Volvo S60, 2011 S60 Wiring Diagram
WIRING DIAGRAM 2011
VOLVO S60 (11-)
TP 39203202
© Volvo Car Corporation
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never fit accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Do not install any accessories in the areas between the A and B-posts, the B and C-posts,
and the C and D-posts.
Test terminal
Fuse in cargo compartment auxiliary fuse box.
Changes introduced up to May 2010
Any changes made to the vehicle after this date are not included in the manual. If necessary,
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Ordering:
Electronic Wiring Diagrams (EWDs) can be ordered from the Technical Information Shop
(TIS) at www.volvocarstechinfo.ford.com/vss
We retain the right to make modifications.
TP39203202 S60 (11-) 3
Vehicles with SRS (Airbag)/SIPS bag /IC
(Inflatable curtain).......................................................... 2
Explanations .................................................................. 6
Abbreviations................................................................. 6
How to use the wiring diagrams 1:2............................... 7
Overview, Electrical center and Cold zone in engine
compartment.................................................................. 9
Overview, Distribution box in cargo compartment ....... 10
Overview, Distribution box in passenger compartment 11
Fuses
Distribution box in engine compartment F1-F7............. 12
Distribution box in engine compartment F8-F23........... 13
Distribution box in engine compartment F27-F36......... 14
Distribution box in engine compartment F37-F38......... 15
Engine compartment electrical center F39-F44............ 16
Central Electronic Module (CEM) F1 - F8.....................17
Central Electronic Module (CEM) F9 - F19...................18
Central Electronic Module (CEM) F20 - F24.................19
Distribution box in passenger compartment F1 - F17... 20
Distribution box in passenger compartment F18 - F30. 21
Distribution box in cargo compartment FA1-FA11........ 22
Battery PF1-PF2........................................................... 23
Relays
Relays in the engine compartment R1-R2................... 24
Relays in the engine compartment R8......................... 25
Relays in the engine compartment R10-R13............... 26
Relays in passenger compartment R1 - R4................. 27
Cargo compartment RA1 - RA2................................... 28
Ground connections
Overview...................................................................... 29
31/1 - 31/7 ................................................................... 30
31/10 - 31/15 continues ............................................... 31
31/15 - 31/68 ............................................................... 32
31/83 - 31/89 ............................................................... 33
31/90 - 31/XX10........................................................... 34
31/XX14 - 31/TRM....................................................... 35
Control modules
Overview locations....................................................... 36
Overview designations................................................. 37
Central Electronic Module (CEM) 1:3 .......................... 38
Data communication, High speed CAN ....................... 41
Data communication intermediate speed CAN, LHD... 42
Data communication intermediate speed CAN, RHD .. 43
Data communication Local CAN.................................. 44
Data communication LIN 1:2 ....................................... 45
Data communication MOST......................................... 47
Steering Wheel Module (SWM) ................................... 48
Group 23 Fuel system
Engine management system, 4-Cyl. Turbo 1:2............ 49
Engine management system, 6-Cyl. Turbo 1:2............ 51
Engine management system, 5-Cyl. Diesel
EURO5 1:3 .................................................................. 53
Emission control 4-Cyl. Turbo...................................... 56
Emission control 6-Cyl. ............................................... 57
Group 26 Cooling system
Cooling fan 4-Cyl. Turbo.............................................. 58
Cooling fan 5-Cyl. Diesel EURO5................................ 59
Cooling fan 6-Cyl. ........................................................ 60
Group 27 Engine controls
Cruise control 4-Cyl. Turbo ...........................................61
Cruise control 5-Cyl. Diesel ..........................................62
Cruise control 6-Cyl. .....................................................63
Group 32 Alternator and voltage regulator
Power supply 4-Cyl...................................................... 64
Power supply 5-Cyl.&6-Cyl. ......................................... 65
Group 33 Starting system
Starting system 4-Cyl................................................... 66
Starting system, 5-Cyl. & 6-Cyl.................................... 67
Group 35 Lighting
High and low beam ...................................................... 68
High and low beam (Dual Xenon) ................................ 69
Beam length adjustment, manual ................................ 70
Running/Parking light, Tail lights S60 .......................... 71
Running/Parking light, Tail lights V60 .......................... 72
Running/Parking light, Tail lights (Dual Xenon) S60 .... 73
Running/Parking light, Tail lights (Dual Xenon) V60 .... 74
