Weber E320LP-2009, E-310LP, 83841001 Owner’s Manual

E/S-310/320, EP -310/320

#89478

YOU MUST READ THiS OWNER'S GUIDE

BEFORE OPERATING YOUR GAS GRILL

Z_ DANGER

if you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flames.

3. Open lid.

4. if odor continues, keep away from the appliance and immediately call your gas

supplier or your fire department.

Leaking gas may cause a fire or explosion

which can cause serious bodily injury or death, or damage to property.

z_ WARNING:

1. Do not store or use gasoline or other flammable liquids or vapors in the

vicinity of this or any other appliance.

2. An LP cylinder not connected for use

shall not be stored in the vicinity of this or any other appliance.

Z_ WARNING: Follow all leak-check

procedures carefully in this manual prior

to barbecue operation. Do this even if the

barbecue was dealer-assembled.

NOTICE TO iNSTALLER: These instructions must be left with the owner and the owner

should keep them for future use.

OUTDOOR USE ONLY.

THIS GAS APPLIANCE iS DESIGNED FOR

z_ WARNING: Do not try to light this

appliance without reading the "Lighting

instructions" section of this manual.

MEMBER

89478 08/22/08 LP

US ENGLISH

DANGER

Failure to follow the Dangers, Warnings and Cautions contained in this Owner's Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.

WARNINGS

z_ Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. z_ Improper assembly may be dangerous. Please follow the assembly instructions carefully.

z_ After a period of storage, and/or nonuse, the Weber ®gas barbecue should be checked for gas leaks and burner obstructions

before use. See instructions in this manual for correct procedures.

z_ Do not operate the Weber _ gas barbecue if there is a gas leak present. z_ Do not use a flame to check for gas leaks. z_ Combustible materials should never be within 24 inches (61 cm) of the back or sides of your Weber _ gas barbecue.

z_ Do not put a barbecue cover or anything flammable on, or in the storage area under the barbecue. z_ Your Weber _ gas barbecue should never be used by children. Accessible parts of the barbecue may be very hot. Keep young

children away while it is in use.

z_ You should exercise reasonable care when operating your Weber ®gas barbecue. It will be hot during cooking or cleaning and

should never be left unattended, or moved while in operation.

z_ Should the burners go out while in operation, turn all gas valves off. Open the lid and wait five minutes before attempting to

relight, using the lighting instructions.

z_ Do not use charcoal or lava rock in your Weber ®gas barbecue. z_ Never lean over open grill or place hands or fingers on the front edge of the cooking box. z_ Should a grease fire occur, turn off all burners and leave lid closed until fire is out.

z_ Do not enlarge valve orifices or burner ports when cleaning the valves or burners. z_ The Weber ®gas barbecue should be thoroughly cleaned on a regular basis. Z_ Liquid propane gas is not natural gas. The conversion or attempted use of natural gas in a liquid propane unit or liquid propane

gas in a natural gas unit is dangerous and will void your warranty.

Z_ Do not attempt to disconnect any gas fitting while your barbecue is in operation. Z_ Use heat-resistant barbecue mitts or gloves when operating barbecue.

Z_ Keep any electrical supply cord and the fuel supply hose away from any heated surfaces. Z_ Combustion byproducts produced when using this product contain chemicals known to the state of California to cause cancer,

birth defects, or other reproductive harm.

Z_ Do not use this barbecue unless all parts are in place. The unit must be properly assembled according to the assembly

instructions.

Z_ Do not build this model of grill in any built-in or slide in construction, ignoring this Warning could cause a fire or an explosion

that can damage property and cause serious bodily injury or death.

z_ Proposition 65 Warning: Handling the brass material on this product exposes you to lead, a chemical known to the state of

California to cause cancer, birth defects or other reproductive harm.

(Wash hands after handfing this product.)

LIQUID PROPANE GAS UNITS ONLY:

z_ Use the pressure regulator and hose assembly that is supplied with your Weber _ gas barbecue. z_ Do not attempt to disconnect the gas regulator and hose assembly or any gas fitting while your barbecue is in operation.

Z_ A dented or rusty liquid propane cylinder may be hazardous and should be checked by your liquid propane supplier. Do not

use a liquid propane cylinder with a damaged valve.

Z_ Although your liquid propane cylinder may appear to be empty, gas may still be present, and the cylinder should be

transported and stored accordingly.

z_ If you see, smell or hear the hiss of escaping gas from the liquid propane cylinder:

1. Move away from liquid propane cylinder.

2. Do not attempt to correct the problem yourself.

3. Call your fire department.

Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber _ gas grill that it will be free of defects in material and workmanship from the date of purchase as follows:

Aluminum castings 25-years (2 years on paint: excludes fading)

Stainless sleel Shroud, 25-years:

Porcelain-enameled shroud, 25-years

Cookbox Assembly 10-years (2 year on paint excludes fading)

Stainless sleel burners tubes, f0-years Stainless steel cooking grates, 5-years no rusl through or burn through Stainless steel F]avorizer bars, 5-years no rust through or burn through

Porcelain-enameled cast-iron

cooking grates, 5-year no rust through or burn through

Porcelain-enameled

cooking grates, 3-years no rust through or burn through

Porcelain-enameled

Flavodzer bars, 2-years no rust through or burn through

Infrared Rotisserie Burner, 2-years

AH remaining parts, 2-years

When assembled and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN

YOUR SALES SLIP OR INVOICE. This Limited Warranty shall be limited to the repair or replacement of parts that prove defective under

normal use and service and which on examination shall indicate, to Weber's satisfaction, they are defective. Before returning any parts, contact the Customer Service Representative in your area

using the contact information on our website. If Weber confirms the defect and approves the claim, Weber will elect to replace such parts without charge. If you are required to return defective parts, transportation charges must be prepaid. Weber will return parts to the purchaser, freight or postage prepaid.

This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse, misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or service, or failure to perform normal and routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this owner's manual.

Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes or tornadoes, discoloration due to exposure to chemicals either directly or in the atmosphere, is not covered by this Limited Warranty.

There are no other express warrants except as set forth herein and any applicable implied warranties of merchantability and fitness are limited in duration to the period of coverage of this express written Limited Warranty. Some regions do not allow limitation on how long an implied warranty lasts, so this limitation may not apply to you.

Weber is not liable for any special, indirect or consequential damages. Some regions do not allow the exclusion or limitation of incidental or consequential damages, so this limitation or exclusion may not apply to you. Weber does not authorize any person or company to assume for it any other obligation or liability in connection with the sale, installation, use, removal, return, or replacement of its equipment; and no

such representations are binding on Weber. This Warranty applies only to products sold at retail.

