Vestil BWK 353-A User Manual

Page 1
SAFETY DATA SHEET
g
BOARDWALK GUM REMOVER 12N6 BWK353A
Version 1.1 Revision Date 07/14/2016 Print Date 03/21/2017
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Material name : Boardwalk Gum Remover BWK353A Material number : 1041286 / A00183
Company : Boardwalk / Essendant Co. Address : One Parkway North
Deerfield, IL 60015
Telephone : 844-828-5617
Emergency telephone numbers For SDS Information : 844-828-5617 For a Medical Emergency : For a Transportation Emer
Recommended use of the chemical and restrictions on use
Recommended use : Specialty Cleaner and Remover
ency
: Chemtel: 1(800)255-3924
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
Appearance Aerosol containing a liquefied gas Colour clear Odour odourless
GHS Classification
Flammable aerosols : Category 1 Gases under pressure : Liquefied gas
GHS label elements
Hazard pictograms :
Signal word : Danger Hazard statements : H222 Extremely flam mable aerosol.
H280 Contains gas under pressure; may explode if heated.
Precautionary statements :
Prevention: P210 Keep away from heat/sparks/open flames/hot surfaces. No smoking. P211 Do not spray on an open flame or other ignition source. P251 Pressurized container: Do not pierce or burn, even after use. Storage: P410 + P412 Protect from sunli ght. Do not expo se to
1 / 10
Page 2
SAFETY DATA SHEET
BOARDWALK GUM REMOVER 12N6 BWK353A
Version 1.1 Revision Date 07/14/2016 Print Date 03/21/2017
temperatures exceeding 50 °C/ 122 °F.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Substance / Mixture : Mixture
Hazardous components
Chemical name CAS-No. Concentration [%] butane 106-97-8 >= 70 - < 90
propane 74-98-6 >= 20 - < 30 The exact percentages of disclosed substances are withheld as trade secrets.
SECTION 4. FIRST AID MEASURES
General advice : Move out of dangerous area.
Show this safety data sheet to the doctor in attendance. Do not leave the victim unattended.
If inhaled : If unconscious place in recovery position and seek medical
advice. If symptoms persist, call a physician.
In case of skin contact : Take off contaminated clothing and shoes immediately.
Get medical attention if irritation develops and pe rsists. Wash contaminated clothing before re-use. Wash off immediately with plenty of water for at least 15 minutes.
In case of eye contact : Remove contact lenses.
Protect unharmed eye. Keep eye wide open while rinsing. If eye irritation persists, consult a specialist. If in eyes, rinse with water for 15 minutes.
If swallowed : Keep respiratory tract clear.
Never give anything by mouth to an unconscious person. If symptoms persist, call a physician. DO NOT induce vomiting unless directed to do so by a physician or poison control center.
SECTION 5. FIREFIGHTING MEASURES
Suitable extinguishing media : Alcohol-resistant foam
Carbon dioxide (CO2) Dry chemical Water spray jet
Unsuitable extinguishing media
Specific hazards during firefighting
: High volume water jet
: Do not allow run-off from fire fighting to enter drains or water
courses.
2 / 10
Page 3
SAFETY DATA SHEET
BOARDWALK GUM REMOVER 12N6 BWK353A
Version 1.1 Revision Date 07/14/2016 Print Date 03/21/2017
Hazardous co mbustion products
Specific extinguishing methods
Further information : For safety reasons in case of fire, cans should be stored
Special pr otective equipment for firefighters
SECTION 6. ACCIDENTAL RELEASE MEASURES
Personal precautions, protective equipment and emergency procedures
Environmental precautions : Prevent product from entering drains.
Methods and materials for containment and cleaning up
: Carbon dioxide (CO2)
Carbon monoxide Smoke
: Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
separately in closed containments. Use a water spray to cool fully closed containers.
: Wear self-contained breathing apparatus for firefighting if
necessary.
: Ensure adequate ventilation.
Remove all sources of ignition. Evacuate personnel to safe areas. Beware of v apours accumulating to form explosive concentrations. Vapours can accumulate in low areas.
Prevent further leakage or spillage if safe to do so. If the produc t contaminat es rivers and lakes or drains inform respective authorities.
: Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust). Sweep up or vacuum up spillage and collect in suitable container for disposal.
SECTION 7. HANDLING AND STORAGE
Advice on safe handling : For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the application area. Take precautionary measures against static discharges. Provide sufficient air exchange and/or exhaust in work rooms. Open drum carefully as content may be under pressure. Dispose of rinse water in accordance with local and national regulations. Always replace cap after use. Do not breathe vapours or spray mist.