Fog lights S60.............................................................. 75
Fog lights V60.............................................................. 76
Brake lights S60........................................................... 77
Brake lights V60........................................................... 78
Reversing lights S60.................................................... 79
Reversing lights V60.................................................... 80
Follow-me-home lighting LHD...................................... 81
Follow-me-home lighting RHD..................................... 82
Interior lighting, LHD 1:2 .............................................. 83
Interior lighting, LHD 2:2 .............................................. 84
Interior lighting, RHD 1:2.............................................. 85
Active headlight ........................................................... 87
Lighting in door sill trims .............................................. 88
Auxiliary lights.............................................................. 89
Table of Contents 1:3
TP39203202 S60 (11-) 4
Group 36 Additional electrical equipment
Rain sensor.................................................................. 90
Direction indicator and hazard warning
flashers LHD S60......................................................... 91
Direction indicator and hazard warning
flashers LHD V60......................................................... 92
Direction indicator and hazard warning
flashers RHD S60........................................................ 93
Direction indicator and hazard warning
flashers RHD V60........................................................ 94
Wiper/washer windshield............................................. 95
Washer headlights....................................................... 96
Wiper/Washer rear windowV60 ................................... 97
Horn ........................................................................ 98
Keyless vehicle 1:2...................................................... 99
Anti-theft alarm .......................................................... 101
Parking assistance..................................................... 102
Collision warning with power brake booster .............. 103
Tire pressure monitoring system (TPMS) .................. 104
Group 37 Wiring and fuses
Diagnostics system.................................................... 105
12 V outlet, S60 ......................................................... 106
12 V outlet, V60 ......................................................... 107
Cable harness towbar/tow hitch 13-pin S60 .............. 108
Cable harness towbar/tow hitch 13-pin V60 .............. 109
Group 38 Instruments
Seat belt reminder ..................................................... 110
Driver information module.......................................... 111
Group 39 Other
Audio Premium 1:3 .................................................... 112
Audio 1:2 ................................................................... 115
Cellular phone 1:2...................................................... 117
DAB Radio................................................................. 119
Multimedia monitor with DVD, Dual Screen (RSE).... 120
TV receiver / TV control module S60......................... 121
TV receiver / TV control module V60......................... 122
Bluetooth Handsfree.................................................. 123
Navigation system and Traffic information, portable.. 124
Satellite radio............................................................. 125
Parking camera front ................................................. 126
Parking camera rear .................................................. 127
Parking camera wide angle front ............................... 128
Group 43 Transmission
Transmission M66...................................................... 129
Automatic transmission, TF-80SC AWD.................... 130
Automatic transmission MPS6................................... 131
Differential Electronic Module (DEM)......................... 132
Group 55 Parking brake
Electric parking brake ................................................ 133
Group 59 Brake system
Brake control system & DSTC ................................... 134
Group 64 Steering
Speed dependent power steering .............................. 135
Group 76 Shock absorbers
Four-C ...................................................................... 136
Group 83 Doors and openings
Central locking front doors LHD................................. 137
Central locking front doors RHD ................................ 138
Central locking rear doors.......................................... 139
Central locking tailgate S60 ....................................... 140
Central locking tailgate V60 ....................................... 141
Central locking fuel filler flap...................................... 142
Signal receiver central locking ................................... 143
Power windows front doors LHD................................ 144
Power windows front doors RHD ............................... 145
Power windows rear doors......................................... 146
Power sunroof............................................................ 147
Group 84 Exterior decorative elements, etc.
