Victory V92C Deluxe 2002 Owner's manual
2002
V92C
V92C DELUXE
WARNING
The engine exhaust from this
product contains chemicals known
to cause cancer, birth defects or
other reproductive harm.
We’ve created a web site, just for YOU!!
S Technical tips
S New product introductions
S Event schedules
S Parts and Service Manual information
S Exciting details about The Way Out
Check it out...
www.polarisindustries.com
All text, photographs, and illustrations in this manual are based on the most current product information available
at the time of publication. Product improvements or other changes may result in differences between this manual
and the motorcycle. Polaris Industries reserves the right to make production changes at any time, without notice
and without incurring any obligation to make the same or similar changes to motorcycles previously built.
2002 OWNER’S MANUAL
V92C/V92C Deluxe
Victory Motorcycle Division, Polaris Industries Inc.
2100 Highway 55, Hamel, Minnesota 55340-9800 Tele: (763) 542-0500 Fax: (763) 542-0599
CopyrightE 2001 Polaris Industries Inc. All rights reserved.
Victory Motorcycles is a registered trademark of Polaris Industries Inc.
Dunlop is a registered trademark of Dunlop Tire Corporation.
Features of Victory motorcycles are covered by U.S. Patent Nos. D397976, D398065, D407169,
D409551, D416831, D436561, with additional patents pending.
Foreword
Thank you for choosing a Victory Motorcycle!
The Owner’s Manual contains information on the following Victory Motorcycles:
V92C Standard Cruiser
V92C Deluxe Cruiser
All photographs and illustrations used are generalizations, and your specific model may be slightly different
than what is shown.
If you misplace or damage the Owner’s Manual, you should purchase a replacement copy from an authorized
Victory dealer. The manual should be considered part of the motorcycle, and remain with the motorcycle
when it is sold.
If after reading the Owner’s Manual you have questions about the operation or maintenance of the
motorcycle, contact an authorized Victory dealer. To locate an authorized Victory dealer near you:
Call 1--800--POLARIS and provide the area code or zip code of your location.
Visit www.polarisindustries.com for a listing of authorized Victory dealers by state, zip code, or area
code.
i
Foreword
Your authorized Victory dealer will resolve all issues regarding the motorcycle. If you are unsatisfied with the
performance of your Victory dealer, contact Polaris Customer Service at 763--417--8650.
Victory motorcycles comply with all federal, state, and local safety and emission regulations for the area of
intended sale.
Have a safe and enjoyable ride.
ii
Table of Contents
Introduction 1.....................
Read the Owner’s Manual 1..............
Symbols and Terms Used in the Owner’s
Manual 2...............................
Safety Precautions 3...............
Safe Riding 4...........................
Design Characteristics 4.................
Safe Riding Practices 5.................
Carrying a Passenger 8.................
Protective Apparel 9.....................
Gross Vehicle Weight Rating (GVWR) 10...
Loading 12..............................
Saddlebags 13...........................
Parking 14...............................
Transporting 14..........................
Product Modifications 15.................
Selecting and Installing Accessories 15...
Gasoline and Exhaust Gases 16...........
Maintenance 17..........................
Location of Safety and Vehicle Information
Labels 19................................
Reporting Safety Defects 22..............
Motorcycle Description 23...........
Vehicle Identification Number 26..........
Engine Identification Number 26..........
Ignition Key Number 27...................
Instruments and Controls 29........
Ignition Key 29...........................
Steering Lock 29.........................
Ignition Switch/Seat Release 30...........
Off Position 30..........................
On Position 30..........................
P (Park) Position 31.....................
Seat Release Position 31.................
Helmet Holders 31........................
Instrument Cluster 32....................
Speedometer 32.........................
Tachometer 32..........................
Indicator Lights 32.......................
Low Oil Pressure Indicator 32.............
Low Fuel Indicator 33....................
iii
Table of Contents
Neutral Indicator 33......................
Turn Signal Indicators 33.................
Headlamp High Beam Indicator 33.........
Multi--Function Display (MFD) 34..........
Odometer 34............................
Trip Odometer 34........................
Clock 35...............................
