Whirlpool XCAE2765FQ0 Installation Guide
INSTALLATION INSTRUCTIONS
Before the dryer is removed from service or discarded,
(ORIgINAL INSTRUCTIONS)
CommerCial Washer
INSTRUCTIONS D’INSTALLATION
(INSTRUCTIONS D’ORIgINe)
lave-linge CommerCial
INSTRUCCIONeS De INSTALACIÓN
(INSTRUCCIONeS ORIgINALeS)
lavadora ComerCial
ISTRUZIONI D’INSTALLAZIONe
(ISTRUZIONI ORIgINALI)
lavatriCe CommerCiale
www.whirlpoolcommerciallaundry.comW10837716A
XCAe2765FQ
TABLE OF CONTENTS
Page
Washer Safety .......................................................................... 3
FOR OWNER
General Use Instructions ........................................................ 4
Typical Full Load Sizes ............................................................ 4
Transporting Your Washer ......................................................5
If You Need Assistance or Service ......................................... 5
FOR WHIRLPOOL AUTHORIZED SERVICE PERSON
Tools & Parts ............................................................................ 6
Alternate Parts & Accessories ............................................... 6
Dimensions .............................................................................. 7
Location Requirements ...........................................................8
Installation Instructions .......................................................... 9
Level Washer ..........................................................................10
Connect Drain Hose .............................................................. 11
Drain System .......................................................................... 12
Connect Inlet Hoses .............................................................. 13
Electrical Requirements........................................................14
Complete Installation ............................................................ 15
Installing Coin Slide and Coin Box ....................................... 15
Washer Disposal .................................................................... 16
Warranty ................................................................................. 17
TABLE DES MATIÈRES
Page
Sécurité du lave-linge ........................................................... 18
POUR LE PROPRIÉTAIRE
Instructions de l’utilisation général ..................................... 19
Taille typique des charges complètes ................................. 19
Transport du lave-linge ......................................................... 20
Si vous avez besoin d’assistance ou service ...................... 20
POUR LE PERSONNEL D’ENTRETIEN AUTORISÉ
PAR WHIRLPOOL
Outillage et pièces ................................................................. 21
Pièces supplémentaires et accessoires .............................. 21
Dimensions ............................................................................ 22
Exigences d’emplacement ................................................... 23
Instructions d’installation ..................................................... 24
Établissement de l’aplomb du lave-linge ............................ 25
Raccordement du tuyau de vidange .................................... 26
Système de vidange .............................................................. 27
Raccordement des tuyaux d’arrivée d’eau ......................... 28
Spécications électriques .................................................... 29
Achever l’installation ............................................................. 30
Installation de la glissière et de la boîte à monnaie ........... 30
Élimination du lave-linge ...................................................... 31
Garantie .................................................................................. 32
ÍNDICE
Página
Seguridad de la lavadora ....................................................... 33
PARA EL PROPIETARIO
Instrucciones del uso general ............................................... 34
Tamaños de cargas típicas de volumen completo .............. 34
Transporte de la lavadora ...................................................... 35
Si necesita asistencia o servicio ........................................... 35
PARA EL PERSONAL DE SERVICIO AUTORIZADO
DE WHIRLPOOL
Herramientas y piezas ...........................................................36
Piezas y accesorios alternativos ..........................................36
Dimensiones ...........................................................................37
Requisitos de ubicación ........................................................38
Instrucciones de instalación .................................................39
Nivelación de la lavadora ....................................................... 40
Conexión de la manguera de desagüe ................................. 41
Sistema de desagüe ............................................................... 42
Conexión de las mangueras de entrada ..............................43
Requisitos eléctricos .............................................................44
Complete la instalación ........................................................45
Instalación del tragamonedas y la caja de monedas ..........45
Eliminación de la lavadora ..................................................... 46
Garantía ................................................................................... 47
SOMMARIO
Pagina
Sicurezza della lavatrice ....................................................... 48
PER IL PROPRIETARIO
Istruzioni del uso generale ................................................... 49
Dimensioni tipiche a carico completo ................................. 49
Transporto della lavatrice ..................................................... 50
Se avete bisogno dell’assistenza o servizio ....................... 50
PER IL PERSONALE DI ASSISTENZA
AUTORIZZATO WHIRLPOOL
Attrezzi e componenti ........................................................... 51
Parti e accessori alternativi .................................................. 51
Dimensioni ............................................................................. 52
Requisiti di posizionamento ................................................. 53
Istruzioni d’installazione ....................................................... 54
Livellamento della lavatrice .................................................. 55
Connessione del tubo di scarico ......................................... 56
Sistema di scarico ................................................................. 57
Collegare i tubi d’ingresso .................................................... 58
Requisiti elettrici .................................................................... 59
Completamento dell’installazione ....................................... 60
Installazione dello scivolo monete e della gettoniera ........ 60
L’eliminazione della lavatrice ............................................... 61
Garanzia ................................................................................. 64
2
WASHER SAFETY
Before the dryer is removed from service or discarded,
NOTE: Washer installation and service must be performed by a Whirlpool authorized service person.
