Specifications and Main Features
- Model: HE (Series 2)
- Type: Induced Draft Boiler, Natural Gas Fired
- Input Capacity Ratings:
- HE-3: 67,000 BTU/Hr
- HE-4: 100,000 BTU/Hr
- HE-5: 133,000 BTU/Hr
- HE-6: 167,000 BTU/Hr
- Efficiency:
- HE-3: 82.4% AFUE
- HE-4: 82.3% AFUE
- HE-5: 82.2% AFUE
- HE-6: 82.2% AFUE
- Standard Equipment:
- Insulated Extended Jacket
- Flue Collector Assembly
- Transition Assembly with Internal Vent Damper
- Blower Cabinet Assembly
- Relite Control Unit
- Gas Control Valve (Main Valve, Redundant Valve, Pressure Regulator, Pilot Fitter)
- Supervised Pilot Burner with Ignition Electrode
- Pressure Switch
- Pre-purge Timer
- Electrical Junction Box
- Thermal Fuse
- Circulator
- Built-in Air Eliminator
- ASME Pressure Relief Valve (side outlet type)
- Combination Pressure-Temperature Gauge
- Drain Valve
- Fill-Trol System (For P-HE models)
Frequently Asked Questions
- Q: What type of fuel does the HE (Series 2) boiler use?
- A: The HE (Series 2) boiler uses natural gas only.
- Q: What is the maximum allowable operating pressure for this boiler?
- A: The maximum pressure is 30 PSIG.
- Q: What guidance do you have to help me verify the efficiency rating of the boiler?
- A: The efficiency rating can be found on the boiler’s nameplate as well as on the manual in the specifications section.
- Q: To fire up the HE boiler, is it acceptable to provide combustion air?
- A: Provided that the instructions for the installation are adequate, than yes, the boiler room should receive sufficient ventilation and combustion air.
- Q: This time, I want to ask, what if the burners of the boiler don’t ignite?
- A: In the event that there are no ignition flames in the burners, you can troubleshoot the problem from the manual.
- Q: If it’s not a big deal for you, then can I place the HE boiler on carpets?
- A: Placing an HE boiler on carpet is prohibited. HE boilers must be placed on brick or cement level bases to avoid any water constructions.
- Q: Once a boiler is acquired, how frequent should it be maintained?
- A: However, as stipulated by the operational guidelines, there should be a clear maintenance schedule that is followed.
User Manual
Page 1
Page 2
Page 3
Page 4
Page 5
Page 6
Page 7
Page 8
Page 9
Page 10
Page 11
Page 12
Page 13
Page 14
Page 15
Page 16
Page 17
Page 18
Page 19
Page 20
Page 21
Page 22
Page 23
Page 24
Page 25
Page 26
Page 27
Page 28
Page 29
Page 30
Page 31
Loading...