Vector BD022806 User Manual

This limited warranty program is the only one that applies to this product, and it sets forth all the
responsibilities of Vector Manufacturing, regarding this product. There is no other warranty, other than those
described herein.

This Vector Manufacturing product is warranted, to the original purchaser only, to be free of defects in materials
and workmanship for two years from the date of purchase without additional charge. The warranty does not
extend to subsequent purchasers or users. Vector Manufacturing will not be responsible for any amount of damage
in excess of the retail purchase price of the product under any circumstances. Incidental and consequential
damages are specifically excluded from coverage under this warranty.

This product is not intended for commercial use. This warranty does not apply to accessories or
damage to units from misuse or incorrect installation/connection. Misuse includes wiring or connecting to
improper polarity power sources.

RETURN/REPAIR POLICY: Defective products, other than accessories, may be returned to Vector Manufacturing.
Any defective product, other than accessories, that is returned to Vector Manufacturing within 30 days of the date
of purchase will be replaced free of charge. If such a product is returned more than 30 days but less than two
years from the purchase date, Vector Manufacturing will repair the unit or, at its option, replace it free of charge.

If the unit is repaired, new or reconditioned replacement parts may be used, at Vector Manufacturing’s option. A
unit may be replaced with a new or reconditioned unit of the same or comparable design. The repaired or replaced
unit will then be warranted under the terms of the remainder of the warranty period. The customer is responsible
for the shipping charges on all returned items after 30 days. During the warranty period, Vector Manufacturing
will be responsible for the return shipping charges.

lIMITATIONS: This warranty does not cover accessories, bulbs, fuses and batteries, defects resulting from normal
wear and tear (including chips, scratches, abrasions, discoloration or fading due to usage or exposure to sunlight),
accidents, damage during shipping to our service facility, alterations, unauthorized use or repair, neglect, misuse,
abuse, failure to follow instructions for care and maintenance, fire, flood and Acts of God.

If your problem is not covered by this warranty, call our Technical Support Department at [phone] or
toll free at [phone] for general repair information and charges if applicable.

STATE LAW RIGHTS: This warranty gives you specific legal rights. Some states do not allow limitations on how
long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages, so the
exclusions or limitations stated herein may not apply. This warranty gives the purchaser specific legal rights; other
rights, which vary from state to state, may apply.

TO REQUEST WARRANTY SERVICE FOR THIS PRODUCT: Contact Vector Manufacturing Technical Support by
telephone, fax or mail. We suggest that you keep the original packaging in case you need to ship the unit. When
returning a product, include your name, address, phone number, dated sales receipt (or copy) and a description
of the reason for return and product serial number. After repairing or replacing the unit, we will make every effort
to return it to you within four weeks.

WARRANTY ACTIVATION: Please complete Warranty Activation Card and mail to Vector Manufacturing. Enter
“VEC1040AMG” as Model and “100 Watt Power Inverter Vehicle Power System” as Product Type. All Vector
Manufacturing products must be registered within 30 days of purchase to activate this warranty. Mail the
completed registration form, along with a copy of the original sales receipt to:

PH: 954-584-4446 • TOLL FREE: 866-584-5504 • Fax: [phone].

TWO YEAR LIMITED WARRANTY PROGRAM

ATTN.: CUSTOMER SERVICE

4140 SW 30th Ave., Ft. Lauderdale, FL 33312

WARRANTY IS NON-TRANSFERABLE AND NON-REFUNDABLE.

© 2006 VECTOR MANUFACTURING

MADE IN CHINA

8

BD022806

VEC1040AMG

100 Watt

Power Inverter

Vehicle Power System

Converts DC Vehicle Power

to 115 Volt AC Household Power

USER’S MANUAL

& WARRANTY INFORMATION

IMPORTANT SAFETY INFORMATION, SAVE THESE

INSTRUCTIONS

TO REDUCE THE RISK OF INJURY, USER MUST READ AND UNDERSTAND
THIS INSTRUCTIONAL MANUAL. THIS MANUAL CONTAINS IMPORTANT
INFORMATION REGARDING THE OPERATION AND WARRANTY OF THIS
PRODUCT. PLEASE RETAIN FOR FUTURE REFERENCE.

4140 S.W. 30th Ave., Ft. Lauderdale, FL 33312 U.S.

Toll Free: [phone]

IMPORTANT SAFETY INSTRUCTIONS

1. Always use the inverter where there is adequate ventilation. Do not block ventilation slots.

2. DO NOT use the inverter near flammable materials or in locations that may accumulate flammable
fumes or gases.

3. ALWAYS turn OFF the inverter by removing it from the DC accessory outlet when not in use.

4. NEVER IMMERSE THE UNIT IN WATER (fresh or salt).

5. DO NOT expose to extreme heat or flames.

6. Make sure nominal powering voltage is 12 volts DC, center connection positive (+), 10 amps minimum.

7. DO NOT replace fuse with higher amperage rating.

WARNINGS

To reduce the risk of fire, electric shock, explosion or injury:

• This is not a toy — keep away from children.

• This equipment employs components that tend to produce arcs or sparks. DO NOT
install in compartments containing batteries or flammable materials.

• Use this unit in properly ventilated areas ONLY.

• Do not open — there are no user-serviceable parts inside.

• Do not insert foreign objects into the outlet.

• Do not expose the unit to flammables, water, rain or snow.

• This inverter has not been tested for use with medical devices.

INTRODUCTION

Thank you for choosing the

Please read this guide carefully before use to ensure best performance and avoid

System.

damage to the unit or items that you are using it with. Read, understand and comply with all
Warnings and Safety Information to ensure safety of persons and equipment.

This inverter is a convenient, easy-to-carry, completely portable source of 115 volt AC to operate
appliances to 100 watts. It can be powered by any 12 volt DC accessory outlet that can supply at
least 10 amperes. It is also ideal for use with 12 volt DC cordless/portable rechargeable DC power
supplies and jump-starter products.

The inverter can be used to operate: 110/120 volt AC laptop computers, game consoles, reading
lamps, small fans, and more.

Recharge: 110/120 volt AC devices (laptop computers, cellular phones, camcorders, power tool
battery packs) that have an appropriate recharging adapter with a three-prong 110/120 volt AC
North American standard-type plug.

VEC1040AMG 100 Watt Power Inverter Vehicle Power

OPERATING AND VISIBLE FEATURES

• 100 watts continuous output – 115 volt AC, 60 Hz

• Easiest inverter to use – truly plug and play

• Adapts to any size 12 volt DC accessory outlet

• Compact, pocket size, efficient, and quiet

• Electronic circuit protection prevents damage due to overload/insufficient ventilation

• Low-battery shutdown automatically occurs when battery discharges to 10.6 volts, preventing
battery damage

• Self recovery from shutdown – if manual reset is required, remove and reinsert the inverter
into the accessory outlet

1

2

5

3

4

6

7

1. 12 volt POSITIVE (+) contact

2. Internal fuse

3. 12 volt NEGATIVE(–) spring contact

4. Power plug adjusts 45°

5. Green operating LED

6. 115 volt AC three-prong outlet

7. Ventilation slots

POWER SOURCE REQUIREMENTS/RUNTIMES

The inverter can be powered by any 12 volt DC accessory outlet that can supply at least 10
amperes. A charged car battery with 50 amp hours of capacity can operate this inverter at 100
watt output for approximately five hours.

2 3