Victory Vision 2008 Owner's manual

Rider’s Manual

2008

For your nearest Victory dealer, call 1-800-POLARIS or visit www.polarisindustries.com Polaris Sales Inc., 2100 Hwy. 55, Medina, MN 55340 Phone 1-888-704-5290 (204-925-7100 French speaking) Part No. 9921252 Rev 03 Printed in USA

California Proposition 65 Warning

This product contains or emits

chemicals known to the state of

California to cause cancer and birth

defects or other reproductive harm.

INTRODUCTION

2008 VICTORY VISION RIDER’S MANUAL

P/N 9921252

Printed in U.S.A.

INTRODUCTION

General Information

All information contained within this publication is based on the latest product information available at the time of publication. Product improvements or other changes may result in differences between this manual and the motorcycle. Depictions and/or procedures in this publication are intended for reference use only.

No liability can be accepted for omissions or inaccuracies. Polaris Industries reserves the right to make changes at any time, without notice and without incurring obligation to make the same or similar changes to motorcycles previously built. Any reprinting or re use of the depictions and/or procedures contained within, whether whole or in part, is expressly prohibited.

All reference to RIGHT, LEFT, FRONT, REAR are from the operator’s perspective seated in a normal riding position.

Features of Victory Motorcycles are covered by U.S. Patent Nos: 6,976,691; 6,407,663; D489670; D482311; D482304; D481980; D481973; D474142.

INTRODUCTION

TRADEMARKS

The following are registered trademarks of Polaris Industries Inc.

POLARIS POLARIS THE WAY OUT VICTORY MOTORCYCLES

FREEDOM DUNLOP is a registered trademark of Dunlop Tire Corporation. LOCTITE is a trademark of Henkel Corporation. XM and its corresponding logos are trademarks of XM Radio Inc. iPod is a registered trademark of Apple Inc.

INTRODUCTION

Before You Ride

Read your Rider’s Manual

This Rider’s Manual contains information that is essential to safe riding and proper maintenance of your Victory Vision

(operators and passengers) must read the Rider’s Manual before riding. Carefully read and understand the information found in the Safety section. Understand and follow the procedures outlined in the Maintenance section to keep your Victory motorcycle in top condition on the road or in storage. Bring the manual with you when you ride. Following the precautions and procedures in the manual will add to your enjoyment and help keep you riding safely . If you lose or damage this manual, you can purchase a new one through any authorized Victory dealer. The Rider’s Manual should be considered part of the motorcycle and remain with it if sold.

WARNING

Failure to follow the safety precautions and operation and maintenance procedures outlined in this manual could result in death or injury (to you or your passenger) or damage to the motorcycle.





motorcycle. Anyone who uses the motorcycle

TABLE OF CONTENTS

BEFORE YOU RIDE 4 SAFETY 7-36 IDENTIFICATION / COMPONENT LOCATION 37-46 INSTRUMENTS, FEATURES, & CONTROLS 47-84 PRE-RIDE CHECKS 85-106 OPERATION 107-128 MAINTENANCE 129-206 CLEANING 207-216 STORAGE 217-224 WARRANTY 225-238 SPECIFICATIONS 239-250

TABLE OF CONTENTS

AUDIO

SYSTEM OVERVIEW 251-258 FEATURES 259-276 CB RADIO - ICOM 277-292 AUX - iPod XM RADIO 299-302 CD CHANGER 303-306

INDEX 307



293-298

SAFETY

Safety Symbols and Terms

Symbols And Terms Used In This Manual

The following safety signal words and symbols appear throughout the Rider’s Manual. Your safety and the safety of others are involved when these words and symbols are used. Become familiar with their meanings before reading the manual.

WARNING

Indicates a hazardous situation, which, if not avoided, could result in death or serious injury.

CAUTION

Indicates a hazardous situation, which, if not avoided, could result in minor or moderate injury.

Safety

NOTICE:

Indicates a situation, which, if not avoided, could result in damage to the motorcycle.

SAFETY

Safe Riding Practices

Safety

WARNING

Improper use of this motorcycle can result in serious injury or death to you, your passenger and others. To minimize the risk of injury, read and understand the information contained in this section before operating the motorcycle. This section contains safety information specific to the Victory motorcycle, as well as information about general motorcycle safety. Anyone who uses the motorcycle (operators and passengers) must follow these safety precautions.