IMPORTANT SAFETY INSTRUCTIONS
WARNING: To reduce the risk of re, electric shock, or injury to persons when using the washer, follow
basic precautions, including the following:
n Read all instructions before using the
washer.
n Do not wash articles that have been previously
cleaned in, washed in, soaked in, or spotted
with petrol, dry-cleaning solvents, or other
ammable or explosive substances as they give
off vapours that could ignite or explode.
n Do not add petrol, dry-cleaning solvents, or
other ammable or explosive substances to the
wash water. These substances give off vapours
that could ignite or explode.
n Under certain conditions, hydrogen gas may
be produced in a hot water system that has not
been used for 2 weeks or more. HYDROGEN
GAS IS EXPLOSIVE. If the hot water system
has not been used for such a period, before
using the washer, turn on all hot water taps
and let the water ow from each for several
minutes. This will release any accumulated
hydrogen gas. As the gas is ammable, do not
smoke or use an open ame during this time.
n The appliance must be disconnected from
its power source during service and when
replacing parts. The power cord plug should be
visible at all times once disconnected to verify
that power remains removed.
n This appliance is not intended for use by
children or by persons with reduced physical,
sensory, or mental capabilities, or lack of
experience and knowledge, unless they
have been given supervision or instructions
concerning safe use of the appliance by
persons responsible for their safety. Such
persons must also understand the possible
hazards involved during use.
n The appliance can be used by children age 8
years and above and persons with reduced
physical, sensory, or mental capabilities, or lack
of experience and knowledge if they have been
given supervision or instructions concerning
safe use of the washer, and if they understand
the hazards involved.
n Children of less than 3 years should be kept
away unless continuously supervised.
n This appliance is intended to be used in
household and similar applications such as staff
kitchen areas, shops, ofces, other working
environments, farm houses. It can also be used
by clients in hotels, motels, other residential
type environments, bed and breakfast type
environments, areas for communal use in
blocks of ats, or in launderettes.
SAVE THESE INSTRUCTIONS
3
n No washer can completey remove oil. Do not
dry anything that has ever had any type of oil
on it (including cooking oils). Doing so can result
in death, explosion, or re.
n It is recommended that berglass items not
be washed in coin-operated washers. If these
items are washed in the washer, run the washer
through a complete cycle to rinse away any
residue that might be left in the washer.
n Cleaning and user maintenance by children must
be supervised.
n Do not allow children to play on, in, or with
the washer. Close supervision of children is
necessary when the washer is used near children.
n Before the washer is removed from service or
discarded, remove the door or lid.
n Do not reach into the washer if the basket, tub,
or agitator is moving.
SAVE THESE INSTRUCTIONS
n Do not install or store the washer where it will be
exposed to the weather.
n Do not tamper with controls.
n After installation, access to mains plug or
mains supply via a double-pole switch must
be maintained at all times in order to ensure
immediate deactivation of the washer in case
of emergency.
n Do not repair or replace any part of the washer
or attempt any servicing unless specically
recommended in this manual. You must also
understand these instructions and have the
skills to carry them out.
n See “Electrical Requirements” for grounding
instructions.