Power door mirrors LHD ............................................ 148
Power door mirrors RHD............................................ 149
Heated door mirrors LHD........................................... 150
Heated door mirrors RHD .......................................... 151
Blind spot information system LHD............................ 152
Blind spot information system RHD ........................... 153
Heated rear window................................................... 154
Table of Contents 2:3
TP39203202 S60 (11-) 5
Group 85 Interior equipment
Power driver’s seat with memory function, LHD ........ 155
Power driver’s seat with memory function, RHD ....... 156
Power passenger seat, LHD...................................... 157
Power passenger seat, RHD ..................................... 158
Heated front seats ..................................................... 159
Heated rear seat........................................................ 160
Group 87 Climate control system
Climate control system, 4-Cyl. 1:2............................. 161
Climate control system 5-Cyl. & 6-Cyl. 1:2 ................ 163
Climate control system PTC-elements ...................... 165
Parking heater, auxiliary heater ................................. 166
Parking heater, remote start ...................................... 167
Group 88 Internal equipment
Rear-view mirror with automatic dimming.................. 168
Supplemental restraint system 1:2 ............................ 169
Remote control opener garage door.......................... 171
Group 89 Body other
Radiator masking blind .............................................. 172
Connectors .............................................. 173
Branching points .....................................204
Cable harness routing in vehicle
Harness engine 4-Cyl. Turbo......................................219
Harness engine, 6-Cyl. Turbo.....................................219
Harness engine, 2.0L Diesel.......................................220
Harness engine, 2.4L Diesel.......................................220
Engine compartment harness LHD.............................221
Engine compartment harness RHD ............................222
Harness dashboard, LHD ...........................................223
Harness Dashboard, RHD ..........................................224
Harness Floor, LHD S60.............................................225
Harness Floor, RHD S60 ............................................226
Floor Harness, LHD V60.............................................227
Harness Floor, RHD V60 ............................................228
Harness infotainment, LHD S60 .................................229
Harness infotainment, RHD S60................................. 230
Harness infotainment, LHD V60 .................................231
Harness infotainment, RHD V60................................. 232
Roof harness, S60 ......................................................233
Roof harness V60 .......................................................233
Center console harness..............................................234
Tunnel harness ...........................................................234
Harness front door, left ...............................................235
Harness front door, right .............................................235
Harness rear door, left ................................................236
Harness rear door, right..............................................236
Trunk lid/tailgate harness, S60 ...................................237
Trunk lid/tailgate harness, V60 ...................................237
Harnesses rear axle....................................................238
Component illustrations ..........................239
Index 1:3 ....................................................293
List of components 1:6 ............................295
Table of Contents 3:3
TP39203202 S60 (11-) 6
Explanations
Abbreviations
Groups
Group 23 = Fuel system
Group 26 = Cooling system
Group 27 = Engine controls
Group 32 = Alternator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 55 = Parking brake
Group 59 = Brake system
Group 64 = Steering
Group 76 = Shock absorbers
Group 83 = Doors and openings
Group 84 = Exterior decorative elements, etc.
Group 85 = Interior equipment
Group 87 = Climate control system
Group 88 = Internal equipment
Designations ignition switch
X = Accessories (audio position)
S = Powered upon insertion of key
15 = The switch remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A = Austria
AUS = Australia
B = Belgium
CDN = Canada
CH = Switzerland
D = Germany
DK = Denmark
E= Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J = Japan
KOR = Korea
N= Norway
NL = Netherlands
S = Sweden
USA = United States of America
WEU = Western Europe
Other
ACC = Adaptive Cruise Control
Ag = Silver plated
Au = Gold plated
AUTO = Automatic transmission
BLIS = Blind Spot Information System
CAN = CAN communication
DPY = Display
ECC = Electronic climate control system
ETA = Throttle unit
EXC = Exclusive
GDL = Gas discharge lamp
HS = High speed data bus
KEYLESS = Keyless vehicle
IR = Infrared sensor
LIN = LIN communication
LH = Left-hand side
LHD = Left-hand drive
MAN = Manual transmission
MEMORY = Memory driver’s seat
MIRCAM = Parking camera in rear-view mirror
MS = Midspeed data bus
MMS = Mass Movement Sensor
PANROOF = Panoramic roof
PETROL = Gasoline
RH = Right-hand side
RHD = Right-hand drive
RTI = Road Traffic Information
SCR = Screened
SRS = Airbag
T = Turbo engine
W/O = Without
2WD = Two-wheel drive
4CYL, I4 = 4-cylinder engine
5CYL, I5 = 5-cylinder engine
6CYL, I6 = 6-cylinder engine
Colors
BK, SB = Black
BN = Brown
BU, BL = Blue
GN = Green
GY, GR = Gray
LGN = Light Green
NL = Natural
OG, OR = Orange
PK, P = Pink
RD, R = Red
VT, VO = Violet
WH, W = White
YE, Y = Yellow
TP39203202 S60 (11-) 7
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily contained in this manual.
The systems are shown in not active status, i.e. "key removed" and when doors,
trunk lid/tailgate and hood are closed.
How to use the wiring diagrams 1:2
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial number, for example x/2.
Combined these give a component designation, for
example 3/2.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respective type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2Relay
3 Switch
4 Control module
5 Driver Information Module
6 Electric motor
7Sensor
8 Actuator
9 Heating element
10 Light
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
27 Optics
31 Ground connection
73 Branching point
74 Connector
B. Branching points
The wiring diagrams contain numbered branching
points, for example 73/5035.
This manual contains a section with a list of branching points. This list shows all the components which
are connected to each branching point.
The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable harnesses and are described in the
"Connectors" section.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Today’s cars contain CAN, LIN and MOST networks
that transfer information. Connections to these networks are not shown in their entirety in the respective wiring diagram. Complete information on CAN,
LIN and MOST communication is found in the section "Control modules".
