Victory Vision 2009 Owner's manual
inside cover.fm Page 202 Tuesday, April 1, 2008 9:45 AM
California Proposition 65 Warning
This product contains or emits
chemicals known to the state of
California to cause cancer and birth
defects or other reproductive harm.
visionownersmanual.book Page 1 Wednesday, February 13, 2008 4:31 PM
2009 VICTORY VISION RIDER’S MANUAL
Copyright2008 Polaris Sales Inc. All Rights Reserved.
P/N 9921967
Printed in U.S.A.
INTRODUCTION
1
visionownersmanual.book Page 2 Wednesday, February 13, 2008 4:31 PM
INTRODUCTION
General Information
All information contained within this publication is based on the latest product information
available at the time of publication. Product improvements or other changes may result in
differences between this manual and the motorcycle. Depictions and/or procedures in this
publication are intended for reference use only.
No liability can be accepted for omissions or inaccuracies. Polaris Industries reserves the
right to make changes at any time, without notice and without incurring obligation to make
the same or similar changes to motorcycles previously built. Any reprinting or reuse of the
depictions and/or procedures contained within, whether whole or in part, is expressly
prohibited.
All reference to RIGHT, LEFT, FRONT, REAR are from the operator’s perspective seated in a
normal riding position.
Features of VICTORY Motorcycles are covered by U.S. Patent Nos: 6,976,691; 6,407,663;
D489670; D482311; D482304; D481980; D481973; D474142.
2
visionownersmanual.book Page 3 Wednesday, February 13, 2008 4:31 PM
Trademarks
The following are registered trademarks of Polaris Industries Inc.
POLARIS
POLARIS THE WAY OUT
VICTORY
VICTORY MOTORCYCLES
VICTORY VISION
FREEDOM
DUNLOP is a registered trademark of Dunlop Tire Corporation.
LOCTITE is a trademark of Henkel Corporation.
XM and its corresponding logos are trademarks of XM Radio Inc.
iPod is a registered trademark of Apple Inc.
INTRODUCTION
3
WARNING
visionownersmanual.book Page 4 Wednesday, February 13, 2008 4:31 PM
INTRODUCTION
Before You Ride
Read your Rider’s Manual
This Rider’s Manual contains information that is essential to safe riding and proper
maintenance of your VICTORY VISION motorcycle. Anyone who uses the motorcycle
(operators and passengers) must read the Rider’s Manual before riding. Carefully read and
understand the information found in the Safety section. Understand and follow the
procedures outlined in the Maintenance section to keep your VICTORY motorcycle in top
condition on the road or in storage. Bring the manual with you when you ride. Following the
precautions and procedures in the manual will add to your enjoyment and help keep you
riding safely. If you lose or damage this manual, you can purchase a new one through any
authorized VICTORY dealer. The Rider’s Manual should be considered part of the
motorcycle and remain with it if sold.
Failure to follow the safety precautions and operation and maintenance procedures outlined
in this manual could result in death or injury (to you or your passenger) or damage to the
motorcycle.
4
visionownersmanual.book Page 5 Wednesday, February 13, 2008 4:31 PM
TABLE OF CONTENTS
BEFORE YOU RIDE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-36
REPORTING SAFETY DEFECTS . . . . . . . . . . . . . . . . . . . . . . 35
IDENTIFICATION / COMPONENT LOCATION . . . . . . . . . . . . . . 37-46
INSTRUMENTS, FEATURES & CONTROLS . . . . . . . . . . . . . . . . 47-84
PRE-RIDE CHECKS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85-106
OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 107-128
MAINTENANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129-206
CLEANING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 207-216
STORAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 217-224
WARRANTY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 225-238
5
visionownersmanual.book Page 6 Wednesday, February 13, 2008 4:31 PM
TABLE OF CONTENTS
SPECIFICATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 239-250
AUDIO
SYSTEM OVERVIEW . . . . . . . . . . . . . . . . . . . . . . . . . . . 251-258
FEATURES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 259-276
CB RADIO - ICOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 277-292
AUX - iPod
XM RADIO . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 299-302
CD CHANGER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 303-306
INDEX. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 307-320
6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 293-298
WARNING
CAUTION
visionownersmanual.book Page 7 Wednesday, February 13, 2008 4:31 PM
SAFETY
Safety Symbols and Terms
Symbols And Terms Used In This Manual
The following safety signal words and symbols appear throughout the Rider’s Manual.
