Vulcan Hart VIR-36 General Manual

Item # __________________________

C.S.I. Section 11420

VIR-36 SERIES

HEAVY DUTY GAS INFRARED BROILER

■■ VIR-36 Top fired infrared gas broiler with standard oven

■■ VIR-36S Top fired infrared gas broiler with

open storage base

STANDARD FEATURES

■ Stainless steel front and front top ledge. Sides and top finished
in black epoxy powder coat paint. 6" adjustable legs.

1

/4" diameter front gas manifold.

■ 1

■ Four 20,000 BTU/hr. heavy duty infrared burners, 80,000

BTU/hr. total input.

■ Pilot ignition system.

■ Two infinite heat control valves.

■ Floating grid rack assembly with positive positioning control

handle. Two section cooking grid measures 25

■ Full width floating drip pan drains into a large capacity grease
collector.

■ Standard oven base (Model VIR-36): Oven controls located
in cool zone. Interior measures 27

1

/2"w x 281/2"d x 141/2"h.
Porcelain enamel on steel oven hearth, rear panel and door
liner. One oven rack and four rack positions. 40,000 BTU/hr.
burner with pilot ignition. Thermostat adjusts from 250° to
500°F. Counterbalanced oven door.

■ Open storage base (Model VIR-36S): Open storage base

interior measures 33"w x 23"d x 13"h.

■ One year limited parts and labor warranty.

1

/2" x 251/2".

Vulcan-Hart Co.

ISO9001

A2780

MODELS: VIR-36 SERIES

SPECIFICATIONS:

Heavy duty top fired gas broiler, Vulcan-Hart Model (VIR-36)
(VIR-36S). Stainless steel front and front top ledge. Sides and top
finished in black epoxy powder coat paint. 6" adjustable legs.

1

/4" diameter front gas manifold. Four 20,000 BTU/hr. heavy

1
duty infrared burners, 80,000 BTU/hr. total input. Pilot ignition
system. Two infinite heat control valves. Floating grid rack
assembly with positive positioning control handle. Two section
cooking grid measures 25

1

/2" x 251/2". Full width floating drip pan

drains into a large capacity grease collector.

Exterior dimensions: 36"w x 38

1

/4"d x 631/2"h on 6" adjustable legs.

CSA design certified. NSF listed.

SPECIFY TYPE OF GAS AND FINISH WHEN ORDERING.
SPECIFY ALTITUDE WHEN ABOVE 2,000 FT.

OPTIONS

■■ Stainless steel side(s). ■■ Left ■■ Right

■■ Stainless steel finishing back.

■■ Cabinet doors with stainless steel fronts on “S” models.

■■ Electronic ignition (oven bases only).

■■ Common stainless steel front top ledge up to 96" wide.

(Drawing required showing the position of each piece of
equipment).

■■ Cap and cover manifold end(s). ■■ Left ■■ Right

■■ Leveling bolts in place of legs for curb mounting.

■■ Stainless steel dolly frame with casters, up to 72" wide.

1

/4" rear gas connection (includes gas pressure regulator).

■■ 1

ACCESSORIES

■■ Set of four 5" diameter casters, two locking.

1

/4" gas pressure regulator.

■■ 1

■■ Flexible gas hose with quick disconnect and restraining

device. Consult price book for available sizes.

Heavy Duty Gas Infrared Broiler

F-32524 (6-04)

VULCAN-HART COMPANY, P.O. BOX 696, LOUISVILLE, KY 40201, TEL. [phone]

502-778-2791 QUOTE & ORDER FAX: [phone]

IMPORTANT

1. A properly sized gas pressure regulator suitable for battery or
single unit application must be furnished and installed.
Natural gas 5.0" W.C., propane gas 10.0" W.C.

2. An adequate ventilation system is required for commercial
cooking equipment. Information may be obtained by writing to
the National Fire Protection Association, Batterymarch Park,
Quincy, MA 02269. When writing refer to NFPA No. 96.

3. These units are manufactured for installation in accordance
with ANSZ223.1a (latest edition), National Fuel Gas Code.
Copies may be obtained from the American Gas Association,
1515 Wilson Blvd., Arlington, VA 22209.

VIR-36 SERIES

HEAVY DUTY GAS INFRARED BROILER

4. Clearances: Combustible Non-Combustible
Rear 2" 0"
Sides 20" 2"

5. For proper combustion, install equipment on adjustable legs
or casters. On curb or platform, allow 3
Leveling bolts are required for curb installation. Specify when
ordering.

6. Cannot be batteried with GH series equipment.

7. This appliance is manufactured for commercial installation
only and is not intended for home use.

1

/2" front overhang.

MODEL

GAS RATED INPUT BTU/HR.

WORKING APPROX.

HEIGHT SHP. WT.

NO. BROILER BASE TOTAL WIDTH DEPTH ON 6" LEGS (lbs./kg)

VIR-36 80,000 40,000 120,000

36" 38

1

/4"63

1

/2"

542/244

VIR-36S 80,000 — 80,000 542/244

NOTE: In line with its policy to continually improve its products, Vulcan-Hart Company reserves the right to change materials and
specifications without notice.

F-32524 (6-04)

VULCAN-HART COMPANY, P.O. BOX 696, LOUISVILLE, KY 40201, TEL. [phone]

502-778-2791 QUOTE & ORDER FAX: [phone]

Printed On Recycled Paper