F. Abbreviations
A number of different abbreviations are used in the
manual. These are explained in the section "Abbreviations".
G. Component location
The end of the manual contains a section that
describes component appearance and location in
numerical order.
TP39203202 S60 (11-) 8
How to use the wiring diagrams 2:2
Explanation of symbols
= System voltage
= Ground connection via wiring
= Ground connection in component/chassis
= Screened wire
= Branching point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal (CAN H)
= CAN low data signal (CAN L)
= LIN communication
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
= CAN communication
= MOST communication
= MOST communication
= Connection with distribution box
= Further connection to...
= Connector between cable
harnesses
= Connector connected in
component
TP39203202 S60 (11-) 9
Electrical distribution 1:3
Overview, Electrical center and Cold zone in engine compartment
15/31
15/33
11B/36
21
11B/37
21
11B/38
21
11B/41
11B/18
12
11B/16
12
11B/17
73/3068
73/3085
12
11B/19
12
1
1B/20
12
1
1B/21
12
1
1B/22
12
11B/23
12
11B/28
12
11B/29
12
RD-VT
RD-VT
YE-GN
YE-GN
RD-VT
RD
RD
RD
RD
GY-BK
RD
RD
GN-VT
RD-BK
RD_BU
RD-GN
RD-GY
RD-BN
15/36
15/36
15/32
4/56C5:2
4/56C5:1
RD
RD
RD
RD
RD
RD
4/46B:16
6 CYL
RD
RD
RD
RD
RD
RD
RD
RD
GY-VT
GY-VT
GY-VT
GY-VT
RD
RD-BK
RD
11B/27
12
11A/1
11A/2
11A/3
11A/4
11A/5
11A/6
12
11A/7
12
12
12
12
12
12
21
11B/40
21
11B/39
21
11A/43
21
11A/42
21
11A/44
21
11B/33
21
11B/32
21
11B/31
21
11B/30
21
11B/35
21
11B/34
21
2
1
3
5
2/22
R13
R10
2
1
3
5
2/31
R8
2
1
3
5
2/32
2
1
3
5
2/17
R2
2
1
3
5
2/35
R12
11B/13
11B/11
11B/9
11B/12
11B/10
12
11B/14
12
12
12
12
12
11B/8
12
73/3076
6/25
31
M
ACM
30
C1:1
6/26
B+
31
G
C1:1
12V
BK
31/3
1/1
PF1
PF2
2
1
1
2
LIN
2
1
3
5
2/182
R1
9/42
4/56C1:45
4/56C1:65
73/3041
73/3138
RD
RD-VT
RD
2/142
R11
5 Cyl. Diesel
2/133
R11
4 Cyl. T
4 Cyl. T &
4 Cyl. T
4 Cyl. T
5 Cyl. D
5 Cyl. D
BU-OG
GN-OG
GN-OG
BU-OG
YE-GN
74/301
16
G042211
TP39203202 S60 (11-) 10
Electrical distribution 2:3
Overview, Distribution box in cargo compartment
11D/A7
21
11D/A6
21
11D/A5
21
11D/A8
21
11D/A3
21
11D/A2
21
11D/A1
21
11D/A4
21
11D/A10
21
11D/A9
21
11D/A11
21
11D/A12
21
2
1
3
5
2/82
15/32
RA2
2
1
3
5
A
RA1
RD-GN
RD-GN
RD-GN
RD-GN
RD-VT
RD-VT
73/5075
2/16
15/31
11A/3
12
3
74/504B
RD-GN
15/31
2
30+
2
G042220
TP39203202 S60 (11-) 11
2
1
3
5
4
R2
R1
2/88
2
1
3
5
4
R3
2
1
3
5
R4
2/193
2
1
3
5
11C/3
12
11C/2
12
11C/1
12
11C/4
12
11C/7
12
11C/6
12
11C/5
12
11C/8
12
11C/10
12
11C/9
12
11C/11
12
11C/14
12
11C/13
12
11C/12
12
11C/15
12
11C/18
12
11C/17
12
11C/19
12
11C/25
12
11C/24
12
11C/23
12
11C/22
12
11C/21
12
11C/16
12
11C/20
12
11C/27
12
11C/26
12
12
11C/28
12
11C/29
12
11C/30
RD
RD
RD
RD
RD
73/5117
15/36
15/31
11A/5
1
2
11A/4
1
2
30+
RD-BN
RD-GY
G042227
Electrical distribution 3:3
Overview, Distribution box in passenger compartment
TP39203202 S60 (11-) 12
Fuses
Distribution box in engine compartment F1-F7
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F1 11A/1 4/56 Central Electronic Module (CEM)
F7 Fuse in the Central Electronic Module (CEM)
F9-F11 Fuses in the Central Electronic Module (CEM)
F21 Fuse in the Central Electronic Module (CEM)
F23 Fuse in the Central Electronic Module (CEM)
relay in CEM
relay in CEM
relay in CEM
relay in CEM
50
F2 11A/2 4/56 Central Electronic Module (CEM)
F3-F6 Fuses in the Central Electronic Module (CEM)