Your safety and the safety of others are involved when these words and symbols are
used. Become familiar with their meanings before reading the manual.
Indicates a hazardous situation, which, if not avoided, could result in death or
serious injury.
Indicates a hazardous situation, which, if not avoided, could result in minor or moderate
injury.
NOTICE:
Indicates a situation, which, if not avoided, could result in damage to the motorcycle.
Safety
7
WARNING
WARNING
visionownersmanual.book Page 8 Wednesday, February 13, 2008 4:31 PM
SAFETY
Safe Riding Practices
Safety
Improper use of this motorcycle can result in serious injury or death to you, your passenger
and others. To minimize the risk of injury, read and understand the information contained in
this section before operating the motorcycle. This section contains safety information
specific to the VICTORY motorcycle, as well as information about general motorcycle
safety. Anyone who uses the motorcycle (operators and passengers) must follow these
safety precautions.
Motorcycling has inherent risks. You can minimize those risks, but you can’t eliminate them
completely. Even if you’re an experienced motorcycle operator or passenger, read all of the
information in this safety section before operating the motorcycle.
8
visionownersmanual.book Page 9 Wednesday, February 13, 2008 4:31 PM
SAFETY
Safe Riding Practices
• Your ability to safely operate the motorcycle depends on your judgment and your use of
safe riding habits. Take a rider education course from the Motorcycle Safety Foundation or
another qualified instructor. The course will help you develop or refresh your expertise in
safe riding habits through instruction and riding. For information on Motorcycle Safety
Foundation rider education courses in your area, call 1-800-446-9227 or visit their home
page at http://www.msf-usa.org.
• Read and understand all information in this Rider’s Manual. It contains safety information
specific to individual components and operations.
• Pay close attention to the motorcycle maintenance requirements in this manual. For
additional information or assistance with technical services specified in the manual or
required by mechanical circumstances, see the VICTORY service manual or your
authorized VICTORY dealer.
Safety
9
visionownersmanual.book Page 10 Wednesday, February 13, 2008 4:31 PM
SAFETY
Safe Riding Practices
Safety
The following design characteristics affect how you should ride the VICTORY motorcycle.
• The motorcycle is designed for on-road use with one rider and one passenger. Do not
exceed the Gross Vehicle Weight rating. See loading examples beginning on page 28 or
the Manufacturer’s label located under the rear panel on the console which contains the
Vehicle Identification Number (VIN), Gross Vehicle Weight Rating (GVWR) and GAWR
(Gross Axle Weight Rating) information.
Riding off-road, riding with more than one passenger, or carrying weight exceeding the
maximum weight rating can make handling difficult, which could cause loss of control.
• In the first 500 miles, operate the motorcycle according to the break-in procedures
beginning on page 108. Operating the motorcycle without following break-in procedures
can result in serious engine damage.
• Some VICTORY models include saddlebags, a windshield, or a touring trunk as standard
equipment. To maintain stability, load cargo properly as described in this Rider’s Manual
and be prepared to reduce the operating speed of motorcycles equipped with these items
as original equipment or as accessories.
10
visionownersmanual.book Page 11 Wednesday, February 13, 2008 4:31 PM
SAFETY
Safe Riding Practices
Follow these general safe riding practices:
• Before each ride, make the checks described in the Pre-Ride Checks section beginning on
page 85. Operating the motorcycle without completing the pre-ride check may cause
damage to the motorcycle or result in an accident.
• Until you’re thoroughly familiar with the VICTORY motorcycle and all of its controls,
practice riding where there is little or no traffic. Practice riding at a moderate speed on
varying road surfaces and under varying weather conditions.
