1.0 OD 20 712-0431 Flange Lock Nut 3/8-16 21 747-3266A Bracket Rod 22 732-0463 Extension Spring 23 732-0800 Extension Spring 24 747-3284 Release Pump Rod RH 25 747-3363 Release Pump Rod LH
PART
NO. DESCRIPTION
5
Page 6
Model Z-165
19
9
21
23
14
16
33
8
25
27
5
9
25
27
14
37
33
26
33
1
33
15
10
17
15
17
21
15
21
7
20
36
24
12
14
9
11
10
17
15
28
9
17
6
20
36
23
24
12
21
9
31
2
19
15
19
22
30
15
10
33
9
9
3
33
26
33
4
33
15
18
34
13
32
22
11
29
35
21
13
15
21
18
19
6
Page 7
REF.
NO.
1 603-0340 Bellcrank Ass’y Upper LH 2 603-0341 Bellcrank Ass’y Upper RH 3 603-0342 Bellcrank Ass’y Lower LH 4 603-0343 Bellcrank Ass’y Lower RH 5 603-0647 Support Ass’y Tower 6 603-0410 Rod Ass’y Control RH 7 603-0411 Rod Ass’y Control LH 8 710-0216 Hex Cap Screw 3/8-16 x .75
9 710-3005 Hex Cap Screw 3/8-16 x 1.25 10 710-3178 Carriage Bolt 3/8-16 x .75 11 711-1111 Control Shaft 12 711-1124 Pin 13 712-0312 Hex Jam Nut LH 3/8-24 14 712-0365 Hex Center Lock Nut 15 712-0431 Hex Flange Lock Nut 3/8-16 16 712-0453 Retainer 1/4-20 17 712-0711 Hex Jam Nut 3/8-24 18 712-3001 Hex Jam Nut 3/8-24 19 712-3004A Hex Flange Lock Nut 5/16-18
PART
NO. DESCRIPTION
REF.
NO.
20 714-0104 Cotter Pin 21 723-0420 Spherical Rod End RH 3/8-24 22 723-0421 Spherical Rod End LH 3/8-24 23 727-3113 Damper Cylinder 24 732-3084 Spring Compression 25 736-0169 Lock Washer 3/8 26 736-0539 Thrust Washer .625 ID x 1.12 OD 27 736-3004 Flat Washer .406 ID x .875 OD 28 737-0280 Grease Fitting 29 737-3072 Grease Fitting w/Tube 30 737-3073 Adapter 1/4-20 31 738-0296 Shoulder Bolt .437 Dia. x .268 32 738-3153 Shoulder Bolt 33 741-3063 Sleeve Bearing 34 747-3281 Control Rod LH 31-5/8 35 747-3282 Control Rod RH 35-3/8 36 736-0300 Flat Washer .406 ID x .87 OD 37 703-3405 Support Plate
PART
NO. DESCRIPTION
7
Page 8
Model Z-165
26
25
63
66
61
63 62
65
62
64
22
21
20
44
19
18
14
12
13
3
5
6
1
4
7
11
12
13
2
8
9
10
30
32
36
31
33
35
67
28
27
29
34
37
40
38
41
24
68
23
39
42
43
44
42
45
15
47
16
46
9
49
48
52
51
50
37
17
53
54
55
56
57
58
59
60
8
Page 9
REF.
NO.