WEBER-STEPHEN PRODUCTS CO. Customer Service Center

1890 RoseHe Road, Suite 308 Schaumburg, IL 60195 USA

For replacement parts call: 1-800-446-1071

www.weber.com ®

Weber-Stephen Products Co., (Weber) mediante la presente le garantiza al COMPRADOR ORIGINAL de esta barbacoa de gas Weber e que la misma estara libra de defectos en cuanto a materiales y fabricacion a partir de la fecha de compra segun Io siguiente:

Piezas coladas de aluminio

Cubierta de acero inoxidable,

Cubierta porcelanizada,

Camara para asar

Tubes de acero inoxidable

de los quemadores.

Parrilas de cocci6n de

acero inoxidable.

Barras Flavorizer de

acero inoxidable,

Parrillas de cocci6n de hierro

Parrillas de cocci6n porcenlanizadas.

cuando se ensambla y opera de acuerdo alas instrucciones impresas que la acompa_an. Weber pudiese requerir prueba razonable de la fecha de compra. PeR LO TANTO, DEBER#, GUARDAR SU RECIBO O FACTURA DE VENTA.

Esta garantia limitada ester limitada a la reparacion o reemplazo de plazas que resultasen defectuosas bale use y servicio normal y las cuales al examinarse indiquen, a plena satisfaccion de Weber, que efectivamente son piezas defectuosas. Antes de devolver cualquier parte, contacte al Representante

de Atencion al Cliente en su _trea, cuya informacion de contacto la encontrar4, en nuestro sitio web. Si Weber confirma el defecto y aprueba el reclamo, esta elegir4, reparar o reemplazar tal pieza sin cargo alguno. Si usted tiene que retornarnos las partes defectuosas, los gastos de transporte deben ser prepagados. Weber retornara las partes al comprador con transporte o franqueo prepagado.

Weber-Stephen Products Co. (Weber) garantit par le present document t_ I'ACHETEUR D'ORIGINE de ce grill a gaz Weber _ que celui-ci ne comportera aucun defaut de piece ni de main d'oeuvre a compter

de la date d'achat comme suit :

Tubes du brQ]eur en acier inoxydab]e,

Grilles de cuisson en acier inoxydab]e,

Barres F]avodzer en acier inoxydab]e,

Grilles de cuisson en fonte far email]Oe,

BrOleur de la rOtissoire & infrarouge,

_tcondition qu'il ait ete assemble et utilise conformement aux instructions imprimees qui I'accompagnent. Weber peut exiger une preuve raisennable de vetre date d'achat. VOUS DEVRIEZ DONC CONSERVER VOTRE TICKET DE CAISSE OU VOTRE FACTURE.

La presente Garantie limitee est limitee a la reparation ou au remplacement des pieces qui s'averent defectueuses dans le cadre d'une utilisation normale et d'un entretien normal et dent I'examen indique, _tla satisfaction de Weber, qu'elles sent defectueuses. Avant de retourner toute piece, veuillez entrer en contact avec le Representant du Service clientele le plus proche gr&ce aux coordonnees

_tvetre disposition sur notre site Internet. Si Weber confirme le defaut et approuve la demande, Weber choisira de remplacer ces pieces sans frais. S'il vous est demande de retourner les pieces defectueuses, les frais de transport devrent ¢tre prepayes. Weber retournera les pieces _t I'acheteur, france de port. La presente Garantie limitee ne couvre pas toute defaillance ou difficulte d'utilisation provequee par un

accident, une utilisation abusive, une mauvaise utilisatien, une alteration, une mauvaise application, un acte de vandalisme, une installation incorrecte eu une maintenance ou un entretien incorrects, ou le

colado porcelanizado,

Barras Flavorizer porcelanizadas.

Qumeador infrarrojo del

asador giratorio.

Todas la demas partes.

Fonte d'aluminium

Structure en acier inoxydable.

Structure emaillee,

Gdl]es de cuisson 6rnai]lees,

Barres Flavorizer 6rnaH]ees,

Toutes les autres pieces,

25-a1_os (2 ai_os para la pintura excluyendo la decoloraci6n) 25-a1_os

25-aiios 10-ai_os (2 ai_os para la pintura excluyendo la decoloraci6n)

10-ai_os

5-ai_os sin pertoraciSn per fuego u oxidaciSn

5-abos sin pertoraciSn per fuego u oxidaciSn 3-abos sin pertoraciSn per fuego u oxidaciSn 2-ai_os sin pertoraciSn per fuego u oxidaciSn

2-abos 2-ai_os

25 ans (2 ans pour lapeinture & rexception de route d@coloration) 25 ans

25 ans

Cuve,

10 ans (2 ans pour la peinture a I'exception de route d@coloration) 10 ans

5 ans sans trou provoque par la rouille ou par une brQlure 5 ans sans trou provoque par la rouille ou par une brQlure 5 ans sans trou provoque par la rouille ou par une brQlure 3 ans sans trou provoque par la rouille ou par une brQlure 2 ans sans trou provoque par la rouille ou par une brt31ure

2 ans 2 ans

defaut d'entretien normal et regulier, y compris mais pas seulement les demmages prevoques par des

Esta Garantia Limitada no cubre ninguna falla o problema de operacion a causa de accidentes, abuse, mal use, alteracion, use en aplicaciones indebidas, vandalismo, instalacion inapropiada o

mantenimiento o servicio inapropiados, o per no Ilevar a cabo el mantenimiento normal y rutinario, entre los que se incluyen, pete sin limitacion, los dafios causados per insectos dentro de los tubes quemadores, segLin se detalla en este manual del propietario. Esta Garantia Limitada no cubre el deterioro o da_os a causa de condiciones de tiempo inclemente

tales come granizo, huracanes, terremotos o tornados ni tampoco la decoloracion per exposicion a sustancias quimicas bien sea per contacto directo o per que las mismas contenidas en la atmosfera.

No existe ninguna otra garantia expresa que no sean las las ac_t indicadas y cualesquier garantias implicitas de comerciabilidad y aptitud de use est_tn limitadas en duracion al tiempo de cobertura de

esta expresa Garantia Limitada per escrito. Algunas regiones no permiten limitacion alguna en el tiempo que una garantia implicita pueda durar, per Io que esta limitacion pudiera no aplicarle a usted. Weber no se hace responsable de cualesquier da_os especiales, indirectos o emergentes. Algunas regiones no permiten la exclusion o limitacion de dafios incidentales o emergentes, per Io que esta limitacion o exclusion pudieran no aplicarle a usted.

Weber no autoriza a persona o empresa alguna a asumir en su nombre ninguna obligacion o responsabilidad en relacion con la venta, instalacion, use, retire, devolucion o reemplazo de sus equipos, y ninguna tal representacion set4. vinculante para Weber. Esta Garantia aplica solo a aquellos productos vendidos al per menor.