Instrument Cluster Light Dimmer 36........
Headlamp High Beam Indicator Light
Dimmer 36.............................
Fuel Gauge 36..........................
Voltmeter 36............................
Check Engine Indicator 37................
Left Side Handlebar Controls 39...........
Fast Idle Lever 39.......................
Headlamp High/Low Beam Switch 39......
Turn Signal Switch 39....................
Horn Button 39..........................
Clutch Lever 40.........................
Multi--Function Display (MFD) Set Button 40
Right Side Handlebar Controls 40.........
Engine Stop/Run Switch 40...............
Emergency Flasher Switch 41.............
Starter Button 41........................
iv
Front Brake Lever 41....................
Throttle Control Grip 41..................
Multi--Function Display (MFD) Mode
Button 41...............................
Gear Shift Pedal 42.......................
Rear Brake Pedal 42......................
Fuel Cap 43..............................
Saddlebags 43...........................
Side Covers 43...........................
Sidestand 44.............................
Pre-Operation Check 45.............
Check Electrical Equipment 45............
Instrument Cluster 45....................
Headlamp 46...........................
Taillight 46..............................
Turn Signals/Running Lights 46............
Emergency Flashers 46..................
Horn 46................................
Engine Stop/Run Switch 47...............
Check Engine Oil Level 47................
Fuel 48..................................
Check Fuel Level 48.....................
Check Fuel Hose, Rail, and Connections 48.
Table of Contents
Check Evaporative Emission Control System
(California model only) 48................
Tires 49.................................
Check Tire Pressure 49..................
Tire Pressure Table 49...................
Check Tire Condition 50..................
Check Tread Depth 50...................
Brakes 50................................
Check Front Brake Lever Movement 50....
Check Front Brake Fluid Level 51..........
Check Rear Brake Pedal Freeplay and
Movement 51...........................
Check Rear Brake Fluid Level 52..........
Check Hoses and Connections 52.........
Check Brake Pads 52....................
Check Throttle Control Grip and Cables 53.
Check Clutch 53.........................
Check Fast Idle Lever 54..................
Check Front Suspension 54...............
Check Steering 55........................
Check Rear Suspension 55...............
Check Drive Belt 55......................
Check Sidestand 56......................
Check Fasteners 56......................
Operation 57.......................
Engine Break--in Period 57................
Fueling and Fill Height 59.................
Starting the Engine 60....................
Shifting Gears 62........................
Accelerating 65..........................
Braking 66...............................
Stopping the Engine 67...................
Parking 67...............................
Maintenance 69.....................
Initial Maintenance 70....................
Periodic Maintenance Intervals 70.........
Periodic Maintenance Interval Table 71.....
Engine Oil 74............................
Change Engine Oil and Oil Filter 74........
Check Engine Oil Level 75................
Inspect Air Filter 76......................
Inspect Drive Sprocket and Sprocket Nut 77
Drive Belt 77.............................
Check Drive Belt Condition 77.............
Check Drive Belt Tension 78..............
Adjust Drive Belt Tension 79..............
Align Rear Wheel 80.....................
v
Table of Contents
Rear Suspension 82......................
Adjust Rear Shock Absorber 82...........
Inspect Swing Arm and Rear Axle 84.......
Front Suspension and Steering 85........
Check Front Forks 85....................
Replace Front Fork Oil 85................
Inspect Steering and Front Axle 86.........
Fuel System 86..........................
Check Fuel Hose, Rail, and Connections 86.
Check Crankcase Ventilation Hose and
Connections 87.........................
Evaporative Emission Control System
(California models only) 87................
Fuel Tank 87............................
Replace Fuel Filter 88....................
Fast Idle Lever 88........................
Check Fast Idle Lever and Cable 88.......
Adjust Fast Idle Lever Freeplay 88.........
Throttle 89...............................
Check Throttle Control Grip and Cable 89...
Adjust Throttle Freeplay 89...............
Clutch 90................................
Check Clutch Lever and Cable 90..........
Lubricate Clutch Lever 90.................
vi
Adjust Clutch Freeplay 91................
Lubricate Control Cables 92..............
Brakes 92................................
