Water Tech RC32-TM, RC48-TM, RC64-TM, RC40-TM, RC80-TM Owner's Manual
...
OWNER'S MANUAL
REIONATOR
®
WHOLE HOUSE WATER CONDITIONER
with Triton Electronic Control Valve
Platinum Series Classic Series
ACTIVATE YOUR WARRANTY
BY REGISTERING YOUR PRODUCT AT
www.watertech.com or call 888-254-8412
WQA Gold Seal certied to NSF/ANSI Standards 42 and 44
for meeting or exceeding industry standards of aesthetic
chlorine reduction and softening efciency.
Fusion Series
Dealer Name:
Dealer Phone Number: Installation Date:
Model Number: Serial Number:
CUSTOMER CHECKLIST
After installation, installer should make sure of the following:
Customer has an Owner's Manual
Customer knows how to restart system if power goes out
Customer knows how to put the system in bypass in case of an emergency
Customer knows what kinds of regenerant to use in brine tank
Customer knows where to purchase regenerant salt or potassium chloride
Customer knows how often to check regenerant salt/potassium level
Customer knows how much salt or potassium chloride to put in brine tank
Customer knows how to contact dealer in case of service needs
Customer is aware that they must register their product online or by phone to activate their
Reionator limited lifetime warranty coverage
DEALER CONTACT AND PRODUCT INFORMATION
ACTIVATE YOUR WARRANTY BY
REGISTERING YOUR PRODUCT AT
www.watertech.com or call 888-254-8412
Maintenance
This manual is applicable to one of the following model numbers:
Classic Series: RC 32-TM, RC40-TM, RC 4 8-TM, RC64-TM, RC80-TM
Platinum Series: RP32-TM, RP40-TM, RP48-TM, RP6 4-TM, RP80-TM
Fusion Series: RF32-TM, RF40-TM, RF48-TM
With minimal care, your system is designed to serve you for many years. While constant attention to
your system is not necessary, the following suggestions will insure your system’s performance and your
convenience and satisfaction.
MAINTENANCE
• Salt in the brine tank is used as a resin ‘cleaner’ to remove contaminants during the regeneration
process. Check the salt level of the brine tank on a regular basis to make sure your system is using salt.
Your REIONATOR® will function properly whether the salt tank is near full or near empty, rell when
necessary.
• Use only premium-grade regenerant salt that is designed specically for use with water softeners and
conditioners. Sodium (NaCl) salt may be used. Potassium (KCl) is recommended in most applications for
superior taste, odor, aesthetic and environmental benets.
SERVICE ISSUES
• If the Triton control valve system display does not appear, check to make sure the system is plugged in
and that there is power at the receptacle. If the unit does not respond with power present, contact your
WaterTech Dealer.
• The manual bypass valve (which is located at the rear of the unit) is designed to isolate the unit from the
plumbing for servicing or to shut off the water supply to the unit in the event of a leak at the conditioner.
Consult the operating diagram on pages 11-12 of this manual for instructions to position your bypass
valve for either service or isolation.
• If you experience an extended power outage (over an hour in length), you may need to reset the time of
day on the Triton control valve. The internal battery is designed to retain the time of day for up to 24
hours. There is no need to reset any other part of the program as this is kept in non-volatile, permanent
memory. Consult the programming instructions on page 10 of this manual for instructions to set the
electronic time clock of the Triton control valve.
• If you experience a change in water quality:
1. First check to see if your brine tank is empty (see above). If necessary, add regenerant salt.
2. Check to see if your system has power (see above).
3. Check to see if the drain line has a kink that may be restricting ow during regeneration. Correct, if
necessary, or contact your WaterTech Dealer.
2
Do’s and Do Not’s
• DO ALWAYS check your state and local regulations regarding plumbing and electrical connections and
placement of the system before installation.
• DO install the REIONATOR® system into the existing cold water supply line before the water heater and
before any cold water outlet that requires treatment.
• DO bypass your system in the event of a water or plumbing related emergency.
• DO decrease your usage of all cleaning products such as: soap, detergents, shampoo, etc. Most
homes can reduce their use of these products by 50% to 75% because they work more efciently in
REIONATOR® conditioned water.
• DO inspect the brine tank monthly.
• DO initiate a regeneration manually if high water usage is expected due to guests, heavy laundry or
other reasons.
• DO contact your WaterTech Dealer if you have any questions about the operation of your system or
water quality issues.
• DO enjoy all the benets of your REIONATOR® conditioned water!
• DO NOT hang or stack items on your equipment. This may cause an equipment imbalance or put a strain
on plumbing and electrical connections.
• DO NOT disconnect or remove any part of the plumbing or electrical cord.
• DO NOT attempt to reprogram your system (except for the time clock setting). Your system has been
factory or eld programmed specically for your application.
• DO NOT overll the brine tank with salt. Approximately 6 inches below the rim is the maximum
recommended ll.
• DO NOT allow your REIONATOR® and attached plumbing to be exposed to extreme temperatures
(below 40° F or above 110° F).
• DO NOT use with water that is microbiologically unsafe or of unknown quality without adequate
disinfection before or after the system.
3
4
Parts List - RC/RP
Overow Elbow
Triton Control Valve
PRODUCT DESCRIPTION PART NUMBER
Resin Tank 9" x 48" 09-03-0948BLK
Resin Tank 10" x 47" 09-03-1047BLK
Resin Tank 10" x 54" 09-03-1054BLK
Resin Tank 12" x 52" 09-03-1252BLK
Resin Tank 13" x 54" 09-03-1354BLK
Brine Tank Assembled 18" x 33" 09-04-1833BKC
Brine Grid 18" 09-04-119
Brine Well Assembly (for 18x33) 09-04-242
Brine Overow Elbow 07-05-004
Triton Control Valve 13-V1CCDM
Resin Tank
Brine Tank
5
Parts List - RF
PRODUCT DESCRIPTION PART NUMBER
Resin Tank 10" x 35" 09-03-1035NB
Resin Tank 12" x 35" 09-03-1235NB
Fusion Cabinet Top 09-05-010
Fusion Cabinet Base 09-05-011
Brine Overow Elbow 07-05-004
Brine Well Assembly 09-04-244
Triton Control Valve 13-V1CCDM
Loading...