Warmington Cardrona Cooker Installation Instructions Manual

15 September 2017

All Dimension are in mm………….Copyright ©

1

Due to continued product improvement, Warmington Ind LTD reserves the right to change product specifications without prior notification.

Cardrona Cooker

Visit www.warmington.co.nz for spec’s, DWG’s and PDF uploads of fires

Fire, Flue System and Instructions to Comply with ASNZS 2918:2001

Keep these Instructions for further reference……Ensure that you have the correct and current Installation details for the Warmington Fire

Installation

The Warmington unit is to be Installed by a Certified Warmington Installer or an Approved NZHHA Installation Technician .

See www.homeheat.co.nz/members for a Certified NZHHA SFAIT Installer in your area .

CLEARANCES TO COMBUSTIBLE SURFACES UNLESS STATED

IMPORTANT

Read all the Instructions carefully before commencing the Installation. Failure to follow these Instructions may result in a Fire Hazard and void the warranty

Cardrona Cooker - wood burner

Installation Instructions

15 September 2017

All Dimension are in mm………….Copyright ©

2

Due to continued product improvement, Warmington Ind LTD reserves the right to change product specifications without prior notification.

Model: Cardrona Cooker

Serial No: SSO - ……………………

TESTED TO AS/NZS 2918.

TEST REPORT : SPECTRUM LABRATORIES LTD

TEST REPORT NO : 0033

Date of installation: _____/_____/20_____

15 September 2017

All Dimension are in mm………….Copyright ©

3

Due to continued product improvement, Warmington Ind LTD reserves the right to change product specifications without prior notification.

Minimum Flue Height

Flue height

3600

Measured from top of cabinet

C + 3600

FIREBOX DETAILS

Description

Cardrona Cooker

Cabinet width

A 660

Cabinet depth

B 642

Cabinet height

C 915

Flue diameter

D 150

To flue centre

E 108

Ceiling height

F 2400

Minimum from fire to ceiling

G 1500

Height from floor protector

H 4600

Note:

Please check with your local Council in regard to
Clean Air Regulation Restrictions prior to installing
your Cardrona Cooker.

Check List

Fit baffle (if required)
Fit bricks (if required)
Fit top plate inspection discs
Fit oven trays
Fit thermometer
Holding down brackets
Check door seals
Check door ampers
Check flue damper & handle
Serial umber check

Loading Badge
Packed by:

Ash hearth only is
needed, refer to
AS/NZS 2918.

15 September 2017

All Dimension are in mm………….Copyright ©

4

Due to continued product improvement, Warmington Ind LTD reserves the right to change product specifications without prior notification.

PLAN VIEW OF CLEARANCES TO COMBUSTIBLES - STRAIGHT WALL INSTALL

Description

Cardrona Cooker

To flue centre - corner

O

410

Hearth depth - corner

P

1247

To wall side - corner

Q

100

To flue centre - corner

S

579

* Measurement taken from front ash lip

PLAN VIEW OF CLEARANCES TO COMBUSTIBLES - CORNER INSTALL

CLEARANCES TO COMBUSTIBLES - BENCH TOP INSTALL

Description mm

Bench top clearance

AA

50

To bench top side

AB

240

To flue centre (side)

AC

570

Description Cardrona Cooker

Hearth width

M 830

Hearth projection*

N 300

Hearth projection to flue centre R 668

Description Cardrona Cooker

To wall behind I 100
To wall side J 350
To flue centre (back) K 251
Hearth depth L 919

Situation

Non-combustible surface, including walls, finishings and
framing without flue shield, e.g. concrete/block/brick/ACC
block. Hearth only needed if installed on heat sensitive
floor material.

Re clearance to a non-combustible materials walls or
surfaces, ref to ASNZS:2918:2001 3.2.1.
The clearance to a non-combustible surface and in­cluding wall can be less that 100mm if a wet back is
not fitted and no requirement for maintenance.

* Construction of flue shield must be in
accordance with ASNZS 2918 (minimum flue shield
height is 1200mm)

Ash hearth only is
needed, refer to
AS/NZS 2918.

15 September 2017

All Dimension are in mm………….Copyright ©

5

Due to continued product improvement, Warmington Ind LTD reserves the right to change product specifications without prior notification.

WETBACK POSITIONS AND PIPE LAYOUT

kw output*

Wetback Boiler 3.5kw

*Value is approx, tested on Lewis Firebox

CARDRONA COOKER INTERNAL MEASUREMENTS

Tested fuel load
(softwood)

Tested fuel
weight

Firebox size
in litres:

Cardrona Cooker up to 4.75kg 50.1

Description

Cardrona Cooker

Internal depth

VV 385

Firebox internal height

WW 271

Firebox internal width

XX 483

Cooker internal height

YY 283

Cooker internal width

ZZ 483

WETBACK FITMENT

Step 1:

Place the wetback into the firebox,
and ensure the pipes are fitted into the
holes securely.

Oven Dimensions Cardrona Cooker

Oven door opening

430 x 250mm

Oven width

485mm

Oven depth

385mm

Oven height

285mm