1 737-3069 Pipe Plug
2 737-3070A Pipe Dipstick
3 603-0639 Hydraulic Tank Assembly
4 727-3116 Connection Fitting
5 721-0223 Seal
6 738-0940 Drain Plug
7 727-3120 Inlet Tube LH
8 727-3155 Tee Fitting
9 727-3154 Outlet Hose RH 10 727-3121 Inlet Tube RH 11 727-3153 Outlet Hose LH 12 710-0216 Hex Cap Screw 3/8-16 x .75 13 712-0455 Retainer Nut 3/8-16 14 747-3360 Belt Retainer Rod RH 15 710-0378 Hex Cap Screw 5/16-18 x 2.5 16 736-3089 Flat Washer 5/16 17 723-3071 Filter Element 18 731-1449A Fan Blade 19 712-0333 Hex Nut 1/2-20 20 703-3168 Mounting Pulley Bracket 21 756-0625 Roller Cable 22 738-0924 Hex Shoulder Screw 1/4-28 x .375 23 703-3169 Retainer Cable Bracket 24 712-0117 Lock Nut 1/4-28 25 618-3165 Complete Transmission Assembly LH 26 712-3050 Lug Nut 27 710-0347 Hex Cap Screw 3/8-16 x 1.75 28 736-0258 Flat Washer .385 ID x 1.0 OD 29 756-0627 Flat Idler Pulley3.5 OD 30 703-3174 Mounting Bracket Cable 31 712-3019 Hex Nut 7/16-14 32 736-0171 Lock Washer 7/16 33 736-3015 Flat Washer .469 ID x .875 OD 34 603-0377A Idler Arm Assembly
PART
NO. DESCRIPTION
REF.
NO.
35 603-0102 Shoulder Screw 36 732-0478 Extension Spring 6.12 Lg 37 712-0431 Flange Lock Nut 3/8-16 38 712-0138 Hex Nut 1/4-28 39 736-0329 Lock Washer 1/4 40 736-0342 Flat Washer .283 ID x .75 OD 41 710-0428 Hex Cap Screw 1/4-28 x 1.25 42 710-3008 Hex Cap Screw 5/16-18 x .75 43 710-3011 Hex Cap Screw 3/8-16 x 2.25 44 603-0362 Idler Pulley Assembly 5.0” 45 703-2888 Idler Bracket 46 712-3004A Flange Lock Nut 5/16-18 47 710-3103 Hex Cap Screw 5/16-18 x 2.0 48 727-3100 Connection Fitting 1/2 x 3/8 49 603-0358B Skid Plate Assembly 50 747-3361 Belt Rod LH 51 603-0450 Support Pump Assembly 52 710-3178 Carriage Bolt 3/8-16 x .75 53 749-3040 Frame Strut 54 736-0921 Lock Washer 1/2 55 710-1189 Hex Washer Screw #12-24 x .625 56 756-0974 Transmission Pulley 57 732-0729 Wire Ring 58 736-0185 Flat Washer 59 710-3144 Hex Cap Screw 3/8-16 x 2.0 60 618-3164 Complete Tranmission Assembly RH 61 710-0751 Hex Cap Screw 1/4-20 x .62 62 703-2907 Bearing Cup 63 741-0600 Ball Bearing 64 756-3085 Idler Pulley 5.0” 65 712-0324 Hex Lock Nut 1/4-20 66 750-3176 Idler Spacer 67 746-3083 Declutching Cable 68 712-3007 Jam Nut 5/16-18
PART
NO. DESCRIPTION
9
Page 10
Model Z-165
1
4
7
6
3
2
8
2
5
REF.
NO.
1 618-3110A Drive Ass’y Complete 2 712-3004A Hex Flange Lock Nut 5/16-18 3 715-0136 Spirol Pin 3/16 x 1.25 4 717-3396 Spur Gear 14T 5 717-3455 Hydro Transmission 6 718-3053 Parking Brake Lever 7 721-0343 O-Ring 2.0 Dia. 8 727-3125 Cap Nut 3/8
PART
NO. DESCRIPTION
10
Page 11
Model Z-165
4
7
1
3
16
18 5
8
5
17
21
5
5
18
6
REF.
NO.