WEBER-STEPHEN PRODUCTS CO. CustomerService Center

1890 RoseHe Road, Suite308 Schaumburg, lL 60195

USA Para partes de repuesto Ilame a:

1-800-446-1071 www.weber.com ®

insectes _t I'interieur des tubes du brQleur, tel que decrit dans le present mode d'emploi. Toute deterioration eu tout dommage resultant de conditions meteerelogiques graves comme de la gr¢le, des ouragans, des seismes ou des tornades, teute deceleration resultant d'une exposition a des agents chimiques directement eu dans I'atmosphere, n'est pas couverte dans le cadre de la presente Garantie limitee.

II n'existe aucune autre garantie expresse hormis celles expesees dans le present document et teute garantie de commercialisation et de ben etat induite est limitee en duree a la periode de couverture de

la presente Garantie limitee ecrite expresse. Certaines regions n'auterisent pas de limitation de duree de la garantie induite ; il est denc posible que cette limitation ne s'applique pas _tveus. Weber ne peut ¢tre tenu pour responsable de tout demmage particulier, induit eu se produisant par vole de consequence. Certaines regions n'auterisent pas I'exclusien ou la limitation des dommages indirects ou se produisant par vole de consequence ; il est denc possible que cette limitation ou

exclusion ne s'applique pas _t veus. Weber n'autorise aucune personne eu societe a presumer en son nem de toute autre obligation eu responsabilite en relation avec la vente, I'installation, I'utilisation, le retrait, le reteur eu le remplacement de ses equipements ; et aucune de ces representations ne lie Weber. La presente Garantie s'applique uniquement aux produits vendus au detail.

Para compras hechas en MExico WEBER-STEPHEN PRODUCTS S.A. de C.V.

MatceJJa No. 338, Colonia Americana

44160 M_×ico, C.P. MExico

Para partes de repuesto Ilame a: (52} (33) 3615-0736

www.weber.com ®

WEBER-STEPHEN PRODUCTS CO. Product Registration

P.O. Box 40530 Burlington, ON L7P 4Wl

Pour des pieces de rechange, appelez le : 1-800-265-2150

www.weber.com ®

VISION I_CLATI_E, DIAGRAHA DE DESPIECE

Genesis_310 LP US 09

1 2

10 11

24 25 26

_27

_28

31 32 33

12 13

16 17

18 19

36 37

38 39

45 46

LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA ViSiON I_CLATI_E

1, Shroud Hardware 18, Catch Pan 35, Back Panel

Accesorios de la cubierta Plato recolector Panel trasero Structure de protection Egouttoir Panneau arriere

2, Thermometer 19, Front Panel 36, Tank Scale

Term6metro Panel frontal Bb,scula del tanque Thermometre Panneau avant Plateau de la bouteille

3, Thermometer Bezel 20, Left Door 37. Manifold

Moldura decorativa del term6metro Puerta izquierda Multiple

Plaque indicatrice du thermometre Porte gauche Collecteur

4. Shroud 21. Right Door 38. Hose/Regulator

Cubierta Puerta derecha Manguera / Regulador T61ede protection Porte droite Tuyau/Regulateur

5, Handle 22. Door Handle 39. Right Frame Panel

Asa Asa de la puerta Panel derecho del basfidor

Poignee Poignee de porte Panneau du cadre droit

6, Warming Rack 23, Control Knob 40, Tank Glides

Rejilla de calentamiento Perilla de control DeslJzaderas del tanque

Grille de rechauffage Bouton de commando Glissieres de la bouteille

7. Left SideTable 24, Bezel #3 41. DripTray

Mesa lateral Jzquierda Moldura decorativa #3 Bandeja de goteo Tablette lat@ale gauche Plaque indicatrice N° 3 Egouttoir

8, Cooking Grates 25, Bezel #2

Parrillas de coccJ6n Moldura decorativa #2

Grilles de cuisson Plaque indicatrice N° 2

9, Crossover®Tube 26, Bezel #1 43, Matchstick Holder

Tubo Crossover _ Moldura decorativa #1 Portacerillos Tuyau Crossover _ Plaque indicatrice N° 1 Porte-allumette

10, Cookbox 27. Igniter Button

Caja de coccidn Bot6n de encendido

Boitier de cuisson Bouton d'allumage

42, RightTrim Piece

Pieza de guarnici6n derecha Piece de garniture droite

44. Right Front Trim Piece

Pieza de guarnici6n frontal derecha Piece de garniture avant droite

11. Left Frame Panel 28, Igniter Module 45, Caster

Panel Jzquierdo del bastidor M6dulo de encendJdo Rueda giratoria Panneau du cadre gauche Module d'allumage Roulette

12, Rear Frame Support 29, Right SideTable 46. Bottom Panel

Soporte posterior del bastidor Mesa lateral derecha Panel inferior Support arriere du cadre Tablette laterale droite Panneau inferieur

13, Front Frame Support 30, Flavorizer _ Bar 47. Locking Caster

Soporte delantero del bastidor Barra Flavorizer _ Rueda giratoria con bloqueo Support avant du cadre Barre Flavorizer :e Roulette autobloquante

14. LeftTrim Piece 31, Rear BurnerTube

PJeza de guarnici6n izquierda Tubo quemador posterior Piece de garniture gauche Tube du brQleur arriere

15, Left Front Trim Piece

PJeza de guarnici6n frontal izquierda Piece de garniture avant gauche

32, Middle BurnerTube

Tubo quemador del medio Tube du brQleur du milieu

16. Catch Pan Holder 33. Front BurnerTube Soporte del plato recolector Tubo quemador frontal

Support d'egouttoir Tube du brQleur avant

17. Disposable Drip Pan

Bandeja de goteo desechable Egouttoi r jetable

34, Igniter Electrode

Electrodo del encendedor Igniter Electrode

ViSiON ECLATEE, DIAGRAiVlA DE DESPIECE

Genesis_320 LP US 09

4 5

26 27 28

12 13

14 15

17 18 19

20 21

33 34 35 36

40 41

44 45

48 49

LISTA DEL DIAGRAIVlA DE DESPIECE, LISTE DE LA ViSiON leCLATleE

1, Shroud Hardware

Accesorios de la cubierta

Structure de protection

2, Thermometer 19, Disposable Drip Pan 36, igniter Electrode

Term6metro Bandeja de goteo desechable Electrodo del encendedor

Thermometre Egouttoir jetable Igniter Eectrode

3, Thermometer Bezel 20, Catch Pan 37, Back Panel

Moldura decorativa del term6metro Plato recolector Panel trasero Plaque indicatrice du thermometre Egouttoir Panneau arriere

