Whalen TEN2PST User Manual

LOT NUMBER:

/ /

DATE PURCHASED:

Tenison 2-pk Stools

Stock # TEN2PST

If you have any questions regarding assembly or if parts are missing, DO NOT return this item to the
store where it was purchased. Please call ou r customer service number and have your instructions and
parts list ready to provide the model name, part name or factory number:

Pacific Standard Time: 8:30 a.m. - 4:30 p.m., Monday to Friday

Or visit our web site 24 hours a day, 7 days a week for product assistance at

Or e-mail your request to [e-mail]

THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT
PLEASE READ AND KEEP FOR FUTURE REFERENCE.

Whalen Furniture Manufacturing Page 1 Factory No. 14697

ADULT ASSEMBLY REQUIRED

866-942-5362

www.whalenstyle.com

SAFETY INFORMATION.

Date 2015-03-03 Rev. 1 Factory: CTHAUP

Stock # TEN2PST

QUALITY GUARANTEE

We are confident that you will be delighted with your Whalen Furniture purchase.
Should this product be defective in workmanship or materials or fail under normal use, we will repair

or replace it for up to one (1) year from date of purchase. Every Whalen Furniture product is designed
to meet your highest expectations. We guarantee that you will immediately see the value of our fine
furniture.

This warranty gives you specific legal rights and you may also have other rights which vary from State
to State.

Customer Service: 866-942-5362

8:30 a.m. - 4:30 p.m., PST, Monday to Friday

www.whalenstyle.com

1. Please read the Assembly Instructions prior to assembling the unit.

2. To avoid damage, assemble the unit on a sturdy, level and non-abrasive surface.

3. Keep all hardware and parts out of the reach of children.

4. Please wait until all steps are completed before fully tightening bolts.

5. Make sure all bolts and screws are tightly fastened before the unit is used.

6. Check that all bolts, screws and knobs are tight at least every 3 months or as needed.

GENERAL INFORMATION, TIPS & TRICKS

Please call for replacement par ts or assis t ance:

866-942-5362

Whalen Furniture Manufacturing Page 2 Factory No. 14697

Stock # TEN2PST

Parts and Hardware List

Please read completely through the instruction s and v erify that all listed parts and hardware are present
before beginning assembly.

A- Seat (2) B- Leg (8)

C- Long Stretcher (4) D-Short Stretcher (4)

(1) Ø5/16" x 2-1/2” Bolt (2) Lock Washer (3) Flat Washer

+1 extra) (16+1 extra) (16+1 extra)

(16

(4) 1-1/2”

Wood Screw (16 +1 extra) Open-end Wrench (1)

Tools required: Open-end wrench (included) and Phillips screwdriver (not included).

Please call for replacement par ts or assis t ance:

866-942-5362

Whalen Furniture Manufacturing Page 3 Factory No. 14697

Stock # TEN2PST

②

Assembly Instructions

ready to assemble. To avoid causing damage to the thread, DO NOT over-tighten the nuts or bolts.

1. Unpack the unit and confirm that you have all the hardware and required parts.

2. Place one Seat (A) upside down on a flat, protected surface as shown.

3. Connect one Short Stretcher (D) between 2 Legs (B) as shown. Make sure the slant holes on the stretcher

will face the floor when the unit is turned upright.

4. Align and attach the leg assembly to the Seat (A) using four 2-1/2” Bolts (1), four Lock Washers (2) and

four Flat Washers (3) as shown. Tighten the bolts with the enclosed open-end wrench.

Ø5/16" x 2-1/2” Bolt

(4 used in this step)

DO NOT fully tighten the bolts or nuts initially until all the bolts or nuts are

①

Lock Washer

(4 used in this step)

Flat Washer

(4 used in this step)

③

Please call for replacement par ts or assis t ance:

Whalen Furniture Manufacturing Page 4 Factory No. 14697

866-942-5362

Stock # TEN2PST

②

Assembly Instru ct i o ns

Ø5/16" x 2-1/2” Bolt

(4 used in this step)

①

Lock Washer

(4 used in this step)

5. Fit 2 Long Stretchers (C) to the mortise of the assembled Legs (B) with the slat holes facing up, as shown.

6. Connect the other 2 Legs (B) with one Short Stretcher (D).

7. Attach the leg assembly to the other end of Seat (A) and insert both Long Stretchers (C) into the mortises

of Legs (B) respectively. Insert four 2-1/2” Bolts (1) with Lock Washers (2) and Flat Washers (3) through
the corner blocks and securely screw into the Legs (B). As shown.

