Wenger Studio Makeup Station Series, 5-light 30-inch Studio Makeup Station, 6-light 36-inch Studio Makeup Station, 8-light 30-inch Studio Makeup Station, 9-light 36-inch Studio Makeup Station International Installation And Owner’s Manual

International Installation and Owner’s Manual

Studio®Makeup Station

International 30-inch Model
International 36-inch Model

©Wenger Corporation 2005 Printed in USA 10/05 Part #187A350-01

Wenger Corporation, 555 Park Drive, P.O. Box 448, Owatonna, Minnesota 55060-0448

Questions? Call.....USA: 01-507-455-4100 • www.wengercorp.com

9-light 36-inch Studio

Makeup Station

CONTENTS

Important User Information . . . . . . . . . . . . . . . . . . . . . . . . . . .2

General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

Manufacturer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

Intended Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

Electrical Rating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

User Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7

Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7

Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8

Electric Receptacle . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9

Mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10

Counter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10

Storage Shelf . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10

Tackboard (36-inch Model Only) . . . . . . . . . . . . . . . . . .11

Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11

Required Tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11

Fasteners and Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . .12

Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12

Fasteners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12

Note: Please read and understand the Studio®Makeup Station Installation and Owner’s Manual

before assembly or installation.

Note: If you need additional information about your Studio Makeup Station, contact the Wenger

Corporation using the information below.

Note: Two people must work together for some assembly steps.
Note: Because wall construction varies, wall anchors are not supplied with the Studio Makeup

Station.

6-light 36-inch Studio

Makeup Station

8-light 30-inch Studio

Makeup Station

5-light 30-inch Studio

Makeup Station

Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

Before Starting the Assembly . . . . . . . . . . . . . . . . . . . . .13

Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

Layout the Space . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

Install the Mounting Bracket . . . . . . . . . . . . . . . . . . . . . .16

Install the First Makeup Station . . . . . . . . . . . . . . . . . . .18

Install Additional Makeup Stations . . . . . . . . . . . . . . . . .22

Complete the Installation . . . . . . . . . . . . . . . . . . . . . . . .22

Attach the Mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23

Attach the Counter . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23

Electrical Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24

Connect the Electrical Source . . . . . . . . . . . . . . . . . . . .24

Wiring Diagram 30-inch Model . . . . . . . . . . . . . . . . . . . .26

Wiring Diagram 36-inch Model . . . . . . . . . . . . . . . . . . . .27

Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28

Broken Mirror Replacement . . . . . . . . . . . . . . . . . . . . . .28

Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29

Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29

Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30

Makeup Station Main Assembly . . . . . . . . . . . . . . . . . . .30

Makeup Station Additional Parts . . . . . . . . . . . . . . . . . . .31

2

GENERAL

Copyright © 2005 by Wenger Corporation

All rights reserved. No part of the contents of this manual may be reproduced, copied, or transmitted in
any form or by any means including graphic, electronic, or mechanical methods or photocopying,
recording, or information storage and retrieval systems without the written permission of the publisher,
unless it is for the purchaser's personal use.

Printed and bound in the United States of America.

The information in this manual is subject to change without notice and does not represent a commitment
on the part of Wenger Corporation. Wenger Corporation does not assume any responsibility for any
errors that may appear in this manual.

In no event will Wenger Corporation be liable for technical or editorial omissions made herein, nor for
direct, indirect, special, incidental, or consequential damages resulting from the use or defect of this
manual.

The information in this document is not intended to cover all possible conditions and situations that
might occur. The end user must exercise caution and common sense when assembling or installing
Wenger Corporation products.
If any questions or problems arise, call Wenger Corporation at 01-507-455-4100.

MANUFACTURER

The Studio Makeup Station is manufactured by:

Wenger Corporation

555 Park Drive

Owatonna, MN 55060

01-507-455-4100

www.wengercorp.com

INSTALLATION

• The Wenger Studio Makeup Station installation must comply with local regulations and codes.

• All personnel (including all temporary workers) installing the Wenger Studio Makeup Station must

read and understand this entire manual.

