Wells WV-FG Service Manual

W E L L S M A N U F A C T U R I N G

WELLS

I T E M N O .

WV-FG, WV-2HG, WV-2HSG

VENTLESS GRIDDLE/FRYER/COOKTOPS

The ventless hood gives you the flexibility to “set up shop” just about anywhere from malls, stadiums and high-rise buildings to basement kitchens and kiosks.

Griddle (All Models)

• Griddle surface (17 1/4”W x 18 1/4”D) has enclosed tubular heat distribution.

• Griddle is controlled by a positive-off thermostat adjustable from 100ºF to 400ºF.

• Griddle features include a full-width front grease

trough, an extra-large removable front grease drawer and a stainless steel splashguard.

elements that provide even

VENTLESS GRIDDLE/FRYER/COOKTOPS

WV-FGRW

(shown with optional drawer warmer)

Ventless Hood (All Models)

• Ventless Hood System exceeds EPA Standard 202 for the release of particulate matter.

• Interlock System will not allow heating elements to be energized if any of the filters are not in place.

• Airflow Sensing System continually monitors airflow through the filtration system, optimizing performance and grease removal.

• Ansul is built into the ventless hood to provide ultimate protection.

• Shatter-resistent interior light for improved visibility.

R-102 Fire Suppression System

Fryer (WV-FG, WV-FGRW)

• Two half-size, rear hanging, interchangeable fry baskets are provided.

• Efficient heating element is flat, heavy-duty stainless steel.

• Fryer on/off switch is located in recessed front control panel.

• The positive-off thermostat controls the element consistent temperatures.

• The fryer has a manual reset safety thermostat that will shut off the heating element if an over-temperature condition is reached.

• Model WV-FGRW includes a Wells RW-26 built-in standard double drawer warmer that replaces lower storage cabinet.

allowing for adjustable and more

Cooktop (WV-2HG, WV-2HSG, WV-2HGRW, WV-2HSGRW)

• Model WV-2HG has two solid cast iron 9" french plate elements that are independently regulated by

an infinite control with a positive-off position.

• Model WV-2HSG has two spiral 8" elements that are independently regulated by an infinite control with a positive-off position.

• Models WV-2HGRW and WV-2HSGRW include a

Wells RW-26 built-in standard double drawer warmer that replaces lower storage cabinet.

COOKING SURFACE ILLUSTRATION

8 INCH SPIRAL ELEMENTS

GRIDDLE: 17 1/4 X 18 1/4

AND PLUG

SUPPLY CORD

6 FT. POWER

OPENING

PANEL

CONTROL

SHIELDS

SPACERS & SIDE

6" CLEARANCE

REQUIRED

(441)

17 3/8

577

22 3/4

1076

42 3/8

688

27 1/16

(2010)

79 1/8

(771)

30 3/8

(898)

35 3/8

(914)

1217

47 15/16

EXHAUST

AIR

E146882

LISTED

E146882

STD.4

W E L L S M A N U F A C T U R I N G

(1237)

48 11/16

(441)

17 3/8

(1076)

42 3/8

(898)

35 3/8

(578)

22 3/4

(2010)

79 1/8

(914)

(771)

30 3/8

(687)

27 1/16

(533)

PANEL

CONTROL

OPENING

EXHAUST

AIR

SHIELDS

SPACERS & SIDE

6" CLEARANCE

REQUIRED

AND PLUG

SUPPLY CORD

6 FT. POWER

COOKING SURFACE ILLUSTRATION

GRIDDLE: 17 1/4 X 18 1/4

FRYER

E146882

LISTED

E146882

STD.4

M O D E L

W V - F G

G R I D D L E , F R Y E R

D I M E N S I O N S :

INCH

(MM)

MINIMUM CLEARANCE REQUIRED FROM UNIT

TO THE NEAREST SURFACE

BACK SIDE BOTTOM TOP NA NA

SEE REQUIRED 6 8

SPACERS (152) (203)

W V - F G E L E C T R I C A L S P E C I F I C AT I O N S :

MODELS VOLTS WATTS

AMPS PER LINE 3 PHASE

L1 L2 L3

POWER SUPPLY CORD

WV-FG 208 10750 30 43 24 NEMA 15-60P

WV-FG 240 11650 26 40 24 NEMA 15-60P

WV-FGRW* 208 11425 32 43 26 NEMA 15-60P

WV-FGRW* 240 12550 28 40 27 NEMA 15-60P

*RW Models include optional RW-26 built-in standard double drawer warmers. NOTE: Specifications are subject to change without notice. SPECIAL ENVIRONMENTAL NOTICE: The hood system is designed to reduce odor emissions but will not eliminate odors.

Air exchange at the installation site must comply with requirements of the local jurisdictional authority. To ensure dilution of odor build-up, minimum recommendation is 400 cubic feet of fresh air per minute both in and out of the area.

+ 2 hidden pages