Check Front Brake Lever Movement 92....
Lubricate Front Brake Lever 93............
Check Front Brake Fluid Level 93..........
Add Front Brake Fluid 93.................
Check Rear Brake Pedal Freeplay and
Movement 95...........................
Adjust Rear Brake Pedal Freeplay 95......
Check Rear Brake Fluid Level 96..........
Add Rear Brake Fluid 96.................
Check Brake Pads 97....................
Check Brake Hoses and Connections 98...
Gear Shift Pedal 98.......................
Adjust Gear Shift Pedal Height 98.........
Tires 99.................................
Check Tire Pressure 99..................
Tire Pressure Table 99...................
Check Tire Condition 100..................
Check Tread Depth 100...................
Check Wheel Spokes
(V92C Deluxe Cruiser) 100.................
Check or Replace Spark Plugs 101.........
Check Engine Compression 103............
Table of Contents
Check Exhaust System 103................
Remove and Install Seats 104..............
Battery 105...............................
Remove Battery 106......................
Charge Battery 106.......................
Install Battery 107........................
Electrical Equipment 108..................
Replace Fuses 108.......................
Adjust Headlamp 109.....................
Remove and Install Saddlebags 110........
V92C Deluxe Cruiser 110..................
Sidestand 110.............................
Lubricate Sidestand 110...................
Inspect Sidestand Pad 111.................
Check Fasteners 112......................
Road Test 112.............................
Cleaning an d Storage 113............
Cleaning 113..............................
Washing and Drying 114...................
Waxing, Polishing, and Applying Protectants
(Items Other Than Windshields and Leather
Saddlebags) 1 16.........................
Windshield Care 1 17......................
Leather Saddlebag Care 1 17...............
Repairing Painted Surface Damage 1 18.....
Storage 118...............................
Preparing for Storage 119.................
Clean and Protect the Motorcycle 119.......
Stabilize Fuel 119.........................
Protect Engine Components 120............
Inflate Tires 120..........................
Remove, Clean, and Store Battery 121......
Park and Cover the Motorcycle 121.........
Maintaining During Storage 121............
Removing from Storage 122...............
Warranties 123.......................
Motorcycle Noise Regulation 123...........
Noise Emission Warranty 124..............
Emissions Control System Warranty 124....
Your W arranty Rights and Obligations 124...
Manufacturer’s Warranty Coverage 125......
Owner’s Warranty Responsibilities 125......
I. Coverage 126..........................
II. Limitations 127.........................
III. Limited Liability 128....................
IV . Legal Rights 129.......................
vii
Table of Contents
V. This Warranty Is In Addition To The
Victory Limited Motorcycle Warranty. 129....
VI. Additional Information. 129..............
Victory Motorcycle Warranty Policy 130.....
Limited Warranty 130.....................
Registration 130..........................
Warranty Coverage And Exclusions: 131.....
Specifications 133...................
Fuel Specifications 137....................
Engine Oil Specifications 137..............
Identification Numbers for Your
Motorcycle 138............................
Index 139............................
viii
Introduction
Read the Owner’s Manual
The Owner’s Manual contains information that is essential to safe riding and proper maintenance of all 2002
Victory motorcycles. Anyone who uses the motorcycle (Operators and Passengers) must read the Owner’s
Manual before riding. Carefully read and understand the information found in the ”Safety Precautions”
section. Understand and follow the procedures in the Owner’s Manual to keep your Victory motorcycle in top
condition on the road or in storage. If possible, bring the manual with you when you ride. Failure to follow
the safety precautions and operation and maintenance procedures may result in death or injury to you
or your passenger, or damage to your motorcycle. Following the precautions and procedures in this manual
will add to your enjoyment, and keep you riding safely.
1
Introduction
Symbols and Terms Used in the Owner’s Manual
The following signal words and symbols appear in the Owner’s Manual. Your safety, and the safety of others
are involved when these words and symbols are used. Become familiar with their meanings before reading the
Owner’s Manual.
! The safety alert symbol indicates a potential for personal injury to you or others.
WARNING
Indicates a potential hazard that could result in serious injury or death.
