Warner Electric Kit No. 5250-101-012
P-1613
819-0522
Installation Instruction Sheet
Failure to follow these
instructions may result in product damage,
equipment damage, and serious or fatal
injury to personnel.
Note: This armature assembly is balanced and care
must be taken to keep it flat and true. Caution
should be used when following instructions
shown below.
®
Locktite
This armaure assembly is a matched component.
When replacement of the armature becomes
necessary, the magnet must also be replaced.
Disassembly
1. To ensure a balanced condition, mark armature
2. Remove the (6) armature mounting screws.
Warner Electric • 800-825-9050 P-1613 • 819-0522
will be needed at re-assembly.
position relative to the hub keyway before
beginning disassembly.
ssiimmiillaarr ddeevviiccee ttoo pprreevveenntt rroottaattiioonn..
Reassembly
3. Inspect the new hub. Check condition of tapped
holes and remove any oil or foreign particles
found anywhere on the hub.
4. Apply a single drop of Loctite #242 to each
of the threaded holes in the hub.
5. Align the keyway with the timing mark made
to the armature in step one.
6. Tighten each capscrew to 16 to 24 ft. lb. Wipe
excess Loctite from all surfaces.
7. Remove any foreign material found on the
assembly.
DDoo nnoott ccllaammpp aarrmmaattuurree iinn aa vviiccee oorr
Warranty
Warner Electric LLC warrants that it will repair or replace (whichever it deems advisable) any
product manufactured and sold by it which proves to be defective in material or workmanship
within a period of one (1) year from the date of original purchase for consumer, commercial or
industrial use.
This warranty extends only to the original purchaser and is not transferable or assignable without
Warner Electric LLC’s prior consent.
Warranty service can be obtained in the U.S.A. by returning any defective product, transportation
charges prepaid, to the appropriate Warner Electric LLC factory. Additional warranty information
may be obtained by writing the Customer Satisfaction Department, Warner Electric LLC, 449
Gardner Street, South Beloit, Illinois 61080, or by calling 815-389-3771.
A purchase receipt or other proof of original purchase will be required before warranty service is
rendered. If found defective under the terms of this warranty, repair or replacement will be made,
without charge, together with a refund for transportation costs. If found not to be defective, you
will be notified and, with your consent, the item will be repaired or replaced and returned to you
at your expense.
This warranty covers normal use and does not cover damage or defect which results from
alteration, accident, neglect, or improper installation, operation, or maintenance.
Some states do not allow limitation on how long an implied warranty lasts, so the above limitation
may not apply to you.
Warner Electric LLC’s obligation under this warranty is limited to the repair or replacement of the
defective product and in no event shall Warner Electric LLC be liable for consequential, indirect,
or incidental damages of any kind incurred by reason of the manufacture, sale or use of any
defective product. Warner Electric LLC neither assumes nor authorizes any other person
to give any other warranty or to assume any other obligation or liability on its behalf.
WITH RESPECT TO CONSUMER USE OF THE PRODUCT, ANY IMPLIED WARRANTIES WHICH
THE CONSUMER MAY HAVE ARE LIMITED IN DURATION TO ONE YEAR FROM THE DATE OF
ORIGINAL CONSUMER PURCHASE. WITH RESPECT TO COMMERCIAL AND INDUSTRIAL
USES OF THE PRODUCT, THE FOREGOING WARRANTY IS IN LIEU OF AND EXCLUDES ALL
OTHER WARRANTIES, WHETHER EXPRESSED OR IMPLIED BY OPERATION OF LAW OR
OTHERWISE, INCLUDING, BUT NOT LIMITED TO, ANY IMPLIED WARRANTIES OF
MERCHANTABILITY OR FITNESS.
Some states do not allow the exclusion or limitation of incidental or consequential damages, so
the above limitation or exclusion may not apply to you. This warranty gives you specific legal rights
and you may also have other rights which vary from state to state.
Changes in Dimensions and Specifications
All dimensions and specifications shown in Warner Electric catalogs are subject to change without
notice. Weights do not include weight of boxing for shipment. Certified prints will be furnished
without charge on request to Warner Electric.
Warner Electric LLC
31 Industrial Park Road
815-389-3771
www.warnerelectric.com
An Altra Industrial Motion Company
• Fax: 815-389-2582
• New Hartford, CT 06057
P-1613 819-0522 06/11 Printed in USA
Loading...