Weber 200, 120 User Manual

Gas Grill Owner’s Guide

Register your grill online at www.weber.com

plaCe stiCKer here

You must read this oWNer’s Guide

before operatiNG Your Gas Grill

m DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flames.

3. Open lid.

4. If odour continues, keep away from the
appliance and immediately call your gas
supplier or your fire service.

Leaking gas may cause a fire or explosion,
which can cause serious bodily injury or
death, or damage to property.

mDANGER

Failure to follow the Dangers, Warnings and Cautions
contained in this Owner's Manual may result in serious
bodily injury or death, or in a fire or an explosion causing
damage to property.

mWARNINGS

m

Follow regulator connection instructions for your type
of gas grill.

m

Do not store a spare or disconnected gas supply
cartridge/cylinder under or near this grill.

m

Do not put a grill cover or anything flammable on or in
the storage area under the grill.

m

Improper assembly may be dangerous. Please carefully
follow the assembly instructions in this manual.

m

After a period of storage and/or non-use, the Weber
gas grill should be checked for gas leaks and burner
obstructions before use. See instructions in this manual
for correct procedures.

m

Do not use a flame to check for gas leaks.

m

Do not operate your Weber® gas grill if there are any
leaking gas connections.

m

Flammable materials should not be present within
approximately 60 cm of the top, bottom, back or sides of
the grill.

m

Your Weber® gas grill should not be used by children.
Accessible parts of the grill may be very hot. Keep
young children away while it is in use.

m

Exercise caution when using your Weber® gas grill. It
will be hot during cooking or cleaning, and should never
be left unattended, or moved while in operation.

m WARNING: Do not try to light the Weber® gas

barbecue without first reading the “Lighting”
instructions in this manual.

m WARNING

1. Do not store spare liquid butane/propane
cartridge/cylinder within 3m (10 feet) of
this appliance.

2. Do not store or use petrol or other
flammable liquids or vapours within 8m
(25 feet) of this appliance.

m WARNING: Follow all leak-check procedures

carefully in this manual prior to barbecue
operation. Do this even if barbecue was dealer­assembled.

INFORMATION FOR THE INSTALLER:
This manual must remain with the owner, who
should keep it for future use.

THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR
USE ONLY.

m

If the burners should go out during cooking, turn off all
gas valves. Open the lid and wait five minutes before
attempting to re-light the gas flame, while observing the
"Lighting"instructions.

m

Do not use charcoal, briquettes or lava rock in your
Weber® gas grill.

m

While cooking, never lean over the open grill or place
hands or fingers on the front edge of the cooking box.

m

Should an uncontrolled flare-up occur, move food away
from the flames until flaring subsides.

m

Should a grease fire occur, turn off all burners and leave
lid closed until fire is out.

m

The Weber® gas grill should be cleaned thoroughly at
regular intervals.

m

When cleaning valves or burners do not enlarge orifices
or ports.

m

Butane/propane gas is not natural gas. The conversion
or attempted use of natural gas in a butane/propane gas
unit is dangerous and will void your warranty.

m

A dented or rusty gas supply cartridge/cylinder may be
hazardous and should be checked by your gas supplier.
Do not use a gas supply cartridge/cylinder with a
damaged valve.

GB-INT. ENGLISH

41009 02/15/06



WARNINGS (CONTINUED)

m Even though your gas supply cartridge/cylinder may

appear to be empty, it might still contain gas. The
cartridge/cylinder should be transported and stored
accordingly.

m

Under no circumstances should you attempt to
disconnect the gas regulator or any gas fitting while your
grill is in operation.

m

Use heat-resistant oven gloves when operating grill.

m

Do not use this grill unless all parts are in place. The unit
must be properly assembled according to the instructions
outlined in the “Assembly Instruction” section of the
Owner’s Guide.

GENERAL INSTRUCTIONS

m

Do not use the Weber® grill in the boot of any vehicle, or
inside an estate car, people carrier, minibus or caravan.

m Use the regulator that is supplied with your Weber® gas

grill.

m

Warning: Make sure you are outdoors and away from
any source of ignition when changing or connecting the
butane/propane cartridge/cylinder.

m Q100- 10 Use butane/propane disposable cartridges with a

minimum capacity of 430g and a maximum capacity of 460g. The
cartridge must have an EN417 valve as illustrated. One type of
cartridge that can be used is a Weber® Baby Q™/Performer® gas
cartridge. Another type of cartridge is a Primus model 2202.

