Vulcan Hart MF85 Manuel de service

SERVICE MANUAL

MF50
MF85

MOBILE FILTERS

MODEL ML

MF50
MF85

- NOTICE -

This Manual is prepared for the use of trai ned Vulcan Service
Technicians and should not be used by those not properly
qualif ied. If you have att ended a Vu lcan Service School for this
product, you may be qualified to perform all the procedures
described in this manual.

Thi s manu al i s no t i nten ded to be al l en comp assi ng . I f you have
not attende d a Vulcan S ervic e School for this produc t, you sho uld
read, in its entirety, the repair procedure you wish to perform to
determine if you have the necessary tools, instruments and skills
required to perform the procedure. Procedures for which you do
not have th e necessary t oo ls, in strument s and skills should be
performed b y a trained Vulcan Service Technician.

52065
52093

Reproduction or other use of this Manual, without the express
written consent of Vulcan-Hart, is prohibited

A product of VULCAN-HART LOUISVILLE , KY 40201-0696
Form 24599 ( 11/97)

.

MOBILE F ILTER

TABLE OF CONTENTS

GENERAL............................................................................. 3

Introduction ........................................................................ 3

Cleaning .......................................................................... 3

Tools ............................................................................. 3

Control Location..................................................................... 3

REMOVAL AND REPLACEMENT OF PARTS ................................................. 3

Motor/switch Cover .................................................................. 3

Switch ............................................................................ 4

Heater Tube ........................................................................ 4

Motor / Pump....................................................................... 5

SERVICE PROCEDURES AND ADJUSTMENTS ............................................... 5

Pump Clean- out ..................................................................... 5

Motor Reset........................................................................ 6

Heating Element Test ................................................................ 6

ELECTRICAL OPERATION ............................................................... 6

Component Func tion ................................................................. 6

Wiring Diagram ..................................................................... 7

Schematic ......................................................................... 7

TROUBLESHOOTING ................................................................... 8

© Vulcan 1997

2

MOBILE F ILTER - GENE RA L

GENERAL

INTRODUCTION

• Mobile filters are used with fr y er s equi pped wi th
the Filter Ready option or Batter y Inter-plumb
Systems.

• Use 1/3 HP pump m otor which is rated at 5.6
gal/min.

• The model 50 can be used with 3 and 4 burner
fryers and can handle up to 50 pounds of frying
compound.

• The model 85 can be used with 5 burner fr y er s
and can handle up to 85 pounds of frying
compound.

CLEANING

Cleaning i nstructions can be found in the
“INSTRUCTION MANUAL”.

CAUTION: Do not run water or cleaning
compound through the pump.

TOOLS

• Standard set of hand tools

• VOM with AC current tester (Any VOM with a
sensitivity of at l east 20,000 ohms per volt can
be used.)

CONTROL LOCATION

SPECIFICATIONS

Model Volts Amps

Motor

50 120 5.0 .625 12” 16½” 31”
85 120 5.0 .625 16” 16I ” 32 ”

* Height measured with qui c k c onnec t in rai sed posit ion.

Amps

Heater

REMOVAL AND REPLACEMENT OF PARTS

MOTOR/SWITCH COVER

WARNING:

BURNS. USE CARE WHEN SE RV ICING THE
FILTER.

WARNING:

1. Empty the oil from tank and remove the fil ter.

2. Remove the wheels fr om the m otor end of t he
filter.

HOT OIL A ND P A RTS CAN CAUSE

UNPLUG UNIT BEFORE SERVICING.

Width Height* Length

3. Remove the screws that secure the cover.

3