Viali V60DWW15, VGGDW60SS Instruction Manual
Freestanding Dishwasher
V60DWW15/ VGGDW60SS
Instruction Manual
12 MONTH WARRANTY
Contents
Guide to the Appliance
Caring for the Environment
Safety Information and Warnings
Installation Instructions
Getting Started
Basic Set Up
Operation Instructions
Troubleshooting
Care and Maintenance
Technical Specifications
2
3
4
7
11
16
21
24
27
31
1
Guide to the Appliance
Control Panel
1. Power indicator light: To show the power supply.
2. Power switch: To turn on/off the power supply.
3. Rinse aid warning light: To show when the dispenser needs to be refilled.
4. Washing Program Selector: To select one of the three washing programs.
5. Start/Pause button: To start the selected washing program or pause the washing program
when the machine is operating.
Dishwasher Features
Front View Back View
1. Upper basket 5. Detergent dispenser 9. Rinse aid dispenser
2. Spray arms 6. Cup shelf 10. Drain pipe connector
3. Lower basket 7. Cutlery basket 11. Inlet pipe connector
4. Main filter 8. Coarse filter
Note: Due to production improvements, the appliance may differ slightly from the diagram
shown. Diagrams in this instruction manual are ready for reference only.
2
1
2
3
4
5
10 11
1
2
3
4
5
6
7
8
9
Caring for the Environment
Responsible disposal of the packaging
The packaging of your appliance has been selected from environmentally friendly materials and
can usually be recycled. Please ensure these are disposed of correctly.
Plastic wrapping can be a suffocation hazard for babies and young children, please ensure all
packaging materials are out of reach and are safely disposed of. Please ensure they are offered
for recycling rather than throwing these materials away.
Responsible disposal of the appliance
At the end of its working life, do not throw this appliance out with your household rubbish. An
environmentally friendly method of disposal will ensure that valuable raw materials can be
recovered and used again
.
Electrical and electronic appliances contain materials and substances which, if handled or
disposed of incorrectly, could be potentially hazardous on the environment and human health.
Observe any local regulations regarding the disposal of electrical consumer goods and dispose
of it appropriately for recycling. Contact your local authorities for advice on recycling facilities in
your area.
The plug must be rendered useless and the cable cut off directly behind the appliance or the
machine to prevent misuse.
DANGER.
Risk of child entrapment: When discarding a dishwasher, make sure to take off the
door and the spring action or bolt catch. Leave the shelves in place so that children cannot easily
climb in, get trapped inside and suffocate.
3
Safety Information and Warnings
IMPORTANT.
To get the best performance from your dishwasher, read all instructions before
using the appliance for the first time.
Read this instruction manual thoroughly before first use, even if you are familiar with this type of
product. We have provided many important safety statements in this manual concerning the use
of this appliance. Always read and observe all safety statements. They reduce the risk of fire,
electric shock and injury when correctly adhered to.
Keep the instruction manual in a safe place for future reference, along with the purchase receipt.
If applicable, pass these instructions on to the next owner of the appliance.
This appliance is intended to be used in household and similar applications such as:
- Staff kitchen areas in shops, offices and other working environments.
- Farm houses
- Clients in hotels, motels and other residential type environments
- Bed and breakfast type environments.
Pay particular attention to safety messages that follow the words
WARNING
or
IMPORTANT
.
These words are used to alert you to a potential hazard that can seriously injure you and others.
The instructions will tell you how to reduce the chance of injury and let you know what can
happen if the instructions are not followed.
WARNING
means that failure to read this safety statement may result in extensive product
damage or serious personal injury.
IMPORTANT
means that failure to read this safety statement may result in minor or moderate
personal injury, property or equipment damage.
We assume no liability for any eventual damages caused by misuse of the appliance or noncompliance with the instructions in this manual.
4
Safety Information and Warnings
WARNING.