If you have questions or need advice regarding
your grill or its safe operation, please log onto

www.weber.com®.

Your Weber® gas barbecue is a portable outdoor
cooking appliance. With the Weber® gas barbecue
you can grill, barbecue, roast and bake with
results that are difficult to duplicate with indoor
kitchen appliances. The closed lid produces that
“outdoor” flavour in the food.
The Weber® gas barbecue is portable, so you can
easily change its location in your garden or on
your patio. Portability means you can take your
Weber® gas barbecue with you if you move.
Butane/propane gas supply is easy to use and
gives you more cooking control than charcoal fuel.

Storage and/or Non-use

• When the Weber® gas barbecue is not in

use, the gas cartridge/cylinder must be
DISCONNECTED and stored outdoors in a
well-ventilated place.

• The Weber® gas barbecue should be
checked for gas leaks and any obstructions
in the burner tubes before using. (See
Sections: “General Maintenance” and
“Annual Maintenance”)

• The Spider /Insect Screen should also be
checked for any obstructions. (See “Annual
Maintenance” section)

• These instructions will give you the minimum
requirements for assembling your Weber®
gas barbecue. Please read the instructions
carefully before using your Weber® gas
barbecue. Improper assembly can be
dangerous.

• Not for use by children.

• This Weber® gas barbecue is designed
for use with butane/propane gas only. Do
not use with natural gas. The valve and
regulator are for Butane/propane gas only.

• Do not use with charcoal fuel.

• This Weber® gas barbecue is not intended
for commercial use.

• The use of alcohol and/or prescription or
non-prescription drugs may impair the
consumer’s ability to properly assemble or
safely operate the appliance.

Operating

m WARNING: This barbecue should only be

used outdoors in a well-ventilated area. Do

not use in a garage, shed, hut or any other

enclosed area.

m WARNING: Your Weber® gas barbecue

must not be used under an unprotected

combustible roof or overhang.

m WARNING: Your Weber® gas barbecue

is not intended for installation in or on

recreational vehicles and caravans and/or

boats.

m WARNING: Do not use the barbecue where

the top, back or sides of the grill are within

60 cm (24 in) of combustible materials.

®

• This Weber
for and should never be used as a heater.

• Do not leave the Weber® gas barbecue
unattended. Keep children and pets away
from the Weber® gas barbecue at all times.

• Check that the area under the control panel
and the bottom tray are free from debris that
might obstruct the flow of combustion or
ventilation air.

• Change the flexible hose when national
regulations stipulate this as a requirement.

• Any parts sealed by the manufacturer must
not be altered by the user.

• Any modification of the appliance may be
dangerous.

m WARNING: The entire cooking box gets hot

when in use. Do not leave unattended.

m WARNING: Keep any electrical power cable

away from any heated surface.

m WARNING: Keep the cooking area clear

of inflammable vapours and liquids such

as petrol, paraffin, alcohol, etc., and other

combustible materials.

m WARNING: Never store an extra (spare)

butane /propane cartridge/cylinder under

or near the Weber® gas barbecue.

m WARNING: When cooking, the appliance

must be on a level, stable surface in an

area clear of combustible material.

gas barbecue is not intended

GENERAL INSTRUCTIONS (CONTINUED)



Cooking

To light the grill: Refer to the lighting instructions

in this owners manual and printed on the fold out
tables (Q120, 200, 220) of your grill.

To preheat the grill: Light the Weber gas grill
according to the lighting instructions in this
owners manual. Close the lid. Preheat the grill for
5-10 minutes (depending on conditions such as
air temperature and wind).

Cleaning

m WARNING: Turn your Weber® gas barbecue

OFF and wait for it to cool before cleaning.

For availability of replacement cooking grate
contact the Customer Service Representative in
your region using the contact information on our
web site. Log onto www.weber.com®.

Outside surfaces - Use a warm soapy water
solution to clean, then rinse with water.

m CAUTION: Do not use oven cleaner,

abrasive cleaning products (kitchen
cleaning products) cleaners that contain
citrus products, or abrasive cleaning pads
on barbecue.