4, Shroud 21, Front Panel 38, Tank Scale

Cubierta Panel frontal Bb,scula del tanque

T61ede protection Panneau avant Plateau de la bouteille

5, Handle 22. Left Door 39. Manifold

Asa Puerta izquierda Multiple Poignee Porte gauche Collecteur

6, Warming Rack 23. Right Door 40, Hose/Regulator

Rejilla de calentamiento Puerta derecha Manguera / Regulador

Grille de rechauffage Porte droite Tuyau/Regulateur

7. Side Burner Table

Mesa del quemador lateral

Tablette du brQleur lat@al

8, Side Burner Lid 25, Control Knob 42, Manifold Hose

Tapa del quemador lateral Perilla de control Manguera del multiple

Couvercle du brQleur lat@al Bouton de commando Tuyau du collecteur

18, Catch Pan Holder

Soporte del plato recolector Support d'egouttoir

35, Front BurnerTube

Tubo quemador frontal

Tube du brQleur avant

24, Door Handle 41. Right Frame Panel

Asa de la puerta Panel derecho del bastidor Poignee de porte Panneau du cadre droit

9, Cooking Grates 26, Bezel #3 43, Tank Glides

Parrillas de cocci6n Moldura decorativa #3 Deslizaderas del tanque

Grilles de cuisson Plaque indicatrice N° 3 Glissieres de la bouteille

10, Side Burner 27. Bezel #2 44. DripTray

Quemador lateral Moldura decorativa #2 Bandeja de goteo BrQleur lat@al Plaque indicatrice N° 2 Egouttoir

11. CrossoverTube 28, Bezel #1

Tubo Crossover Moldura decorativa #1

Tuyau Crossover Plaque indicatrice N° 1

12, Cookbox 29, Igniter Button 46. MatehstickHolder

Caja de cocci6n Bot6n de encendido Portacerillos Boitier de cuisson Bouton d'allumage Porte-allumette

13, Left Frame Panel

Panel izquierdo del bastidor Panneau du cadre gauche

30, igniter Module

M6dulo de encendido Module d'allumage

45, RightTrim Piece

Pieza de guarnici6n derecha Piece de garniture droite

47. Right Front Trim Piece PJeza de guarnici6n frontal derecha Piece de garniture avant droite

14. Rear Frame Support 31, Right SideTable 48, Caster

Soporte posterior del bastidor Mesa lateral derecha Rueda giratoria

Support arriere du cadre Tablette laterale droite Roulette

15, Front Frame Support 32, FJavorizer ®Bar 49, Bottom Panel

Soporte delantero del bastidor Barra Flavorizer _ Panel inferior

Support avant du cadre Barre Flavorizer :e Panneau inferieur

16. LeftTrim Piece Pieza de guarnicidn izquierda

Piece de garniture gauche

33. Rear BurnerTube Tubo quemador posterior

Tube du brQleur arriere

50, Locking Caster

Rueda giratoria con bloqueo Roulette autobloquante

17. Left FrontTrim Piece PJeza de guarnici6n frontal izquierda Piece de garniture avant gauche

34. Middle Burner Tube

Tubo quemador del medio

Tube du brQleur du milieu

Your Webei _ gas barbecue is a portable outdoor cooking appliance. With the Weber ¢ gas barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flavorizer ¢ Bars produce that "outdoor" flavor in the food.

The Weber ¢ gas barbecue is portable so you can easily change its location in your yard or on your patio. Portability means you can take your Weber _ gas barbecue with, if you

move. Liquid Propane (LP) gas supply is easy to use and gives you more cooking control than

charcoal fuel. o These instructions will give you the minimum requirements for assembling your

Weber _ gas barbecue. Please read the instructions carefully before using your Weber ¢ gas barbecue. Improper assembly can be dangerous.

Not for use by children. If there are local codes that apply to portable gas grills, you will have to conform to them. Installation must conform with local codes or, in the absence of local codes,

with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,

B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable.

The pressure regulator supplied with the Weber _ gas barbecue must be used. This regulator is set for 11 inches of water column (pressure).

This Weber s gas barbecue is designed for use with liquid propane (LP) gas only. Do not use with natural (piped in city) gas. The valves, orifices, hose and regulator

are for LP gas only. Do not use with charcoal fuel.

Check that the area under the control panel and the bottom tray are free from debris that might obstruct the flow of combustion or ventilation air.

The areas around the LP cylinder must be free and clear from debris. Replacement pressure regulators and hose assemblies must be those specified

by Weber-Stephen Products Co.

FOR INSTALLATION IN CANADA

These instructions, while generally acceptable, do not necessarily comply with the Canadian Installation codes, particularly with piping above and below ground. In

Canada the installation of this appliance must comply with local codes and/or Standard CSA-B149.2 (Propane Storage and Handling Code).

OPERATING

WARNING: Only use this barbecue outdoors in a well-

ventilated area. Do not use in a garage, building, breezeway or any other enclosed area.

WARNING: Keep ventilation openings for cylinder enclosure free and clear from debris.

z_ WARNING: Your Weber _ gas barbecue shall not be used

under overhead combustible construction.

z_ WARNING: Your Weber _ gas barbecue is not intended to be

installed in or on recreational vehicles and/or boats. WARNING: Do not use the barbecue within 24 inches of

combustible materiaJs to the back or sides of the grill. WARNING: The entire cooking box gets hot when in use. Do

not leave unattended. WARNING: Keep any electrical supply cord and the fuel

suppJy hose away from any heated surface. WARNING: Keep the cooking area clear of flammable vapors and liquids such as gasoline, alcohol, etc., and combustible

materials.

z_ WARNING: Never store an extra (spare) LP cylinder under or

near the Weber _ gas barbecue. WARNING: The LP cylinder used with your barbecue must be with a listed OPD (Overfilling Prevention Device) and a QCCl or Type 1 (CGA810) cylinder connection. The cylinder connection must be compatible with the barbecue

connection.

STORAGE AND/OR NONUSE

o The gas must be turned off at the liquid propane cylinder when the Weber _ gas

barbecue is not in use.

o When the WebeP gas barbecue is stored indoors, the gas supply must be

DISCONNECTED and the LP cylinder stored outdoors in a well-ventilated space.

o LP cylinder must be stored outdoors in a well -ventilated area out of reach of

children. Disconnected LP cylinder must not be stored in a building, garage or any other enclosed area.

o When the LP cylinder is not disconnected from the Weber _ gas barbecue, the

appliance and LP tank must be kept outdoors in a well-ventilated space.

o The Weber _ gas barbecue should be checked for gas leaks and any obstructions

in the burner tubes before using. (See Section: "Maintenance/Annual Maintenance).

o Check that the areas under the control panel and the slide out bottom tray are free

from debris that might obstruct the flow of combustion or ventilation air.

o The Spider/Insect Screens should also be checked for any obstructions.