1 611-3012 Axle Assembly
2 618-3106 Carrier Assembly, Output
3 618-3107 Gear Assembly, 51T Internal & 20T
4 618-3109 Housing Ass’y
5 710-1342 Hex Washer Screw 1/4-20 x 1-1/8
6 711-1048 Brake Shaft
7 712-3027 Hex Flange Lock Nut 1/4-20
8 715-0156 Roll Pin
9 715-0219 Dowel Pin 10 715-3045 Bushing 11 716-3015 Inverted Retaining Ring 12 716-3018 Snap Ring
PART
NO. DESCRIPTION
618-3110A Drive Ass’y Complete 710-0852 Ribbed Neck Stud
20
12
2
13
10
24
9
23
REF.
NO.
13 717-3395 Spur Gear 13T 14 717-3397 Ring Gear 46T 15 719-3114 Axle Outer Housing 16 721-0381 Oil Seal 17 721-0393 Oil Seal 18 727-3124 Elbow Fitting 19 732-0752 Brake Shoe Spring 20 736-0351 Shim Washer .76 x 1.5 x .030
21 741-0665 Needle Bearing 22 741-3033A Ball Bearing 23 741-3080 Needle Bearing 24 761-3049 Shoe Brake
19
14
PART
NO. DESCRIPTION
736-0492 Shim Washer .76 x 1.5 x .010 736-0493 Shim Washer .76 x 1.5 x .020
7
15
22
11
11
Page 12
Model Z-165
19
21
18
20
17
31
49 32
30
35
34
33
7
4 5
6
8
1
42
28
29
25
26
50
9
10
23
49
24
11
12
13
14
15
3
27
51
22
16
35
47
41
38
48
37
36
39
40
2
44
43
45
46
12
Page 13
REF.
NO.
1 HG-70304 Housing Ass’y Upper 2 HG-50301 Lower Housing 3 HG-70299 Center Section Assembly 4 HG-9008000-0128 Lip Seal 5 HG-2003018 Spacer 6 HG-2003016 Wire Retaining Ring 7 HG-2003052 Retaining Ring 8 HG-2003043 Ball Bearing
9 HG-2003023 Cradle Bearing 10 HG-2003087 Variable Swashplate 11 HG-50551 Thrust Bearing 12 HG-50303 Input Shaft 13 HG-2003017 Block Thrust Washer 14 HG-2003014 Block Spring 15 HG-70079 Cylinder Block Assembly 16 HG-70082 Cylinder Block Assembly 17 HG-50304 Output Shaft (Motor) 18 HG-50552 Thrust Bearing 19 741-0361 Ball Bearing 20 HG-2000022 Wire Retaining Ring 21 HG-50329 Retaining Ring 22 HG-50649 Motor Bearing Retaining 23 HG-2000015 Slot Guide 24 HG-2003005 TrunnionArm 25 HG-9008000-0126 Lip Seal
PART
NO. DESCRIPTION
717-3455 Transmission Ass’y Hydro
REF.
NO.
26 HG-45007 Control Arm 27 712-0237 Hex Lock Nut 5/16-24 28 HG-50426 Short Stud 5/16-24 29 HG-50281 Friction Puck 30 HG-2003554 Bypass Plate 31 HG-2003555 Bypass Actuator 32 HG-45074 Lip Seal 33 HG-50270 Bypass Arm 34 HG-44870 Retaining Ring 35 HG-50002 Pin 36 HG-50016 Screw 37 HG-2000029 Charge Relief Spring 38 HG-9001214-2500 Ball 39 HG-50578 O-Ring 40 HG-50331 Gasket 41 HG-44876 Self Tapping Screw 42 HG-9005110-8700 Drain Plug 43 HG-50273 Gerotor Assembly 44 HG-9004101-1340 O-Ring 45 HG-50260 Gerotor Cover 46 HG-50095 Screw 47 HG-50651 Relief Plate 48 HG-50653 Screw 49 HG-50650 Retaining Ring 50 736-0371 Washer 51 HG-50018 Set Screw
PART
NO. DESCRIPTION
13
Page 14
Model Z-165
1
3
4
7
8
19
20
21
2
5
6
17
22
23
11
18
24
16
12
9
10
13
14
15
25
31
35
33
34
37
40
42
41
44
45
43
39
27
12
38
32
36
30
29
26
28
27
14
Page 15
REF.