Conditions for safe storage : BEWARE: Aerosol is pressurized. Keep away from direct sun
exposure and temperatures over 50 °C. Do not open by force or throw into fire even after use. Do not spray on flames or red-hot objects. No smoking. Observe label precautions. Keep in a cool, well-ventilated place. Electrical installations / working materials must comply with the technological safety standards.
Materials to avoid : Strong oxidizing agents
3 / 10
Page 4
SAFETY DATA SHEET
r
BOARDWALK GUM REMOVER 12N6 BWK353A
Version 1.1 Revision Date 07/14/2016 Print Date 03/21/2017
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
Components CAS-No. Value type
(Form of
exposure) butane 106-97-8 TWA 800 ppm TWA 800 ppm propane 74-98-6 TWA 1,000 ppm ACGIH
TWA 1,000 ppm TWA 1,000 ppm TWA 1,000 ppm
Engineering measure s
Personal protective equipment
Respiratory protection : In case of insufficient ventilation, wear suitable respiratory
Hand protection Remarks : The suitability for a specific workplace should be discussed
Eye protect ion : Eye wash bott l e wit h pure water
Skin and body protection : Impervious clothing
Hygiene measures : Wash hands before breaks and at the end of workday.
: effective ventilation in all processing areas
equipment.
with the producers of the protective gloves.
Tightly fitting safety goggles
Choose body protection according to the amount and concentration of the dangerous substance at the work place.
When using do not s m o k e. When using do not eat or drink.
Control parameters / Permissible concentration
1,900 mg/m3 1,900 mg/m3
1,800 mg/m3 1,800 mg/m3 1,800 mg/m3
Basis
NIOSH REL OSHA P0
NIOSH REL OSHA Z-1 OSHA P0
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance : Aerosol containing a liquefied gas Colour : clear
: odourless
Odou Odour Threshold : No data available pH : Not applicable
4 / 10
Page 5
SAFETY DATA SHEET
BOARDWALK GUM REMOVER 12N6 BWK353A
Version 1.1 Revision Date 07/14/2016 Print Date 03/21/2017
Melting point/freezing point : No data available Boiling point : No data available Flash point :
No data available Evaporation rate : No data available Flammability (solid, gas) : Extremely flammable aerosol.
Upper explosion limit : No data available Lower explosion limit : No data available Vapour pressure : No data available Relative vapour density : No data available Density : No data available Solubility(ies) Water solubility : negligible Partition coefficient: n-
octanol/water Auto-ignit i on te mperature : not determined Thermal decomposition : No data available
: No data available
Viscosity Viscosity, kinematic : No data available Heat of combustion : 49.35 kJ/g
SECTION 10. STABILITY AND REACTIVITY
Reactivity : Stable Chemical st ab i l ity : Stable unde r no rm a l conditions. Possibility of hazardous
reactions Vapours may form explosive mixture with air.
Conditions to avoid : Heat, flames and sparks.
Incompatible materials : Strong oxidizing agents Hazardous decomposition
products
: No decomposition if stored and applied as directed.
Extremes of temperature and direct sunlight.
: Carbon oxides
SECTION 11. TOXICOLOGICAL INFORMATION
Potential Health Effects
5 / 10
Page 6
SAFETY DATA SHEET
A
BOARDWALK GUM REMOVER 12N6 BWK353A
Version 1.1 Revision Date 07/14/2016 Print Date 03/21/2017
Carcinogenicity:
IARC
ACGIH
OSH
NTP
Acute toxicity
Components: butane:
Acute inhalation toxicity :
propane:
Acute inhalation toxicity :
Skin corrosion/irritation
No data available
Serious eye damage/eye irritation
No data available
Respiratory or skin sensitisation
No data available
Germ cell mutagenicity
No data available
Carcinogenicity
No data available
No component of this product present at levels greater than or equal to 0.1% is identified as probable, possible or confirmed human carcinogen by IARC. No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by ACGIH. No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by OSHA. No component of this product present at levels greater than or equal to 0.1% is identified as a known or anticipated carcinogen by NTP.