Note: Wind and weather may require
adjustment of the burner control knob to
obtain the correct cooking temperature.

If the burner goes out during cooking, open
the lid, turn off the burner, and wait five
minutes before relighting.

Drippings and grease: Excess drippings and

grease will collect in the catch pan in the slide-out
bottom tray (located on the underside of the grill).
Disposable Weber drip pans are available that fit
the catch pan.

Slide-out bottom tray - Remove excess grease,
then wash with warm soapy water, then rinse.

Cooking grate - Clean with a suitable brass
bristle brush. Remove from grill and wash with
warm soapy water, then rinse with
water, as required.

Catch pan - Disposable foil trays are available, or
you can line the catch pan with aluminum foil. To
clean the catch pan, wash with warm soapy water,
then rinse.

Inside cooking box - Brush any debris off burner
tubes. DO NOT ENLARGE BURNER PORTS
(OPENINGS). Wash the inside of cooking box
with warm soapy water and rinse with water.

m WARNING: Check the catch pan and the
bottom of the grill for grease build-up before
each use. Remove excess grease to avoid a
fire in the bottom of the grill.

m WARNING: Do not move the Weber® gas
grill when operating or while the grill is hot.

Inside lid - While lid is warm, wipe inside with

paper towel to prevent grease build-up. Flaking
built-up grease resembles paint flakes.

Swing-up work tables (Q120, 200, 220) - Wash with
a soft cloth and a soap-and-water solution.

Do not use cleaners that contain acid, mineral
spirits or xylene. Rinse well after cleaning.

Swing-up work tables (Q120, 200, 220) are not to
be used as cutting boards.

Lid - 1

Disposable Drip Pan - 2

Catch Pan - 1

PARTS LIST

Cooking Grate - 1

Cotter Pin - 2

Handle - 1

Control Knob - 1

Handle Spacer - 2

Stainless Steel Pan Head Phillips Screw
(1/4 - 20 x 1 1/2” Screw) - 2

Hinge Pin - 2

Thermometer - 1

Wing Nut - 1



1 -

2 -

2 -

2 -

2 -

1 -

1 - 1 -

2

1

ASSEMBLY

a

C

b

d

e

WEBER-STEPHEN PRODUCTS CO.

www.weber.com

©2006 The following trademarks are registered in the name of Weber-Stephen Products Co., an Illinois corporation, located at 200 East Daniels Road, Palatine,
Illinois 60067 U.S.A. Australia; Smokey Joe, Weber, Kettle Silhouette®, Genesis, Austria; Kettle Silhouette®, Smokey Joe, Weber, Benelux; Kettle Silhouette®,
Smokey Joe, Weber, Compact Grill Configuration, Botswana; Weber, Canada; Smokey Joe, Genesis, China; Kettle Silhouette®, Denmark; Kettle Silhouette®, Smokey Joe, Weber,
Finland; Smokey Joe, France; Kettle Silhouette®, Smokey Joe, Weber, One-Touch, Germany; Smokey Joe, Weber, One-Touch, Greece; Smokey Joe, Ireland; Kettle Silhouette®,
Smokey Joe, Italy; Smokey Joe, Weber, Japan; Smokey Joe, Weber, Korea; Smokey Joe, Weber, New Zealand; Weber, Smokey Joe, Nigeria; Weber,
Norway; Smokey Joe, Weber, Portugal; Weber, South Africa: Smokey Joe, Weber, Kettle Configuration, Spain; Smokey Joe, Weber, Sweden; Kettle Silhouette®, Smokey Joe,
Switzerland; Kettle Silhouette®, Smokey Joe, Weber, United Kingdom; Smokey Joe, Weber, Weber One-Touch, U.S.A.; Kettle Configuration, Kettle Silhouette,
Smokey Joe, Weber, One-Touch, Firespice, Go-Anywhere, Kettle Configuration, Kettle Silhouette, Genesis, Flavorizer, Crossover, Flamgo, Performer, Rapidfire, Tuck ‘N Carry,
Jumbo Joe, Bar-B-Kettle, Master-Touch, Spirit, Grill Out, Summit, Platinum, 1-800-Grill-Out, Ranch, Matchless Flame, Zimbabwe; Weber, Kettle Configuration, Kettle Silhouette®.

®