NO.
1 710-1314 Cap Screw 5/16-18 2 736-0119 Lock Washer 5/16 3 751-0619 Exhaust Pipe 4 710-0642 Hex Washer Screw 1/4-20 x .75 5 721-0208 Exhaust Gasket 6 710-3178 Carriage Bolt 3/8-16 x .75 7 751-3140 Oil Drain 8 751-3142 Oil Drain Cap
9 751B213146 Throttle Clamp 10 710-1237 Hex Washer Screw #10-32 x .625 11 703-3004 Muffler Bracket 12 725-0157 Cable Tie 13 710-3009 Screw #10-24 x .75 14 746-3074 Throttle Cable Control 32” 15 746-3073 Choke Cable Control 32.25” 16 712-0161 Hex Lock Nut #10 - 24 17 751-0617 Muffler 18 749-3048 Fuel Line 19 751-3141 Oil Drain Hose 20 751-0564 Muffler Deflector 21 710-0148 Hex Washer Screw #8-32 x .375 22 726-0205 Hose Clamp 23 751-0535 Fuel Line Hose
PART
NO. DESCRIPTION
REF.
NO.
24 736-0607 Lock Washer 5/16 25 725-1711 Retainer Clip 26 710-0751 Hex Cap Screw 1/4-20 x .620 27 712-0291 Hex Lock Nut 1/4-20 28 736-3006 Lock Washer 1/4 ID x 3/4 OD 29 725-3001 Solenoid 30 736-0270 Bell Washer .265 ID x .75 OD 31 712-0431 Flange Lock Nut 3/8-16 32 603-0317 Clutch Retainer Ass’y 33 736-0258 Flat Washer .385 ID x 1.0 OD 34 747-3362 Rear Belt Retainer Rod 35 736-3010 Flat Washer .407 ID x .812 OD 36 726-3008 Heat Shield Cable Clip 37 710-1007 Hex Washer Screw 3/8-16 x 1.5 38 710-0502A Hex Washer Screw 3/8-16 x 1.25 39 754-3076 V-Belt 40 756-3060 Pulley 41 714-0128 Key 42 717-3467 Electric Clutch 43 750-3106 Spacer Clutch 44 710-0510 Hex Cap Screw 7/16-20 x 3.0 45 736-0171 Lock Washer 7/16
PART
NO. DESCRIPTION
15
Page 16
Model Z-165
2
3
4
29
5
24
22
21
23
17
18
20
19
17
15
16
12
14
13
6
8
11
7
9
10
25
9
26
27
28
16
Page 17
REF.
NO.
1 629-3033 WireHarness, Main - Not Shown
2 723-0455 Foam Protector, Indicator Light 3 710-3013 Hex Cap Screw 1/4-20 x .50 4 703-2809 Bracket, Indicator Bulb Mtg. 5 712-3027 Nut, Hex Flange Lock, 1/4-20 6 725-1718 Relay 7 703-2836 Bracket, Headlight Mtg. 8 710-0134 Carriage Screw 1/4-20 x .62
9 725-3164A Switch, Plunger Safety 10 725-0157 Cable Tie 11 725-1347 Cap, Ignition Switch 12 725-1346 Nut, Ignition Switch, 5/8-32 13 725-3163 Switch, Ignition
PART
NO. DESCRIPTION
629-3037 Wire Harness, Engine 629-3039 Battery Cable, Red 629-3040 Battery Cable, Red 629-3041 Battery Cable, Black
REF.
NO.