(See Section: "Maintenance/Annual Maintenance").

COOKING z_ WARNING: Do not move the Weber _ gas barbecue when

operating or while barbecue is hot.

You can adjust BURNER 1,2, and 3 as desired.The control settings: High (H), Medium (M), Low (L), or Off (O) are described in your Weber e cookbook.The cookbook uses

these notations to describe the settings of BURNER 1,2, and 3. For example, to sear steaks, you would set all burners at H (high).Then to complete cooking, you would set

BURNER 1 and BURNER 3 at M (medium). Refer to your Weber _ cookbook for detailed cooking instructions.

Note: The temperature inside your cooking box for the first few uses, while surfaces are still very reflective, may be hotter than those shown in your cookbook. Cooking condi-

tions such as wind and weather, may require the adjustment of the burner controls to obtain the correct cooking temperatures.

Preheating - Your Weber ¢ gas barbecue is an energy-efficient appliance. It operates at an economical low BTU rate.To preheat: after lighting, close lid and turn all burners to

high (H). Preheating to between 500 ° and 550 ° F (260 ° and 290 ° C) will take 10 to 15 minutes depending on conditions such as air temperature and wind.

Drippings and grease - The Flavorizer ¢ bars are designed to "smoke" the correct amount of drippings for flavorful cooking. Excess drippings and grease will accumulate in

the catch pan under the slide out bottom tray. Disposable foil drip pans are available that fit the catch pan.

WARNING: Check the bottom tray for grease build-up before each use. Remove excess grease to avoid a grease fire in the slide out bottom tray.

CLEANING

WARNING: Turn your Weber ®gas barbecue off and wait for it to cool before cleaning. CAUTION: Do not clean your Flavorizer _ bars or cooking grates in a self-cleaning oven.

For availability of replacement cooking grates and Fmavorizer ° bars contact the Customer Service Representative in your area using the contact information on

our website. Log onto www.weber.com ® Outside surfaces - Use a warm soapy water solution to clean, then rinse with water.

z_ CAUTION: Do not use oven cleaner, abrasive cleansers

(kitchen cleansers), cleaners that contain citrus products, or abrasive cleaning pads on barbecue or cart surfaces.

Slide out Bottom tray - Remove excess grease, then wash with warm soapy water, then rinse.

Flavorizer e bars and Cooking grates - Clean with a suitable brass bristle brush. As needed, remove from grill and wash with warm soapy water, then rinse with water.

Catch pan - Disposable foil trays are available, or you can line the catch pan with aluminum foil. To clean the catch pan, wash with warm soapy water, then rinse.

Thermometer - Wipe with warm soapy water; clean with plastic scrub ball. Inside cooking module - Brush any debris off of burner tubes. DO NOT ENLARGE

BURNER PORTS (OPENINGS). Wash inside of cooking box with warm soapy water and a water rinse.

Inside Lid - While lid is warm, wipe inside with paper towel to prevent grease build-up. Flaking built-up grease resembles paint flakes.

Stainless steel surfaces - Wash with a soft cloth and a soap and water solution. Be careful to scrub with the grain direction of the stainless steel.

Do not use cleaners that contain acid, mineral spirits or xylene. Rinse well after cleaning.

Preserve Your Stainless Steel - Your grill or its cabinet, lid, control panel and shelves may be made from stainless steel. To keep the stainless steel looking its best is a simple matter. Clean it with soap and water, rinse with clear water and wipe dry. For

stubborn particles, the use of a non-metallic brush can be used.

Z_ IMPORTANT: Do not use a wire brush or abrasive cleaners

on the stainless steel surfaces of your grill as this will cause scratches.

z_ IMPORTANT: When cleaning surfaces be sure to rub/wipe

in the direction of the grain to preserve the look of your stainless steel.

IMPORTANT LP CYLINDER INFORMATION

Failure to fellow these DANGER statements exactly may result in a fire causing death or serious injury.

AkDANGER

z_ NEVER store a spare LP Cylinder under or near this

barbecue.

z_ NEVER fill the tank beyond 80% full.

Your Weber ° gas grill is equipped for a cylinder supply system designed for vapor withdrawal.

z_ WARNING: Only use this grill outdoors in a well=ventilated

area. Do not use in a garage, building, breezeway or any other enclosed area.

CONNECTING THE LIQUID PROPANE CYLINDER

All Weber ¢ liquid propane gas grill regulators are equipped with a UL-listed tank connection as per the latest edition of ANSI Z21.58. This will require a liquid propane

tank that is similarly equipped with a Type 1 connection in the tank valve. This Type 1 coupling allows you to make a fast and totally safe hookup between your gas grill and

your liquid propane tank. It eliminates the chance of leaks due to a POL fitting that is

not properly tightened. Gas will not flow from the tank unless the Type 1 coupling is fully

engaged into the coupling.

z_ WARNING: Make sure that the LP cylinder valve is closed.

Close by turning valve clockwise.

Ak DANGER

Do not use an open flame to check for gas leaks. Be sure there are no sparks or open flames in the area while you check for leaks. Sparks or flames will result in a fire or explosion which can cause serious bodily injury or death, and damage to property.

The proper filling methods for the filling of your cylinder are by weight or volume, as described in NFPA 58. Please make sure your filling station fills your LP cylinder by

weight or volume. Ask your filling station to read purging and filling instructions on the LP cylinder before attempting to fill.

LEAK CHECK PREPARATION

CHECK THAT ALL BURNER VALVES ARE OFF

Valves are shipped in the "OFF" position, but you should check to be sure that they are turned off. Check by pushing down and turning clockwise. If they do not turn, they are off. Proceed to the next step. If they do turn continue turning them clockwise until they

stop, then they are off. Proceed to the next step.

1 Type 1 Valve 2 Hand Wheel

3 External Thread 4 Thermally Sensitive Nut

5 Propane Regulator

To connect the hose to the cylinder:

1) Pass the regulator hose through the side panel opening to the inside of the base cabinet.

2) Locate hose retention clip (a) on regulator hose. Secure into slot (b) on underside of tank scale.

z_ WARNING: The hose must be secured to the tank scale

with the Hose Retention Clip. Failure to do so could cause damage to the hose resulting in a fire or explosion which can cause serious bodily injury or death, and damage to property.

The LP cylinder is installed inside the base cabinet, on the tank scale (right side).

3) Open base cabinet doors.

