Viking Designer DGCU155-6B, Designer DGSU1004BSS, Designer DGCU165-5B, Designer DGSU100-4B, Designer DGSU160-5B Installation Manual
...
Viking Installation Guide
Professional and Designer
Built-In Gas Cooktops
Viking Range Corporation
111 Front Street
Greenwood, Mississippi 38930 USA
(662) 455-1200
For product information,
call 1-888-VIKING1 (845-4641)
or visit the Viking Web site at
vikingrange.com
F20562A EN
(081109J)
IMPORTANT
• Before beginning, please read these
instructions completely and carefully.
• DO NOT remove permanently affixed
labels, warnings, or plates from product.
This may void the warranty.
• All local and national codes and
ordinances must be observed. Installation
must conform with local codes or in the
absence of codes, the National Fuel Gas
Code ANSI Z223.1 NFPA54-latest edition.
• The installer must leave these instructions
with the consumer for local inspector’s use
and for future reference.
Installation of any gas-fired equipment
should be made by a licensed plumber. A
manual gas shut-off valve must be installed
in the gas supply line ahead of the cooktop
in the gas stream for safety and ease of
service.
In Canada: Installation must be in
accordance with the current CAN/CGA
B149.1 & 2 Gas Installation codes and/or
local codes. Electrical installation must be in
accordance with the current CSA C22.1
Canadian Electrical Codes Part 1 and/or
local codes.
In Massachusetts: All gas products must be
installed by a “Massachusetts” licensed
plumber or gasfitter. A “T” type handle
manual valve must be installed in the gas
supply line to the appliance.
3
– Please Read and Follow
Your safety and the safety of others is
very impor tant.
We have provided many important safety
messages in this manual and on your
appliance. ALWAYS read and obey all
safety messages.
This is the safety alert symbol. This
symbol alerts you to hazards that
can kill or hurt you and others.
All safety messages will be preceded by
the safety alert symbol and the word
“DANGER,” “WARNING” or “CAUTION.”
These words mean:
Hazards or unsafe practices
which WILL result in severe personal
injury or death
DANGER
Hazards or unsafe practices
which COULD result in severe personal
injury or death
Hazards or unsafe practices which
COULD result in minor personal injury
or property damage.
All safety messages will identify the
hazard, tell you how to reduce the chance
of injury, and tell you what can happen if
the instructions are not followed.
WARNING
CAUTION
Table of Contents
Warnings & Important Safety Instructions _______________________________________________3
Dimensions (VGSU Professional) _______________________________________________________6
Specifications (VGSU Professional) _____________________________________________________7
Dimensions (DGSU Designer) _________________________________________________________8
Specifications (DGSU Designer) _______________________________________________________9
Dimensions (DGCU Designer) ________________________________________________________10
Specifications (DGCU Designer) ______________________________________________________11
Cutout Dimensions _________________________________________________________________12
Cutout Dimensions (VGSU Cooktop over Single Electric Oven)___________________________13
Cutout Dimensions (DGSU/DGCU Cooktop over Single Electric Oven) ____________________14
Clearance Dimensions (Proximity to Cabinets) __________________________________________15
Clearance Dimensions (Wood/Composite Overlay) _____________________________________16
Electrical & Gas Requirements _______________________________________________________17
General Information ________________________________________________________________19
Installation_________________________________________________________________________20
Optional Gasket Installation ______________________________________________________20
Gas & Electrical Connection ______________________________________________________20
VGSU Bracket Installation ________________________________________________________21
DGSU/DGCU Bracket Installation _________________________________________________21
Final Preparation ___________________________________________________________________22
Performance Checklist ______________________________________________________________22
Service & Registration _______________________________________________________________23
2
IMPORTANT5– Please Read and FollowIMPORTANT4– Please Read and Follow
FIRE/EXPLOSION
HAZARD
IF THE INFORMATION IN
THIS MANUAL IS NOT
FOLLOWED EXACTLY, A FIRE OR
EXPLOSION MAY RESULT CAUSING
PROPERTY DAMAGE, PERSONAL
INJURY, OR DEATH.
• DO NOT store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
• WHAT TO DO IF YOU SMELL GAS:
–DO NOT try to light any appliance.
–DO NOT touch any electrical switch.
–DO NOT use any phone in your
building.
–Immediately call your gas supplier
from a neighbor’s phone.
–Follow the gas supplier’s instructions.
–If you cannot reach your gas supplier,
call the fire department.
• Installation and service must be
performed by a qualified installer,
service agency, or the gas supplier.
