Wells WVOC-2HFG, WVOC-2HSG User Manual

WELLS BLOOMFIELD, LLC

2 ERIK CIRCLE, P. O. Box 280 Verdi, NV 89439

telephone: 775-689-5703

fax: 775-689-5976

www.wellsbloomfield.com

PARTS LIST

PL505

505

WVOC-2HFG WVOC-2HSG

VENTLESS CONVECTION OVEN

WITH GRIDDLE/HOTPLATE COOKTOP

CONTENTS

Description page

Parts List ………………………………………………….. 2 WVOC-2H(F)(S)G Hood Section Cabinet ………………………………………………… 4 Hood Electrical and Vacuum ……………………….. 5 WVOC-2H(F)(S)G Convection Oven Section Cabinet Components …………………………………. 6 Electrical Components ………………………………. 7 WVOC-2H(F)(S)G Cooktop Components ……………… 8

Ansul© Fire Detection & Suppression ………………..... 9

PRINTED IN UNITED STATES OF AMERICA

p/n PL505 Rev. D 080602 cps

PART # DESCRIPTION

OPTIONAL ACCESSORIES

20804 SET, CASTER, (2 FIXED, 2 SWIVEL) 21375 SUPPORT, OVEN RACK (M4200) 21376 RACK, OVEN (M4200) 22617 LEG, ADJ. (pk 2) 22618 PREFILTER 22619 FILTER PACK 22682 POWER CORD NEMA 15-60P 4’ 22683 CAGE, PRE-FILTER 22684 GREASE BAFFLE (TYPE 3)

LITERATURE & DOCUMENTATION

302731 PLUMBING LAYOUT, VAC 302796 GLD VENTLESS SYS WOV-2HG 302874 ANSUL FIRE SUPPRESSION SYS 304350 INSTR INSTALL LEGS 304906 DIA WIRING WVOC-2HG 208/240V 3P 304963 OPMANUAL WVOC-2HG-SERIES 304982 SCHEMATIC WIRING WVOC

SV505 SERVICE MANUAL WVOC-2HG

PART # DESCRIPTION

MECHANICAL

51968 CLAMP, ELEM CTR SMALL GRIDDLE 51969 CLAMP, ELEM END SMALL GRIDDLE 51973 HANDLE, DOOR 53302 SEALANT 1/4x37 LONG 53474 CLIP, TIE-DOWN INSUL (pk 12) 53948 PANEL, FRONT GREASE DRAWER 55677 BRKT ELEM MTG RW 57407 INSUL FG (1” x 2ft x 4ft) 57748 FITTING, CONDUIT STRAIGHT 3/8 63738 BOOT, ROCKER SWITCH 63787 BRACKET, PROX.SWITCH 63797 WHEEL, BLOWER 63804 TRIM, LOWER FRONT 63817 GASKET, OVEN DOOR TOP&BTM 63918 GASKET, OVEN DOOR SIDES 63836 COVER, ELEM GASKET, INNER 63837 COVER, ELEM GASKET, OUTER 63889 CLIP, RACK SUPPORT (M4200) 63896 DOOR HINGE, BOTTOM ASSY 63899 PLATE, DOOR PIVOT 63900 SLEEVE, DOOR HINGE 63948 MAGNET, PERMANENT OVEN DOOR 65278 ASSEMBLY, GREASE TRAY 65644 KNOB, BLACK LLSC 65647 SHIELD, PROX. SWITCH 65653 KNOB, OVEN CONTROLLER 67439 KNOB OC-1 RS 68746 ADAPTER BAYONET 3/8-24x7/8 68989 GASKET, CLOSE CELL (rl 50ft)

PART # DESCRIPTION

MECHANICAL

500356 KNOB, BLACK (NOTE: GRAY OBS) 500984 SPACER, LATCH STRIKE PLATE 501389 REMOTE PULL STA ASSY 501451 BKT, SOLID ELEMENT HOLD-DOWN 501774 ASSEMBLY, GREASE DRAWER 502588 TUBING ASSY VACUUM UNIV HOOD 502772 GASKET SILICONE .25X.5X15.25 502773 GASKET SILICONE .25X.5X18.5 502782 FACEPLATE FRNT PNL UNIV HOOD 503252 GASKET, CLOSED CELL, OVEN POT 504112 LINK, FUSIBLE TYPE B 212ºF 504184 KIT, CONTROLLER SHIELD 504405 GREASE TRAY, HOOD DRIP 504444 ASSEMBLY, OVEN DOOR 504724 OVERLAY, CONTROL PANEL OC-1 505099 GLASS GLOBE VCS HOOD 505610 PIN, DOOR HINGE 505612 HANDLE, DOOR (M4200) 505615 ASSEMBLY, DOOR LATCH 505616 STRIKER, DOOR LATCH 505619 BUSHING, UPPER DOOR HINGE