• Know your skills and limits, and ride within them.
• Allow only licensed, experienced operators to ride your motorcycle, and then only after
they have read this manual and become familiar with its controls and operation.
• Do not ride when you’re fatigued or under the influence of alcohol, prescription drugs,
over-the-counter drugs or any other drugs. Fatigue, alcohol and drugs can cause
drowsiness, loss of coordination and loss of balance. They can also affect your awareness
and judgment.
• If your motorcycle operates abnormally, correct the problem immediately (see the
VICTORY service manual or contact your authorized VICTORY dealer).
11
Safety
visionownersmanual.book Page 12 Wednesday, February 13, 2008 4:31 PM
SAFETY
Safe Riding Practices
Safety
• The most common cause of accidents involving a motorcycle and an automobile is the
automobile driver’s failure to see the motorcycle. Ride defensively, as if you are invisible
to other motorists, even in broad daylight. Ride where you’re clearly visible to other
motorists, and observe their behavior carefully, as they may not see or be aware of you.
• Be especially cautious at intersections, as these are the most likely places for an accident.
• To prevent loss of control while operating the motorcycle, keep your hands on the
handlebars and your feet on the footrests whenever the motorcycle is moving.
• Obey the speed limit and adjust your speed and riding technique based on road, weather
and traffic conditions. As you travel faster, the influence of all other conditions increases,
which can affect the motorcycle’s stability and increase the possibility of losing control.
• Do not move or operate the motorcycle with the steering locked, as the severely restricted
steering could result in loss of control.
12
visionownersmanual.book Page 13 Wednesday, February 13, 2008 4:31 PM
Safe Riding Practices
• Reduce your speed when:
- The road has potholes or is otherwise rough or uneven.
- The road has sand, dirt, gravel or other loose substances on it.
- The road is wet, icy, or oily.
- The road contains painted surfaces, manhole covers, metal grating, railway
crossings or other slippery surfaces.
- The weather is windy.
- The traffic is heavy, congested, not allowing sufficient space between
vehicles or otherwise not flowing smoothly.
- You are being passed in either direction by a large vehicle that produces a
wind blast in its wake.
SAFETY
Safety
13
visionownersmanual.book Page 14 Wednesday, February 13, 2008 4:31 PM
SAFETY
Safe Riding Practices
Safety
• To maximize braking effectiveness, use the front and rear brakes together. Improper
braking may cause loss of control or may not slow the vehicle in time to avoid a collision.
Be aware of the following braking facts and practices:
- The rear brake provides 40% of the motorcycle’s stopping power, at most.
- Consider road conditions before applying the brakes. When the road is wet
or rough or contains loose or other slippery substances, apply the brakes
gradually.
- Bring the motorcycle to the upright position before applying the brakes, and
avoid applying the brakes in a corner if at all possible. When the motorcycle
is leaning through a corner, the amount of traction available for braking is
reduced, increasing the possibility of the tires skidding when the brakes
are applied.
14
visionownersmanual.book Page 15 Wednesday, February 13, 2008 4:31 PM
SAFETY
Safe Riding Practices
• When approaching a curve, choose a speed and lean angle that allows you to pass
through the curve in your own lane without applying the brakes. Excessive speed,
improper lean angle or braking in a curve can cause loss of control.
• Ground clearance is reduced when the motorcycle leans. Do not allow components
to contact the road surface when leaning the motorcycle in a curve, as this could
cause loss of control.
• Retract the sidestand fully before riding. If the sidestand is not fully retracted, it
could contact the road surface and cause loss of control.
• Do not tow a trailer. Towing a trailer can make the motorcycle hard to control.
Safety
15
visionownersmanual.book Page 16 Wednesday, February 13, 2008 4:31 PM
SAFETY
Carrying A Passenger
Safety
To carry a passenger safely, do the following:
• Direct the passenger to hold on to you or to the passenger hand grips and to keep both
feet on the passenger footrests. Do not carry a passenger who cannot place both feet
firmly on the footrests. A passenger who is not holding on properly, or who cannot reach
the passenger footrests, can shift their body erratically, which can make the motorcycle
hard to handle and cause a loss of control.