Caution
Indicates a potential hazard that may result in minor personal injury or damage to the motorcycle.
Caution
Indicates a situation that may result in damage to the motorcycle.
Notice Highlights important information that we don’t want you to overlook.
2
Safety Precautions
WARNING
Improper use of this motorcycle can result in serious injury or death. To minimize the risk of
injury to you, your passenger, and others, read and understand the information contained in this
section before operating the motorcycle. This section contains safety information specific to the
Polaris Victory, as well as information about general motorcycle safety. Anyone who uses the
motorcycle (Operators and Passengers) must follow these safety precautions.
Motorcycling has inherent risks. You can minimize those risks, but you can’t eliminate them completely. Take
the time to read and understand the following information to help minimize risk and maximize pleasure when
operating the motorcycle. Even if you are an experienced motorcycle operator or passenger, read this section
of the Owner’s Manual before operating the motorcycle.
S Your ability to safely operate the motorcycle depends on your judgment and use of safe riding habits.
Take a rider education course from the Motorcycle Safety Foundation or another qualified instructor. The
course will help you develop or refresh your expertise in safe riding habits through instruction and riding.
For information on Motorcycle Safety Foundation rider education courses in your area, call
1--800--446--9227 or visit their homepage at http://msf--usa.org.
S Read and understand the rest of the Owner’s Manual. The Manual contains safety information specific to
individual components and operations throughout.
3
Safety Precautions
S Pay close attention to the motorcycle maintenance requirements in this Manual. For additional
information or assistance regarding technical service specified in the Owner ’s Manual or required by
mechanical circumstances, see the Victory Service Manual or your authorized Victory Dealer.
Safe Riding
Design Characteristics
The following design characteristics affect how you should ride the Victory motorcycle:
S The motorcycle is designed for on--road use with one rider and one passenger. Do not exceed the gross
vehicle weight rating (see Specifications or the certification label on the steering head). Riding off--road,
riding with more than one passenger, or carrying weight exceeding the maximum weight rating can make
handling difficult, which could cause you to lose control of the motorcycle.
S In the first 500 miles, operate the motorcycle according to the break--in procedures described in “Engine
Break--in” on page 57. Operating the motorcycle without following break--in procedures can result in
serious engine damage.
S Some Victory motorcycles include saddlebags, a windshield, and a passenger backrest as standard
equipment. Under certain conditions it may be necessary to reduce the operating speed of motorcycles
with this equipment.
4
Safety Precautions
Safe Riding Practices
Follow these general safe riding practices:
S Before you ride, make sure you can operate the motorcycle safely and properly b y following the
recommendations given at the beginning of the Safety Precautions section on page 3.
S Each time you ride, make the checks described in the Pre--Operation Check section. Operating the
motorcycle without completing the pre--operation check can cause damage to the motorcycle or result in
an accident.
S Until you are thoroughly familiar with the Victory motorcycle and all of its controls, practice riding
where there is little or no traffic. Practice riding at moderate speed on varying road surfaces and under
varying weather conditions.
S Know your skills and limits, and ride within them.
S Allow only licensed, experienced operators to ride your motorcycle, and then only after they have
become familiar with its controls and operation.
S Do not ride when you are fatigued or under the influence of alcohol, prescription drugs, over--the--counter
drugs, or any other drugs. Fatigue, alcohol, and drugs can cause drowsiness, loss of coordination, loss of
balance, and can affect your awareness and judgment.
S If your motorcycle operates abnormally, correct the problem immediately (see the Victory Service Manual
or contact your authorized Victory Dealer). If you continue to operate the motorcycle in this condition,
you are likely to aggravate the initial problem, increase the cost of repairs, and threaten your safety.
5
Safety Precautions
Safe Riding Practices (continued)
S The most common cause of accidents involving a motorcycle and an automobile is the automobile
driver’s failure to see the motorcycle. Ride defensively, as if you are invisible to other motorists, even in
broad daylight. Ride where you are visible to other motorists and observe their behavior carefully, as they
may not see or be aware of you.
S Be especially cautious at an intersection, as this is the most likely place for an accident. Remember
that you are more vulnerable to injury on a motorcycle than in an enclosed vehicle.