14 783-0462 Bracket, PTO Switch Retainer 15 725-1722 Battery 16 725-3253 Switch, Seat 17 712-0397 Nut, Nylon Wing, 1/4-20 18 712-0271 Nut, Hex Sems, 1/4-20 19 710-3015 Screw, Hex Cap, 1/4-20 x .75 GR5 20 703-3149 Strip, Battery Retainer 21 747-3347 Rod, Battery Retainer 22 731-3233 Tray, Battery 23 725-3250 Headlight Assembly
24 731-3184 Bezel, Headlight 25 732-0816 Spring, Switch Mounting 26 710-0425 Screw, Machine, #10-24 x 5/8 27 712-0161 Nut, Hex Insert Lock, #10-24 28 725-3251 Voltage Sensor 29 726-0349 Ratchet Retainer
PART
NO. DESCRIPTION
759-3864 Bulb,Headlight - O nly
17
Page 18
Model Z-165
1
12
2
3
4
5
9
10
11
13
2
4
6
6
5
14
7
8
14
REF.
NO.
1 757-3006 Seat 2 731-3154 Seat Slide 3 738-0372 Shoulder Spacer 4 710-1260A Hex Washer Screw 5/16-18 x .75 5 738-0296 Shoulder Screw 6 712-3004A Flange Lock Nut 5/16-18 7 720-0190 Height Knob 8 732-3098 Spring Index
9 603-0294 Seat Base Bracket Assembly 10 712-3005 Flange Lock Nut 3/8-16 11 732-3080 Compression Spring 12 703-3498 Seat Plate 13 710-0514 Hex Cap Screw 3/8-16 x 1.0 14 710-3105 Bolt 5/16-18 x .875
PART
NO. DESCRIPTION
757-3006 Seat
13
18
Page 19
Model Z-165
10
2
3
8
9
8
7
4
13
1
3
14
15
12
11
REF.
NO.
1 712-0251 Retainer Nut 3/8-16 2 712-0455 Retainer Nut 3/8-16 3 710-0216 Hex Cap Screw 3/8-16 x .75 4 712-0431 Flange Lock Nut 3/8-16 5 710-3144 Hex Cap Screw 3/8-16 x 2.0 6 749-3061 Lower Bumper Tube 7 712-3004A Flange Lock Nut 5/16-18 8 736-0451 Washer.320 ID x .93 OD 9 603-0720 Frame Assembly
10 749-3087 Upper Bumper
PART
NO. DESCRIPTION
7
4
6
REF.
NO.
11 710-1174 Carriage Bolt 5/16-18 x 2.0 12 703-3504 Bumper Bracket 13 710-0521 Hex Cap Screw 3/8-16 x 3.0 14 710-0859 Hex Cap Screw 3/8 - 16 x 2.5 15 719-3130 Counter Weight 16 726-0298 End Cap 17 603-0620 Bumper Ass’y 18 736-3004 Flat Washer .406 ID x .875 OD 19 712-0431 Flange Lock Nut 3/8-16
5
16
17
18
19
PART
NO. DESCRIPTION
19
Page 20
Model Z-165
2
3
4
12
13
5
15
21
21
28
14
16
18
17
20
19
6
7
8
9
10
11
1
27
26
25
24
4
22
23
33
36
35
32
31
30
29
34
37
38
20
39
20
Page 21
REF.
NO.
1 711-0642A Handle Button 2 731-3158 Handle Deck Lift Grip 3 732-3097 Compression Spring 4 747-3405 FrontLift Rod 5 738-0507B Shoulder Screw .500 Dia x .434 6 710-0216 Hex Cap Screw 3/8-16 x .75 7 603-0422 Shaft Mounting Bracket - LH 8 603-0370 Pivot Link Bearing Ass’y
9 603-0313 Lift Shaft Ass’y 10 703-2621 Adjustable Deck Lift Link 11 703-2780 Lift Parallel Link 12 603-0327 Handle Bearing Ass’y 13 703-2772 Deck Height Adjustable Plate 14 738-3150 Lift Handle Shoulder Screw 15 712-3020 Top Lock Jam Nut 3/8-16 16 603-0423 Shaft Mounting Bracket - RH 17 710-3083 Hex Cap Screw5/16-18 x 1.375 18 711-0773 Eye Bolt Adjustable Link 19 738-0380 Shoulder Screw 3/8-16 20 712-0206 Hex Nut 1/2-13
PART
NO. DESCRIPTION
REF.