• Personnel installing the Wenger Studio Makeup Station must comply with the warnings and cautions

in the Safety Section.

• Always refer to the Electrical Installation information when connecting the Studio Makeup Station to

a power source.

INTENDED USE

• The Wenger Studio Makeup Station is intended for indoor use in normal ambient temperature and

humidity conditions — it must not be exposed to outside weather conditions.

• The Wenger Studio Makeup Station is intended to be permanently installed only as described in this

manual.

NOTE: If you decide to contact Wenger Corporation about your Studio Makeup Station, you may need

to find the date of manufacture which is engraved on the steel frame below the Counter.

IMPORTANT USER INFORMATION

3

ELECTRICAL RATING

The Studio Makeup Station outlet ratings are:

IMPORTANT USER INFORMATION CONTINUED

Standard Lamp Load Outlet Rating

W01 German Standard 5-light: 1.25 Ampere

6-light: 1.5 Ampere
8-light: 2.0 Ampere
9-light: 2.25 Ampere

16 Ampere (Max)
250 VAC

W02 Japan Standard 5-light: 2.5 Ampere

6-light: 3.0 Ampere
8-light: 4.0 Ampere
9-light: 4.5 Ampere

15 Ampere (Max)
125 VAC

W03 British Standard 5-light: 1.25 Ampere

6-light: 1.5 Ampere
8-light: 2.0 Ampere
9-light: 2.25 Ampere

13 Ampere (Max)
250 VAC

W04 Chinese Standard 5-light: 1.25 Ampere

6-light: 1.5 Ampere
8-light: 2.0 Ampere
9-light: 2.25 Ampere

10 Ampere (Max)
250 VAC

W05 French Standard (Socket)

German Standard (Plug)

5-light: 1.25 Ampere
6-light: 1.5 Ampere
8-light: 2.0 Ampere
9-light: 2.25 Ampere

16 Ampere (Max)
250 VAC

W06 Australian Standard

New Zealand Standard

5-light: 1.25 Ampere
6-light: 1.5 Ampere
8-light: 2.0 Ampere
9-light: 2.25 Ampere

10 Ampere (Max)
250 VAC

W07 Swiss Standard 5-light: 1.25 Ampere

6-light: 1.5 Ampere
8-light: 2.0 Ampere
9-light: 2.25 Ampere

10 Ampere (Max)
250 VAC

4

The Studio Makeup Station is guaranteed free of defects in materials and workmanship for five full
years.

Our guarantee assures you of either a full refund or repair or replacement of the defective materials or
workmanship without charge, at the discretion of our Customer Service Department. Just call a
Customer Service Representative at 01-507-455-4100 or fax [phone] and state the reason you
are dissatisfied. If a product return is necessary, your representative will issue a return authorization.
This is your sole remedy for breach of this warranty.

Should you have a question or problem with any Wenger product, don’t hesitate to call, even if the
product is past warranty. It’s important to us that all our customers be satisfied.

This is the sole warranty made by Wenger. Wenger disclaims all other warranties, including the
warranties of merchantability and fitness for a particular purpose, as well as all liability for incidental,
consequential, special, and indirect damage. Wenger liability for direct damages shall be limited to the
amount you paid for the product involved. Wenger reserves the right to make product changes without
obligation to incorporate such changes into products previously sold.

Some countries do not allow the exclusion or limitation of damages or warranties, so the above may not
apply to you. This warranty gives you specific legal rights. You may also have other rights which vary
from one legal authority to another legal authority.

WARRANTY

5

Throughout this manual you will find WARNINGS and CAUTIONS which are defined as follows.

• WARNING means that failure to follow the instruction may result in serious injury or death.

• CAUTION means that failure to follow the instruction may result in injury or damage to property.

Read and understand the following Safety Instructions before installing or using the Studio Makeup
Station. Failure to observe these instructions can result in damage to property, serious injury or death!

SAFETY

INSTALLATION

Do not connect the Makeup
Station to an electrical
source until the installation
is complete and the mirror
and counter are in place.

!

WARNING

The Makeup Station must be
permanently connected to a
grounded wiring system.

