Whirlpool Maax Pearl Hot Tub User Manual
COMPLETE AND RETURN WARRANTY CARD
(ENCLOSED INSIDE)
Owner's Record
Installation Date:
Installer's Name:
Address:
Telephone:
This information may be required for service and warranty.
URGENT SAFETY INFORMATION A HAZARD THAT WILL CAUSE SERIOUS
INJURY!
IMPORTANT SAFETY INFORMATION A HAZARD THAT MIGHT CAUSE SERIOUS
INJURY!
Information for preventing damage to
equipment.
WHIRLPOOL BATH
OWNER'S MANUAL
Safety, Operation, Maintenance, & Warranty
SAFETY GUIDELINES
This manual contains information for you. This information relates to YOUR SAFETY and will
also help in PREVENTING PROBLEMS. To help you recognize these items of importance, we
will use the following symbols. PLEASE read the manual and pay special attention to these sections.
SAVE THESE INSTRUCTIONS!!!
Model:
Serial #:
IMPORTANT SAFETY INSTRUCTIONS PERTAINING
TO A RISK OF FIRE, ELECTRIC SHOCK, PERSONAL
INJURY OR DAMAGE TO
WHIRLPOOL.
WHEN USING THIS WHIRLPOOL, THESE BASIC
PRECAUTIONS SHOULD BE FOLLOWED:
READ AND FOLLOW ALL INSTRUCTIONS!
The unit must be connected only to a supply circuit that is protected by a ground-fault circuit-interrupter
(GFCI). Such a GFCI should be provided by the installer and should be tested on a routine basis. To test the
GFCI, push the test button. The GFCI should interrupt power. Push the reset button. Power should be restored. If the GFCI
fails to operate in this manner, the GFCI is defective. If the GFCI interrupts power to the bathtub without the test button being
pushed, a ground current is flowing, indicating the possibility of an electric shock. Do not use this hydromassage bath.
Disconnect the hydromassage bath and have the problem corrected by a qualified service representative before using.
(For permanently connected units) Agreen colored terminal (or a wire connector mark “G”, “GR”, “Ground”, or “Grounding”)
is provided within the terminal compartment. To reduce the risk of electric shock, connect this terminal or connector to the
grounding terminal of your electric service or supply panel with a conductor equivalent in size to the circuit conductors supplying this equipment.
Never operate electrically connected devices in or near the bath. Never drop or insert any object into any
opening. Do not use electrical appliances while in the tub.
To r educe the risk of injury, do not permit children to use this unit unless they are closely supervised at all times. Those requiring supervision for any reason, should never be allowed to use the whirlpool unattended.
Use this whirlpool only for its intended use as described in this manual. Do not use attachments not recommended by the manufacturer.
Do not use the whirlpool if the protective cover is not installed on the suction intake. Keep foreign objects, including hair, away
from the suction intake as they could block the intake or get caught in it. For comfort and safety, persons with long hair should
tie their hair up to keep it out of the water and away from the suction fitting. Never place your head below the surface of the
water.
Tampering or modification of this whirlpool by anyone other than an authorized service technician will inval-
idate all warranties.
INSTALLER/OWNER BEARS ALL RESPONSIBILITY FOR COMPLYING WITH ALL STATE AND LOCAL CODES WHEN
INSTALLING THIS UNIT. Access for each pump or blower, approximately 18” x 24” per access, is required to make each pump
or blower available for servicing.
Persons under a doctor's care, pregnant women, persons with high or low blood pressure, heart disease, diabetes, or any serious illness, should not use a whirlpool without prior consultation with their physician. Never use a whirlpool while under the
influence of any drugs or alcohol. The maximum temperature of the water should never exceed 104°F. Hot baths, showers,
saunas or steam baths can put stress on the body.
* To reduce risk of injury, enter and exit the bath carefully.
* Do not fill the tub with water above the air volume controls or overflow.
* Never run the whirlpool without water in the tub.
* Do not bathe pets in your whirlpool. Their hair could clog the pump.
* When filling the whirlpool with water, make sure the temperature does not exceed 104° F (60°C).
* Damage and discoloration of the acrylic surface may occur.
* The whirlpool should be drained after each use.
* The use of oil based additives is not recommended unless
you follow the cleaning instructions outlined in
this book after each use of your whirlpool bath.
* Do not use harsh abrasives or solvents for cleaning your whirlpool.
1
SAVE THESE INSTRUCTIONS
Table of Contents
Important Safety Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Pearl Whirlpool Bath System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Whirlpool Jets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Air Volume Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Safety Suction Return System. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Back Massage System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
PearlAir System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
In-Line Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Skirts. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Mood Light(s) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Bath Waste . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Valve & Hand Held Spray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Whirlpool On/Off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
How To Use Your Whirlpool Bath . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Water Temperature. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Filling the Tub. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Turning on the Whirlpool . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Tuning your Whirlpool for Personal Pleasure. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Bath Additives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Hints from Pearl . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
User Maintenance Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Cleaning the Tub Surface. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Commercial Installation (cleaning) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Cleaning the Pump and Plumbing System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Minor Scratches and Scuffs. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Major Repair to the Surface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Jet Hardware Wrench. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Trouble Shooting Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Description of Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Limited Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Dear Homeowner,
Thank you for choosing Pearl. The minute you sit back and relax in your new bath you'll see and feel the difference.
In your Pearl whirlpool, jets are strategically placed to create a soothing, swirling flow of relaxing water. It's True
Whirlpool
®
action you'll only experience in a Pearl.
Relax and enjoy!! There's only one True Whirlpool
®
Pearl.
Sincerely,
Pearl Baths, Inc.
