Viking DGRT series Installation Manual

Viking Installation Guide

Built-In Gas Rangetops

IMPORTANT - PLEASE READ AND FOLLOW

•Before beginning, please read these instructions
completely and carefully.

•Do not remove permanently affixed labels, warnings, or
plates from the product. This may void the warranty.

•Please obseve all local and national codes and ordinances.

•Please ensure that this product is properly grounded.

•The installer should leave these instructions with the
consumer who should retain for local inspector's use and

for future reference.

Installation must conform with national and local codes or in
the absence of codes, the National Fuel Gas Code, ANSI
Z223.-latest edition. Electrical installation must be in
accordance with National Electrical Code, ANSI/NFPA 70
and/or local codes. IN CANADA: Installation must be in
accordance with the current CAN/CGA B149.1 & 2 Gas
Installation codes and/or local codes. Electrical installation
must be in accordance with the current CSA C22.1 Canadian
Electrical Codes Part 1 and/or local codes.

Installation of any gas-fired equipment should be made by a
licensed plumber. A manual gas shut-off valve must be
installed in the gas supply line ahead of the oven in the gas
stream for safety and ease of service.

In Massachusetts: All gas products must be installed by a
"Massachusetts" licensed plumber or gasfitter. A "T"
handle type manual gas valve must be installed in the gas
supply line to the appliance.

ELECTRICAL GROUNDING

INSTRUCTIONS

This rangetop must be electrically grounded in
accordance with local codes. This appliance is
equipped with a three-prong plug for your
protection against shock hazard and should be
plugged directly into a properly grounded
reeptacle. Do not cut or remove the grounding
prong from this plug.

FOR PERSONAL SAFETY, THIS APPLIANCE

MUST BE PROPERLY GROUNDED.

IF THE INFORMATION IN THIS MANUAL
IS NOT FOLLOWED EXACTLY, A FIRE OR

EXPLOSION MAY RESULT CAUSING

PROPERTY DAMAGE, PERSONAL INJURY,

OR DEATH.

1. Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.

2. WHAT TO DO IF YOU SMELL GAS:

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use

any phone in your building.

• Immediately call your gas supplier from a

neighbor's phone.

• Follow the gas supplier's instructions.

• If you cannot reach your gas supplier, call the fire

department.

3. Installation and service must be performed by a
qualified installer, service agency, or the gas
supplier.

If not installed, operated and maintained in
accordance with the manufacturer's instructions,

this product could expose you to substances in fuel
or from fuel combustion which can cause death or

serious illness and which are known to cause cancer,
birth defects, or other reproductive harm.

For example, benzene is a chemical which is part of
the gas supplied to the cooking product. It is
consumed in the flame during combustion.
However exposure to a small amount of benzene is
possible if a gas leak occurs. Formaldehyde and
soot are by-products of incomplete combustion.
Properly adjusted burners with a bluish rather than
yellow flame will minimize incomplete combustion.

Basic Specifications

VGRT Models

Description
Overall width

Overall height

Overall depth from
rear

Cutout width

24" W. Models
23 718" (60.6 cm)

To top of spider grate -
To top of burner grate -
To top of island trim -
To top of 6" backguard-
To top of high shelf -

24" (61.0 cm)

30" W. Models
29 7/8" (75.8 cm)

9 1/4" (23.5 cm) (Open top Burners only)
9 1/8" (23.2 cm) (Sealed Burners only)

8 7/8" (22.5 cm)
13 7/8" (35.2 cm)
31 3/8" (79.7 cm)

To end of side panel - 24" (61.0 cm)
To end of control panel - 25 3/4" (65.4 cm)
To end of knobs - 27 3/4" (70.5 cm)

30" (76.2 cm)

Cutout Height Open top Burners - 7 1/2" (19.1 cm) Top of grate support should be 3/8" (1.0cm) above countertop.

Sealed Burners - 7 5/8" (19.4 cm) Top ot: grate support should be 3/8" (1 .O cm) above countertop.