WARNING

Motorcycling has inherent risks. You can minimize those risks, but you can’t eliminate them completely. Even if you’re an experienced motorcycle operator or passenger, read all of the information in this safety section before operating the motorcycle.

SAFETY

Safe Riding Practices

• Your ability to safely operate the motorcycle depends on your judgment and your use of safe riding habits. Take a rider education course from the Motorcycle Safety Foundation or another qualified instructor. The course will help you develop or refresh your expertise in safe riding habits through instruction and riding. For information on Motorcycle Safety Foundation rider education courses in your area, call 1-800-446-9227 or visit their home page at http://www.msf-usa.org.

• Read and understand all information in this Rider’s Manual. It contains safety information specific to individual components and operations.

• Pay close attention to the motorcycle maintenance requirements in this manual. For additional information or assistance with technical services specified in the manual or required by mechanical circumstances, see the Victory Service Manual or your

authorized Victory Dealer.

Safety

SAFETY

Safe Riding Practices

Safety

The following design characteristics affect how you should ride the Victory motorcycle.

• The motorcycle is designed for on-road use with one rider and one passeng er. Do not exceed the Gross Vehicle Weight rating. See loading examples beginning on page 28 or the Manufacturer’s label located under the rear panel on the console which contains the Vehicle Identification Number (VIN), Gross Vehicle Weight Rating (GVWR) and GAWR (Gross Axle Weight Rating) information. Riding off-road, riding with more than one passenger, or carrying weight exceeding the maximum weight rating can make handling difficult, which could cause loss of control.

• In the first 500 miles, operate the motorcycle according to the break-in procedures beginning on page 108. Operating the motorcycle without following break-in procedures can result in serious engine damage.

• The Victory Vision touring trunk as standard equipment. The Victory Vision Street model includes saddlebags and a windshield. To maintain stability, load cargo properly as described in this Rider’s Manual and be prepared to reduce the operating speed of motorcycles equipped with these items as original equipment or as accessories.



Tour motorcycle includes saddlebags, a windshield, and a

SAFETY

Safe Riding Practices

Follow these general safe riding practices:

• Before each ride, make the checks described in the Pre-Ride Checks section

beginning on page 85. Operating the motorcycle without completing the pre-ride check may cause damage to the motorcycle or result in an accident.

• Until you’re thoroughly familiar with the Victory motorcycle and all of its controls,

practice riding where there is little or no traffic. Practice riding at a moderate speed on varying road surfaces and under varying weather conditions.

• Know your skills and limits, and ride within them.

• Allow only licensed, experienced operators to ride your motorcycle, and then only

after they have read this manual and become familiar with its controls and operation.

• Do not ride when you’re fatigued or under the influence of alcohol, prescription

drugs, over-the-counter drugs or any other drugs. Fatigue, alcohol and drugs can cause drowsiness, loss of coordination and loss of balance. They can also affect your awareness and judgment.

• If your motorcycle operates abnormally, correct the problem immediately (see the

Victory Service Manual or contact your authorized Victory dealer).

Safety

SAFETY

Safe Riding Practices

Safety

• The most common cause of accidents involving a motorcycle and an automobile is the automobile driver’s failure to see the motorcycle. Ride defensively, as if you are invisible to other motorists, even in broad daylight. Ride where you’re clearly visible to other motorists, and observe their behavior carefully, as they may not see or be aware of you.

• Be especially cautious at intersections, as these are the most likely places for an accident.

• To prevent loss of control while operating the motorcycle, keep your hands on the handlebars and your feet on the footrests whenever the motorcycle is moving.

• Obey the speed limit and adjust your speed and riding technique based on road, weather and traffic conditions. As you travel faster, the influence of all other conditions increases, which can affect the motorcycle’s stability and increase the possibility of losing control.

• Do not move or operate the motorcycle with the steering locked, as the severely restricted steering could result in loss of control.

Safe Riding Practices

• Reduce your speed when:

- The road has potholes or is otherwise rough or uneven.

- The road has sand, dirt, gravel or other loose substances on it.

- The road is wet, icy, or oily.

- The road contains painted surfaces, manhole covers, metal grating, railway crossings or other slippery surfaces.

- The weather is windy.