F8 Fuse in the Central Electronic Module (CEM)
F13-F16 Fuses in the Central Electronic Module (CEM)
F22 Fuse in the Central Electronic Module (CEM)
F24 Fuses in the Central Electronic Module (CEM)
relay in CEM
relay in CEM
-
-
-
50
F3 11A/3 11D/A1-11D/A11 Fuses in distribution box cargo compartment - 60
F4 11A/4 2/193 Relay, comfort functions
11C/1-11C/15 Fuses in distribution box passenger compartment
11C/21-11C/22 Fuses in distribution box passenger compartment
11D/A5 Fuses in distribution box cargo compartment
-
-
2/193
-
60
F5 11A/5 2/88 Relay, 15-feed
11C/23-11C/25 Fuses in distribution box passenger compartment
11C/26-11C/30 Fuses in distribution box passenger compartment
-
2/88
60
F7 11A/7 9/42 PTC-element - 100
continues
TP39203202 S60 (11-) 13
Fuses
Distribution box in engine compartment F8-F23
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F8 11B/8 2/182 Relay, headlight washer motor
6/104 Washer motor headlights
-
2/182
20
F9 11B/9 6/1 Wiper motor module (WMM) - 30
F10 11B/10 4/7 Combustion Preheater Module (CPM)
4/106 Control module, remote parking heater start
-
-
25
F11 11B/11 4/31 Fan control module
6/28 Motor, passenger compartment fan
-
-
40
F13 11B/13 4/16 Brake Control Module (BCM), pump - 40
F14 11B/14 4/16 Brake Control Module (BCM), valves - 20
F16 11B/16 4/118 Headlamp control module (HCM)
10/1 Left-hand front lamp housing
10/2 Right-hand front lamp housing
-
-
-
10
F17 11B/17 4/56 Central Electronic Module (CEM)
F18-F20 Fuses in the Central Electronic Module (CEM)
-20
F18 11B/18 4/16 Brake Control Module (BCM) - 5
F19 11B/19 4/99 Electronic power steering control module
6/164 Electrical power steering module (EPS)
-
-
5
F20 11B/20 4/9 Supplemental Restraint System (SRS)
4/28 Transmission Control Module (TCM)
4/46 Engine Control Module (ECM)
-
-
-
10
F21 11B/21 9/43 Heated windshield washer nozzle, left
9/44 Heated windshield washer nozzle, right
-
-
10
F22 11B/22 2/133 Relay vacuum pump - 5
F23 11B/23 3/111 Light Switch Module (LSM) - 5
continues
TP39203202 S60 (11-) 14
Fuses
Distribution box in engine compartment F27-F36
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F27 11B/27 2/31 Relay, 15-feed - 5
F28 11B/28 2/64 Relay auxiliary lights
10/65 Auxiliary light, front right
10/69 Auxiliary light, front left
-
2/64
2/64
20
F29 11B/29 2/17 Relay, horn
16/10 Horn 1
16/11 Horn 2
-
2/17
-
15
F30 11B/30 2/32 Main relay, engine management system
4/46 Engine Control Module (ECM)
-
-
10
F31 11B/31 4/28 Transmission Control Module (TCM) - 15
F32 11B/32 8/3 Electromagnetic clutch, climate control system 2/22 15
F33 11B/33 2/22 Relay, climate control system - 5
F34 11B/34 6/25 Starter motor 2/35 30
F35 11B/35 4/109 Control module glow plug, 5-Cyl. Diesel
20/3-6 Spark plug with ignition coil, 4-Cyl. Turbo
-10
20/3-8 Spark plug with ignition coil, 6-Cyl. Turbo
20/16 Capacitor, 6-Cyl. Turbo
-
-
20
F36 11B/36 4/46 Engine Control Module (ECM), 5-Cyl. Diesel - 15
4/46 Engine control module (ECM), 4-Cyl. Turbo & 6-Cyl. Turbo - 10
continues
TP39203202 S60 (11-) 15
Fuses
Distribution box in engine compartment F37-F38
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F37 11B/37 7/17 Mass air flow sensor MAF, 5-Cyl. Diesel
8/98 Control valve fuel pressure, 5-Cyl. Diesel
8/111 Control valve fuel flow, 5-Cyl. Diesel
-
-
-
15
4/46 Engine Control Module (ECM), 6-Cyl. Turbo