NO.
21 712-0431 Flange Lock Nut 3/8-16 22 738-3151 Shoulder Screw 3/8-16 .56 x .27 23 712-3015 Jam Nut 5/8-11 24 736-0158 Lock Washer 5/8 25 712-3016 Lock Hex Nut 5/8-11 26 711-3266 Clevis Pin 27 703-3407 Front Lift Bracket 28 603-0401 Lift Arm Ass’y 29 738-0183 Shoulder Screw 3/8-16 .50 x .21 30 603-0257 Fork Lift Ass’y 31 710-3011 Hex Cap Screw 3/8-16 x 2.25 32 747-3276 Lift Link Rod 33 736-0300 Flat Washer .406 x .875 34 747-3267 Handle Arm 35 750-3200 Spacer .448 ID x .688 OD 36 712-0290 Lock Nut 7/16-14 37 712-3009 Hex Center L-Nut 5/16-18 38 710-0431 Hex Screw 3/8-16 x 1.50 39 737-0280 Grease Fitting
PART
NO. DESCRIPTION
21
Page 22
Model Z-165
1
2
3
4
5
12
8
7
6
9 10
11
12
REF.
NO.
1 712-3075 Hex Lock Nut, 1.0-14 2 736-0274 Flat Washer 3 603-0389A Pin Ass’y, Pivot 4 737-3090 Adapter, 1/8 NPTF x 1/8 NPTF 5 737-3072 Grease Fitting, 65° w/Extension 6 712-0431 Hex Flange Lock Nut, 3/8-16 7 712-0229 Push Nut, 3/8 ID 8 710-3178 Carriage Bolt, 3/8-16 x .75 9 710-0514 Hex Cap Screw, 3/8-16 x 1.0
10 736-0169 Lock Washer 3/8
PART
NO. DESCRIPTION
18
15
17
13
2
REF.
NO.
11 712-0239 Hex Center Lock Nut, 1/2-20 12 731-0374 Flange Bearing 1.0 ID 13 737-0280 Grease Fitting 14 603-0363 Castor Wheel Bracket 15 712-0239 Hex Center Lock Nut 1/2-20 16 710-0506 Hex Cap Screw, 1/2-20 x 5.5 17 750-0456 Spacer,.79 ID x .347 Lg ‘ 18 634-3164 Wheel Comp 11.0 x 4.0 x 5.0 19 750-3197 Wheel Spacer
12
14
16
19
17
PART
NO. DESCRIPTION
22
Page 23
Model Z-165
1
2
3
1
4
5
6
7
REF.
NO.
1 710-1260A Hex Washer Screw 5/16-18 x .75 2 651-3004 Tank 4.0 Gal 3 703-3490 Fuel Tank Mounting Bracket 4 712-0431 Flange Lock Nut 3/8-16 5 710-0216 Hex Cap Screw 3/8-16 x .75 6 734-3118 Tire 20.0 x 7.0 x 8.0 7 634-3031 Rim Ass’y 8.0 x 4.85 8 734-0255 Tubeless Air Valve
PART
NO. DESCRIPTION
8
23
Page 24
Model Z-165
1
7
5
44
47
21
48
42
39
43
45
41
38
35
37
40
32
49
33
4
2
3
27
34
36
55
54
52
51
50
25
26
28
29
30
31
17
56
53
4
22
24
57
60
23
21
19
6
59
20
58
63
18
62
4
23
59
17
57
16
2
11
12
13
2
11
10
15
30
29
28
61
9
8
14
27
24
60
Page 25
REF.
NO.