LC50 Mouse: 1,237 mg/l
Exposure time: 2 h
LC50 Rat: 1,355 mg/l
LC50 Mouse: 1,237 mg/l
Exposure time: 2 h
LC50 Rat: 658 mg/l
Exposure time: 4 h
LC50 Rat: 1,355 mg/l
Reproductive toxicity
No data available
butane: propane:
STOT - single exposure
No data available
6 / 10
Page 7
SAFETY DATA SHEET
r
BOARDWALK GUM REMOVER 12N6 BWK353A
Version 1.1 Revision Date 07/14/2016 Print Date 03/21/2017
STOT - repeated exposure
No data available
Aspiration toxicity
No data available
Further information
Product:
Remarks: No data available
SECTION 12. ECOLOGICAL INFORMATION Ecotoxicity
No data available
Persistence and degradability
No data available
Bioaccumulative potential
Product:
Partition coefficient: n-
: Remarks: No data available
octanol/water
Components: butane :
Partition coefficient: n­octanol/wate
Mobility in soil
No data available
Other adverse effects
No data available
Product:
: Pow: 2.89
Regulation 40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B). Additional ecological
: No data available
information
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
7 / 10
Page 8
SAFETY DATA SHEET
g
BOARDWALK GUM REMOVER 12N6 BWK353A
Version 1.1 Revision Date 07/14/2016 Print Date 03/21/2017
Waste from residues : Dispose of in accordance with local regulations. Do not dispose of waste into sewer.
Do not contaminate ponds, waterways or ditches with
chemical or used contain er. Contaminated packaging : Empty remaining contents.
Dispose of as unused product.
Do not re-use empty containers.
Do not burn, or use a cutting torch on, the empty drum.
SECTION 14. TRANSPORT INFORMATION
Transportation Regulation: 49 CFR (USA): ORM-D, CONSUMER COMMODITY
Transportation Regulation: IMDG (Vessel): UN1950, AEROSOLS, 2.1, - Limited quantity
Transportation Regulation: IATA (Cargo Air): UN1950, Aerosols, flammable, 2.1, - Limited quantity
Transportation Regulation: IATA (Passenger Air): UN1950, Aerosols, flammable, 2.1, - Limited quantity
Transportation Regulation: TDG (Canada): UN1950, AEROSOLS, 2.1, - Limited quantity
The product as delivered to the customer conforms to packaging requirements for shipment by road under US Department of Transportation (DOT) regulations. Additional transportation classifications noted above are for reference only, and not a certification or warranty of the suitability of the packaging for shipment under these alternative transport regulations.
SECTION 15. REGULATORY INFORMATION
EPCRA - Emergency Planning and Community Right-to-Know Act CERCLA Reportable Quantity
This material does not contain any components with a CERCLA RQ.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
SARA 311/312 Hazards
SARA 302
SARA 313
: Sudden Release of Pressure Hazard
Fire Hazard
: No chemicals in this material are subject to the reporting
requirements of SARA Title III, Section 302.
: This material does not contain any chemical components with
known CAS numbers that exceed the threshold (De Minimis) reportin
levels established by SARA Title III, Section 313.
8 / 10
Page 9
SAFETY DATA SHEET
BOARDWALK GUM REMOVER 12N6 BWK353A
Version 1.1 Revision Date 07/14/2016 Print Date 03/21/2017
California Prop 65 This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other reproductive harm.
The components of this product are reported in the following inventories: TSCA
DSL
For information on the country notification status for other regions please contact the manufacturer’s regulatory group.
Inventory Acronym and Validity Area Legend:
TSCA (USA), DSL (Canada), NDSL (Canada)
SECTION 16. OTHER INFORMATION
Further information NFPA: HMIS III:
Health
Special hazard.
OSHA GHS Label Information:
Hazard pictograms :
On TSCA Inventory All components of this product are on the Canadian DSL
Flammability
4
3
Instability
0
HEALTH
FLAMMABILITY
PHYSICAL HAZARD
0 = not significant, 1 =Slight, 2 = Moderate, 3 = High 4 = Extreme, * = Chronic
3 4
2
Signal word : Hazard statements : Extremely flammable aerosol. Contains gas under pressure; may explode if heated. Precautionary statements :
Danger:
Prevention: Keep away from heat/sparks/open flames/hot surfaces. No smoking. Do
not spray on an open flame or other ignition source. Pressurized container: Do not pierce or burn, even after use.
Storage: Protect from sunlight. Do not expose to temperatures exceeding 50 °C/ 122 °F.
Version: 1.1
Revision Date: 07/14/2016
9 / 10
Page 10
SAFETY DATA SHEET
BOARDWALK GUM REMOVER 12N6 BWK353A
Version 1.1 Revision Date 07/14/2016 Print Date 03/21/2017
Print Date: 03/21/2017
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind. The information in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. Users should make their own investigations to determine the suitability and applicability of the information for their particular purposes. This SDS has been prepared b y the Compliance Services organization supporting this manufacturer, supplier or distributor.
10 / 10
Loading...