Volvo 31330114, 9487196, 31330113, 9487195, 31330811 Installation Instructions Manual
...
Instruction No
Version
Part. No.
31330111
1.3
31330114, 31330113, 9487196, 9487195, 9487194, 31330811, 31330810, 31330115, 31330112, 31330614,
31330613
Navigation system, portable
IMG-
346750
Instruction No
Version
Part. No.
31330111
1.3
31330114, 31330113, 9487196, 9487195, 9487194, 31330811, 31330810, 31330115, 31330112, 31330614,
31330613
Navigation system, portable
IMG-
346750
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Navigation system, portable- 31330111 - V1.3
Page 1 / 41
Equipment
IMG-
242205
A0000162
IMG-
239664
IMG-
239660
IMG-
327738
IMG-
239681
IMG-
239682
IMG-
240673
IMG-
239944
IMG-
239980
IMG-
244945
IMG-
317443
IMG-
348826
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Navigation system, portable- 31330111 - V1.3
Page 2 / 41
INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
Note!
Some steps in these installation instructions are presented
with illustration only.
These installation instructions apply to left-hand drive
vehicles. When installing in a right
-hand drive vehicle, the
procedure is carried out on the opposite side and/or mirrored.
Where the version differs, right-hand versions are also
displayed with text and images.
Applies to the S60 (11-)/V60
Note!
In instances where installation kit TMC is to be installed,
perform this at the same time.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Navigation system, portable- 31330111 - V1.3
Page 3 / 41
1
IMG-
332193
Set the ignition key to position 0.
Note!
Wait at least one minute before unplugging the connectors or
removing other electrical equipment.
2
IMG-
339918
3
IMG-
346741
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Navigation system, portable- 31330111 - V1.3
Page 4 / 41
4
IMG-
346751
Remove the marked components.
5
IMG-
346752
Remove the screws.
6
IMG-
346745
Remove the marked components.
Unplug the connector.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Navigation system, portable- 31330111 - V1.3
Page 5 / 41
7
IMG-
347861
Remove the rubber strip.
8
IMG-
346753
Remove the screw.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Navigation system, portable- 31330111 - V1.3
Page 6 / 41
9
IMG-
346731
Remove the panel.
10
IMG-
346742
11
IMG-
346728
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Navigation system, portable- 31330111 - V1.3
Page 7 / 41
12
IMG-
346755
Cut out the discs.
13
IMG-
347232
Place the mountingA over the drilled hole.
14
IMG-
346729
Centred the hole in the mounting Aopposite the drilled hole in the
panel.
Adjust the mounting so that it is fully against the panel and hold
fast.
Drill out the two holes.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Navigation system, portable- 31330111 - V1.3
Page 8 / 41
15
IMG-
346740
16
IMG-
346730
Carefully drill out the mounting and panel.
Drill horizontally.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Navigation system, portable- 31330111 - V1.3
Page 9 / 41
17
IMG-
346732
Remove the screws.
18
IMG-
347714
Adjust the cable length so that the end of the marking is as
illustrated.
19
IMG-
348302
Adjust the cable length so that the end of the marking is as
illustrated.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Navigation system, portable- 31330111 - V1.3
Page 10 / 41
20
IMG-
347715
Installing holder
Note!
Be sure to position the mounting (A) so that it is against the
panel.
21
IMG-
347716
22A
IMG-
347717
Illustrations A and B
Insert the cables in the dashboard.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Navigation system, portable- 31330111 - V1.3
Page 11 / 41
22B
IMG-
348171
23A
IMG-
348235
23B
IMG-
348234
Illustrations A and B
Reinstall the panel.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Navigation system, portable- 31330111 - V1.3
Page 12 / 41
24
IMG-
298585
Applies to all vehicles
Remove the panel.
Right-hand drive vehicles
Applies to both sides.
25
IMG-
340522
Applies to all vehicles
Remove the panel.
26A
IMG-
303385
Illustrations A and B
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Navigation system, portable- 31330111 - V1.3
Page 13 / 41
Loading...