1 732-0556 Extension Spring .94 OD x 7.57 Lg 2 712-3006 Hex Nut 1/4-20 3 710-0597 Hex Cap Screw 1/4-20 x 1.0 4 712-3004A Flange Lock Nut 5/16-18 5 703-2559 Stop Bracket 6 703-2945 LH Pulley Cover 7 754-3091 V-Belt 8 732-0602 Torsion Spring
9 726-0106 Speed Cap Nut 10 710-0751 Hex Cap Screw 1/4-20 x .620 11 736-0270 Bell Washer .265 OD x .75 ID 12 711-0792 Hinge Pin .25 Dia. x 6.75 Lg 13 703-1693 Hinge Mounting Bracket 14 731-1032 Deflector Ass’y Chute 15 603-0316 Deck Ass’y 16 711-3314 Roller Pin 17 731-3005 Roller 18 703-3237 RH Pulley Cover 19 756-3089 Pulley 4.0 Dia 20 710-1336 Spindle Bolt 3/4-16 x 4.25 21 737-3000 Grease Fitting 3/16 22 603-0580 Engag Rod Ass’y 23 618-3129 Deck Spindle Ass’y 24 732-0851A Extension Spring .75 OD x 8.63 Lg 25 738-0213 Shoulder Screw .498 x 1.45 Lg 26 736-0192 Flat Washer .531 OD x .93 OD 27 747-3013 Support Mower Pin 28 715-3003 Spirol Pin 29 732-0802 Compression Spring .63 OD x 6.3 Lg 30 736-0160 Flat Washer .536 ID x .930 OD 31 750-0151 Spacer .550 ID x .750 OD
PART
NO. DESCRIPTION
REF.
NO.
32 711-3358 Deck Roller Pin 33 712-0431 Flange Lock Nut 3/8-16 34 736-0258 Flat Washer .385 OD x 1.0 OD 35 710-3151 Hex Cap Screw 5/8-18 x 4.25 36 756-0627 Flat Idler Pulley 3.5 OD 37 736-0290 Flat Washer 5/8 ID x 1.0 OD 38 741-0524 Bearing .625 ID x 1.574 OD 39 716-3020 Snap Ring 40 712-0239 Lock Nut 1/2-20 41 736-0179 Flat Washer 1/2 ID x 1.25 OD 42 736-0188 Flat Washer .76 ID x 1.49 OD 43 741-0338 Flange Bearing 3/4 ID x .52 Lg 44 732-0850 Extension Spring 1.0 OD x 6.140 Lg 45 750-0656 Spacer .50 OD x .75 ID 47 603-0581 Pivot Arm Pulley Ass’y 48 736-0100 Flat Washer .531 ID x 1.25 OD 49 603-0584 Deck Plate Ass’y 50 736-0187 Flat Washer .64 ID x 1.24 OD 51 710-3037 Hex Cap Screw 3/8-16 x 1.75 52 738-0988 Shoulder Spacer .875 Dia x .245 53 703-3147 Idler Pivot Arm 54 750-3164 Spacer .635 ID x 2.0 Lg 55 756-3103 Pulley 56 754-3092 V-Belt 57 710-1260A Hex Washer Screw 5/16-18 x .75 58 710-3178 Carriage Bolt 3/8-16 x .75 59 748-3065 Deck Spindle Spacer 60 712-3078 Hex Flange Nut 3/4-16 61 742-3033 Blade 62 710-3008 Hex Cap Screw 5/16-18 x .75 63 714-0115 Cotter Pin
PART
NO. DESCRIPTION
IMPORTANT: For a proper working machine, use Factory Approved Parts. V-Belts are specially designed to engage and disengage safely. A substitute (non OEM) V-belt can be dangerous
by not disengaging completely.
NOTE: For painted parts, please refer to the list of color codes below. Please add the applicable color code, wherever needed, to the part number to order a replacement part. For instance, if a part, numbered 700-xxxx, is painted Oyster Gray, the part number to order would be 700-xxxx-0662.
Oyster Gray: 0662
Powder Black: 0637
25
Page 26
26
Page 27
27
Loading...