4) Turn the LP cylinder so the opening of the valve is either to the front, side or rear of the Weber _ gas barbecue. Lift and hook the cylinder onto the fuel gauge.

5) Lift tank up into position on the tank scale.

6) Loosen the cylinder lock wing nut. Swing the cylinder lock down. Tighten the wing nut.

Some LP tanks have differing top collar assembles. (The top collar is the metal protective ring around the valve.) One series of tanks mount with the valve facing front

(a). The other tanks mount with the valve facing away from the fuel scale (b). Weber recommends the use of cylinder manufacturer's Manchester and Worthington, with a

47.6 Ib water capacity. Other cylinders may be acceptable for use with the appliance

provided they are compatible with the appliance retention means (see illustrations).

7) Remove the plastic dust cover from the valve.

8) Screw the regulator coupling onto the tank valve, clockwise, or to the right. Hand- tighten only.

Note: This is a new type of connection. It tightens clockwise and will not allow gas to flow unless the connection is tighL The connection requires tightening by hand only.

z_ WARNING: Do not use a wrench to tighten the connection.

Using a wrench could damage the regulator coupling and could cause a leak.

You will need: LP cylinder, a soap and water solution and a rag or brush to apply it.

9) Mix soap and water.

10) Turn on the cylinder valve.

11) Check for leaks by wetting the fitting with the soap and water solution and watching for bubbles. If bubbles form, or if a bubble grows, there is a leak.

If there is a leak, turn off the gas and tighten the fitting.Turn the gas back on and recheck with the soap and water solution.

If leak does not stop, contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®. Do not use the

barbecue.

12) When leak checking is complete, turn gas supply OFF at the source and rinse connections with water.

REMOVE CONTROL KNOBS & CONTROL PANEL FOR LEAK TESTING

You will need: Phillips screwdrive_

1) Remove control knobs.

2) Remove screw and washer from back of control panel with a Phillips screwdriver.

3) Tilt the back edge of the control panel up. Push in on the front edge to release

locking tabs. Carefully pull control panel away from frame.

4) Disconnect the igniter wires from the ignition module.

5) Replace control panel when Leak Check is completed.

CHECK FOR GAS LEAKS

DANGER

Do not use an open flame to check for gas leaks. Be sure there are no sparks or open flames in the area while you check for leaks. Sparks or open flames will result in a fire or explosion, which can cause serious bodily injury or death and damage to property.

z_ WARNING: You should check for gas leaks every time you

disconnect and reconnect a gas fitting.

Note: Aft factory-made connections have been thoroughly checked for gas leaks. The burners have been flame-tested. As a safety precaution however, you should recheck

aft fittings for leaks before using your WebeK Gas Barbecue. Shipping and handting may loosen or damage a gas fitting.

z_ WARNING: Perform these leak checks even if your barbecue

was dealer or store assembled.

You will need: a soap and water solution, and a rag or brush to apply it.

Note. Since some leak test solutions, including soap and water, may be slightly corrosive, all connections should be rinsed with water after checking for leaks.

If your grill has a side burner make sure the side burner is off.

To perform leak checks: open cylinder valve by turning the cylinder valve hand-wheel counterclockwise.

z_ WARNING: Do not ignite burners when leak checking.

Check for leaks by wetting the connections with the soap and water solution and watching for bubbles. If bubbles form or if a bubble grows, there is a leak.

Check:

1) Hose-to-manifold connection.

z_ WARNING: if there is a leak at connection (1), retighten the

fitting with a wrench and recheck for leaks with soap and water solution, if a leak persists after retightening the fitting, turn OFF the gas. DO NOT OPERATETHE GRILL. Contact

the Customer Service Representative in your area using the contact information on our web site.

Log onto www.weber.com ®.

2) Regulator-to-cylinder connection.

3) The hose-to-regulator connection.

4) Valves-to-manifold connections.

z_ WARNING: If there is a leak at connections (2), (3) or (4),

turn OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the

contact information on our web site. Log onto www.weber.com ®.

When leak checks are complete, turn gas supply OFF at the source and rinse connections with water.

*The grill illustrated may have

slight differences than the

model purchased.

(4)

Check:

1) Hose to manifold connection.

2) Side burner hose to manifold connection and side burner hose to side burner gas line connection.

3) Side burner hose to side burner connection, side burner valve and orifice connections.

z_ WARNING: If there is a leak at connection (1,2, or 3),

retighten the fitting with a wrench and recheck for leaks with soap and water solution. If a leak persists after re-tightening the fitting, turn OFF the gas. DO NOT OPERATE THE GRILL.

Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ®.

4) Regulator to cylinder connection.

5) Hose to regulator connection.

6) Valves to manifold connections.

z_ WARNING: If there is a leak at connections (4, 5 or 6), turn

OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the

contact information on our web site. Log onto www.weber.com ®.

When leak checks are complete, turn gas supply OFF at the source and rinse connections with water.

REFILLING THE LIQUID PROPANE CYLINDER

We recommend that you refill the LP cylinder before it is completely empty. Removal of the LP cylinder

1) Close cylinder valve (turn clockwise).

2) Unscrew regulator coupling by turning counterclockwise, by hand only.

3) Loosen cylinder lock wing nut and turn cylinder lock up out of the way.

4) Lift cylinder off.

To fill, take the LP cylinder to a gas propane dealer, or look up "gas-propane" in the phone book for other sources of LP gas.

Z_ WARNING: We recommend that your LP cylinder be filled

at an authorized LP gas dealer, by a qualified attendant, who fills the cylinder by weight. IMPROPER FILLING IS

DANGEROUS.

z_ CAUTION: Place dust cap on cylinder valve outlet whenever

the cylinder is not in use. Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in leakage of

propane.

*The grill illustrated may have

slight differences than the model purchased.

(2)

(1)

(5)

CHECKING THE FUEL LEVEL IN YOUR TANK

Check the fuel level by viewing the color indicator level line on the side of the tank scale.

1) Empty

2) Medium

3) Full

(1)

(2) (3)

SAFE HANDLING TIPS FOR LIQUID PROPANE GAS CYLINDERS

o Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas.

LP gas is a gas at regular temperatures and pressures. Under moderate pressure, inside a cylinder, LP gas is a liquid. As the pressure is released, the liquid readily

vaporizes and becomes gas. LP gas has an odor similar to natural gas. You should be aware of this odor.

LP gas is heavier than air. Leaking LP gas may collect in low areas and prevent dispersion.

To fill, take the LP cylinder to a gas propane dealer, or look up "gas-propane" in the phone book for other sources of LP gas.

WARNING: We recommend that your LP cylinder be filled at an authorized LP gas dealer, by a qualified attendant,

who fills the tank by weight. IMPROPER FILLING IS DANGEROUS.

