Vulcan Hart VCBB24 General Manual
Item # __________________ C.S.I. Section 11420
VULC A N V SERI E S HEAVY DUTY RANGES
HEAVY DUTY GAS RANGE
24" WIDE CHARBROILER GAS RANGE
VCBB24 T 24" Charbroiler / Modular
VCBB24B T 24" Charbroiler / Cabinet Base
STANDARD FEATURES
Stainless steel front, front top ledge, burner box, sides, ■
base, exterior bottom and stub back
1
1 ■
⁄4" diameter front gas manifold
Four 65,000 BTU/hr. burners ■
Individual pilots for each burner ■
Heavy-duty slant cast grates and char-radiants ■
Stainless steel supercharger burner dividers ■
4" stainless steel stub riser ■
6" adjustable stainless steel legs for “B” models ■
(no legs for modular model)
Stainless steel cabinet base door ■
Universal rack guides, with one removable shelf ■
(cabinet base)
One year limited parts and labor warranty ■
Model VCBB24B shown on a cabinet base
SPECIFICATIONS
24" wide heavy duty gas range, Vulcan Model No. VCBB24
(modular) or VCBB24B (cabinet base). Stainless steel front,
plate ledge, front top ledge with pull-out condiment rails, sides,
base, exterior bottom, stub back and 6" adjustable legs. 1
diameter front gas manifold. Four burners, totaling 65,000 BTU/hr.
Cast burners and char-radiants with stainless steel super-charger
burner dividers. Individual pilots and controls for each burner.
Heavy duty cast slant grates, easy lift-off of 4 each for 24"
wide units. Total input 65,000 BTU/hr.
Exterior Dimensions:
3
36
⁄4"d x 24"w x 36"h on 6" adjustable legs
1
⁄4"
OPTIONAL FEATURES (Factory Installed)
Cap and cover front manifold T
4" adjustable anged feet for modular models T
6" adjustable anged feet for cabinet base models T
Less legs for dolly mounting of cabinet base models T
Set of 4 casters. 6" high T (two locking)
3" high toe base for curb mounting for “S”, “C”, & “B” models T
3
⁄4", 1", or 1 1⁄4" gas pressure regulator
T
(specify gas type – pack loose)
Common condiment type, telescoping plate rails T
ACCESSORIES (Packaged & Sold Separately)
Extra removable shelves for use with Universal rack T
guides (cabinet base)
Banking strip T
10", 22", or 34" high back risers T (no shelf)
22" single deck solid or o-thru high shelf risers T
34" double deck solid or o-thru high shelf risers T
Flexible gas hose with quick disconnect and T
restraining device
Common condiment type, telescoping plate rails T
(starting at 24" length)
P.O. Box 696
F37429 (10/09)
Vulcan & Wolf Range
a division of ITW Food Equipment Group LLC
n
Louisville, KY 40201 n Toll-free: 1-800-814-2028 n Local: 502-778-2791 n Quote & Order Fax: 1-800-444-0602
VULC A N V SERI E S HEAVY DUTY RANGES
HEAVY DUTY GAS RANGE
24" WIDE CHARBROILER GAS RANGE
INSTALLATION INSTRUCTIONS
A properly sized gas pressure regulator suitable for battery 1.
or single unit application must be furnished and installed.
Natural gas 6.0" W.C., propane gas 10 W.C.
An adequate ventilation system is required for commercial 2.
cooking equipment. Information may be obtained by
writing to the National Fire Protection Association,
1 Batterymarch Park, Quincy, MA 02269, www.NFPA.org.
When writing, refer to NFPA No. 96.
These units are manufactured for installation in 3.
accordance with ANSZ223.1A (latest edition), National
Fuel Gas Code. Copies may be obtained from The
American Gas Association, 400 N Capitol St. NW,
Washington, DC 20001, www.AGA.org.
Clearances4. Rear Sides
Combustible 10" 10"
Non-combustible 0" 0"
For proper combustion, install equipment on adjustable 5.
legs or casters. On curb or platform, allow 3 overhand. Toe base with leveling bolts are required for
curb installation. Specify when ordering.
Cannot be batteried with GH series equipment.6.
This appliance is manufactured for commercial 7.
installation only and is not intended for home use.
NOTE: In line with its policy to continually improve its
product, Vulcan reserves the right to change materials
and specications without notice.
Specify type of gas when ordering. Specify altitude when
above 2,000 feet.
1
⁄2" front
P.O. Box 696
F37429 (10/09)
TOP
CONFIGURATION
n
Louisville, KY 40201 n Toll-free: 1-800-814-2028 n Local: 502-778-2791 n Quote & Order Fax: 1-800-444-0602
MODEL
NUMBER
VCBB24 24" Charbroiler / Modular 65,000 305 / 139
VCBB24B 24" Charbroiler / Cabinet Base 65,000 405 / 184
DESCRIPTION
TOTAL INPUT
BTU / HR
SHIPPING WEIGHT
LBS / KG
Vulcan & Wolf Range
a division of ITW Food Equipment Group LLC
Loading...