Ultrafryer Systems REO-1620SE Installation Manual

MODEL REO-1620SE

ELECTRIC RETHERMALIZER

OPERATING INSTRUCTIONS

302 Spencer Lane P.O. Box 5369 San Antonio, Texas 78201
[phone] [phone] FAX: [phone]

PREFACE

This manual was written and published by the Technical Publications Department, Ultrafryer Systems, for
use by store employees who will operate and maintain the Electric Model REO-1620SE Rethermalizer.
Proper use of this manual will allow store employees to properly operate, clean and maintain this equip­ment which will reduce service call expenses.

TECHNICAL PUBLICATIONS DEPARTMENT
ULTRAFRYER SYSTEMS
302 SPENCER LANE
SAN ANTONIO, TEXAS 78201
TELEPHONE: [phone] EXT. 5007

PN 30A049 PUBLISHED DECEMBER 2001

i

TABLE OF CONTENTS

Page

Warranty Information 2

General Information

Safety 4
Description 4
Specications 4

Installation and Initial Cleaning

Installation 6
Initial Cleaning 6

Model REO-1620SE Electric Rethermalizer Operation

General 8
Cooking Procedures 8

Preventive Maintenance, Troubleshooting and Cleaning

Preventive maintenance 10
Troubleshooting Chart 10
Cleaning 11

Technical Assistance, Ordering Information and Parts Identication

Technical Assistance 13
Ordering Information 13
Parts Identication 13

Wiring Diagram 15

ii

WARRANTY

INFORMATION

1

ULTRATHERM RETHERMALIZER WARRANTY

Ultrafryer Systems warrants to the original purchaser of a gas or electric ULTRATHERM RETHERMAL­IZER sold within the United States, it’s territories and Canada, that it will be free of defects in material and
workmanship for the period listed below:
RETERMALIZER PARTS – All parts on the Electric or Gas Rethermalizer are covered for a period not
to exceed one (1) year after the initial start up. This is to include computers, valves, switches, thermostats,
etc. Ultrafryer Systems reserves the right to charge for certain parts such as computers or any item over
$100.00 until the defective part is received by the Warranty Department. After inspection, credit for the
part will be issued to the purchaser provided the part is deemed defective and that defect is not the result
of neglect or abuse by the user.
PROCESSING WARRANTY CLAIMS – The equipment owner must promptly notify Ultrafryer Systems
Warranty Department of any alleged defects as soon as they are discovered by calling 800-525-8130. After
such notice, the Warranty Department will perform its obligation under this warranty within a commercially
reasonable period of time. If alleged defects develop after normal business hours, on weekends, holidays the
owner must call Ultrafryer Systems rst at the above number. This number is answered 24 hours a day and 7
days a week. Ultrafryer Systems will notify an AUTHORIZED service agent to make repairs during normal
and after hours. Any parts that need to be shipped back to Ultrafryer Systems will be shipped back prepaid

by the customer attn: WARRANTY DEPARTMENT.
NON WARRANTY COVERAGE – This warranty does not include coverage for any consequential cost of

damages including, but not limited to, any loss in store sales, spoiled food products, transportation, duty or
custom cost or failure / damage to component parts due to scaling caused by hard water. This does not cover
original installation and adjustments such as leveling, calibrations and electrical and gas connections. This
warranty does not cover travel over 100 miles or 2 hours drive time from the location of the Retermalizer,
or overtime, or holiday charges unless the Warranty Department granted prior approval. This warranty
does not cover improper or unauthorized repairs or installation, damage in shipment, normal maintenance.

Ultrafryer Systems reserves the right to void component part warranty on any ULTRATHERM
RETHERMALIZER that is stored for more than 6 (six) months after shipment from Ultrafryer
Systems and not put into service.
LABOR COVERAGE – The cost for labor to replace parts or service the Rethermalizer is covered for

one year after the initial start up. The Warranty Department must be promptly notied of any defects
within the rst year of operation. Labor is covered by Ultrafryer Systems for repairs and service by an
AUTHORIZED service agent.

DISCLAIMER OF WARRANTIES

Other than as stated herein Ultrafryer Systems makes no warranty of any kind, express or implied, including
but not limited to any warranty of merchantability of tness for a particular purpose, including trade
usage. Ultrafryer Systems sole obligation, and purchaser’s sole remedy, under this warranty is repair or
replacement, at the discretion of Ultrafryer Systems, of any part or component that proves to be defective
in materials or workmanship. In no event shall Ultrafryer Systems be liable for consequential, incidental, or
special loss or damages arising from the use of, or inability to use, the Rethermalizer. There are no other
documents or oral statements for which Ultrafryer Systems will be responsible.

2

GENERAL INFORMATION

3