When using your dishwasher, follow the precautions listed below:
Grounding Instructions
• This appliance must be grounded. In the event of a malfunction or breakdown, grounding
will reduce the risk of an electric shock by providing a path of least resistance of electric
current. This appliance is equipped with a cord having an equipment-grounding
conductor and a grounding plug.
• The plug must be plugged into an appropriate outlet that is installed and grounded in
accordance with all local codes and ordinances.
•
WARNING.
Improper connection of the equipment-grounding conductor can result in the
risk of an electric shock.
• Check with a qualified electrician or service representative if you are in doubt whether the
appliance is properly grounded. Do not modify the plug provided with the appliance; if it
does not fit the outlet. Have a proper outlet installed by a qualified electrician.
Proper Use
• Do not abuse, sit on, or stand on the
door or dish rack of the dishwasher.
• Do not touch the heating element
during or immediately after use. (This
instruction is only applicable to
machines with a visual heating
element.)
• Do not operate your dishwasher
unless all enclosure panels are
properly in place. Open the door very
carefully if the dishwasher is
operating; there is a risk of water
squirting out.
• Do not place any heavy objects on or
stand on the door when it is open.
The appliance could tip forward.
• When loading items to be washed:
1. Locate sharp items so that they are
not likely to damage the door seal;
2.
Warning
: Knives and other utensils
with sharp points must be loaded in
the basket with their points down or
placed in a horizontal position.
• When using your dishwasher, you
should prevent plastic items from
coming into contact with the heating
element. (This instruction is only
applicable to machines with a visual
heating element.)
• Check that the detergent
compartment is empty after
completion of the wash cycle.
• Do not wash plastic items unless they
are marked dishwasher safe or the
equivalent. For plastic items not so
marked, check the manufacturer's
recommendations.
• Use only detergent and rinse
additives designed for an automatic
dishwasher.
• Never use soap, laundry detergent,
or hand washing detergent in your
dishwasher. Keep these products out
of the reach of children.
• Keep children away from detergent
and rinse aid, keep children away
from the open door of the
dishwasher, there could still be some
detergent left inside.
5
Safety Information and Warnings
• This appliance is not intended for use
by persons (including children) with
reduced physical, sensory or mental
capabilities, or lack of experience and
knowledge ,unless they have been
given supervision or instruction
concerning use of the appliance by a
person responsible for their safety.
• Children should be supervised to
ensure that they do not play with the
appliance.
• Dishwasher detergents are strongly
alkaline, they can be extremely
dangerous if swallowed. Avoid
contact with skin and eyes and keep
children away from the dishwasher
when the door is open.
• The door should not be left open,
since this could increase the risk of
tripping.
• If the supply cord is damaged, it must
be replaced by the manufacturer or
its service agent or a similarly
qualified person in order to avoid a
hazard.
• Remove the door to the washing
compartment when removing an old
dishwasher from service or discarding
it.
• Please dispose of packing materials
properly.
• Use the dishwasher only for its
intended function.
• During installation, the power supply
cord must not be excessively or
dangerously bent or flattened. Do not
tamper with controls.
• The appliance is to be connected to
the water mains using new hose sets
and old hose-sets should not be
reused.
• When not using the appliance for a
long period, disconnect the mains
plug from the mains socket and turn
off the water tap.
• Inlet water supply,
Cold water pressure: 600kPa max 50 kPa min.
If cold water pressure is excess of 600
kPa, a pressure reducing valve should
be used. Check for leaks.
• The maximum number of place
settings to be washed is 12.
• Where flooding due to a burst hose
occurs due to excessive water
pressure and a pressure limiting valve
not being fitted we will not be liable
for any damage resulting from
flooding and this device not being
fitted.
6
Installation Instructions
Positioning the Appliance
Position the appliance in the desired location. The back should rest against the wall behind it,
and the sides, along the adjacent cabinets or walls, see below for measurements and required
space. The dishwasher is equipped with water supply and drain hoses that can be positioned
either to the right or the left sides to facilitate proper installation.
