Viking Designer DGRT3014BSS, Professional VGRT300-4B, Designer DGRT3605BSS, Designer DGRT361-5B, Professional VGRT421-4Q Install Manual

F1239P (080307J)

Viking Range Corporation

111 Front Street

Greenwood, Mississippi 38930 USA

[phone]

For product information,

call 1-888-VIKING1 (845-4641)

or visit the Viking web site at

vikingrange.com

Viking Installation Guide

Built-In Gas Rangetops

2

Basic Specifications

Description 24” W. Models 30” W. Models
Overall width 23 7/8” (60.6 cm) 29 7/8” (75.8 cm)
Overall height

To top of spider grate - 9 1/4” (23.5 cm)

(Open top Burners only)

To top of burner grate - 9 1/8” (23.2 cm)

(

Sealed Burners only

)
To top of island trim - 8 7/8” (22.5 cm)
To top of 6” backguard- 13 7/8” (35.2 cm)
To top of high shelf - 31 3/8” (79.7 cm)

Overall depth from To end of side panel - 24” (61.0 cm)

rear To end of control panel - 25 3/4” (65.4 cm)

To end of knobs - 27 3/4” (70.5 cm)

Cutout width 24” (61.0 cm) 30” (76.2 cm)
Cutout Height Open top Burners - 7 1/2” (19.1 cm) Top of grate support should be 3/8” (1.0 cm) above countertop.

Sealed Burners - 7 5/8” (19.4 cm) Top of grate support should be 3/8” (1.0 cm) above countertop.

Cutout Depth Minimum 24” (61.0 cm) Maximum 25 3/4” (65.4 cm)
Electrical 120 VAC/60 Hz 4ft. (121.9 cm), 3-wire cord with grounded 3-prong plug
requirements
Gas requirements Shipped natural or LP/Propane gas ; field convertible with conversion kit (purchased separately);

accepts standard residential 1/2” (1.3 cm) ID gas service line

Maximum amp .3 amps .3 amps
usage
Surface burner 15.000 BTU Nat./13,500 BTU LP/Propane
rating (4.4 kW Nat./4.0 kW LP/Propane)
Approximate 100 lbs. 125 lbs.
Shipping Wt. (45.0 kg) (56.3 kg)

VGRT Models

MINIMUM CLEARANCES

Minimum clearances from the product to adjacent surfaces or construction:

• Below 36” (91.4 cm)
Sides - 0”
Rear - 0”

• Above 36” (91.4 cm)
Sides - 6” (15.2 cm)
Within the 6” (15.2 cm) side clearance, wall cabinets shall be no deeper than 13” (33.0 cm) and must be a minimum
of 18” (45.7 cm) above the countertop.
Rear - 0” with backguard or high shelf

0” with island trim and non-combustible heat resistant rear wall
6” (15.2 cm) with island trim and combustible rear wall

• Wall cabinets directly above the product must be minimum of 36” (91.4 cm) above the countertop for open top

burners and 42” (106.7 cm) for sealed burners.

To maintain product warranty, the responsibility for ensuring the use of non-combustible heat resistant materials when
required, lies with individual owner, contractor or end user.

*It is not recommended to install two or more units side by side.

1

IMPORTANT - PLEASE READ AND FOLLOW

•Before beginning, please read these instructions
completely and carefully.

•Do not remove permanently affixed labels, warnings, or
plates from the product. This may void the warranty.

•Please obseve all local and national codes and ordinances.

•Please ensure that this product is properly grounded.

•The installer should leave these instructions with the
consumer who should retain for local inspector’s use and
for future reference.

Installation must conform with national and local codes or in
the absence of codes, the National Fuel Gas Code, ANSI
Z223.-latest edition. Electrical installation must be in
accordance with National Electrical Code, ANSI/NFPA 70
and/or local codes.

I

N CANADA:

Installation must be in
accordance with the current CAN/CGA B149.1 & 2 Gas
Installation codes and/or local codes. Electrical installation
must be in accordance with the current CSA C22.1 Canadian
Electrical Codes Part 1 and/or local codes.

Installation of any gas-fired equipment should be made by a
licensed plumber. A manual gas shut-off valve must be
installed in the gas supply line ahead of the oven in the gas
stream for safety and ease of service.

I

n Massachusetts:

All gas products must be installed by a
“Massachusetts” licensed plumber or gasfitter. A “T”
handle type manual gas valve must be installed in the gas
supply line to the appliance.

1. Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.

2.

W

HAT TO DO IF YOU SMELL GAS:

•Do not try to light any appliance.

•Do not touch any electrical switch; do not use

any phone in your building.