GENERAL USE INSTRUCTIONS
n Water pressure of 138–690 kPa (20–100 psi) is needed for
operation of the washer.
n Use new hoses supplied with the washer. Do not reuse old
hoses.
n If the supply cord is damaged, it must be replaced by the
manufacturer, its service agent, or similarly qualied persons
in order to avoid a hazard.
TYPICAL FULL LOAD SIZES
Load Type Loading Suggestion Load Type Loading Suggestion
Mixed Load 3 double sheets
4 pillowcases
6 pair shorts
8 T-shirts
2 shirts
2 blouses
8 handkerchiefs
Permanent Press 2 double or 1 king size sheet
1 tablecloth
1 dress
1 blouse
2 slacks
3 shirts
2 pillowcases
Heavy Work Clothes 3 pair pants
3 shirts
1 coverall
4 pair jeans
1 overall
Knits 3 blouses
4 slacks
6 shirts
4 tops
4 dresses
4
TRANSPORTING YOUR WASHER
WHIRLPOOL® COMMERCIAL LAUNDRY
LIMITED WARRANTY
n Shut off both water faucets. Disconnect and drain water
inlet hoses.
n Disconnect drain from drain system and drain any remaining
water into a pan or bucket. Disconnect drain hose from back
of washer.
n Unplug power cord.
n Place inlet hoses and drain hose inside washer basket.
n Drape power cord over edge and into washer basket.
n Place packing tray from original shipping materials back inside
washer and reuse shipping base to support the motor and tub.
If you do not have original packaging, place heavy blankets
or towels above basket, between the washer top and the tub
ring. Close lid and place tape over lip and down the front of the
washer. Keep lid taped until washer is moved to new location.
IF YOU NEED ASSISTANCE OR SERVICE
Your installation may require additional parts. To order, please contact your authorised commercial laundry distributor from
whom you purchased your washer or an authorised service company.
You will need the washer model number and serial number. Both numbers can be found on the serial-rating plate located
on the washer.
IF YOU NEED SERVICE:
Contact your authorized Whirlpool
visit www.WhirlpoolCommercialLaundry.com.
®
Commercial Laundry distributor. To locate your authorized Whirlpool® Commercial Laundry distributor,
Whirlpool® Commercial Laundry Service Department
For written correspondence:
2000 N M 63
Benton Harbor, Michigan 49022-2632 USA
5
TOOLS & PARTS
Tools Needed:
Level Pliers
14 mm (9/16")
Open-End Wrench
or Adjustable Wrench
Optional tools:
Flashlight Bucket
Parts Supplied:
Utility Knife
Flat-Blade Screwdriver
Water Inlet Hoses (2) Inlet Hose Washers (4)
Drain Hose with Clamp,
U-Form, and Cable Tie
ALTERNATE PARTS & ACCESSORIES
Your installation may require additional parts. To order, please
contact the dealer from whom you purchased your washer
or an authorised service company.
If You Have: You Will Need:
Overhead sewer Standard 76 L (20 gal.) 990 mm
(39") tall drain tub or utility sink,
sump pump, and connectors
(available from local plumbing
suppliers)
1" (25 mm) standpipe 51 mm (2") diameter to
25 mm (1") diameter Standpipe
Adapter Part Number 3363920,
Connector Kit Part Number
285835
Lint clogged drain Drain Protector Part Number
367031, Connector Kit Part
Number 285835
Floor drain system Siphon Break Part Number
285320, Connector Kit (x2) Part
Number 285835, Extension Drain
Hose Part Number 285863
If You Have: You Will Need:
Water faucets beyond
reach of ll hoses
If You Have: You Will Need:
Drain beyond the reach
of drain hose
2 longer water ll hoses:
1.8 m (6 ft.) 90° bend hose
Part Number 76314, 3.0 m (10 ft.)
Part Number 350008
Inlet hoses are sold as a pair
in kit W10575888
Accessories
Washer Drip Trays
Part Number 8212526
Fabric Softener Dispenser Kit
Part Number 63594
1.2 m (4 ft.) Drain Hose Extension
Part Number DRNEXT4
6
Loading...