Levelling the Appliance
Once the appliance is positioned for levelling, the height of the
dishwasher may be altered via adjustment of the screwing level of
the feet. In any case, the appliance should not be inclined more
than 2 degrees.
7
Installation Instructions
Power Connection
WARNING.
For personal safety:
• Do not use an extension cord or an adapter plug with this appliance.
• Do not, under any circumstances cut or remove the earthing connection from the power
cord.
Electrical Requirements
Please look at the rating label to know the rating voltage and connect the dishwasher to
the appropriate power supply. Ensure the power circuit has a minimum of a 10amp fuse or
circuit breaker.
Electrical Connection
WARNING.
Insure proper ground exists before use.
Ensure the voltage and frequency of the power being used corresponds to those on the rating
plate. Only insert the plug into an electrical socket which is earthed properly. If the electrical
socket to which the appliance must be connected is not appropriate for the plug, replace the
socket, rather than using an adaptor or the like as they could cause overheating and burns.
Grounding Instructions
This appliance must be earthed. In the event of a malfunction or breakdown, earthing will reduce
the risk of electric shock by providing a path of least resistance for the electric current. This
appliance is equipped with a cord having an equipment-earthing conductor and an earthing
plug. The plug must be plugged into an appropriate outlet that is installed and earthed in
accordance with all local standards and requirements.
WARNING.
• Improper connection of the equipment earthing conductor can result in the risk of an
electric shock.
• Check with a qualified electrician or service representative if you are in doubt whether the
appliance is properly earthed.
• Do not modify the plug provided with the appliance. If the plug does not fit properly to
the outlet, please have a qualified electrician to install a proper outlet.
8
Installation Instructions
Water Connection
Cold Water Connection
Connect the cold water supply hose to a threaded 3/4(inch) connector and make sure that it is
fastened tightly in place.
If the water pipes are new or have not been used for an extended period of time, let the water
run to make sure that the water is clear. This precaution is necessary to avoid the risk of the
water inlet being blocked and damaging the appliance.
Drain Hose Connection
Upon connection of the dishwasher please ensure the following points have been followed
before leaving the premises:
• Sink ‘S’ Bend spigot hole that the drain hose connects to be drilled out using a 13mm drill
to allow for sufficient draining.
• Prior to fully installing the dishwasher, run it though a short cycle and inspect all water
connections including those behind the appliance for leaks.
9
FRONT VIEW
Inlet pipe connector Drain pipe
connector
SINK
DISHWASHER
Min 100mm
spigot connection, Drill
out spigot hole with
13mm drill before fitting
drain hose.
Drain hose
Inlet hose
Inlet Water
supply
POWER
OUTLET
Installation Instructions
How to Drain Excess Water from Hoses
If the sink is 1000mm high from the floor, the excess water in hoses cannot be drained directly
into the sink. It will be necessary to drain excess water from hoses into a bowl or suitable
container that is held outside and lower than the sink.
Water Outlet (Drain Hose)
Connect the water drain hose. The drain hose must be correctly fitted to avoid water leaks.
Ensure that the water inlet hose is not kinked or squashed.
Drill out drain pipe spigot to 13mm diameter prior to fitting drain hose.
Extension Hose
If you need a drain hose extension, make sure to use a similar drain hose. It must be no longer
than 4 metres; otherwise the cleaning effect of the dishwasher could be reduced.
Syphon Connection
The waste connection must be at a height of between 40cm (minimum) and 100cm (maximum)
from the bottom of the dish. The water drain hose should be fixed by a hose clip.
Before First Use
The following things should be checked before starting the dishwasher.
• The dishwasher is level and fixed properly.
• The inlet valve is open.
• There is no leakage at the connections of the hoses.
• The power cord is not trapped or squashed.
• The appliance is plugged in and the power is switched on.
• The inlet and drain hoses are not kinked or squashed.
• All packing materials and printings should be taken out from the dishwasher.
IMPORTANT.
After installation, please make sure to keep this instruction manual. The content of
this manual is very helpful to the users.
10
Loading...