Vulcan Hart GR45F, GR65F, GR85F General Manual
FRYERS
GR KLEENSCREEN PLUS® FILTRATION SYSTEM
BUILT-IN FILTER SYSTEM FOR 2GRF, 3GRF & 4GRF FRYERS
Model
2GR45DF
SPECIFICATIONS
Built-in lter system, Vulcan-Hart Model No. 2GR (lb. capacity –
45, 65 or 85) (control type M, A, D, or C) F (add sufx-F to fryer
battery model No., i.e. 2GR45DF). Filter system accommodates
minimum of two, maximum of four cabinets for GR45F and
maximum of three for GR65F and GR85F. Filter vessel constructed
of 18 gauge series stainless steel. The 2GR45F lter pan
weighs only 12.2 lbs. and the lter pan for the 2GR65 & GR85F
weighs only 20.5 lbs.
compound at the rate of 8 gallons per minute, activated by a
solenoid push button switch. System provided standard with
paperless stainless steel mesh lter screen. A complimentary
package of KleenScreen PLUS
Standard equipment comes on casters, a primary crumb catch
basket, tank brush, scoop and clean-out rod. Hands free oil return
line connection. Drain valve interlock switch turns fryer's burners
off when drain valve is opened on (A), (D) and (C) controls. Requires
120 volt, 60 Hz, 1 phase power supply.
CSA design certied. NSF listed.
1
⁄3 H.P. motor/pump circulates hot frying
®
Fabr ic E nvelo pes is a lso included.
Item # C.S.I. Section 11420
STANDARD FEATURES
Filter system accommodates minimum of two, maximum ■
of four fryer cabinets (GR45F), maximum of three
(GR65F or GR85F)
Boil Out ByPass ■
™
removes water
Drain valve interlock switch – turns off gas burners ■
automatically when draining oil on (A), (D), and (C) controls
6" Casters adjustable – 2 locking, 2 non-locking ■
Drawn (seamless) 18 gauge stainless steel lter pan. 70 lbs. ■
frying compound capacity on GR45F, 110 lbs. capacity on
GR65 & GR85F
Paperless stainless steel lter screen lters from 2 sides ■
lter area = 270 square inches. Micro Filtration Fabric
Envelope lter area = 350 square inches
1
■
⁄3 H.P. motor and pump circulates frying compound at a rate
of 8.0 gallons per minute
Solenoid activated one touch push button switch to engage ■
pump and motor (solid state controls (A) & (D) and
computer (C) models only)
6' High Temperature Discard Hose. ■
Large primary crumb catch basket ■
Tank brush, stainless steel crumb scoop and clean-out rod ■
120 volt, 60 Hz, 1 phase (NEMA 5-15P) ■
One year limited parts and labor warranty ■
10 year fry tank limited warranty ■
ACCESSORIES (Packaged & Sold Separately)
Stainless steel tank cover – doubles as a work surface top
Micro-Filtration Fabric Envelopes – 6 lters/per package
“Add-On” Frymate™ – VX15 or VX21S
Rear oil reclamation discard connection (Factory Installed)
GR45F – Twin Basket Lifts (Factory Installed)
GR65F & GR85F – Single and Twin Basket Lifts
(Factory Installed)
Prison Security Package (Factory Installed)
Flexible gas hose with quick disconnect
OPTIONS
SPECIF Y TYPE OF GAS WHEN ORDERING
Natural Gas
Second year extended limited parts and labor warranty
REFERENCE MATERIALS
Propane Gas
See 1GR45 Spec Sheet F32630 ■
SPECIF Y ALTITUDE
Natural Gas for above 2,000 ft.
See 1GR65 Spec Sheet F32631 ■
See 1GR85 Spec Sheet F32632 ■
Propane Gas for above 3,500 ft.
a divisi on of ITW F ood Equip ment Gro up LLC
P.O. Box 696 ■ Louisville, KY 40201 ■ Toll-free: 1-800-814-2028 ■ Local: 502-778-2791 ■ Quote & Order Fax: 1-800-444-0602
F32530 (07/10)
INSTALLATION INSTRUCTIONS
2GR45F, 2GR65F
31.000" (787)
2GR85F
42.000" (1067)
.875" (22)
6.000"
(152)
9.000"
(288)
2GR85F
34.375"
(1168)
2GR45F,
2GR65F
30.125"
(765)
2GR45F,
2GR65F
48.750"
(1238)
2GR85F
54.375"
(1387)
36.250"
(921)
46.250"
(1175)
FRYERS
GR KLEENSCREEN PLUS® FILTRATION SYSTEM
BUILT-IN FILTER SYSTEM FOR 2GRF, 3GRF & 4GRF FRYERS
A combination valve with pressure regulator is provided with 1.
this unit.
• Natural Gas 4.0" (102 mm) W.C.
• Propane Gas 10.0" (254 mm) W.C.
An adequate ventilation system is required for Commercial 2.
Cooking Equipment. Information may be obtained by writing
to the National Fire Protection Association, Batterymarch Park,
Quincy, MA 02269. When writing refer to NFPA No. 96.
All models require a 6" (152 mm) clearance at both sides and rear 3.
adjacent to combustible construction.
All models require a 16" (407 mm) minimum clearance to adjacent 4.
open top burner units.
This appliance is manufactured for commercial installation only 5.
and is not intended for home use.
Service Connections:
11⁄4" (32 mm) NPT common rear gas connection.
120 volt, 60 Hz, 1 phase electrical connection (NEMA 5-15P).
NOTE: In line with its policy to continually improve its product,
Vulcan reserves the right to change materials and specications
without notice.
Views
Front, Side and Top
2GR45F, 2GR65F, 2GR85F,
Model
Filter Pan
Capacity
GR45F 70 lbs.
GR65F
110 lbs.
GR85F
Filter Area /
Fabric
Envelope Motor Pump
1
⁄3 HP
1750 RPM
1
⁄3 HP
1750 RPM
270 sq. in
350 sq. in
270 sq. in
350 sq. in
Electric
Amps
Electric
Power
8 Gal /Min 115V 5.0A 115V 60Hz 1Ph 31" 46
8 Gal / Min 115V 5.0A 115V 60Hz 1Ph 42" 63" —
This appliance is manufactured for commercial use only and is not intended for home use.
a divisi on of ITW Food Equip ment Gro up LLC
P.O. Box 696 ■ Louisville, KY 40201 ■ Toll-free: 1-800-814-2028 ■ Local: 502-778-2791 ■ Quote & Order Fax: 1-800-444-0602
F32530 (07/10)
Battery Dimensions (Widths)
2
Fryers3 Fryers4 Fryers
1
⁄2" 62"
Loading...