Vieluxe 36251, 37251 Owner's Manual
61267 0204
Liquid Propane Dual Burner Station Owner’s Guide
YOU MUST READ THIS OWNER’S GUIDE BEFORE OPERATING YOUR BURNER STATION
Vieluxe®Slide-In Dual Burner Station
(Model #: 36251)
Vieluxe
®
Countertop Dual Burner Station
(Model #: 37251)
NOTICE TO INSTALLER: These
instructions must be left with the owner
and the owner should keep them for
future use.
WARNING: Follow all leak-check
procedures carefully in this manual
prior to burner station operation. Do
this even if burner station was
dealer-assembled.
WARNING: Do not try to light this
appliance without reading "Lighting"
instructions section of this manual.
THIS GAS APPLIANCE IS DESIGNED
FOR OUTDOOR USE ONLY.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your
gas supplier or your fire department.
Leaking gas may cause a fire or
explosion which can cause serious
bodily injury or death, or damage to
property.
WARNING
1. Do not store spare liquid propane
cylinder within 10 feet (3m) of this
appliance.
2. Do not store or use gasoline or other
flammable liquids or vapors within
25 feet (8m) of this appliance.
2
DANGER
Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual
may result in serious bodily injury or death, or in a fire or an explosion causing damage
to property.
WARNINGS
Do not store a spare or disconnected liquid propane cylinder under or near this burner station.
Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual.
After a period of storage, and/or non use, the Vieluxe®burner station should be checked for gas leaks
and burner obstructions before use. See instructions in this manual for correct procedures.
Do not operate the Vieluxe®burner station if there is a gas leak present.
Do not use a flame to check for gas leaks.
Combustible materials should never be within 26 inches of the top, bottom, back or sides of your
Vieluxe®burner station.
Do not put a cover or anything flammable on, or in the storage area under the burner station.
Your Vieluxe®burner station should never be used by children. Accessible parts of the burner station
may be very hot. Keep young children away while it is in use.
You should exercise reasonable care when operating your Vieluxe®burner station. It will be hot during
cooking or cleaning and should never be left unattended, or moved while in operation.
Should the burners go out while in operation, turn all gas valves off. Wait five minutes before attempting
to relight, using the lighting instructions.
Never lean over open burner station or place hands or fingers on the front edge of the burner station.
Should a grease fire occur, turn off all burners and close lid until fire is out.
Do not enlarge valve orifices or burner ports when cleaning the valves or burners.
The Vieluxe
®
burner station should be thoroughly cleaned on a regular basis.
Liquid propane gas is not natural gas. The conversion or attempted use of natural gas in a liquid
propane unit or liquid propane gas in a natural gas unit is dangerous and will void your warranty.
Do not attempt to disconnect any gas fitting while your grill is in operation.
Use heat-resistant grill mitts or gloves when operating burner station.
Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.
Combustion by-products produced when using this product contain chemicals known to the State of
California to cause cancer, birth defects, or other reproductive harm.
Do not put food directly on the burner station grates.
LIQUID PROPANE GAS UNITS ONLY:
Do not attempt to disconnect the gas regulator or any gas fitting while your burner station is
in operation.
A dented or rusty liquid propane cylinder may be hazardous and should be checked by your liquid
propane supplier. Do not use a liquid propane cylinder with a damaged valve.
Although your liquid propane cylinder may appear to be empty, gas may still be present.The cylinder
should be transported and stored accordingly.
If you see, smell or hear the hiss of escaping gas from the liquid propane cylinder:
1. Move away from liquid propane cylinder
2. Do not attempt to correct the problem yourself.
3. Call your fire department.
3
TABLE OF CONTENTS
WARRANTY 4
GENERAL INSTRUCTIONS 5
STORAGE 5
OPERATING 5
CLEANING 5
GAS INSTRUCTIONS 6
LIGHTING THE LEFT & RIGHT SIDE BURNERS 11
TO EXTINGUISH 11
MANUALLY LIGHTING THE LEFT & RIGHT
BURNERS 12
TO EXTINGUISH 12
GENERAL MAINTENANCE 13
CHECK FOR GAS LEAKS 13
REMOVE CONTROL PANEL 13
REINSTALL CONTROL PANEL 15
REINSTALL BURNER CONTROL KNOBS &
IGNITER 15
FLAME PATTERN 16
REPLACE IGNITER BATTERY 16
BURNER STATION TROUBLESHOOTING 17
BURNER STATION EXPLODED VIEW 18
TRADEMARKS 18
- Double-Walled Stainless Steel Doors Ltd. Lifetime
- Brushed Stainless Steel Work Surface
- Porcelain-Enameled Cast Iron Burner Grate
- Battery-Powered, Weather Sealed Continuous-Spark Igniter 10 - Year Limited
- Brass Infinite Control Valves, with Heavy-Duty Control Knobs
Weber-Stephen Products Co. (Weber-Stephen) hereby warrants to the ORIGINAL PURCHASER of this
Vieluxe®appiance that it will be free of defects in material and workmanship from the date of purchase as follows:
When assembled and operated in accordance with the printed instructions accompanying it.
Weber-Stephen may require reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN
YOUR SALES RECEIPT OR INVOICE.
This Limited Warranty shall be limited to the repair or replacement of parts that prove defective under normal use
and service and which on examination shall indicate, to Weber-Stephen’s satisfaction, they are defective. Before
returning any parts, contact Customer Service Toll Free at 1-866-VIELUXE
SM
. If Weber-Stephen confirms the
defect and approves the claim, Weber-Stephen will elect to replace such parts without charge. If you are required to
return defective parts, transportation charges must be prepaid. Weber-Stephen
®
will return parts to the purchaser,
freight or postage prepaid.
This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse, misuse, alteration,
misapplication, vandalism, improper installation or improper maintenance or service, or failure to perform normal and
routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this
owner’s manual.
Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes or tornadoes,
discoloration due to exposure to chemicals either directly or in the atmosphere, is not covered by this Limited
Warranty.
There are no other express warrants except as set forth herein and any applicable implied warranties of
merchantability and fitness are limited in duration to the period of coverage of this express written Limited Warranty.
Some regions do not allow limitation on how long an implied warranty lasts, so this limitation may not apply to you.
Weber-Stephen is not liable for any special, indirect or consequential damages. Some regions do not allow the
exclusion or limitation of incidental or consequential damages, so this limitation or exclusion may not apply to you.
Weber-Stephen does not authorize any person or company to assume for it any other obligation or liability in
connection with the sale, installation, use, removal, return, or replacement of its equipment; and no such
representations are binding on Weber-Stephen.
This Warranty applies only to products sold at retail.
Vieluxe
®
Customer Service
1890 Roselle Road, Suite 308
Schaumburg, IL 60195
USA
www.vieluxe.com
For Replacement Parts or Service Contact Customer Service Toll Free at 1-866-VIELUXESM.
4
WARRANTY
5
GENERAL INSTRUCTIONS
• Not for use by children.
• If there are local codes that apply to gas grills, you will have to conform to them. If there are no local codes, you
must conform to the latest edition of the National Fuel Gas Code: ANSI Z223.1/NFPA 54.
• The burner station is set for operation at 10.5 inches of water column (pressure).
• This Vieluxe
®
burner station is designed for use with liquid propane (LP) gas only. Do not use with natural (piped
in city) gas. The valves, orifices, hose and regulator are for LP gas only.
• Do not use with charcoal fuel.
• Check that the area under the control panel and the bottom tray are free from debris that might obstruct the flow
of combustion or ventilation air.
Storage
• The gas must be turned OFF at the LP cylinder when the Vieluxe®burner station is not in use.
Operating
WARNING: Only use this burner station outdoors in a well-ventilated area. Do not use in a garage,
building, breezeway or any other enclosed area.
WARNING: Never use your Vieluxe
®
burner station under an unprotected combustible roof or overhang.
WARNING: Your Vieluxe®burner station is not intended to be installed in or on recreational vehicles
and/or boats.
WARNING: Do not use combustible materials within 26 inches of the top, bottom, back or sides of
the burner station.
WARNING: The entire cooking box gets hot when in use. Do not leave unattended.
WARNING: Keep any electrical supply cord and the fuel supply hose away from any heated surface.
WARNING: Keep the cooking area clear of flammable vapors and liquids such as gasoline, alcohol, etc.,
and combustible materials.
WARNING: Never store an extra (spare) LP cylinder under or near the Vieluxe®burner station.
WARNING: Keep the ventilation openings of the cylinder enclosure free and clear of debris.