!

WARNING

Branch circuits must always
be designed by an electrical
engineer and comply with
local electrical regulations
and user requirements.

!

WARNING

Make sure that anyone Installing the
Studio Makeup Station has read and
understands this manual.

!

CA UTION

The 36-inch Studio Makeup Station weighs
about 80 lbs (37 kg) and the 30-inch Studio
Makeup Station weighs about 72 lbs (33 kg)
when completely assembled. Serious injury or
damage to the Station can happen if only one
person attempts to move or lift the Station.
Two people must always work together when
lifting or moving the Studio Makeup Station.

!

CA UTION

Never lift the assembled
Makeup Station by grasping
the wire cages or the Shelf.
Damage to the wire cages
can occur.
Always lift or move the
Station by grasping the steel
frame or the mirror surround.

!

CA UTION

Always wear safety glasses
and safety shoes when
installing the Makeup Station
or when replacing any
broken glass.

!

CA UTION

6

SAFETY CONTINUED

GENERAL

Never pour, spray or splash
liquids onto the lighting or
onto the Mirror Surround.

!

WARNING

Always observe and comply
with the Warnings and
Cautions posted on the
system equipment.

!

CA UTION

MAINTENANCE

Never insert any object into
the lampholders other than
the recommended bulbs.

!

WARNING

Always use the Makeup
Station only for its intended
purpose as described in
these instructions.

!

CA UTION

Always use only 60 watt or
smaller incandescent bulbs
or 15 watt swirl fluorescent
bulbs.

!

CA UTION

Never hang anything near the
light bulbs or from the light
bulb cages.

!

CA UTION

Never leave appliances
plugged into the Makeup
Station operating and
unattended.

!

CA UTION

Never plug appliances into
the Makeup Station electrical
outlets that will exceed the
current capacity of the
circuit.

!

CA UTION

Never sit or stand on the
Makeup Station counter.

!

CA UTION

Never place items heavier
than 75 lbs (35 kg) onto the
Makeup Station Counter.

Never place items heavier
than 25 lbs (12 kg) onto the
Makeup Station Shelf.

!

CA UTION

Always provide adult
supervision when children
use the Makeup Station.

!

CA UTION

Do not alter the electrical
circuits without the
expressed permission of
Wenger Corporation.

!

WARNING

Replace any broken light
bulbs immediately.
Always turn the light switch
off before changing bulbs.

!

CA UTION

Replace any malfunctioning
electrical components only
with components with the
same specification.

!

WARNING

Always disconnect power to
the Makeup Station before
cleaning.

!

CA UTION

Replace the Mirror
immediately if it is cracked or
broken.

!

CA UTION

7

USER INSTRUCTIONS

DESCRIPTION

The Studio Makeup Station is intended to provide the necessary elements to apply makeup or create
special visual effects. It has the following features.

1. Lighting that is bright and untainted in color.

2. An electrical outlet for makeup appliances.

3. A large mirror.

4. A storage shelf that also is a light diffuser.

5. A counter with ample elbow room and a light-diffusing surface.

6. A tackboard (36-inch Models only) for makeup design renderings, schedules, etc.

Shelf

Tackboard

Electrical Outlet

Mirror

The Studio Makeup Station can be installed as a single unit or in a row of two or more Stations. Each
Station, whether a single unit or a row, has the features outlined above.

9-light Studio Makeup Station

9-light or 8-light Studio Makeup Station

6-light or 5-light Studio Makeup Station

Lights

The Makeup Station on the right is always a 9­light or 8-light Station. All others in a row are
6-light or 5-light Stations.

Counter

8

USER INSTRUCTIONS CONTINUED

LIGHTING

Light bulbs are not supplied with the Studio Makeup Station. The end user should choose the light bulb
that is best suited for the Makeup Station use. For accurate color rendering, Wenger Corporation
recommends either of the following.

• GE Reveal

®

60 watt or GE Reveal® 40 watt incandescent bulbs or equivalent.

• Full-spectrum, 15-watt, swirl fluorescent bulbs.