•Immediately call your gas supplier from a

neighbor’s phone.

•Follow the gas supplier’s instructions.

•If you cannot reach your gas supplier, call the fire

department.

3. Installation and service must be performed by a
qualified installer, service agency, or the gas
supplier.

ELECTRICAL GROUNDING

INSTRUCTIONS

This rangetop must be electrically grounded in
accordance with local codes. This appliance is
equipped with a three-prong plug for your
protection against shock hazard and should be
plugged directly into a properly grounded
reeptacle. Do not cut or remove the grounding
prong from this plug.

FOR PERSONAL SAFETY, THIS APPLIANCE

MUST BE PROPERLY GROUNDED.

W ARNING

IF THE INFORMATION IN THIS MANUAL

IS NOT FOLLOWED EXACTLY, A FIRE OR

EXPLOSION MAY RESULT CAUSING

PROPERTY DAMAGE, PERSONAL INJURY,

OR DEATH.

W ARNING

W ARNING

If not installed, operated and maintained in
accordance with the manufacturer’s instructions,
this product could expose you to substances in fuel
or from fuel combustion which can cause death or
serious illness and which are known to cause cancer,
birth defects, or other reproductive harm.

For example, benzene is a chemical which is part of
the gas supplied to the cooking product. It is
consumed in the flame during combustion.
However exposure to a small amount of benzene is
possible if a gas leak occurs. Formaldehyde and
soot are by-products of incomplete combustion.
Properly adjusted burners with a bluish rather than
yellow flame will minimize incomplete combustion.

4

Basic Specifications -

DGRT Models

Description 30” W. Models 36” W. Models
Overall width 29 7/8” (759. cm) 35 7/8” (91.1 cm)
Overall height To top of grate - 6 1/8” (15.6 cm)

To top of island trim - 6 1/8” (15.6 cm)
To top of 6” backguard- 12 1/8” (30.8 cm)
To top of high shelf - 24 1/8” (61.3 cm)

Overall depth from To end of side panel - 24 1/2” (62.2 cm)

rear To end of control panel - 26 1/8” (66.4 cm)

To end of knobs - 27 5/8” (70.5 cm)

Cutout width 30” (76.2 cm) 36” (91.4 cm)
Cutout Height 5 3/4” (14.6 cm) (top of grates should be 3/8” [1.0 cm] above countertop.

Cutout Depth 24 1/2” (62.2 cm)
Electrical 120 VAC/60 Hz 4ft. (121.9 cm), 3-wire cord with grounded 3-prong plug
requirements
Gas requirements Shipped natural or LP/Propane gas ; field convertible with conversion kit (purchased separately);

accepts standard residential 1/2” (1.3 cm) ID gas service line
Maximum amp 2.0 amps 2.0 amps
usage
Surface burner rating

left front 16,000 BTU Nat./15,500 BTU LP/Propane 12,000 BTU Nat./11,500 BTU LP/Propane

(4.7 kW Nat./4.5 kW LP/Propane) (3.5 kW Nat./3.4 kW LP/Propane)

left rear 12,000 BTU Nat./11,500 BTU LP/Propane 10,000 BTU Nat./9,500 BTU LP/Propane

(3.5 kW Nat./3.4 kW LP/Propane) (2.5 kW Nat./2.4 LP/Propane)

center N/A 16,000 BTU Nat/15,500 BTU LP/Propane

(4.7 kW Nat./4.5 kW LP/Propane)

right rear 8,000 BTU Nat./7,500 BTU LP/Propane 8,000 BTU Nat./7,500 BTU LP/Propane

(2.0 kW Nat./1.9 kW LP/Propane) (2.0 kW Nat./1.9 kW LP/Propane)

right front 6,000 BTU Nat./5,500 BTU LP/Propane 6,000 BTU Nat./5,500 kW LP/Propane

(1.5 kW Nat./1.4 kW LP/Propane) (1.5 kW Nat./1.4 kW LP/Propane)
Approximate

125 lbs. (56.3 kg) 150 lb.(67.5kg)

Shipping Wt.

MINIMUM CLEARANCES

Minimum clearances from the product to adjacent surfaces or construction:

• Below 36” (91.4 cm)
Sides - 0”
Rear - 0”

• Above 36” (91.4 cm)
Sides - 6” (15.2 cm)
Within the 6” (15.2 cm) side clearance, wall cabinets shall be no deeper than 13” (33.0 cm) and must be a
minimum of 18” (45.7 cm) above the countertop.
Rear - 0” with backguard or high shelf

0” with island trim and non-combustible heat resistant rear wall
6” (15.2 cm) with island trim and combustible rear wall

• Wall cabinets directly above the product must be minimum of 36” (91.4 cm) above the countertop for open top

burners and 42” (106.7 cm) for sealed burners.

