Vector AIRPRO VEC259 Owner's Manual

THIS MANUAL CONTAINS IMPORTANT INFORMATION REGARDING SAFETY,
OPERA

TION, MAINTENANCE AND STORAGE OF THIS PRODUCT

. BEFORE USE, READ
AND UNDERSTAND ALL CAUTIONS, WARNINGS, INSTRUCTIONS AND PRODUCT
LABELS. FAILURE TO DO SO COULD RESULT IN INJURY AND/OR PROPERTY DAMAGE.

4140 SW 28th Way, FT. LAUDERDALE, FL 33312

Tel [phone] • TOLL FREE: 866-584-5504 • Fax [phone]

www.vectormfg.com

OWNER’S MANUAL

& WARRANTY INFORMATION

41

40 SW 28th Way, Ft. Lauderdale, FL 33312

PH: 954-584-4446 • TOLL FREE: 866-584-5504 • Fax: [phone].

Y

ou may also contact us at our web site www.vectormfg.com.

MS062703

VEC259

CORDED, CORDLESS,

RECHARGEABLE COMPRESSOR, INFLATOR

AND LANTERN LIGHT COMBO

1

NOTE: This product is shipped in a partially charged state. Before use,

charge battery using AC method for 24 hours.

IMPORTANT SAFETY INFORMATION

Be sure to read and understand all WARNINGS and CAUTIONS before using this
product. Please read this guide carefully before use to ensure optimum performance and
avoid damage to the system or items that you are using it with. Failure to follow
instructions may cause property damage, and/or personal injury. Warnings define
conditions that can cause injury to people. Cautions define conditions that may cause
damage to equipment.

WARNINGS:

1. Improperly attached hoses or nozzles can fly out under compressor pressure. Make
sure all connections are tight before turning compressor ON.

2. There is risk of dust or dirt being released if the compressor hose or nozzles are not
clean when the compressor is turned on.

3. Wearing protective goggles while operating these appliances can protect eyes from fly­ing particles of dust and dirt.

4. Keep out of reach of children. These appliances are not toys!

5. Replace worn or defective parts immediately - contact Vector

®

customer

service department [phone] or toll free (866)-584-5504.

6. During AC recharge, make sure that the AC charging adapter is kept away from water
or moisture during use. If recharging around water, make sure the 120 volt AC outlet
is GFCI protected.

7. Make sure all cords and adapter wires are placed so they are not tripped over or dam­aged by pinching, abrading or cutting. Do not place wires near moving objects, doors
or sharp objects.

8. Never exceed recommended pressures - bursting articles can cause serious injury.
Always check pressure with the pressure gauge.

9. Do not carry charger and adapters by their cords; carry items by the body of unit itself.

10. There are no user serviceable parts except for replaceable battery pack, AC recharge

adapter, hose and pumps.

11. Do not operate unit if there is any evidence of damage.

12. Never use air compressor or inflator near flammable liquids, gas or open flames.

13. Keep working area well lit.

14. Do not direct air into eyes, ears, nose or other parts of the body.

CAUTIONS:

1. When the compressor, inflator or lamp are powered from external DC, make sure the
voltage is rated at 12 volt DC. Do not operate with 6 volts or 24 volts.

2. Make sure that the compressor or inflator are not operated continuously for more than
10 minutes. Allow to cool for at least five minutes before turning back on.

3.

Make sure battery pack is fully charged before operating. Recharge every 60 days for
the recommended time to extend life of battery pack’s internal battery. For immediate use,
attach the DC adapter and operate the appliances from an external 12 volt DC source.

4. T

o avoid over-inflation, carefully follow instructions on ar

ticles to be inflated.

5. Never leave appliances unattended while in use. Allow compressor to cool for five
minutes after 10 minutes of continuous operation.

6. Do not use accessories that are not designed to be used with these appliances.

7. Do not place battery pack on heater; keep it out of sunlight.

8.

Do not charge batter

y when it is at, or above, 122

°

F (50° C). Allow the battery pack

to cool before charging.