DANGER
CHEMICAL HAZARD
If not installed, operated and
maintained in accordance
with the manufacturer’s
instructions, this product could expose
you to substances in fuel or from fuel
combustion which can cause death or
serious illness and which are known to
cause cancer, birth defects, or other
reproductive harm.
For example, benzene is a chemical
which is part of the gas supplied to the
cooking product. It is consumed in the
flame during combustion. However
exposure to a small amount of benzene
is possible if a gas leak occurs.
Formaldehyde and soot are byproducts
of incomplete combustion. Properly
adjusted burners with a bluish rather
than yellow flame will minimize
incomplete combustion.
WARNING
ELECTRICAL GROUNDING
INSTRUCTIONS
The cooktop must be electrically grounded
in accordance with local codes or, in the
absence of codes, with the ANSI/NFPA
No. 70-latest edition. Installation should
be made by a licensed electrician. This
appliance is equipped with a three-prong
grounding plug for your protection against
shock hazard and should be plugged
directly into a properly grounded
receptacle. DO NOT cut or remove the
grounding prong from the plug.
For personal safety, this appliance
must be properly grounded. DO NOT
under any circumstances cut or
remove the third (ground) prong from
the power plug.
WARNING
BURN HAZARD
The use of cabinets for storage above the
appliance may result in a potential burn
hazard. Combustible items may ignite,
metallic items may become hot and
cause burns. If a cabinet storage is to be
provided the risk can be reduced by
installing a range hood that projects
horizontally a minimum of 5” (12.7 cm)
beyond the bottom of the cabinets.
CAUTION
Before placing the cooktop into operation,
always check for gas leaks with a soapy
water solution or other acceptable method.
DO NOT USE AN OPEN FLAME TO
CHECK FOR LEAKS.
CAUTION
This appliance shall not be used for
space heating. This information is based
on safety considerations.
WARNING
Specifications (VGSU Professional)
7
Dimensions (VGSU Professional)
6
2
1
”
(
5
3
.
3
c
m
)
3
0
-
3
/
4
”
(
7
8
.
1
cm
)
2
1
”
(
5
3
.
3
c
m
)
3
6
-
3
/
4
”
(
9
3
.
3
c
m
)
1”
(2.5 cm)
2-1/2”
(6.4 cm)
5”
(12.7 cm)
13/16”
(2.1 cm)
6-19/32”
(16.7 cm)
30” Gas Cooktop
36” Gas Cooktop
Professional Gas Cooktops
Description
V
GSU103
V
GSU163
Overall width
30-3/4” (78.1 cm) 36-3/4” (93.3 cm)
Overall height from bottom
to top of grate
5” (12.7 cm)
Overall depth from rear
21” (53.3 cm)
Cutout width
26-7/8” (68.3 cm) min. to
29-7/8” (75.9 cm) max.
34-3/8” (87.3 cm) min. to
35-7/8” (91.1 cm) max.
Cutout height
2-1/2” (6.4 cm)
Cutout depth
18-5/8” (47.3 cm) min. to
20-1/8” (51.1 cm)
Gas requirements Tofield convert from natural or LP/Propane, the orifice spuds and regulator
must be physically changed.Order conversionkit NK2VGSU to convertto
natural andLPK3VGSU to convertto LP. Uses standard residential
1/2” (1.3 cm)I.D. gas service line.
Electrical requirements
120 VAC/60Hz; 4 ft. (121.9 cm), 3-wire cord with grounded
3-prong plug attached to product.
Maximum amp usage 2.0 amps
Surface element rating
Left front
Left rear
Center front/rear
Right front
Right rear
16,000 Nat./15,500 LP (BTU)
(4.8 Nat./4.65 LP (kw))
12,000 Nat./11,500 LP (BTU)
(3.6 Nat./3.45 LP (kw))
N/A
6,000 Nat./5,500 LP (BTU)
(1.8 Nat./1.65 LP (kw))
8,000 Nat./7,500 LP (BTU)
(2.4 Nat./2.25 LP (kw))
16,000 Nat./15,500 LP (BTU)
(4.8 Nat./4.65 LP (kw))
12,000 Nat./11,500 LP (BTU)
(3.6 Nat./3.45 LP (kw))
12,000 Nat./11,500 LP (BTU)
(3.6 Nat./3.45 LP (kw))
6,000 Nat./5,500 LP (BTU)
(1.8 Nat./1.65 LP (kw))
8,000 Nat./7,500 LP (BTU)
(2.4 Nat./2.25 LP (kw))
Approximate
shipping weight
67 lb. (30.2 kg) 80 lb. (36.0 kg)
Front view Right side view
Loading...