S To prevent loss of control while operating the motorcycle, keep your hands on the handlebars and your
feet on the footrests.
S Obey the speed limit and adjust your speed and riding technique based on road, weather, and traffic
conditions. As you travel faster, the influence o f all other conditions increases, which can lessen the
motorcycle’s stability and increase the possibility of your losing control of the motorcycle.
S Do not move or operate the motorcycle with the steering locked, as steering is severely restricted and you
could drop or lose control of the motorcycle.
S If in doubt, reduce your speed when:
-- The road has potholes or is otherwise rough or uneven.
-- The road h as sand, dirt, gravel or other loose substances on it.
-- The road i s wet, icy, or oily.
-- The road contains painted surfaces, manhole covers, metal grating, railway crossings, or other
slippery surfaces.
6
Safety Precautions
Safe Riding Practices (continued)
S If in doubt, reduce your speed when:
-- The weather is windy, raining, or otherwise causing slippery or rapidly changing conditions.
-- The traffic is heavy, congested, not allowing sufficient space between vehicles, or otherwise not
flowing smoothly.
-- You are being passed in either direction by a large vehicle that produces a wind blast in its wake.
S To maximize braking effectiveness, use the front and rear brakes together. Be aware of the following
braking facts and practices:
-- The rear brake provides 40% of the motorcycle’s stopping power, at most.
-- Consider road conditions before applying the brakes; when the road is wet, rough, or contains loose
or other slippery substances, apply the brakes gradually.
-- Bring the motorcycle to the upright position before applying the brakes, and avoid applying the
brakes in a corner if at all possible. When the motorcycle is leaning through a corner, the amount of
traction available for braking is reduced, increasing the possibility of the tires skidding when you
apply the brakes.
-- Improper braking may cause you to lose control of the motorcycle or may not slow you in time to
avoid a collision.
S As you approach a curve, choose a speed and a lean angle that allow you to pass through the curve in
your own lane without applying the brakes. Excessive speed, improper lean angle, or braking in a curve
can cause you to lose control of the motorcycle.
7
Safety Precautions
Safe Riding Practices (continued)
S Ground clearance is reduced when you lean the motorcycle. Do not allow components to contact the road
surface when leaning the motorcycle in a curve, as this could cause you to lose control of the motorcycle.
S Retract the sidestand fully before riding. If the sidestand is not fully retracted while you are riding, it
could contact the road surface and cause you to lose control of the motorcycle.
S Do not tow a trailer. Towing a trailer can make the motorcycle hard to handle and cause you to lose
control of the motorcycle.
Carrying a Passenger
To carry a passenger safely, do the following:
S Direct the passenger to hold onto you, or the seat strap, with both hands and to keep both feet on the
passenger footrests. Do not carry a passenger who cannot place both feet firmly on the passenger
footrests. A passenger who is not holding on properly or who cannot reach the passenger footrests can
shift their body erratically, which can make the motorcycle hard to handle and cause you to lose control
of the motorcycle.
S If necessary, adjust the rear shock absorber preload according to the instructions in “Rear Shock Absorber
Adjustment” page 82. Improper preload adjustment can make your motorcycle hard to handle and cause
you to lose control of the motorcycle.
S Before you ride, be sure your passenger knows safe riding procedures. Discuss any safety information
unfamiliar to your passenger. A passenger who is unaware of safe riding procedures may distract you or
make movements that make the motorcycle hard to handle and cause you to lose control of the
motorcycle.
8
Safety Precautions
Carrying a Passenger (continued)
S Adjust your riding style to compensate for the differences in handling, acceleration, and braking caused
by the additional weight of the passenger. Failure to do so can cause you to lose control of the
motorcycle.
Protective Apparel
To decrease the risk of injury and increase riding comfort, wear the following:
S Wear a Department of Transportation (DOT) or SNELL approved helmet. Some state laws require that
you wear an approved helmet. In accidents involving motorcycles, head injuries are the leading cause
of motorcyclist fatalities, and statistics prove that an approved helmet is the most effective
protection in preventing or reducing head injuries.