- The traffic is heavy, congested, not allowing sufficient space between vehicles or otherwise not flowing smoothly.

- You are being passed in either direction by a large vehicle that produces a wind blast in its wake.

SAFETY

Safety

SAFETY

Safe Riding Practices

Safety

• To maximize braking effectiveness, use the front and rear brakes together. Improper braking may cause loss of control or may not slow the vehicle in time to avoid a collision. Be aware of the following braking facts and practices:

- The rear brake provides 40% of the motorcycle’s stopping power, at most.

- Consider road conditions before applying the brakes. When the road is wet or rough or contains loose or other slippery substances, apply the brakes gradually.

- Bring the motorcycle to the upright position before applying the brakes, and avoid applying the brakes in a corner if at all possible. When the motorcycle is leaning through a corner, the amount of traction available for braking is reduced, increasing the possibility of the tires skidding when the brakes are applied.

SAFETY

Safe Riding Practices

• When approaching a curve, choose a speed and lean angle that allows you to pass

through the curve in your own lane without applying the brakes. Excessive speed, improper lean angle or braking in a curve can cause loss of control.

• Ground clearance is reduced when the motorcycle leans. Do not allow components

to contact the road surface when leaning the motorcycle in a curve, as this could cause loss of control.

• Retract the sidestand fully before riding. If the sidestand is not fully retracted, it

could contact the road surface and cause loss of cont rol.

• Do not tow a trailer. Towing a trailer can make the motorcycle hard to control.

Safety

SAFETY

Carrying A Passenger

Safety

To carry a passenger safely, do the following:

• Direct the passenger to hold on to you or to the passenger hand grips and to keep both feet on the passenger footrests. Do not carry a passenger who cannot place both feet firmly on the footrests. A passenger who is not holding on properly, or who cannot reach the passenger footrests, can shift their body erratically, which can make the motorcycle hard to handle and cause a loss of control.

• To obtain the best ride and handling characteristics, adjust the rear shock absorber air pressure according to instructions beginning on page 153.

• Before riding, be sure your passenger knows safe riding procedures. Discuss any safety information unfamiliar to your passenger. A passenger who is unaware of safe riding procedures may distract you or make movements tha t make the motorcycle hard to handle.

• Adjust your riding style to compensate for the differences in handling, acceleration and braking caused by the additional weight of the passenger. Failure to do so can cause loss of control.

SAFETY

Carrying Cargo

Use the following guidelines when attaching cargo or accessories to the motorcycle. Where applicable, these guidelines also refer to the contents of any accessories.

• Keep cargo and accessory weight to a minimum, and keep items as close to the

motorcycle as possible to minimize a change in the motorcycle’s center of gravity. Changing the center of gravity can cause loss of stability and handling and could cause loss of control.

• Distribute weight evenly on both sides of the motorcycle. Maintain even weight

distribution by checking accessories and cargo to make sure they’re securely attached to the motorcycle before riding and whenever you t ake a break from riding. Uneven weight distribution, or accessories or cargo that shift suddenly while you’re riding can make the motorcycle hard to handle and could cause loss of control.

• Do not attach large or heavy cargo such as sleeping bags, duf fel bags or tent s to the

handlebars, front fork area or front fender. Cargo or accessories placed in these areas can cause instability (due to improper weight distribution or aerodynamic changes) and could cause loss of control. Such items can also blo ck air flow to the en gine and cause overheating that can damage the engine.

• Do not exceed the maximum cargo weight limit of any accessory (see accessory

instructions and labels), and do not attach cargo to an accessory not designed for that purpose, as these could result in an accessory failure that could cause loss of control.

• Do not attach anything to the motorcycle unless specifically designed for that purpose

by Victory.

Safety

SAFETY

Protective Apparel

Safety

To decrease the risk of injury and increase riding comfort, wear protective riding apparel:

• Wear a Department of Transport ation (DOT) or SNELL approved helmet. Some state laws require that you wear an approved helmet. In accidents involving motorcycles, head injuries are the leading cause of motorcyclist fatalities. An approved helmet is the most effective protection in preventing or reducing head injuries.

• Wear eye protection. Some state laws require that you wear eye protection. Eye protection reduces the chance that your vision could be impaired by wind or by airborne particles and objects.