Minimum 24" (61.0 cm) Maximum 25 3/4" (65.4 cm)

120 VAC/60 Hz 4ft. (121.9 cm), 3-wire cord with grounded 3-prong plug

Cutout Depth
Electrical

requirements
Gas requirements Shipped natural or LP/Propane gas ; field convertible with conversion kit (purchased separately);

accepts standard residential 1/2" (1.3 cm) ID gas service line
Maximum amp .3 amps .3 amps
usage
Surface burner 15.000 BTU Nat./13,500 BTU LP/Propane
rating (4.4 kW Nat./4.0 kW LP/Propane)
Approximate 100 Ibs. 125 Ibs.
Shipping Wt. (45.0 kg) (56.3 kg)

MINIMUM CLEARANCES

Minimum clearances from the product to adjacent surfaces or construction:

• Below 36" (91.4 cm)
Sides - 0"

Rear - 0"

• Above 36" (91.4 cm)
Sides - 6" (15.2 cm)
Within the 6" (15.2 cm) side clearance, wall cabinets shall be no deeper than 13" (33.0 cm) and must be a minimum
of 18" (45.7 cm) above the countertop.
Rear - 0" with backguard or high shelf

O" with island trim and non-combustible heat resistant rear wall
6" (15.2 cm) with island trim and combustible rear wall

• Wall cabinets directly above the product must be minimum of 36" (91.4 cm) above the countertop for open top

burners and 42" (106.7 cm) for sealed burners.

To maintain product warranty, the responsibility for ensuring the use of non-combustible heat resistant materials when
required, lies with individual owner, contractor or end user.

*it is not recommended to install two or more units side by side.

1 2

Basic Specifications - VGRT Models

Description 36" W. Models 42" W. Models

Overall width
Overall height

Overall depth from
_ear

Cutout width
Cutout Height

Cutout Depth
Electrical

_equirements
Gas requirements

35 7/8" (91.1 cm) 42" (106.7 cm)
To top of spider grate - 9 1/4" (23.5 cm)
To top of burner grate - 9 1/8" (23.2 cm)
To top of island trim - 8 7/8" (22.5 cm)
To top of 6" backguard- 13 7/8" (35.2 cm)
To top of high shelf -

48" W. Models 60" W. Models

47 7/8" (121.6 cm) 59 1/2" (151.1cm)

(Open top Burners only)
(Sealed Burners only)

31 3/8" (79.7 cm)
To end of side panel - 24" (61.0 cm)
To end of control panel - 25 3/4" (65.4 cm)

To end of knobs - 27 3/4" (70.5 cm)

36" (91.4 cm) 42 1/8" (107 cm) 48" (121.9 cm) 59 5/8" (151.4 cm)
Open top Burners - 7 1/2" (19.1 cm) (top of grate support should be 3/8" [1.0 cm] above countertop.

Sealed Burners - 7 5/8" (19.4 cm) (top of side trim should be 3/8" [1.0 cm] above countertop.

Minimum 24" (61.0 cm) Maximum 25 3/4" (65.4 cm)

120 VAC/60 Hz 4ft. (121.9 cm), 3-wire cord with grounded 3-prong plug

Shipped natural or LP/Propane gas; field convertible with conversion kit (purchases separately);
accepts standard residential 1/2" (1.3 cm) ID gas service line

Maximum amp
usage

6B - .6amps
4G - 3.9amps
4Q - .6amps

6G - 4.2 amps

6Q - .6 amps

4G - 7.2 amps

4GQ- 4.2 amps

4K - .6 amps

4Q - .6 amps

Surface burner
_ating

_Vok Burner
_ating (if applicable)

Griddle burner
_ating

BTU LP
Grill burner
_atJng
Approximate
Shipping Wt.

6G - 7.8 amps
6GQ- 4.2 amps

15.000 BTU Nat./13,500 BTU LP/Propane
(4.4 kW Nat./4.0 kW LP/Pro)ane)

N/A 27,800 BTU Nat./LP N/A

(8.2 kW Nat./LP

12"/18" Wide

15,000 BTU Nat./13,500 BTU LP

(4.4 kW / 4.0 kW )
12" Wide - 1 @ 18,000 BTU Nat. (5.3 kW)/16,000 BTU LP/Propane (4.7 kW)
24" Wide - 2 @ 15,000 BTU Nat. (4.4 KW) / 13,500 BTU LP/Propane (4.0 kW)

6B-150 Ib.(67.Skg) 6G -203 Ib.(91.4kg) 6G - 2561b.(115.2kg)
4G - 160 Ib.(72.0kg) 6Q -198 Ib.(89.1kg) 6GQ-251 Ib.(113.0kg)
4Q - 155 Ib.(69.8 kg) 4G - 213 Ib.(95.6kg)

4GQ-208 Ib.(93.6 kg)
4K - 213 Ib.(95.6 kg)
4Q - 198 Ib.(89.1 kg)

24" Wide
Two 15,000 BTU Nat./13,500

(4.4 kW / 4.0 kW)

MINIMUM CLEARANCES

Minimum clearances from the product to adjacent surfaces or construction:

• Below 36" (91.4 cm)
Sides- 0"

Rear- 0"

• Above 36" (91.4 cm)
Sides- 6" (15.2 cm)

Within the 6" (15.2 cm) side clearance, wall cabinets shall be no deeper than 13" (33.0 cm) and must be a minimum of 18"

(45.7 cm) above the countertop.