7/17 Mass air flow sensor MAF, 6-Cyl. Turbo
8/6-11 Injection valves, 6-Cyl. Turbo
-
-
-
F38 11B/38 7/17 Mass air flow sensor MAF, 4-Cyl. Turbo
8/18 EVAP valve, 4-Cyl. Turbo
8/19 Solenoid, variable valve timing, intake, 4-Cyl. Turbo
8/28 Turbocharger control valve, 4-Cyl. Turbo
8/81 Solenoid, variable valve timing, exhaust, 4-Cyl. Turbo
-
-
-
-
10
7/35 Oil level sensor, 5-Cyl. Diesel
8/3 Electromagnetic clutch, climate control system, 5-Cyl. Diesel
8/113 Bypass valve, EGR cooling, 5-Cyl. Diesel
-
-
-
4/46 Engine Control Module (ECM), 6-Cyl. Turbo
8/3 Electromagnetic clutch climate control system, 6-Cyl. Turbo
8/28 Turbocharger control valve, 6-Cyl. Turbo
8/68 Relief valve, 6-Cyl. Turbo
8/117 Solenoid, variable valve timing, intake, 6-Cyl. Turbo
-
-
-
-
-
continues
TP39203202 S60 (11-) 16
Fuses
Engine compartment electrical center F39-F44
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F39 11B/39 7/15 Front heated oxygen sensor, 4-Cyl. Turbo
7/82 Rear heated oxygen sensor bank 1, 4-Cyl. Turbo
10
4/136 Radiator masking blind module (AGM)
7/15 Front heated oxygen sensor, 5-Cyl. Diesel
-
7/15 Front heated oxygen sensor bank 1, 6-Cyl. Turbo
7/82 Rear heated oxygen sensor bank 1, 6-Cyl. Turbo
8/18 EVAP valve, 6-Cyl. Turbo
-
-
-
15
F40 11B/40 2/142 Relay pre-heater fuel filter, 5-Cyl. Diesel
6/114 Vacuum pump, 4-Cyl. Turbo
9/38 Heated fuel filter, 5-Cyl. Diesel
-
2/142
2/142
20
F41 11B/41 6/67 Pump, fuel leakage control 6-Cyl.
9/32 PTC resistor crankcase ventilation, 5-Cyl. Diesel
-
-
5
F42 11A/42 20/22-26 Glow plug, 5-Cyl. Diesel 4/109 70
F43 11A/43 4/71 Control module cooling fan 4-Cyl. Turbo - 60
4/71 Cooling fan control module, 5-Cyl. Diesel & 6-Cyl. Turbo - 80
F44 11A/44 6/164 Electrical power steering module (EPS) - 100
TP39203202 S60 (11-) 17
Fuses
Central Electronic Module (CEM) F1 - F8
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F1 2/16 Relay, rear window wiper
6/32 Rear window wiper motor
-
2/16
15
F3 3/27 Switch unit, power passenger seat
3/176 Power window switches, driver’s door
4/52 Power Seat Module (PSM)
4/76 Remote control opener garage door
10/25 Ceiling light, cargo compartment
10/29 Glove compartment lighting
10/125 Left-hand front courtesy lighting
10/126 Right-hand front courtesy lighting
10/150A Rear reading light
10/150B Rear reading light
17/45 Alcolock outlet
26/6 Converter/control module, sill moldings, driver’s side
26/7 Converter/control module, sill moldings, passenger side
26/8 Alcolock charging cradle
-
-
-
-
-
-
-
-
-
-
-
-
-
-
7,5
F4 5/1 Driver Information Module (DIM) - 5
F5 4/80 Forward Sensing Module (FSM)
7/203 Forward-aimed radar (FLR)
-
-
10
F6 7/149 Rain Sensor Module (RSM)
10/114 Left-hand vanity mirror lighting
10/115 Right-hand vanity mirror lighting
-
-
-
7,5
F7 3/4 Steering wheel switch left (SWSL)
3/131 Steering wheel switch right (SWSR)
3/130
3/130
7,5
F8 6/37 Lock motor, fuel filler cover - 10
continues
TP39203202 S60 (11-) 18
Fuses
Central Electronic Module (CEM) F9 - F19
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F9 6/127 Washer motor - 15
F10 6/127 Washer motor - 15
F11 6/8 Central locking motor, trunk lid - 10
F13 4/83 Fuel pump control module
6/33 Fuel pump
-
4/83
20
F14 4/6 Climate Control Module (CCM) - 5
F15 4/102 Steering column lock module (SCL) - 15
F16 16/35 Siren Control Module (SCM)
17/13 Data link connector
-
-
5
F18 4/9 Supplemental Restraint System (SRS)