• To obtain the best ride and handling characteristics, adjust the rear shock absorber air
pressure according to instructions beginning on page 153.
• Before riding, be sure your passenger knows safe riding procedures. Discuss any safety
information unfamiliar to your passenger. A passenger who is unaware of safe riding
procedures may distract you or make movements that make the motorcycle hard to
handle.
• Adjust your riding style to compensate for the differences in handling, acceleration and
braking caused by the additional weight of the passenger. Failure to do so could result in
loss of control.
16
visionownersmanual.book Page 17 Wednesday, February 13, 2008 4:31 PM
SAFETY
Carrying Cargo
Use the following guidelines when attaching cargo or accessories to the motorcycle. Failure
to do so could result in loss of control. Where applicable, these guidelines also refer to the
contents of any accessories.
• Keep cargo and accessory weight to a minimum, and keep items as close to the
motorcycle as possible to minimize a change in the motorcycle’s center of gravity
• Distribute weight evenly on both sides of the motorcycle. Maintain even weight
distribution by checking accessories and cargo to make sure they’re securely attached to
the motorcycle before riding and whenever you take a break from riding.
• Do not attach large or heavy cargo such as sleeping bags, duffel bags or tents to the
handlebars, front fork area or front fender. Cargo or accessories placed in these areas can
cause instability (due to improper weight distribution or aerodynamic changes). Such
items can also block air flow to the engine and cause overheating that can damage the
engine.
• Do not exceed the maximum cargo weight limit of any accessory (see accessory
instructions and labels), and do not attach cargo to an accessory not designed for that
purpose.
• Do not attach anything to the motorcycle unless specifically designed for that purpose by
VICTORY.
17
Safety
visionownersmanual.book Page 18 Wednesday, February 13, 2008 4:31 PM
SAFETY
Protective Apparel
Safety
To decrease the risk of injury and increase riding comfort, wear protective riding apparel:
• Wear a Department of Transportation (DOT) or SNELL approved helmet. Some state laws
require that you wear an approved helmet. In accidents involving motorcycles, head
injuries are the leading cause of motorcyclist fatalities. An approved helmet is the most
effective protection in preventing or reducing head injuries.
• Wear eye protection. Some state laws require that you wear eye protection. Eye protection
reduces the chance that your vision could be impaired by wind or by airborne particles
and objects.
• You and your passenger should wear bright or light colored and/or reflective clothing to
improve visibility to other motorists. A motorist’s failure to see or recognize a motorcycle
is the leading cause of automobile/motorcycle accidents.
• Wear gloves, a jacket, heavy boots and long pants to prevent or reduce abrasions,
lacerations or burns should the motorcycle fall.
• Wear boots with low heels, as high heels can catch on pedals or footrests. The
combination of boots and pants should completely cover legs, ankles and feet, protecting
skin from engine and exhaust system heat. The engine and exhaust system get hot soon
after the engine is started and stay hot for about half an hour after the engine is turned off.
• Do not wear loose, flowing clothing or long boot laces, as they can catch on handlebars,
levers or footrests, or become entangled in the wheels, causing loss of control and
serious injury or death.
18
visionownersmanual.book Page 19 Wednesday, February 13, 2008 4:31 PM
SAFETY
Saddlebags & Trunk
Whenever operating a motorcycle with original equipment or accessory saddlebags:
• Never ride at speeds exceeding 80 mph (120 kph). Depending on load and weather
conditions, the maximum safe operating speed may be less than 80 mph (120 km/h).
Saddlebags, combined with the lifting or buffeting effects of wind, can make the
motorcycle unstable and cause loss of control.
• Distribute weight evenly in each of the saddlebags.
