Waldorf RN8910G, RNL8910G, RNB8910G, RNLB8910G Installation And Operation Manual

1

Installation and Operation Manual

Series

RN8910G RNL8910G RNB8910G RNLB8910G

Gas Range Static Oven

Date Purchased

Serial Number

Dealer

Service Provider

232779-8

For use in GB & IE

The reproduction or copying of any part of this manual by any means whatsoever is strictly forbidden unless auth orized previously in
writing by the manufacturer.

In line with policy to continually develop and improve its products, Moffat Ltd. reserves the right to change the specifications and
design without prior notice.

© Copyright Moffat Ltd. November 2014.

MANUFACTURED BY

Moffat Limited

Rolleston 7675
New Zealand

INTERNATIONAL CONTACTS

AUSTRALIA

Moffat Pty Limited
Web: www.moffat.com.au
E.Mail: [e-mail]
Main Office: (tel) [phone]

(fax) [phone]

Service: (tel): 1800 622 216
Spares: (tel): 1800 337 963
Customer Service: (tel): 1800 335 315
(fax): 1800 350 281

CANADA

Serve Canada
Web: www.servecanada.com
E.Mail: [e-mail]
Sales: (tel): 800 551 8795 (Toll Free)
Service: (tel): 800 263 1455 (Toll Free)

NEW ZEALAND

Moffat Limited
Web: www.moffat.co.nz
E.Mail: [e-mail]
Main Office: (tel): 0800 663328

UNITED KINGDOM

Blue Seal
Web: www.blue-seal.co.uk
E.Mail: [e-mail]
Sales: (tel): [phone]

(fax): [phone]
Spares: (tel): [phone]
(fax): [phone]
Service: (tel): [phone]
(fax): [phone]

UNITED STATES

Moffat
Web: www.moffat.com
Sales: (tel): 800 551 8795 (Toll Free)

(tel): [phone]
(fax): [phone]
Service: (tel): 800 858 4477 (Toll Free)
(tel): [phone]
(fax): [phone]

REST OF WORLD

Moffat Limited
Web: www.moffat.co.nz
E.Mail: [e-mail]

Contents List

Waldorf Gas Range Static Oven

RN(L)(B)8910G Gas Range Static Oven - 4 Burner, 900mm Wide.

Introduction .............................................................................................. 2

Specification .............................................................................................. 3

Model Numbers Covered in this Specification
General
Gas Supply Requirements
Gas Connection

Dimensions ................................................................................................ 6

Installation ................................................................................................ 7

Installation Requirements
Unpacking
Location
Clearances
Assembly
Gas Connection
Commissioning

Operation ................................................................................................. 10

Operation Guide
Description of Controls
Open Burners
Lighting the Oven Pilot Burner
Lighting the Oven Main Burner
Turning the Oven to ‘Stand-By’ (Pilot ‘ON’ Only)
Oven ‘Shut Down’

Cleaning and Maintenance ...................................................................... 14

Before Commencing Cleaning
Open Burner Cleaning
Oven Interior Cleaning
Stainless Steel Surfaces

Fault Finding ............................................................................................ 16

Gas Conversion and Specifications ......................................................... 17

Conversion Procedure
Gas Specifications

Replacement Parts List ............................................................................ 22

2

Introduction

We are confident that you will be delighted with your WALDORF GAS RANGE STATIC OVEN and it will
become a most valued appliance in your commercial kitchen.

To ensure you receive the utmost benefit from your new Waldorf appliance, there are two important things
you can do.

Firstly:

Please read the instruction book carefully and follow the directions given. The time taken will be well
spent.

Secondly:

If you are unsure of any aspect of the installation, instructions or performance of your appliance,
contact your WALDORF dealer promptly. In many cases a phone call could answer your question.

CE Only:

These instructions are only valid if the country code appears on the appliance. If the code does not
appear on the appliance, refer to the supplier of this appliance to obtain the technical instructions for
adapting the appliance to the conditions for use in that country.

GREAT CARE MUST BE TAKEN BY THE OPERATOR TO USE THE EQUIPMENT SAFELY TO GUARD IT AGAINST RISK OF

FIRE.

 T

HE APPLIANCE MUST NOT BE LEFT ON UNATTENDED.

 I

T IS RECOMMENDED THAT A REGULAR INSPECTION IS MADE BY A COMPETENT SERVICE PERSON TO

ENSURE CORRECT AND SAFE OPERATION OF YOUR APPLIANCE IS MAINTAINED.

 DO NOT

STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPOURS OR LIQUIDS IN THE VICINITY OF

THIS OR ANY OTHER APPLIANCE.



DO NOT SPRAY AEROSOLS IN THE VICINITY OF THIS APPLIANCE WHILE IT IS IN OPERATION.

Warning



This appliance is for professional use and is only to be used by qualified
persons.



Only authorised service persons are to carry out installation, servicing or gas
conversion operations.



Components having adjustments protected (e.g. paint sealed) by the
manufacturer should not be adjusted by the user / operator.



DO NOT operate the appliance without the legs supplied fitted.