4/125 Closing velocity module (CVM)
7/93 Occupant Weight Sensor (OWS)
-
-
-
10
F19 4/80 Forward Sensing Module (FSM)
7/203 Forward-aimed radar (FLR)
-
-
5
continues
TP39203202 S60 (11-) 19
Fuses
Central Electronic Module (CEM) F20 - F24
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F20 3/65 Switch, heated rear seat
7/51 Accelerator pedal sensor
8/48 Auto-dimming rearview mirror
9/42 PTC-element
-
-
-
-
7,5
F21 3/281 Infotainment control module (ICM)
16/1 Integrated Audio Module (IAM)
16/159 Control module, mobile phone handsfree
-
-
-
15
F22 3/9 Brake light contact - 5
F23 4/33 Sunroof Module (SRM) - 20
F24 3/132 Start control module (SCU) - 5
TP39203202 S60 (11-) 20
Fuses
Distribution box in passenger compartment F1 - F17
15/36 Distribution box in passenger compartment
No. No. Fuse function via A
F1 11C/1 11C/17-19 Fuses in distribution box passenger compartment
16/105 Audio module (AUD)
-
-
40
F6 11C/6 3/273 Lock contact, LH front door
3/274 Lock contact, RH front door
3/275 Lock contact, left rear door
3/276 Lock contact, RH rear door
-
-
-
-
5
F8 11C/8 3/126 Driver door module (DDM) - 25
F9 11C/9 3/127 Passenger door module (PDM) - 25
F10 11C/10 3/129 Right rear door module (RDM) - 25
F11 11C/11 3/128 Left rear door module (LDM) - 25
F12 11C/12 4/93 Keyless vehicle module (KVM) - 7,5
F13 11C/13 3/26 Switch unit, power driver’s seat
4/52 Power Seat Module (PSM)
-
-
20
F14 11C/14 3/27 Switch unit, power passenger seat - 20
F16 11C/16 3/281 Infotainment control module (ICM) - 5
F17 11C/17 16/36 Television module (TVM)
16/46 RTI display
16/145 Remote Digital Audio Receiver (RDAR)
16/162 Digital Audio Broadcast Module (DABM)
-
-
-
-
10
continues
TP39203202 S60 (11-) 21
Fuses
Distribution box in passenger compartment F18 - F30
15/36 Distribution box in passenger compartment
No. No. Fuse function via A
F18 11C/18 3/281 Infotainment control module (ICM)
16/1 Integrated Audio Module (IAM)
16/159 Control module, mobile phone handsfree
-
-
-
15
F19 11C/19 16/60 Phone Module (PHM) - 5
F21 11C/21 4/33 Panoramic roof control module
6/48 Damper Motor Module (DMM), recirculation
6/95 Damper Motor Module (DMM), temperature, left side
6/96 Damper Motor Module (DMM), temperature, right side
6/102 Damper Motor Module (DMM), defroster
6/103 Damper Motor Module (DMM), floor/ventilation
7/159 Air Quality Sensor (AQS)
10/22 Ceiling light
16/159 Control module, mobile phone handsfree
-
-
-
-
-
-
-
4/56
-
5
F22 11C/22 9/1 Outlet 12V front
9/25 Outlet 12V rear
-15
F23 11C/23 9/13 Seat Heating Module (SHM), passenger side - 15
F24 11C/24 9/12 Seat Heating Module (SHM), driver’s side - 15
F26 11C/26 9/15 Control module, rear right seat heater - 15
F27 11C/27 9/14 Control module, rear left seat heater - 15
F28 11C/28 4/86 Parking Assistance Module (PAM)
4/110 Trailer Module (TRM)
4/120 Parking Assistance Camera (PAC)
-5
F29 11C/29 4/82 Differential Electronic Module (DEM) - 10
F30 11C/30 4/84 Suspension Module (SUM) - 10
TP39203202 S60 (11-) 22
I0143231
Fuses
Distribution box in cargo compartment FA1-FA11
15/32 Distribution box in cargo compartment
No. No. Fuse function via A
FA1 11D/A1 4/115 Park Brake Module (PBM) - 30
FA2 11D/A2 4/115 Park Brake Module (PBM) - 30
FA3 11D/A3 2/82 Relay, heated rear window
9/2 Heated rear window
-
2/82
30
FA4 11D/A4 17/39 13-pin outlet, cable harness towbar/tow hitch - 15
FA5 - - --