Air must be removed from a new LP cylinder before the initial filling. Your LP dealer is equipped to do this.

The LP cylinder must be installed, transported and stored in an upright position. LP cylinders should not be dropped or handled roughly.

Never store or transport the LP cylinder where temperatures can reach 125 ° F (too hot to hold by hand - for example: do not leave the LP cylinder in a car on a

hot day).

Note: A refill will last about 18-20 hours of cooking time at norma! use. The fuel scale will indicate the propane supply so you can refill before running ouL You do not have

to run out before you refill.

Treat "empty" LP cylinders with the same care as when full. Even when the LP tank is empty of liquid there still may be gas pressure in the cylinder. Always

close the cylinder valve before disconnecting.

z_ CAUTION: Place dust cap on cylinder valve outlet whenever

the cylinder is not in use. Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder

valve. Other types of caps or plugs may result in leakage of propane.

= Do not use a damaged LP cylinder. Dented or rusty LP cylinders or LP cylinders

with a damaged valve may be hazardous and should be replaced with a new one

immediately. Liquid Propane (LP) Cylinder(a) = The joint where the hose connects to the LP cylinder must be leak tested each

time the LP cylinder is reconnected. For example, test each time the LP cylinder is

refilled.

Be sure the regulator is mounted with the small vent hole pointed downward so

that it will not collect water. This vent should be free of dirt, grease, bugs etc.

The gas connections supplied with your Weber ¢ gas barbecue have been

designed and tested to meet 100% CSA and ANSI requirements.

WARNING: Replacement LP tanks must match the regulator connection supplied with this barbecue.

LIQUID PROPANE CYLINDER REQUIREMENTS

Check to be sure cylinders have a D.O.T. certification (1), and date tested (2) is within five years. Your LP gas supplier can do this for you. All LP tank supply systems must include a collar to protect the cylinder valve.

The LP cylinder must be a 20-lb. size approximately (18_A inches high, 12_A inches in diameter).

The cylinder must be constructed and marked in accordance with the Specifications for LP - Gas Cylinders of the U.S. Department of Transportation (D.O.T.) or the National Standard of Canada, CAN/CSA-B339,

Cylinders, Spheres and Tubes or Transportation of Dangerous Goods; and Commission, as applicable.

IN CANADA

LIQUID PROPANE CYLINDER REQUIREMENTS

Note: Your retailer can help you match a replacement tank to your barbecue.

The LP cylinder must be constructed and marked in accordance with the specifications for LP gas cylinders, T.C.

00/0_

LIGHTING

Summary lighting instructions are inside the left hand cabinet doo_

DANGER

Failure to open the lid while igniting the barbecue's burners,

or not waiting 5 minutes to allow the gas to clear if the

barbecue does not light, may result in an explosive flame=up which can cause serious bodily injury or death.

CROSSOVER ®IGNITION SYSTEM

Note: The CrossoveF Ignition System ignites BURNER 1 with a spark from the igniter electrode inside the Gas Catcher T"ignition chambe_ You generate the energy for the

spark by pushing the electronic ignition button. You will hear it sparking.

& WARNING: Check hose before each use of barbecue for nicks,

cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace using onlyWeber e authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on

our web site. Log onto www.weber.com ®.

MAIN BURNER LIGHTING

1) Open the lid.

2) Make sure all burner control knobs are turned OFR (Push control knob down and turn clockwise to ensure that it is in the OFF position.)

Z_ WARNING: The burner control knobs must be in the OFF

position before turning on the liquid propane cylinder tank valve. If they are not in the OFF position, when you turn on the LP cylinder valve, the "excess gas flow control" feature

will activate, limiting the flow of gas from the LP cylinder. If this should occur, turn OFF the LP cylinder valve and burner

control knobs. Start over.

z_ DANGER

When the "excess gas flow control" feature is activated, a small amount of gas is still flowing to the burners. After turning OFF the cylinder vMve, wait at least 5 minutes for the

gas to clear before attempting to light the barbecue. Failure to do so may result in an explosive flame=up, which can cause serious bodily injury or death.

3) Turn the cylinder on by slowly turning the cylinder valve counterclockwise.

z_ WARNING: Do not lean over the open barbecue. Keep your

face and body at least one foot away from the matchlight hole when lighting the barbecue.

4) Push BURNER 1 control knob down and turn to START/HI.

5) Push and hold the electronic ignition button. You will hear it sparking.

6) Check that the burner is lit by looking through the matchlight hole on the front of the cooking box.You should see a flame.

z_ WARNING: If the burner does not light in five (5) seconds,

turn the Burner 1 control knob to OFF and wait 5 minutes to let the gas clear before you try again or try to light with a

match.

7) After BURNER 1 is lit you can turn on BURNER 2 (and BURNER 3).

Note - Always light BURNER I first. The other burners ignite from BURNER 1.

TO EXTINGUISH

Push down and turn each burner control knob clockwise to the OFF position. Turn gas supply OFF at the source.

MAIN BURNER LIGHTING

*The grill illustrated may have

slight differences than the

model purchased.

ELECTRONIC

IGNITER

MAIN BURNER MANUAL LIGHTING

z_ DANGER

Failure to open the lid while igniting the barbecue's burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can

cause serious bodily injury or death.

1) Open the lid.

2) Make sure all burner control knobs are turned OFR (Push each knob down and turn clockwise to ensure they are in the "OFF" position.)

Z_ WARNING:The burner control knobs must be in the OFF

position before turning on the liquid propane cylinder valve. If they are not in the OFF position, when you turn on the LP cylinder valve, the "excess gas flow control" feature will activate, limiting the flow of gas from the LP cylinder. If this

should occur, turn OFF the LP tank valve and burner control knobs. Start over.

MAIN BURNER MANUAL LIGHTING

*The grill illustrated may have

slight differences than the model purchased.

DANGER

When the "excess gas flow control" feature is activated, a small amount of gas is still flowing to the burners. After

turning OFF the cylinder and burner control knobs, wait at

least 5 minutes for the gas to clear before attempting to light the barbecue. Failure to do so may result in an explosive flame=up, which can cause serious bodily injury or death.

3) Turn the cylinder on by turning the cylinder valve counterclockwise.

4) Insert match holder with lit match into the matchlight hole in the front of the cooking box.

z_ WARNING: Do not lean over open barbecue. Keep your face

and body at least one foot away from the matchlight hole when lighting the barbecue.

5) Push BURNER 1 control knob down and turn to START/HI.

6) Check that the burner is lit by looking through the matchlight hole on the front of the cooking box.You should see a flame.

WARNING: If the burner does not light in five seconds, turn the Burner 1 control knob to OFF and wait 5 minutes to let

the gas clear before you try again.

