Vollrath Refrigeration 40701 Installation Manual
The Vollrath Company, L.L.C.
1236 North 18
P.O. Box 611
Sheboygan, WI 53082-0611
th
Street
Operating and Safety
Instructions
Countertop Convection
Oven
Model Number:
40703, Mini Prima Pro, 120volt – 1,400watts
40701, Prima Pro, 220volt – 2,400watts
40702, Proton, 220volt – 5,600watts
2500117-A
CONVECTION OVEN
Convection Oven
Thank you for purchasing this Vollrath Countertop Convection Oven. Before
this unit, read and familiarize yourself with the following operating and safety
instructions. SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE.
WARNING
FIRE, INJURY OR DEATH HAZARD
HAVE THIS EQUIPMENT INSTALLED BY A QUALIFIED INSTALLER IN
ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL CODES. FAILURE
TO INSTALL THIS EQUIPMENT PROPERLY CAN RESULT IN INJURY OR
DEATH.
WARNING
FIRE HAZARD
THIS UNIT IS DESIGNED TO BE USED WITH LEGS. DO NOT USE WITHOUT
LEGS INSTALLED. USE OF THIS EQUIPMENT WITHOUT LEGS CAN
CAUSE THE UNIT TO OVERHEAT AND CAUSE A FIRE.
operating
WARNING
FIRE AND BURN INJURIES OR DEATH CAN OCCUR IF
THIS EQUIPMENT IS NOT USED PROPERLY. TO REDUCE
RISK OF INJURY OR DEATH:
Unit should only be used in a flat, level position.
Let hot unit cool before cleaning or moving.
Do not spray controls or outside of unit with liquids or cleaning agents.
Do not operate unattended.
Function and Purpose
:
This unit is intended to be used for cooking fresh or frozen foods in commercial
foodservice operations only. It is not intended for household use.
Before using this equipment it must be cleaned thoroughly. Clean all surfaces before
use. Failure to clean surfaces before using the unit could cause food contamination.
WARNING
FIRE, INJURY OR DEATH HAZARD
HAVE THIS EQUIPMENT INSTALLED BY A QUALIFIED INSTALLER IN
ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL CODES. FAILURE
TO INSTALL THIS EQUIPMENT PROPERLY CAN RESULT IN INJURY OR
DEATH.
2500117-A
CONVECTION OVEN
Installing the Convection Oven:
1. Remove all packing material and tape, as well as any protective plastic from the
unit.
2. Clean any glue residue left over from the plastic or tape.
3. Place the unit in the desired position, at least 6” from any adjacent wall.
4. Plug unit into a properly grounded electrical supply matching the nameplate
rating. Damage to the unit can occur if incorrect power is supplied to unit.
Model 40702 ONLY
This model is equipped with a water spray feature. To utilize the water spray feature
the unit should be connected to a suitable potable water supply with a pressure
between 3 and 30 p.s.i.
Note: Before using the appliance, clean the interior of the oven with hot water and
soap; rinse thoroughly. Set the bake control to 550°F and heat the oven for 30
minutes to eliminate any manufacturing oils.
WARNING
BURN HAZARD
BURN INJURIES CAN OCCUR IF THIS EQUIPMENT IS NOT USED
PROPERLY. NEVER TOUCH HOT SURFACES. ALWAYS USE HOT PADS
OR HOLDERS UNTIL THE UNIT HAS COOLED OFF.
Using the Countertop Convection Oven:
All Models
Baking Function – Used to bake or cook
1. Place the shelves in the desired positions inside the unit. Allow a space of at
least 2” between pans for proper air circulation.
2. Set the bake control to the desired temperature setting between 140°F and
570°F.
3. Set the timer control to the desired time between 0 and 120 minutes. The fan
and oven light will operate continuously however the heating elements will switch
off at the end of the timer cycle. The timer can be set to continuous use by
turning to the “ON” position.
4. The bake pilot light will indicate when the heating elements are energized and
will start to cycle on and off with the heating elements when the set temperature
is reached.
5. Place food into the unit and monitor.
Loading...