PL505 Service Parts List for WVOC-2H Ventless Cook Center

PART # DESCRIPTION

ELECTRICAL

50131 TERMINAL BLOCK 3P 85A 50293 ELEM, SPIRAL HOTPLATE 240V 50496 ELEM, GRIDDLE 240V 2250W 50516 LIGHT, INDICATOR AMBER 240V 50562 INF. SWITCH 240V HOTPLATE 50516 LIGHT, SIGNAL AMBER 240V 51157 LIGHT, INDICATOR RED 240V 52054 JUMPER, ELEM SHORT GRIDDLE 53068 TERMINAL BLOCK 2P (FIRE ALARM) 54005 JUMPER, FLAME SENSOR 54769 FUSEHOLDER HPA-EE 10A 240V 54871 FUSE SC-10 (pk 4) 55697 LIGHT, INDICATOR GREEN 240V 60877 LIGHT, SIGNAL WHITE 240V 63738 BOOT, ROCKER SWITCH 63783 ELEMENT, OVEN INNER 240V 63800 ELEMENT, OVEN CENTER 240V 63880 RELAY, 208/240V 63932 MOTOR, OVEN 1/4HP 208/230V 2SPD 64514 RELAY, BLDG FIRE ALARM 64834 BUZZER 240V 65180 THERMO, SNAP-DISC 65239 PROXIMITY SWITCH, OVEN 65651 SWITCH, DPDT 250V 15A 65846 CONTROLLER 400ºF GRIDDLE 67273 SWITCH ELECTRIC (FIRE ALARM) 69623 PROBE, TEMP 1/4 TURN GRIDDLE

69823 CAPACITOR, MOTOR START 500407 SWITCH FILTER INTERLOCK 502584 ASSY, BLOWER FAN & MOTOR 502590 VACUUM SWITCH #1 502591 VACUUM SWITCH #2 502592 VACUUM SWITCH #3 502593 VACUUM SWITCH #4 502789 CONTACTOR 208/240V 3ø 50A 503973 ELEMENT, SOLID HOTPLATE 240V 504712 PROBE, TEMP OVEN 504713 CONTROLLER TIME/TEMP OVEN 504892 E-SAFE RELAY 208/240V 40A

PL505 Service Parts List for WVOC-2H Ventless Cook Center

505098 HOUSING, LIGHT SOCKET 505100 LIGHT BULB APPLIANCE 230V 100W 8528-40 SWI T CH, POWER (NO LIGHT)

PART #

51053 NUT, 8-32 KEPS SS (pk 100) 51038 RETAINER TRADEMARK (pk 10) 51040 GROMMET INSULATION 7/8D HEYCO 51053 NUT, 8-32 KEPS (pk 100) 51717 SCREW, 8-32x7/8 (pk 40) 51718 SCREW, 6-32x3/16 (pk 10) 52428 SPRING, HEAD SUPPORT ROD 53890 SCREW, 12-24x3/4 (pk 10) 53935 SCREW 6X1/4 SHEET METAL (pk 100) 53977 SCREW, 8-32x3/8PHBD (pk 100) 54136 FTG FLEX COND 90DEGx1/2IN 54222 WASHER FLAT #10 54284 RIVET, POP 3/32Dx1/8 54285 SCREW, 8-32x3/8 (pk 50) 55135 SCREW, 6-32x1/4 RD (pk 25) 55485 NUTS, 1/4-20 (pk 100) 55487 SCREW, 8-32x11/16 (pk 50) 55530 SCREW, 8-32x3/8 )pk 100) 55565 WASHER 2-1/4 DRWR BACK RWS 55566 SCREW, 6x1/4 SS (pk 100) 55736 NUT, 8-32 KEPS GREEN (pk 10) 57748 FTG CONDUIT STRAIGHT 1/2IN 60612 SCREWS, 1/4-20x1/2 60680 NUTS, 10-32 KEPS SS (pk 10) 61262 RIVET 1/8X1/4SS ROLL WRMR (pk 50) 61974 NUT, 8-32x7/8 LONG AL (pk 10) 62504 CLAMP BULB SAFETY (pk 4) 63271 CLIP RETAINER PILOT LIGHT (pk 10)

65405 SPACER DRWR STOP SS RWS 500102 STRAIN RELIEF 504420 STRAIN RELIEF 1 1/4NPT

18-302 NUT, 8-32 HEX SS

8543-74 NUT, 4-40 HEX SS

DESCRIPTION

HARDWARE

PART # DESCRIPTION

ANSUL© COMPONENTS

NOTE: Provided for reference only

All servicing of the fire detection and suppression

system must be performed by an authorized Ansul

53068 TERMINAL BLOCK 2P (no Ansul p/n) 67273 SWITCH ELECTRIC (Ansul p/n 423575)

501389

502583

504112

FUSIBLE LINK 165ºF Model K (no Ansul p/n)

FUSIBLE LINK 212ºF Type B (no Ansul p/n)

CABLE, WIRE ROPE , 50 FT/15m (Ansul p/n 15821)

ANSULEX® FIRE EXTINGUISHING MEDIA, 1.5 GAL. (Ansul p/n 79694)

EXPELLANT GAS CARTRIDGE ASSY LT-20-R (Ansul p/n 67099)

QUICK-SEAL ADAPTER, 3/8” (Ansul p/n 77284)

QUICK-SEAL ADAPTER, 1/4” (Ansul p/n 78195)

MOUNTING BRACKET, RELEASE MECH. R-102 (Ansul p/n 79493)

CABLE, WIRE ROPE , 500 FT/152m (Ansul p/n 79653)

DESIGN, INSTALLATION, RECHARGE AND MAINTENANCE MANUAL FOR R-102 RESTAURANT FIRE SUPPRESSION SYSTEM (STD. UL 300 LISTED) (Ansul p/n 418087-05)

NOZZLE 1W (Ansul p/n 419336) NOZZLE 290 (Ansul p/n 419342) PULLEY ELBOW, COMPRESSION

ENDS (Ansul p/n 423250) TANK, 1.5 GAL ANSULEX®

(Ansul p/n 429864)

technician

+ 7 hidden pages