Rear - 0" with backguard or high shelf

0" with island trim and non-combustible heat resistant rear wall
B" (15.2 cm) with island trim and combustible rear wall

• Wall cabinets directly above the product must be minimum of 36" (91.4 cm) above the countertop for open top burners and 42"

(108.7 cm) for sealed burners.

To maintain product warranty, the responsibility for ensuring the use of non-combustible heat resistant materials when required, lies
with individual owner, contractor or end user.

*it is not recommended to install two or more units side by side.

Basic Specifications - DGRT Models

Description
Overall width

Overall height

Overall depth from
rear

Cutout width
Cutout Height

Cutout Depth
Electrical

requirements
Gas requirements

Maximum amp
usage
Surface burner rating

left front

left rear

center

right rear

right front

Approximate
Shipping Wt.

30" W. Models

29 7/8" (759. cm)
To top of grate - 6 1/8" (15.6'cm)
To top of island trim - 6 1/8" (15.6 cm)
To top of 6" backguard- 12 1/8" (30.8 cm)
To top of high shelf - 24 1/8" (61.3 cm)

To end of side panel - 24 1/2" (62.2 cm)

To end of control panel - 26 1/8" (66.4 cm)

To end of knobs - 27 5/8" (70.5 cm)

30" (76.2 cm) 36" (91.4 cm)
5 3/4" (14.6 cm) (top of grates should be 3/8" [1.0 cm] above countertop.

36" W. Models
35 7/8" (91.1 cm)

24 1/2" (62.2 cm)

120 VAC/60 Hz 4ft. (121.9 cm), 3-wire cord with grounded 3-prong plug

Shipped natural or LP/Propane gas ; field convertible with conversion kit (purchased separately);
accepts standard residential 1/2" (1.3 cm)ID gas service line

2.0 amps 2.0 amps

16,000 BTU Nat./15,500 BTU LP/Propane
(4.7 kW Nat./4.5 kW LP/Propane)
12,000 BTU Nat./11,500 BTU LP/Propane
(3.5 kW Nat./3.4 kW LP/Propane)
N/A

12,000 BTU Nat./11,500 BTU LP/Propane
(3.5 kW Nat./3.4 kW LP/Propane)
10,000 BTU Nat./9,500 BTU LP/Propane
(2.5 kW Nat./2.4 LP/Propane)
16,000 BTU Nat!1 5,500 BTU LP/Propane
(4.7 kW Nat./4.5 kW LP/Propane)
8,000 BTU Nat./7,500 BTU LP/Propane
(2.0 kW Nat./1.9 kW LP/Propane)
6,000 BTU Nat./5,500 kW LP/Propane
(1.5 kW Nat./1.4 kW LP/Propane)

150 Ib.(67.Skg)

8,000 BTU Nat./7,500 BTU LP/Propane
(2.0 kW Nat./1.9 kW LP/Propane)
6,000 BTU Nat./5,500 BTU LP/Propane
(1.5 kW Nat./1.4 kW LP/Propane)

125 Ibs. (56.3 kg)

MINIMUM CLEARANCES

Minimum clearances from the product to adjacent surfaces or construction:

• Below 36" (91.4 cm)
Sides - 0"
Rear - 0"

• Above 36" (91.4 cm)
Sides - 6" (15.2 cm)

Within the 6" (15.2 cm) side clearance, wall cabinets shall be no deeper than 13" (33.0 cm) and must be a
minimum of 18" (45.7 cm) above the countertop.
Rear - 0" with backguard or high shelf

0" with island trim and non-combustible heat resistant rear wall
6" (15.2 cm) with island trim and combustible rear wall

• Wall cabinets directly above the product must be minimum of 36" (91.4 cm) above the countertop for open top

burners and 42" (106.7 cm) for sealed burners.

To maintain product warranty, the responsibility for ensuring the use of non-combustible heat resistant materials when
required, lies with individual owner, contractor or end user.

*It is not recommended to install two or more units side by side.

3 4