NOTE: Studio Makeup Stations manufactured for 125 VAC power sources (W02 - Japan Standard)

require bulbs with E26 bases. Stations with 250 VAC power sources require bulbs with E27
bases.

Configurations

• Each 5-light Studio Makeup Station has five lights, three on the left and two on the top. The Light

Switch on the lower left of the Mirror turns the lights on and off.

• Each 8-light Studio Makeup Station has eight lights, three on the right, two on the top and three on

the left side. The Light Switch on the lower left of the Mirror turns the lights on and off.

• Each 6-light Studio Makeup Station has six lights, three on the left and three on the top. The Light

Switch on the lower left of the Mirror turns the lights on and off.

• Each 9-light Studio Makeup Station has nine lights, three on the right, three on the top and three on

the left side. The Light Switch on the lower left of the Mirror turns the lights on and off.

NOTE: When a 9-light Station and a 6-light Station are adjacent to each other, they share the

9-light Station left column of lights.

Electrical Outlet and Light Switch

9-light 36-inch Studio

Makeup Station

6-light 36-inch Studio

Makeup Station

8-light 30-inch Studio

Makeup Station

5-light 30-inch Studio

Makeup Station

Always use only 60 watt or
smaller incandescent bulbs
or 15 watt swirl fluorescent
bulbs.

!

CA UTION

Never hang anything near the
light bulbs or from the light
bulb cages.

!

CA UTION

9

USER INSTRUCTIONS CONTINUED

LIGHTING CONTINUED

Refer to the illustration below describing the light switch function.

If this Station is used, it is necessary to
turn on the lights for this Station and the
Station immediately to the right.

This column of light is common to both
Stations and is controlled by the Station
to the right.

ELECTRIC RECEPTACLE

An electrical receptacle is located on the lower left of the Mirror on each Makeup Station.
Additional appliances can plug into this receptacle.

Typical Receptacle

(W06 - Australian/New Zealand Standard

Receptacle is shown)

Rocker Switch

Never pour, spray or splash
liquids onto the lighting or
onto the Mirror Surround.

!

WARNING

Never plug appliances into
the Makeup Station electrical
outlets that will exceed the
current capacity of the
circuit.

!

CA UTION

Never plug a device with
faulty wiring into the Makeup
Station electrical outlets.

!

CA UTION

10

USER INSTRUCTIONS CONTINUED

MIRROR

The Studio Makeup Station Mirror is shatter-resistant and shatter-controlled. It is not unbreakable.

NOTE: Refer to page 28 for instructions regarding replacing a broken mirror or call Wenger Corporation

Customer Service.

COUNTER

• The Counter surface is matte white for light diffusion and is mar and stain resistant. The surface can

withstand the operating temperatures typical of the dressing room environment.

• Refer to the Maintenance Section on page 27 regarding cleaning the Counter surface.

• The Counter will support loads up to 75 lbs (34 kg).

STORAGE SHELF

The Shelf is suitable for storage of wigs, hats, makeup kits, etc.

• The Shelf surface is matte white for light diffusion and is mar and stain resistant. The surface can

withstand the operating temperatures typical of the dressing room environment.

• The Shelf will support loads up to 25 lbs (12 kg).

• Refer to the Maintenance Section on page 27 regarding cleaning the Shelf surface.

Never strike the mirror. Never
han le broken mirror with bare
hands. Use Caution when
replacing a broken mirror.

!

CA UTION

Never place items or
materials directly on the
Counter surface tht could
scratch, burn or cause
damage to the surface.

!

CA UTION

Never place items heavier
than 75 lbs (35 kg) onto the
Makeup Station Counter.

!

CA UTION

Always use only 60 watt or
smaller incandescent bulbs
or 15 watt swirl fluorescent
bulbs.

!

CA UTION

Never sit or stand on the
Makeup Station counter.

!

CA UTION

Never place items or
materials directly on the
Counter surface tht could
scratch, burn or cause
damage to the surface.

!

CA UTION

Never place items heavier
than 25 lbs (12 kg) onto the
Makeup Station Shelf.

!

CA UTION