• Do not exceed the individual weight limit of each saddlebag or the trunk. A weight capacity
label is attached inside for reference. See Loading Examples beginning on page 28. See
page 27 for GVWR information.
• NEVER EXCEED GROSS VEHICLE WEIGHT RATING (GVWR), regardless of whether or not
the saddlebags and/or trunk are loaded to capacity. Exceeding the weight rating can
reduce stability and handling and cause loss of control.
19
Safety
visionownersmanual.book Page 20 Wednesday, February 13, 2008 4:31 PM
SAFETY
Modifications
Safety
Modifying the motorcycle by removing any equipment or by adding equipment not
approved by VICTORY may void your warranty. Such modifications could make the
motorcycle unsafe to ride and could result in severe injury to operator or passengers, as
well as damage to the motorcycle. Some modifications may also be illegal in some states.
If in doubt, contact your authorized VICTORY dealer.
Parking The Motorcycle
When leaving the motorcycle unattended, turn the engine off and lock the steering (see
page 48.) Remove the ignition key. Park in a well lit area to discourage thieves.
Park the motorcycle where people are not likely to touch the hot engine or exhaust system
or place combustible materials in close proximity to these hot areas. Do not park near a
flammable source such as a kerosene heater or an open flame, where hot components
could ignite combustible materials.
Park the motorcycle on a firm, level surface. Sloped or soft surfaces may not support the
motorcycle when it’s parked, and it may tip over. If you must park on a slope or soft
surface, follow the precautions outlined on page 126.
20
visionownersmanual.book Page 21 Wednesday, February 13, 2008 4:31 PM
SAFETY
Accessory Selection and Installation
Because VICTORY cannot test and make specific recommendations concerning every
accessory or combination of accessories sold, the operator is responsible for determining
that the motorcycle can be safely operated with any accessories or additional weight. Use
the following guidelines when choosing and installing accessories:
• Do not install accessories that impair the stability, handling or operation of the
motorcycle. Before installing an accessory, be sure that it does not:
- Reduce ground clearance when the motorcycle is either leaned or in a vertical position.
- Limit suspension or steering travel or your ability to operate controls.
- Displace you from your normal riding position.
- Obscure lights or reflectors.
• Bulky or large accessories can cause instability (due to the lifting or buffeting effects of
wind) and loss of control.
• Do not install electrical accessories that exceed the capacity of the motorcycle’s
electrical system. Never install higher wattage light bulbs than those supplied as original
equipment. An electrical failure could result and cause hazardous loss of engine power
or lights, or damage to the electrical system. See page 198 for more information.
• Use only genuine VICTORY accessories designed for your model.
21
Safety
To loop on frame.
(One tiedown each side)
To shock/strut mount, or rear tip-over bar
(One tiedown each side)
visionownersmanual.book Page 22 Wednesday, February 13, 2008 4:31 PM
SAFETY
Transporting The Motorcycle
Safety
If you must transport the motorcycle, use a truck or
trailer. Do not tow the motorcycle with another
vehicle, as towing will impair the motorcycle’s
steering and handling, which can cause loss of
control.
• Position and restrain the motorcycle so it remains
upright on the truck or trailer, as gasoline may
leak out of the fuel tank if the motorcycle leans to
one side. Gasoline is a fire hazard and it can also
damage the motorcycle’s finish.
• Do not restrain the motorcycle using the
handlebars. In front, hook the tiedowns in the
loop provided in the bottom of the frame. Place
tie-downs as wide apart as possible on the truck
or trailer bed for best stability. Secure the
motorcycle as shown at right.
22
visionownersmanual.book Page 23 Wednesday, February 13, 2008 4:31 PM
SAFETY
Fueling Precautions
For complete fueling procedure see page 110. Gasoline is highly flammable and can be
explosive in certain conditions. Observe the following precautions when you refuel or
service the fuel system:
• Turn off the engine.
• Open the fuel cap slowly.
• Add fuel in a well-ventilated area.
• Do not spill gasoline on the engine or the exhaust system. Immediately wipe, or rinse with
water, gasoline spilled on any part of the motorcycle or the surrounding area.