7) After BURNER 1 is lit you can turn on BURNER 2 (and BURNER 3).

Note -A/ways fight BURNER 1 first.The other bumers ignite from BURNER 1.

TO EXTiNGUiSH

Push down and turn each burner control knob clockwise to the OFF position. Turn gas supply OFF at the source.

MAIN BURNER MANUAL LIGHTING

*The grill illustrated may have

slight differences than the model purchased.

LIGHTING THE SIDE BURNER

DANGER

Failure to open the lid while igniting the side burner, or not

waiting 5 minutes to allow the gas to clear if the side burner

does not light, may result in an explosive flame=up which can cause serious bodily injury or death.

WARNING: Check hose before each use of barbecue for

nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace

using only Weber ® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.

com e .

1) Open the side burner lid.

2) Check that the side burner valve is turned off (Push control knob in and turn clockwise to ensure that it is in the "OFF" position), turn all burners not being

used to the "OFF" position (push in and turn clockwise).

WARNING:The burner control knobs must be in the OFF

position before turning on the liquid propane cylinder valve. If they are not in the OFF position, when you turn on the LP cylinder valve, the "excess gas flow control" feature

will activate, limiting the flow of gas from the LP cylinder.

If this should occur, turn OFF the LP tank valve and burner

control knobs. Start over.

DANGER

When the "excess gas flow control" feature is activated, a small amount of gas is still flowing to the burners. After turning OFF the cylinder and burner control knobs, wait at

least 5 minutes for the gas to clear before attempting to light the barbecue. Failure to do so may result in an explosive flame-up, which can cause serious bodily injury or death.

3) Turn the gas supply valve on.

4) Pushdownandturnthesideburnercontrolvalveto"HI".

5) Presstheigniterbuttonseveraltimessoitclickseachtime.

z_ CAUTION: Side burner flame may be difficult to see on a

bright sunny day.

WARNING: If the side burner does not light in five (5)

seconds:

a) Turn off the side burner control valve, main burners

and gas supply at source.

b) Wait 5 minutes to let the gas clear before you try

again, or try lighting with a match (see "Manually

Lighting the Side Burner").

MANUALLY LIGHTING THE SIDE BURNER

DANGER

Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive flare=up that can

cause serious bodily injury or death.

i \.!

1) Open the side burner lid.

2) Check that the side burner valve is turned off (Push control knob in and turn clockwise to ensure that it is in the "OFF" position), turn all burners not being used

to the "OFF" position (push in and turn clockwise).

WARNING: The burner control knobs must be in the OFF position before turning on the liquid propane cylinder valve.

If they are not in the OFF position, when you turn on the LP cylinder valve, the "excess gas flow control" feature will activate, limiting the flow of gas from the LP cylinder. If this

should occur, turn OFF the LP tank valve and burner control knobs. Start over.

DANGER

When the "excess gas flow control" feature is activated, a small amount of gas is still flowing to the burners. After

turning OFF the cylinder and burner control knobs, wait at least 5 minutes for the gas to clear before attempting to light the barbecue. Failure to do so may result in an explosive flame=up, which can cause serious bodily injury or death.

3) Turn the gas supply valve on.

4) Put match in a match holder and strike match.

5) Hold match holder and lit match by either side of the side burner.

6) Push down and turn the side burner control valve to "HI".

z_ CAUTION: Side burner flame may be difficult to see on a

bright sunny day.

z_ WARNING: If the side burner does not light in five (5)

seconds:

a) Turn off the side burner control valve, main burners

and gas supply at source.

b) Wait 5 minutes to let the gas clear before you try

again.

PROBLEM CHECK

Burners burn with a yellow or orange flame, in Inspect Spider/Insect Screens for possible obstructions. Clean Spider/Insect Screens. (See Section 'Annual conjunction with the smell of gas. (Blockage of holes.) Maintenance")

CURE

Symptoms:

Burners do not light. -or- Burners have a small flickering flame in the "HF position. -or-

Barbecue temperature onmy reaches 250 ° to 300 ° in the "HF position.

Burner does not might, or flame is mow in "HI"

position.

Experiencing flare-ups:

CAUTION: Do not line the bottom tray

with aluminum foil.

Burner flame pattern is erratic. Fmame is low when Are burners clean? Clean burners. (See Section "Maintenance'.') burner is on "Hi'; Flames do not run the whole

length of the burner tube. inside of midappears to be "peeling." (Resembmes The lid is porcelain enamel or stainless steel, not paint. Clean thoroughly. (See Section "Cleaning'.')

paint peeling.) It cannot "peeE What you are seeing is baked on grease

Cabinet doors are not aligned. Check the adjustment pin on the bottom of each door. Loosen adjustment nut/s. Slide dooris until aligned. Tighten

if problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ®.

The excess flow safety device, which is part of the barbecue to cylinder connection, may have activated.

Is LP fuel low or empty? Is fuel hose bent or kinked?

Does Burner 1 light with a match?

Are you preheating barbecue in the prescribed manner?

Are the cooking grates and Flavorize¢ _bars heavily coated with burned-on grease?

Is the bottom tray "dirty" and not allowing grease to flow into catch pan?

that has turned to carbon and is flaking off. THIS IS NOT A DEFECT.

To reset the excess flow safety device turn all burner control

knobs and the cylinder valve off. Disconnect the regulator

from the cylinder. Turn burner control knobs to "HI'.' Wait at

least 1 minute. Turn burner control knobs to "OFF Reconnect

the regulator to the cylinder. Turn cylinder valve on slowly.

Refer to "Lighting Instructions'.' Refill LP cylinder.

Straighten fuel hose. If you can light Burner 1 with a match, then check the

Crossover _ ignition system.

All burners on HI for 10 to 15 minutes for preheating.

Clean thoroughly. (See Section "Cleaning")

Clean bottom tray.

nut.

PROBLEM

Side Burner does not light.

Flame is low in "HI" position. Is the fuel hose bent or kinked? Straighten hose.

Push button ignition does not work. Does burner light with a match? If match lights burner, check igniter (see Sideburner Maintenance).

if problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our

web site. Log onto www.weber.com ®.

Is gas supply off?

The excess flow safety device, which is part of the barbecue to cylinder connection, may

have activated.

CHECK

CURE

Turn supply on.

To reset the excess flow safety device turn all burner control knobs and the cylinder valve off. Disconnect the regulator from the cylinder. Turn burner control knobs to

START/HI. Wait at least 1 minute. Turn burner control knobs to "OFF". Reconnect the regulator to the cylinder. Turn cylinder valve on slowly. Refer to "Lighting

Instructions".

+ 39 hidden pages