• Y ou and your passenger should wear bright or light colored and/or reflective clothing to improve visibility to other motorists. A motorist’s failure to see or recognize a motorcycle is the leading cause of automobile/motorcycle accidents.

• Wear gloves, a jacket, heavy boots and long pants to prevent or reduce abrasions, lacerations or burns should the motorcycle fall.

• Wear boots with low heels, as high heels can catch on pedals or footrests. The combination of boots and pants should completely cover legs, ankles and feet, protecting skin from engine and exhaust system heat. The engine and exhaust system get hot soon after the engine is started and stay hot for about half an hour after the engine is turned off.

• Do not wear loose, flowing clothing or long boot laces, as they can catch on handlebars, levers or footrests, or become entangled in the wheels, causing loss of control and serious injury or death.

SAFETY

Saddlebags & Trunk

Whenever operating a motorcycle with original equipment or accessory saddlebags:

• Never ride at speeds exceeding 80 mph (120 kph). Depending on load and weather

conditions, the maximum safe operating speed may be less than 80 mph (120 km/h). Saddlebags, combined with the lifting or buffeting effects of wind, can make the motorcycle unstable and cause loss of control.

• Distribute weight evenly in each of the saddlebags.

• Do not exceed the individual weight limit of each saddlebag or the trunk. A weight

capacity label is attached inside for reference. See Loading Examples beginning on page 28, and page 27 for GVWR infor mat i on .

• NEVER EXCEED GROSS VEHICLE WEIGHT RATING (GVWR), regardless of

whether or not the saddlebags and/or trunk are loaded to capacity.Exceeding the weight rating can reduce stability and handling and cause loss of control.

Safety

SAFETY

Modifications

Safety

Modifying the motorcycle by removing any equipment or by adding equipment not approved by Victory may void your warranty. Such modifications could make the motorcycle unsafe to ride and could result in severe inju ry to operator or passengers, a s well as damage to the motorcycle. Some modifications may also be illegal in some states. If in doubt, contact your authorized Victory dealer.

Parking The Motorcycle

When leaving the motorcycle unattended, turn the engine off and lock the steering (see page 48.) Remove the ignition key. Park in a well lit area to discourage thieves.

Park the motorcycle where people are not likely to touch the hot engine or exhaust system or place combustible materials in close proximity to these hot areas. Do not park near a flammable source such as a kerosene heater or an open flame, where hot components could ignite combustible materials.

Park the motorcycle on a firm, level surface. Sloped or soft surfaces may not support the motorcycle when it’s parked, and it may tip over . If you must p ark on a slope or soft surface, follow the precautions outlined on page 127.

SAFETY

Accessory Selection and Installation

Because Victory cannot test and make specific recommendations concerning every accessory or combination of accessories sold, the operator is responsible for determining that the motorcycle can be safely operated with any accessories or additional weight. Use the following guidelines when choosing and installing accessories:

• Do not install accessories that impair the stability, handling or operation of the

motorcycle. Before installing an accessory, be sure that it does not:

- Reduce ground clearance when the motorcycle is either leaned or in a vertical position.

- Limit suspension or steering travel or your ability to operate controls.

- Displace you from your normal riding position.

- Obscure lights or reflectors.

• Bulky or large accessories can cause instability (due to the lifting or buffeting effects

of wind) and loss of control.

• Do not install electrical accessories that exceed the capacity of the motorcycle’s

electrical system. Never install higher wattage light bulbs than those supplied as original equipment. An electrical failure could result and cause hazardous loss of engine power or lights, or damage to the electrical system. See page 198 for more information.

• Use only genuine Victory accessories designed for your model.

Safety

SAFETY

Transporting The Motorcycle

Safety

If you must transport the motorcycle, use a truck or trailer. Do not tow the motorcycle with another vehicle, as towing will impair the motorcycle’s steering and handling, which can cause loss of control.

• Position and restrain the motorcycle so it remains upright on the truck or trailer, as gasoline may leak out of the fuel tank if the motorcycle leans to one side. Gasoline is a fire hazard and it can also damage the motorcycle’s finish.

• Do not restrain the motorcycle using the handlebars. In front, hook the tiedowns in the loop provided in the bottom of the frame. Place tie-downs as wide apart as possible on the truck or trailer bed for best stability. Secure the motorcycle as shown at right.