WARNING:Turn off the gas at the LP gas supply cylinder when the outdoor cooking gas appliance is not
in use.
WARNING: Never store an outdoor cooking gas appliance indoors unless the LP cylinder is disconnected
and removed from the outdoor cooking gas appliance.
WARNING: LP Cylinders must be stored outdoors out of the reach of children and must not be stored in a
building, garage, or any other enclosed area.
WARNING:The LP pressure regulator and hose assembly supplied with the outdoor cooking gas
appliance must be used. Replacement LP pressure regulators and hoses must be obtained from
Weber-Stephen Product Co..
Cleaning
WARNING:Turn your Vieluxe®gas grill OFF and wait for it to cool before cleaning.
CAUTION: Do not clean your Flavorizer®bars or cooking grates in a self-cleaning oven. For availability of
replacement cooking grates and Flavorizer®bars contact Vieluxe®Customer Service at 1-866-VIELUXE.
Outside surfaces - Use a warm soapy water solution to clean, then rinse with water.
CAUTION: Do not use oven cleaner, abrasive cleansers (kitchen cleansers) cleaners that contain citrus
products, or abrasive cleaning pads on barbecue or cart surfaces.
Slide out Bottom tray - Remove excess grease, then wash with warm soapy water, then rinse
Flavorizer®bars and Cooking grates - Clean with a suitable brass bristle brush. As needed, remove from grill and
wash with warm soapy water, then rinse with water.
Catch pan - You can line the catch pan with aluminum foil. To clean the catch pan, wash with warm soapy water,
then rinse.
Thermometer - Wipe with warm soapy water; clean with plastic scrub ball. Do not put in dishwasher or
submerge in water.
Inside cooking module - Brush any debris off of burner tubes. DO NOT ENLARGE BURNER PORTS
(OPENINGS). Wash inside of cooking box with warm soapy water and a water rinse.
Inside Lid - While lid is warm, wipe inside with paper towel to prevent grease build-up. Flaking built-up grease
resembles paint flakes.
Stainless steel surfaces - Wash with a soft cloth and a soap and water solution. Be careful to scrub with the grain
direction of the stainless steel.
Do not use cleaners that contain acid, mineral spirits or xylene. Rinse well after cleaning.
6
GAS INSTRUCTIONS
Fill liquid propane cylinder
To fill, take the liquid propane cylinder and filler adapter
to an RV center or look up gas-propane in the phone
book for other sources of liquid propane gas.
WARNING: We recommend that your liquid
propane cylinder be filled at an authorized
liquid propane gas dealer by a qualified
attendant, who fills the tank by weight.
IMPROPER FILLING IS DANGEROUS.
Tell your liquid propane dealer that this is a new liquid
propane cylinder. The air must be removed from a new
liquid propane cylinder before the initial filling. Your
liquid propane cylinder dealer is equipped to do this.
The liquid propane cylinder must be installed,
transported and stored in an upright position, and
should not be dropped or handled roughly.
Never store or transport the liquid propane cylinder
where temperatures can reach 125° Fahrenheit (too hot
to hold by hand – for example: do not leave the liquid
propane cylinder in a car on a hot day).
For full instructions on safe handling of liquid propane
cylinders, see Section “Operating”.
Important LP Cylinder Information
Failure to follow these DANGER statements exactly
may result in a fire causing death or serious injury.
DANGER
NEVER store a spare LP Cylinder under or near
this grill.
NEVER fill the tank beyond 80% full.
Your Weber
®
gas grill is equipped with a cylinder
supply system designed for vapor withdrawal.
WARNING: Only use this grill outdoors in a well-
ventilated area. Do not use in a garage, building,
breezeway or any other enclosed area.
Check that all burner valves are off
Valves are shipped in the OFF position, but you should
check to be sure that they are turned OFF. Check by
pushing down and turning clockwise. If they do not
turn, they are off. Proceed to the next step. If they do
turn continue turning them clockwise until they stop,
then they are off. Proceed to the next step.
Connecting the Liquid Propane Cylinder
WARNING: Make sure that the LP cylinder valve
is closed. Close by turning valve clockwise.
DANGER
Do not use an open flame to check for gas leaks.
Be sure there are no sparks or open flames in the
area while you check for leaks. Sparks or flames
will result in a fire or explosion which can cause
serious bodily injury or death, and damage to
property.
Loading...