NOTE: DO NOT fully tighten all the bolts until the stool has been adjust and level all the legs so that
they do not wobble. Once adjusted then go back and tighten while making sure that the unit remains level.

Flat Washer

(4 used in this step)

③

Please call for replacement par ts or assis t ance:

866-942-5362

Whalen Furniture Manufacturing Page 5 Factory No. 14697

Stock # TEN2PST

④

Assembly Instru ct i o ns

8. Securely attach Stretchers (C and D) to Legs (B) using two 1-1/2” Wood Screws (4) per stretcher. Fully

tighten the wood screws with a Phillips screwdriver (not included).

9. Stand the assembled unit upright on a flat surface. Press down the seat cushion to even all legs. Now,

tightly fasten all bolts with the enclosed open-end wrench.

10. Repeat the same procedure to assemble the other stool.

1-1/2” Wood Screw
(8 used in this step)

Please call for replacement par ts or assis t ance:

Whalen Furniture Manufacturing Page 6 Factory No. 14697

866-942-5362

Stock # TEN2PST

Care and Maintenance

 Use a soft, clean cloth that will not scratch the surface when dusting.
 Use of furniture polish is not necessary. Should you choose to use polish, test first in an inconspicuous area.
 Using solvents of any kind on your furniture may damage the finish.
 Never use water to clean your furniture as it may cause damage to the finish.
 Always use coasters under beverage glasses and flowerpots.
 Liquid spills should be removed immediately. Using a soft clean cloth, blot the spill gently. Avoid rubbing.
 Always use protective pads under hot dishes and plates. Heat can cause chemical changes that may create

spotting within the furniture finish.

 Stains or marks from crayons or ink markers will be difficult to remove.
 In the event that your furniture is stained or otherwise damaged during use, we recommend that you call a

professional to repair your furniture.

 Check bolts/nuts periodically and tighten them if necessary.

INFORMATION FOR USE

1. This is one type of stool for commercial or home use. Please use it only on smooth, even flooring.

2. Please check that all bolts, screws and knobs are tight at least every 3 months or as needed.

3. If parts are missing, broken, damaged or wrong, please stop using this product until repairs are done by a

trained person.

 Do not stand or step on this stool. Do not use this stool as a stepladder.
 Do not sit on the front edge of the stool.
 Use only for seating, one person at a time.
 Use over smooth, level, seamless surfaces only.
 Do not use this stool unless all bolts, screws and knobs are firmly secured.
 Dispose of packing material properly. Do not use plastic cover as head covering. It may cause suffocation.
 Use this stool for its intended purpose only.
 Use mild detergent only for cleaning.
 Failure to follow these warnings could result in serious injury.
 Maximum load weight 102 kg (225 pounds).

MAXIMUM WEIGHTS INDICATED. USE WITH LOAD HEAVIER THAN THE
MAXIMUM WEIGHTS INDICATED MAY RESULT IN INSTABILITY, CAUSING
POSSIBLE INJURY.

THIS UNIT IS INTENDED ONLY FOR USE WITHIN THE

We hope you enjoy your purchase for many years.

Thank you for your purchase!

Please call for replacement par ts or assis t ance:

866-942-5362

Whalen Furniture Manufacturing Page 7 Factory No. 14697

*TEN2PST-4-SS Short Stretcher *TEN2PST-8-1 1/2WS 1-1/2" Wood Screw

*TEN2PST-CH Complete Hardware *TEN2PST-9-OW Open-end Wrench

*TEN2PST-3-LS Long Stretcher *TEN2PST-7-FW Flat Washer

*TEN2PST-2-L Leg *TEN2PST-6-LW Lock Washer

IF YOU NEED TO ORDER ANY REPLACEMENT PARTS, PLEASE USE THE LIST BELOW

*TEN2PST-1-SFC Seat Frame with Cushion *TEN2PST-5-2 1/2B Ø5/16" x 2-1/2” Bolt

Tenison 2-pk Stools