Volvo 31285547 Installation Instructions Manual

Instruction No Version Part. No.

31310093 1.3 31285547

USB/Ipod Music Player, Bluetooth handsfree

Instruction No Version Part. No.

31310093 1.3 31285547

USB/Ipod Music Player, Bluetooth handsfree

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 1 / 56

Equipment

IMG-

242205

A0000162

IMG-

239664

IMG-

332314

IMG-

246925

IMG-

333125

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 2 / 56

IMG-

331666

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 3 / 56

IMG-

333126

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 4 / 56

INTRODUCTION

Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to

minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available

before starting installation.
Certain steps in the instructions are only presented in the form

of images. Explanatory text is also given for more complicated
steps.

In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.

Note!

This installation instruction shows the installation of the
USB/iPod adapter and Handsfree with Bluetooth on left-hand
drive vehicles. When installing in right-hand drive vehicles the
steps are performed on the opposite side and/or mirrored. The
right-hand drive design is also shown with text and pictures
when operations differ.

When installing Velcro fasteners/tape the underlying surface
must be kept at a temperature of at least +20° C (68°F).

The cable between USB/iPod adapter and music player can be
ordered for USB, iPod, or both.

Wiring A is for vehicles with an internal amplifier that is
located in the media player.

Wiring B and C are for vehicles with an external amplifier,
located on the left-hand side of the cargo compartment.

Cars with Performance Sound have internal amplifier.
Cars with the High Performance and Premium Sound audio

systems have external amplifier.
There may be components in the accessories kit that are not

used for this installation.
Place the manual for this accessory in a suitable place in the

vehicle.

Preparations

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 5 / 56

1

IMG-

245980

Preparations

Turn the ignition key to position 0.

Note!

Wait at least three minutes before unplugging the connectors or
removing other electrical equipment.

2

J8504532

Open the glovebox.
Carefully pry off the panel at the rear of the centre console. Use

a plastic weatherstrip tool. The panel is attached by two clips on
each of the short sides.

Pull the panel away downwards.

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 6 / 56

3

IMG-

239762

Apply tape to the center console to protect it during removal and
installation of the glove compartment.

4

IMG-

240082

Remove the panel.

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 7 / 56

5

IMG-

244221

Detach the clip holding the vent from the glove compartment.

6

J8803318

Remove the rubber mat from the glovebox.
Remove the 5 x screws from the opening.
Pull the glovebox straight back in the vehicle in order to release

the hidden clips, 2 pcs, in the top edge.
Remove the outer section of the glovebox.

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 8 / 56

7

IMG-

222669

Unplug the connectors on the top.

8

IMG-

239763

Remove the screws for the vent.
Pull off the vent to the right and place to one side.

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 9 / 56

9

J8504871

Remove the clips at the rear edge of the soundproofing panel
and remove it.

10

J8504893

Remove the surround around the display and media player:
Press in the catch at one of the surround's upper corners. Use a

small screwdriver. Carefully pry off the surround on the same
side. Use a plastic weatherstrip tool.

Note!

Do not damage the panel and dashboard.

Repeat the procedure for the other side and then fold the
surround backwards into the vehicle. Pull the surround up until it
detaches.

Hint

If the panel is difficult to remove, press the panel on both sides
again and repeat the procedure starting at the other side.

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 10 / 56

11

J8504534

Remove the ignition control module (ICM). It is secured by hidden
clips, 2 pcs.

Hint

Grip with both hands and pull.

Disconnect the two connectors. Put the display to one side.

12

IMG-

263205

Detach the hand brake panel by pulling it carefully sideways.

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 11 / 56

13

IMG-

273610

Fold up the tunnel console's armrest and remove the cover at the
bottom.

14

IMG-

273611

Loosen the rear edge of the panel, it should not be completely
removed.

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 12 / 56

15

IMG-

273630

Remove the two screws.

16

IMG-

270744

Applies to all models

Remove the two screws along the front edge of the tunnel
console.

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 13 / 56

17

IMG-

263505

Remove the front storage compartment by prying it off at the
front edge using a weatherstrip tool and lifting it out.

18

IMG-

263586

Carefully lift the catches at the front edge of the tunnel console.

Hint

Use special tool, P/N 9995919.

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 14 / 56

19

IMG-

263587

Hold up the lock catch and at the same time slide the entire tunnel
console back 20 mm, so that the two rear screws in the centre
console are accessible.

20

IMG-

263589

Remove the two screws.

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 15 / 56

21

IMG-

270745

Applies to cars with manual gearbox

Remove the gear selector lever boot from the center console.
First pry it off at the front edge using a weatherstrip tool and
then unhook it at the rear edge.

22

IMG-

240085

Remove the two screws holding the centre console's panel to
the dashboard.

Loosen the connector to the centre console at the rear.
Remove the center console.

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 16 / 56

23

IMG-

268148

Lift up the tunnel console and pull it back slightly.
Unplug the big gray connector at the front.

24

IMG-

269724

Lift out the console and turn it upside down

Note!

Protect hand brake and gear lever when removing and installing
the tunnel console.

Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

©

Volvo Car Corporation USB/Ipod Music Player, Bluetooth handsfree- 31310093 - V1.3

Side 17 / 56