Caution

IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR MAINTENANCE CA N CAUSE PROPERTY

DAMAGE, INJURY OR DEATH. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS
THOROUGHLY BEFORE INSTALLING OR SERVICING THIS APPLIANCE.

Warning

INSTRUCTIONS

TO BE FOLLOWED IN THE EVENT THE USER SMELLS GAS ARE TO BE POSTED IN A PROMINENT

LOCATION. THIS INFORMATION SHALL BE OBTAINED BY CONSULTING THE LOCAL GAS SUPPLIER.

Warning

3

Specifications

Model Numbers Covered in this Specification

RN[1]8910G-[2] Gas Static Oven + 4 Open Burners.

NOTE:

[1]: - Model Options;

- - Standard Models.
L - Low Back Models.
B - Bold Front.
LB - Low Back and Bold Front.

[2] - Open Burner Options;

F - With Flame Failure Protection.
PF - With Pilot and Flame Failure Protection.

General

A heavy duty, general purpose gas range created for compact modular kitchens. It is available on
industrial adjustable feet or on robust rollers.

Open Burners are available in either 'PF' (Pilot and Flame Failure) or 'F' (Flame Failure Only) options.
Open Burners are fitted with individual flame failure for each open burner.
Oven is fitted with pilot and flame failure with piezo ignition.

Easy clean stainless steel external finish.

4

Specifications

Gas Supply Requirements

- Australia:

- New Zealand:

- UK Only:

Category: II

2H3P

(20, 37).

Flue Type: A1.

* Measure burner operating pressure at manifold test point with two burners operating at full

setting. Operating pressure is ex-factory set through the appliance regulator and is not to be
adjusted, apart from when carrying out gas conversion, if required. (Refer to ‘Gas
Conversion’ section for details).

Natural Gas (G20) Propane (G31)

Open Burner

(each)

Oven Open Burner

(each)

Oven

Heat Input (nett)

Nominal

6.5 kW 7.8 kW 6.5 kW 7.8 kW

Reduced

1.75 kW --- 1.75 kW ---

Gas Rate (nett)

Nominal

0.69 m3/hr 0.83 m3/hr 0.51 kg/hr 0.61 kg/hr

Reduced

0.19 m3/hr --- 0.14 kg/hr ---

Supply Pressure

20 mbar 37 mbar

Burner Operating Pressure (*)

9.5 mbar 26 mbar

Gas Connection

3

/4” B.S.P. Male

Natural Gas LP Gas (Propane)

Input Rate (N.H.G.C.)

- each Open Burner

28 MJ/hr

28 MJ/hr

- Oven 30 MJ/hr 30 MJ/hr

Supply Pressure 1.13 - 3.40 kPa 2.75 - 4.50 kPa
Burner Operating Pressure (*) 0.95 kPa 2.6 kPa
Gas Connection

3

/4” B.S.P. Male

Natural Gas LP Gas

Input Rate (N.H.G.C.)

- each Open Burner

28 MJ/hr

28 MJ/hr

- Oven 30 MJ/hr 30 MJ/hr

Supply Pressure 1.13 - 3.40 kPa 2.75 - 4.50 kPa
Burner Operating Pressure (*) 0.95 kPa 2.6 kPa
Gas Connection

3

/4” B.S.P. Male

5

Specifications

- All Other Markets:

NOTE:

 (*) Measure Burner operating pressure at manifold test point with 2 burners operating at

'High Flame' setting.

 NAT, LPG & Butane Only - Operating pressure is ex-factory set and is not to be adjusted,

unless when converting between gases, if required.

 (**) TOWN GAS Only - Adjust burner operating pressure using adjustable gas regulator

supplied.

 Refer to ‘Gas Conversion and Specifications' section in this manual for further details.

Gas Connection

Gas supply connection point is located at rear of appliance, approximately 130mm from right hand
side, 32mm from rear and 655mm from floor and is reached from beneath appliance. (Refer to
‘Dimensions’ section).

Connection is ¾" BSP male thread.

Electrical Supply Requirements

230-240 V a.c, 50 Hz, 1.6A, 1P+N+E.

0.4kW.
Oven Fan Motor - 100W.

Natural Gas Town Gas (**)

Input Rate (N.H.G.C.)

- each Open Burner

28MJ/hr 28MJ/hr

- Oven 30 MJ/hr 30 MJ/hr

Supply Pressure 1.13 - 3.40kPa 0.75 - 1.50kPa
Burner Operating Pressure (*) 0.95kPa 0.63 Pa
Gas Connection See ‘Gas Connection’ information overleaf

LP Gas (Propane) Butane

Input Rate (N.H.G.C.)

- each Open Burner

28MJ/hr 28MJ/hr

- Oven 30 MJ/hr 30 MJ/hr

Supply Pressure 2.75 - 4.50kPa 2.75 - 4.50kPa
Burner Operating Pressure (*) 2.6kPa 2.6kPa
Gas Connection See ‘Gas Connection’ information overleaf

6

Dimensions

RN

(L)

8910G