S Wear eye protection. Some state laws require that you wear eye protection. Eye protection reduces the
chance that your vision could be impaired by wind or by airborne particles and objects.
S You and your passenger should wear bright or light colored and/or reflective clothing to improve your
visibility to other motorists. A motorist’s failure to see or recognize a motorcycle is the leading cause
of automobile/motorcycle accidents.
S Wear gloves and a jacket to prevent or reduce abrasions, lacerations, or burns that you can suffer if you
fall.
9
Safety Precautions
Protective Apparel (continued)
S Wear heavy boots and pants to prevent or reduce abrasions, lacerations, or burns that you can suffer if you
fall. Wear boots with low heels because boots with high heels can catch on pedals or footrests. The
combination of your boots and pants should completely cover your legs, ankles, and feet, protecting you
from engine and exhaust system heat. The engine and exhaust system get hot soon after the engine is
started, and stay hot for about half an hour after the engine is turned off.
S Do not wear loose, flowing clothing or long boot laces, as they can catch on components like handlebars,
levers, or footrests, or get caught in the wheels, causing you to lose control of the motorcycle.
Gross Vehicle Weight Rating (GVWR)
Gross vehicle weight is the total weight of the motorcycle, the operator, and the passenger.
S The weight of the motorcycle includes: the motorcycle and all its fluids; any accessories and their
contents; and any additional cargo on the motorcycle.
S The weight of the operator or passenger includes: body weight, all apparel, and objects in or on apparel.
Do not exceed the motorcycle’s gross vehicle weight rating. Exceeding the weight rating can reduce stability
and handling and could cause you to lose control of the motorcycle.
For the gross vehicle weight rating of your specific Victory model, see Specifications or the certification label
on the steering head.
10
Safety Precautions
Example 1: V92C Standard Cruiser with no accessories or cargo
Gross Vehicle Weight Rating 1150 lbs (522 kg)
Item Weight
Standard Cruiser - with full capacity of all fluids 675 lbs (306 kg)
Operator - with recommended riding apparel 220 lbs (100 kg)
Passenger - with recommended riding apparel 155 lbs (70 kg)
Total Weight 1050 lbs (522 kg)
Example 2: V92C Deluxe Cruiser with cargo
Gross Vehicle Weight Rating 1150 lbs (522 kg)
Item Weight
Deluxe Cruiser - with full capacity of all fluids 706 lbs (320 kg)
Cargo - saddlebags at capacity 14 lbs (6 kg)
Operator - with recommended riding apparel 220 lbs (100 kg)
Passenger - with recommended riding apparel 155 lbs (70 kg)
Total Weight 1095 lbs (496 kg)
11
Safety Precautions
Loading
Use the following guidelines when attaching cargo or accessories to the motorcycle. Where applicable, these
guidelines refer to accessories and their contents.
S Keep cargo and accessory weight to a minimum, and keep it as close to the motorcycle as possible, to
minimize a change in the motorcycle’s center of gravity. Changing the center of gravity can lessen
stability and handling and could cause you to lose control of the motorcycle.
S Distribute weight evenly on both sides of the motorcycle. Maintain even weight distribution by checking
accessories and cargo to make sure they are securely attached to the motorcycle before riding and
whenever you take a break while riding. Uneven weight distribution, or accessories or cargo that shift
suddenly while you are riding, can make the motorcycle hard to handle and cause you to lose control of
the motorcycle.
S Do not attach large or heavy cargo such as sleeping bags, duffle bags, or tents to the handlebars, front fork
area, or front fender. If you add accessories to the handlebars or the front fork area, they must be as small
and as lightweight as possible. Cargo or accessories placed in any of these areas can cause instability due
to improper weight distribution or aerodynamic changes, and can cause you to lose control of the
motorcycle. Such items can also block airflow to the engine and could cause overheating that can damage
the engine.
S Do not exceed the maximum cargo weight limit of any accessory (see accessory instructions and labels),
and do not attach cargo to an accessory not designed for that purpose, as either of these could result in an
accessory failure that could cause you to lose control of the motorcycle.