2

CONTENTS

1. Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

2. Additional key features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

3. Attaching the compressor’s air hose . . . . . . . . . . . . . . . . . . . . . 5

4. Powering the compressor, inflator or lamp . . . . . . . . . . . . . . . . . 5

4.1 Powering from the battery pack . . . . . . . . . . . . . . . . . . . . 5

4.2 DC power adapter use . . . . . . . . . . . . . . . . . . . . . . . . 5, 6

5. Charging/recharging the battery pack . . . . . . . . . . . . . . . . . . . 6

5.1 AC Recharge of battery pack . . . . . . . . . . . . . . . . . . . . 6, 7

6. Compressor/tire inflator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

6.1 Tire inflation or products with a valve stem . . . . . . . . . . 7, 8

6.2 Inflate other articles (without valve stem) . . . . . . . . . . . . . . 8

7. Typical inflation times . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

8. Inflating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9

8.2 Delfating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9

9. Lantern light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-10

9.1 Parts replacement lantern light . . . . . . . . . . . . . . . . . . 10-11

9.2 Quartz halogen bulb replacement . . . . . . . . . . . . . . .11-12

9.3 Fluorescent lamp replacement . . . . . . . . . . . . . . . . . . . . 12

10. Maintenance/replacement parts . . . . . . . . . . . . . . . . . . . . . . .12

11. Battery replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12

13. Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

W

arranty

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

4

The compressor on/off switch controls operation of the compressor. It can be
conveniently depressed and released to control inflation. An exact pressure is obtained
by observing the gauge and releasing the trigger when the correct pressure is
achieved. For longer inflation operations, the trigger lock can be moved laterally to
lock the trigger in the ON position. Pushing the trigger lock to the opposite direction
releases the trigger and stops inflation.

2. ADDITIONAL KEY FEATURES

• Trigger switch with lock to allow hands free operation

• Corded - includes a DC power adapter for use with standard 12 volt DC power
supply

• Battery pack includes non-spillable, maintenance-free, heavy duty, sealed,

high-density, lead-acid battery

• Requires no maintenance (other than recharging and cleaning) for optimum
operation

•

Supplied 120 volt AC charger is Underwriter Laboratories (UL) safety tested and listed

• Battery charging LED on battery automatically activated during AC recharge

• Analog pressure gauge to 260 PSI compressor

• Nozzle hatch for storing nozzles in compressor

• 3 nozzles for inflator

FIGURE 2

CAUTION:

This battery pack is delivered in a partially charged state - you must fully charge
it before using it for the first time. Initial AC charge should be for 24 hours. Refer
to Section 6 for use of AC adapter and detailed charging instructions.

3

1. INTRODUCTION

Congratulations on selecting the Vector AirPro™ Model VEC259 Compressor/Inflator

and

Lantern Light combo. This system is an advanced, high-pressure (up to 260 PSI),
multi-use air compressor system with unique features that set it far above the value and
utility of ordinary compressors for mobile use. It is supplied with a standard tire valve
chuck for filling auto, truck, bike, and motorcycle tires. Additionally, two different
adapters are supplied to inflate soccer balls, footballs, and popular inflatables. These
adapters are conveniently stored in a hatch in the compressor body. It is powered
from its own snap-on/off powerful battery, to be used anywhere it is needed. It can
also operate from a standard 12 volt DC electrical system found on: trucks, cars, boats,
airplanes, RVs and tractors, using the supplied DC power adapter. A supplied stan­dard 120 volt AC charger recharges the battery when required. Typically, up to three
completely flat tires can be inflated before the battery pack has to be recharged.

The inflator and light share the battery pack and DC power adapter. The inflator
is used to inflate and deflate air beds, balls, rafts, etc. The lantern is versatile and
provides a spotlight, fluorescent area light, and emergency flasher.

Extra battery packs can be purchased, if completely cordless operation is required
(part VEC194). Operating these appliances with the DC power adapter is ideal for
use with Vector 12 volt DC cordless, portable, rechargeable DC power supplies, if
extended operating time in the field is required.

COMPRESSOR OUTLET

HOSE RETAINING RING

RIBBED BRASS FITTING

COMPRESSOR HOSE

TRIGGER LOCK

TRIGGER SWITCH

TIRE CHUCK

NOZZLE HATCH COVER

NOZZLE HATCH COVER

NOZZLES

PRESSURE GAUGE