To maintain product warranty, the responsibility for ensuring the use of non-combustible heat resistant materials when
required, lies with individual owner, contractor or end user.

*It is not recommended to install two or more units side by side.

Description 36” W. Models 42” W. Models 48” W. Models 60” W. Models
Overall width 35 7/8” (91.1 cm) 42” (106.7 cm) 47 7/8” (121.6 cm) 59 1/2” (151.1cm)
Overall height To top of spider grate - 9 1/4” (23.5 cm)

(

Open top Burners only)

To top of burner grate - 9 1/8” (23.2 cm)

(

Sealed Burners only

)
To top of island trim - 8 7/8” (22.5 cm)
To top of 6” backguard- 13 7/8” (35.2 cm)
To top of high shelf - 31 3/8” (79.7 cm)

Overall depth from To end of side panel - 24” (61.0 cm)

rear To end of control panel - 25 3/4” (65.4 cm)

To end of knobs - 27 3/4” (70.5 cm)

Cutout width 36” (91.4 cm) 42 1/8” (107 cm) 48” (121.9 cm) 59 5/8” (151.4 cm)
Cutout Height Open top Burners - 7 1/2” (19.1 cm) (top of grate support should be 3/8” [1.0 cm] above countertop.

Sealed Burners - 7 5/8” (19.4 cm) (top of side trim should be 3/8” [1.0 cm] above countertop.

Cutout Depth Minimum 24” (61.0 cm) Maximum 25 3/4” (65.4 cm)
Electrical 120 VAC/60 Hz 4ft. (121.9 cm), 3-wire cord with grounded 3-prong plug
requirements
Gas requirements Shipped natural or LP/Propane gas; field convertible with conversion kit (purchases separately);

accepts standard residential 1/2” (1.3 cm) ID gas service line

Maximum amp 6B - .6 amps 6G - 4.2 amps 6G - 7.8 amps
usage 4G - 3.9 amps 6Q - .6 amps 6GQ- 4.2 amps

4Q - .6 amps 4G - 7.2 amps

4GQ- 4.2 amps
4K - .6 amps

4Q - .6 amps
Surface burner 15.000 BTU Nat./13,500 BTU LP/Propane
rating (4.4 kW Nat./4.0 kW LP/Propane)
Wok Burner N/A

27,500 BTU Nat./LP N/A

rating (If applicable) (8.2 kW Nat./LP
Griddle burner

12”/18” Wide 24” Wide

rating 15,000 BTU Nat./13,500 BTU LP Two 15,000 BTU Nat./13,500

BTU LP (4.4 kW / 4.0 kW ) (4.4 kW / 4.0 kW)
Grill burner

12” Wide - 1 @ 18,000 BTU Nat. (5.3 kW)/ 16,000 BTU LP/Propane (4.7 kW)

rating 24” Wide - 2 @ 15,000 BTU Nat. (4.4 KW) / 13,500 BTU LP/Propane (4.0 kW)

Approximate

6B-150 lb.(67.5kg) 6G -203 lb.(91.4kg) 6G - 256lb.(115.2kg)

Shipping Wt. 4G - 160 lb.(72.0kg) 6Q -198 lb.(89.1kg) 6GQ-251 lb.(113.0kg)

4Q - 155 lb.(69.8 kg) 4G - 213 lb.(95.6kg)

4GQ-208 lb.(93.6 kg)

4K - 213 lb.(95.6 kg)

4Q - 198 lb.(89.1 kg)

3

MINIMUM CLEARANCES

Minimum clearances from the product to adjacent surfaces or construction:

• Below 36” (91.4 cm)
Sides - 0”
Rear - 0”

• Above 36” (91.4 cm)
Sides - 6” (15.2 cm)
Within the 6” (15.2 cm) side clearance, wall cabinets shall be no deeper than 13” (33.0 cm) and must be a minimum of 18”
(45.7 cm) above the countertop.
Rear - 0” with backguard or high shelf

0” with island trim and non-combustible heat resistant rear wall
6” (15.2 cm) with island trim and combustible rear wall

• Wall cabinets directly above the product must be minimum of 36” (91.4 cm) above the countertop for open top burners and 42”

(106.7 cm) for sealed burners.

To maintain product warranty, the responsibility for ensuring the use of non-combustible heat resistant materials when required, lies
with individual owner, contractor or end user.

*It is not recommended to install two or more units side by side.

Basic Specifications -

VGRT Models