• Do not smoke while fueling.
• Do not fuel in an area where there are sparks or open flames.
23
Safety
visionownersmanual.book Page 24 Wednesday, February 13, 2008 4:31 PM
SAFETY
Gasoline and Exhaust Precautions
Safety
Gasoline and gasoline vapors are poisonous and can cause severe injury.
• Do not swallow gasoline, inhale gasoline vapors, or spill gasoline on yourself or your
clothes.
• If you swallow gasoline, inhale more than a few breaths of gasoline vapor, or get gasoline
in your eyes, see a physician immediately.
• If you spill gasoline on your skin, wash it off immediately with soap and water. If you spill
gasoline on your clothes, change your clothes immediately.
Exhaust gases contain carbon monoxide, a colorless, odorless gas that can cause
unconsciousness or severe injury or death in a short time. Observe the following
precautions to avoid the effects of exhaust gases:
• Do not inhale exhaust gases.
• Do not start or run the engine in an enclosed area.
24
visionownersmanual.book Page 25 Wednesday, February 13, 2008 4:31 PM
SAFETY
Periodic Maintenance
Failure to perform safety maintenance as recommended can result in difficult handling and
loss of control, which could result in serious injury or death. Always perform the safety
maintenance procedures as recommended. Perform maintenance and repairs promptly
as outlined in the VICTORY service manual, or see your authorized VICTORY dealer for
service.
• Before each ride, complete a pre-ride check as outlined beginning on page 85.
• Perform periodic maintenance according to the intervals outlined in the Periodic
Maintenance Interval tables beginning on page 133.
• Maintain proper tire pressure and tread condition and proper wheel and tire balance.
Inspect tires regularly and replace them if they’re worn or damaged. Use only an
approved replacement tire and see the VICTORY service manual or your authorized
VICTORY dealer for tire replacement.
• Check proper steering head bearing adjustment. Regularly inspect the rear shock
absorber and the front forks. Check for fork oil or shock absorber fluid leaks. Operating
the motorcycle with a loose, worn, or damaged steering system or front or rear
suspension system can make the motorcycle hard to handle and cause loss of control.
25
Safety
visionownersmanual.book Page 26 Wednesday, February 13, 2008 4:31 PM
SAFETY
Periodic Maintenance
Safety
• Keep the motorcycle clean. In addition to extending the service life and the original
appearance of the motorcycle, a complete and thorough cleaning can reveal items in
need of repair.
• Keep equipment required by federal, state, and local laws in place and in good working
condition. Your license plate must be clean, clearly visible in all conditions, and installed
in a position specified by law.
• Each fastener used in the motorcycle meets our quality specifications for strength, finish
and type. When replacement fasteners are needed, use only genuine VICTORY parts,
tightened to the proper torque. A fastener that does not meet original specifications
could fail and result in damage to the motorcycle or injury to riders.
Electromagnetic Interference
This vehicle complies with European directive 97/24/EC Chapter 8 requirements, which is
equivalent to Canadian ICES-002.
26
visionownersmanual.book Page 27 Wednesday, February 13, 2008 4:31 PM
SAFETY
Gross Vehicle Weight Rating (GVWR)
Gross Vehicle Weight is the maximum allowable weight of the vehicle, and includes the
total weight of the motorcycle, the operator, and the passenger. NEVER exceed the
motorcycle’s Gross Vehicle Weight Rating. Exceeding the weight rating can reduce
stability and handling and could cause loss of control.
• The weight of the motorcycle includes the motorcycle and all of its fluids, any
accessories and their contents, and any additional cargo on the motorcycle.
• The weight of the operator or passenger includes body weight, all apparel and objects
in or on apparel.
• Examples of loading and calculating Gross Vehicle Weight are included on the following
pages. Refer to the specifications section of this manual (beginning on page 239) or to
the certification label (located under the rear console panel in front of the seat) for
additional GVWR information on your specific model.
27
Safety
Loading...