FA6 11D/A6 17/19 12 V outlet, cargo compartment - 15
FA11 11D/A 114/110 Trailer Module (TRM)
17/19 12 V outlet, cargo compartment, V60
-
-
40
TP39203202 S60 (11-) 23
Fuses
Battery PF1-PF2
1/1 Battery
No. Fuse function via A
PF1 11A/1-11A/7 Main fuses in distribution box engine compartment
11A/42-11A/44 Main fuses in distribution box engine compartment
11B/8-11B/14 Fuses in the engine compartment distribution box
11B/16-11B/22 Fuses in the engine compartment distribution box
11B/23 Fuses in the engine compartment distribution box
11B/27-11B/32 Fuses in the engine compartment distribution box
11B/33 Fuses in the engine compartment distribution box
11B/34 Fuses in the engine compartment distribution box
11B/35-11B/41 Fuses in the engine compartment distribution box
-
-
-
2/31
-
-
2/32
-
2/32
150
PF2 6/25 Starter motor
6/26 Alternator Control Module (ACM)
-
-
150
TP39203202 S60 (11-) 24
Relays
Relays in the engine compartment R1-R2
15/33 Engine compartment cold zone
Pos Relay function
R1 2/182 Relay, headlight washer motor
R2 2/17 Relay, horn
TP39203202 S60 (11-) 25
Relays
Relays in the engine compartment R8
15/31 Distribution box in engine compartment
Pos Relay function
R8 2/31 Relay, 15-feed
TP39203202 S60 (11-) 26
1
Relays
Relays in the engine compartment R10-R13
15/31 Distribution box in engine compartment
Pos Relay function
R10 2/32 Main relay, engine management system
R11 2/133 Relay vacuum pump, 4-Cyl. Turbo
2/142 Fuel filter preheater relay
R12 2/35 Starter motor relay
R13 2/22 Relay, climate control system
TP39203202 S60 (11-) 27
Relays
Relays in passenger compartment R1 - R4
15/36 Distribution box in passenger compartment
Pos Relay function
R1 2/88 Relay, 15-feed
R4 2/193 Relay, comfort functions
TP39203202 S60 (11-) 28
I0143230
Relays
Cargo compartment RA1 - RA2
15/32 Distribution box in cargo compartment
Pos Relay function
RA1 2/82 Relay, heated rear window
RA2 2/16 Relay, rear window wiper
TP39203202 S60 (11-) 29
31/AL
31/1
31/96
31/XX4
31/2
31/4
31/3
31/7
31/6
31/84
31/10
31/15
31/68
31/65
31/47
31/67
31/83
31/93
31/95
31/
INFOT
31/88
31/89
31/90
31/66
31/
XX10
31/94
31/5
31/48
31/TRM
31/
XX15
31/
XX14
G034229
Ground connections
Overview
TP39203202 S60 (11-) 30
31/1 Ground connection, PTC
9/42 PTC-element
31/2 LH wheel housing
4/71 Cooling fan control module
6/114 Vacuum pump, 4-Cyl. Turbo
8/84 Switch vacuum pump 4-Cyl. Turbo
31/3 Body, battery
1/1 Battery
7/240 Battery monitoring sensor
31/4 Engine
31/XX4 Ground connection
31/5 Rear edge roof
9/2 Heated rear window
31/6 Bottom rail, left
3/27 Switch unit, power passenger seat, RHD
3/126 Driver Door Module (DDM), LHD
3/127 Passenger Door Module (PDM), RHD
3/128 Left rear door module (LDM)
3/176 Switch, driver’s door power window, LHD
4/52 Power Seat Module (PSM), LHD
9/12 Seat Heating Module (SHM), driver’s side, LHD
9/13 Seat Heating Module (SHM), passenger side, RHD
31/7 Bottom rail, left
3/271 Contact, immobilizer, clutch pedal, LHD
3/281 Infotainment Control Module (ICM), RHD
3/284 Diagnostic contact, brake light, LHD
4/56 Central Electronic Module (CEM), RHD
7/51 Accelerator pedal sensor, LHD
7/175 Weight sensor passenger seat, seat belt reminder, RHD
8/51 Igniter side airbag front left, LHD
8/52 Igniter side airbag front right, RHD
16/1 Integrated Audio Module (IAM), RHD
16/36 Television module (TVM)
Ground connections
31/1 - 31/7
Loading...