2
fig. 3
fig. 1
PUMP
Essence - S Designer - S Classic - S
Our commercial quality pump is the heart of your whirlpool system. The pump
is positioned on a specially designed cantilevered mounting base. It helps isolate
and dampen vibration and noise, adding to your comfort and pleasure. The
pump can (at times) take a minute or two to prime and begin water circulation.
PATENTED WHIRLPOOL JETS
Essence - S Designer - S Classic - S
Pearl Whirlpool Bathtubs are not ordinary jetted tubs. Jet location in our tubs is
designed to give you the very best in whirlpool bathing. Shown in fig. 1 is our
Venturi jet. The nozzle is directionally adjustable and turns
over a 30°range.
AIR VOLUME CONTROLS
Essence - S Designer - S Classic - S
Each jet is moving approximately 30 gallons of water per minute. The more air
that is introduced into the flow of water, the deeper the massage. The amount of
air is regulated by the air control knobs. Two air controls, (as shown in fig. 2) are
located inside the tub. One knob controls a single jet. The other controls one or
two whirlpool jets, depending on your model.
Do not fill the tub above the air controls or overflow.
PATENTED SAFETY SUCTION RETURN SYSTEM
Essence - S Designer - S Classic - S
This fitting allows water to return from the tub to the pump. The protective louvered screen prevents foreign objects from entering the pump. Do not use the
whirlpool bath if protective cover is missing. Do not remove the protective
louvered cover (fig. 3). Keep the cover of the return fitting clean. An obstructed
cover reduces the whirlpool action and may cause damage to the pump. To clean,
remove any hair or debris and wash cover with a soft brush and soap. If blockage occurs, such as a foot, or hand too close to the return fitting, the pump instantly disengages and stops the whirlpool action until the obstruction is removed.
Please do not be alarmed. This is a safety feature designed for your protection.
BACK MASSAGE SYSTEM/COMFORT PACKAGE
Essence - S Designer - O* (Selected Models) Classic - O (Selected Models)
* Not
available with PearlAir System
Comprised of six rotating jets on ES and DS (8 on the Andorra), and four rotating
jets on the CS, these ergonomically positioned jets provide a stimulating massage
action to those sore tired muscles. The intensity of these rotating jets can be
adjusted by turning the diverter valve located on the side of the bath (fig. 4).
PEARLAIRTMSYSTEM
Essence - NA Designer - O* (Selected Models) Classic - NA
* Not
available with Back Massage System
Comprised of 10-14 air injectors (depending on the size of the whirlpool) these
strategically placed bottom air jets provide a stimulating massage action. The
system features a variable speed blower.
3
fig. 2
PEARL WHIRLPOOL BATH SYSTEM
Series-S (Standard Feature) O (An Option) NA (Not Available)
Off Position
Note: 1/4 turn to open
back massage jets
fig. 4
IN-LINE HEATER
Essence - S Designer - O* Classic - O
* Not
available with PearlAir System and the Ducetta
The In-Line Heater (fig. 5) is designed to maintain the starting water temperature.
The heater is not a substitute for an adequately sized water heater. Proper water
heater size should be determined by a plumber prior to the whirlpool installation.
During bathing, it is normal to experience an impression that the water is cooling.
This is the result of the body becoming acclimated to the water temperature. You
may want to purchase a water thermometer to verify actual temperature. THE
HEATER MUST HAVE A SEPARATE 20 AMP LINE (GFCI PROTECTED).
High Limit Reset Button
The heater includes an exclusive High Limit Reset. This limit control will not
"false trip" from hot tap water. It will only turn the heater off if the thermostat
fails. See instruction on heater for resetting high limit switch. If the High Limit
trips frequently, call our Technical Service Department (fig. 5).
On/Off Indicator Light
This light turns on when the heater is in operation. When water has reached temperature set on thermostat control, the light will cycle on and off as heater maintains indicated temperature (fig. 5).
Safety Features
In addition to the thermostat control and High Limit Reset Button, the heater is
also equipped with a built-in pressure switch. This switch will not allow the
heater to turn on if the pump is not running.
The thermostat is preset and not adjustable. Water tempera-
ture should never exceed 104° F. (40°C). Prolonged use in
water temperature higher than this could induce hyperthermia. Hyperthermia
occurs when the internal temperature of the body reaches a level several degrees
above the normal body temperature of 98.6°F. The symptoms of hyperthermia
include an increase in the internal temperature of the body, dizziness, lethargy,
drowsiness, and fainting. The effects of hyperthermia include failure to perceive
heat, failure to recognize the need to and the physical inability to exit the tub,
unawareness of impending hazard and fetal damage to pregnant women. The
effects of hyperthermia could include unconsciousness resulting in the danger of
drowning.
The use of alcohol, drugs or medication can greatly increase
the risk of hyperthermia.
fig. 6a
fig. 6c
fig. 6b
4
Skirt with panel
Skirt without panel
fig. 5
SKIRT WITH REMOVABLE PANEL - Field Installed
Essence - NA Designer - NA Classic - O*
* Available on rectangular drop in units.
The front skirt is installed permanently in place by the installer. The panel can be
pulled out (Fig. 6a) to service the pump.
INTEGRAL FLANGE & SKIRT WITH REMOVABLE PANEL
Essence - NA Designer - S* Classic - S**/O***
* Designer Series Models Standard, Metropolitan & Tranquil (Fig. 6c).
** Standard on Classic Series IFS Whirlpool Models.
***An Optional Removable Panel on IFS Tub Only Models (Fig. 6b).
The skirt and panel are standard features on these models. To remove the access
panel, use the supplied suction cup to release one side of the panel at a time. Do
not pull from the center of the panel.
Skirt without panel
Skirt with panel
Loading...