To loop on frame. (One tiedown each side)

To shock/strut mount, or rear tip-over bar (One tiedown each side)

SAFETY

Fueling Precautions

For complete fueling procedure see page 110. Gasoline is highly flamma b le an d ca n be explosive in certain conditions. Observe the following precautions when you refuel or service the fuel system:

• Turn off th e engine.

• Open the fuel cap slowly.

• Add fuel in a well-ventilated area.

• Do not spill gasoline on the engine or the exhaust system. Immediately wipe, or

rinse with water,gasoline spilled on any part of the motorcycle or the surrounding area.

• Do not smoke while fueling.

• Do not fuel in an area where there are sparks or open flames.

Safety

SAFETY

Gasoline and Exhaust Precautions

Safety

Gasoline and gasoline vapors are poisonous and can cause severe injury.

• Do not swallow gasoline, inhale gasoline vapors, or spill gasoline on yourself or your clothes.

• If you swallow gasoline, inhale more than a few breaths of gasoline vapor, or get gasoline in your eyes, see a physician immediately.

• If you spill gasoline on your skin, wash it off immediately with soap and water. If you spill gasoline on your clothes, change your clothes immediately.

Exhaust gases contain carbon monoxide, a colorless, odorless gas that can cause unconsciousness or severe injury or death in a short time. Observe the following precautions to avoid the effects of exhaust gases:

• Do not inhale exhaust gases.

• Do not start or run the engine in an enclosed area.

SAFETY

Periodic Maintenance

Maintain the motorcycle according to the following requirements:

• Before each ride, complete a pre-ride check as outlined beginning on page 85.

Operating the motorcycle without completing the pre-ride check can cause damage to the motorcycle or result in an accident.

• Perform periodic maintenance according to the intervals outlined in the Periodic

Maintenance Interval tables beginning on page 133. Operating the motorcycle without performing periodic maintenance can damage the motorcycle or result in bodily injury.

• Maintain proper tire pressure and tread condition and proper wheel and tire balance.

Inspect tires regularly and replace them if they’re worn or damaged. Use only an approved replacement tire and see the Victory Service Manual or your authorized Victory Dealer for tire replacement. Operating the motorcycle with improper tire pressure or tread condition, or improper wheel or tire balance, can make the motorcycle hard to handle and cause loss of control.

• Check proper steering head bearing adjustment. Regularly inspect the rear shock

absorber and the front forks. Check for fork oil or shock absorber fluid leaks. Operating the motorcycle with a loose, worn, or damaged steering system or front or rear suspension system can make the motorcycle hard to handle and cause loss of control. To repair steering or suspension system wear or damage, see the Victory Service Manual or contact your authorized Victory Dealer.

Safety

SAFETY

Periodic Maintenance

Safety

Keep the motorcycle clean. In addition to extending the service life and the original appearance of the motorcycle, a complete and thorough cleaning can reveal items in need of repair. For complete cleaning procedures, see page 207.

• Keep equipment required by federal, state, and local laws in place and in good working condition. Your license plate must be clean, clearly visible in all conditions, and installed in a position specified by law.

• Each fastener used in the motorcycle meets our quality specifications for strength, finish and type. When replacement fasteners are needed, use only genuine Victory parts, tightened to the proper torque. A fastener that does not meet original specifications could fail and result in damage to the motorcycle or injury to riders.

Electromagnetic Interference

This vehicle complies with European directive 97/24/EC Chapter 8 requirements, which is equivalent to Canadian ICES-002.

SAFETY

Gross Vehicle Weight Rating (GVWR)

Gross Vehicle Weight is the maximum allowable weight of the vehicle, and includes the total weight of the motorcycle, the operator , and the passenger. NEVER exceed the motorcycle’ s Gross Vehicle W eight Rating. Exceeding the weight rating can reduce stability and handling and could cause loss of control.

• The weight of the motorcycle includes the motorcycle and all of its fluids, any

accessories and their contents, and any additional cargo on the motorcycle.

• The weight of the operator or passenger includes body weight, all apparel and

objects in or on apparel.

• Examples of loading and calculating Gross Vehicle Weight are included on the

following pages. Refer to the specifications section of this manual (beginning on page 239) or to the certification label (located under the rear console panel in front of the seat) for additional GVWR information on your specific model.

Safety

+ 293 hidden pages