12
Safety Precautions
Saddlebags
Saddlebags are included with some Victory models. Use the following guidelines when operating a
motorcycle with saddlebags installed.
S Never ride a motorcycle with saddlebags above 80 mph (120 km/h). Depending on load and weather
conditions, the maximum safe operating speed may be less than 80 mph (120 km/h). Saddlebags can
make the motorcycle unstable due to the lifting or buffeting effects of wind and can cause you to lose
control of the motorcycle.
S Distribute weight evenly in each of the saddlebags.
S Do not exceed the maximum cargo weight limit of the saddlebags.
Leather saddlebags = 7 lbs. (3.2 kg) each
S Do not exceed the motorcycle’s gross vehicle weight rating. Exceeding the weight rating can reduce
stability and handling and could cause you to lose control of the motorcycle.
13
Safety Precautions
Parking
For complete parking procedures, see “Parking” page 67.
When leaving the motorcycle unattended, turn the engine off, engage the steering lock, and take the ignition
key with you.
The engine and exhaust system are very hot after the engine has been running. Therefore, park the motorcycle
where people are not likely to touch the engine or exhaust system or place combustible materials in close
proximity to these hot areas.
Do not park near a flammable source such as a kerosene heater or an open flame, as the motorcycle could
catch fire.
Park the motorcycle on a firm level surface if possible. Sloped or soft surfaces may not support the
motorcycle when it is parked, and it may fall over. If you must park on a sloped or soft surface, reduce the
chances of the motorcycle falling over by following the procedures described in “Parking” page 67.
Transporting
If you must transport the motorcycle, do the following:
S Use a truck or trailer. Do not tow the motorcycle with another vehicle, as towing will impair the
motorcycle’s steering and handling, which can cause you to lose control of the motorcycle.
S Position and restrain the motorcycle so it is kept upright on the truck or trailer, as gasoline may leak out
of the fuel tank if the motorcycle leans over. Gasoline is a fire hazard and it can also damage the
motorcycle’s finish.
14
Safety Precautions
Product Modifications
Modifying the motorcycle by removing any equipment or adding equipment not approved by Victory may
void your warranty. Such modifications may also make the motorcycle unsafe to ride and could severely
injure you or others or damage the motorcycle. Some modifications may be illegal in some states. If in doubt,
contact your authorized Victory Dealer.
Selecting and Installing Accessories
Because Victory cannot test and make specific recommendations concerning every accessory or combination
of accessories sold, you are responsible for determining that your motorcycle can be safely operated with
accessories you install or additional weight you carry. Use the following guidelines when choosing and
mounting accessories:
S Do not install accessories that impair the stability, handling, or operation of the motorcycle. Before
installing an accessory, be sure that it does not:
-- Reduce ground clearance when the motorcycle is either leaned or in a vertical position.
-- Limit suspension o r steering travel or your ability to operate controls.
-- Displace you from your normal riding position.
-- Obscure lights or reflectors.
S Bulky or large accessories can make the motorcycle unstable due to the lifting or buffeting effects of wind
and can cause you to lose control of the motorcycle.
15
Safety Precautions
Selecting and Installing Accessories (continued)
S Do not install electrical accessories that exceed the capacity of the motorcycle’s electrical system. An
electrical failure could result and cause hazardous loss of engine power or lights, or damage to the
electrical system.
S If you want to add a windshield, backrest, or luggage rack, choose one designed and approved by Victory
specifically for your model, and follow the instructions for proper installation and use. An improperly
designed or installed windshield, backrest, or luggage rack can reduce stability, causing you to lose
control of the motorcycle.
Gasoline and Exhaust Gases
For complete fueling procedures, see “Fueling and Fill Height” page 59.
Gasoline is highly flammable and can be explosive in certain conditions. Observe the following precautions
when you refuel or service the fuel system:
S Turn off the engine.
S Use a well--ventilated area.
S Remove the fuel cap slowly.
S Do not spill gasoline on the engine or the exhaust system. Immediately wipe, or rinse with water, gasoline
spilled on any part of the motorcycle or the surrounding area.
S Do not smoke while fueling.
S Do not fuel in an area where there are sparks or open flame.
16
Loading...