tyco EMC User Manual
EMC Series
LINE
LOAD
UL Recognized
CSA Certified
VDE Approved
CORCOM Product Guide
Compact and Cost Effective Dual Stage RFI Power Line Filters
EMC Series
The EMC Series of RFI filters has been developed to
reduce conducted noise to acceptable limits for equipment
that must comply with the requirements of CISPR in Europe
and the FCC specifications in the USA.
The EMC Series is the most compact dual stage filter
available from Tyco Electronics. This cost effective design
has a maximum current rating of 30 amps; higher than any
similar catalog product. The EMC Series was designed to
address the need for more differential mode attenuation in
the lower frequency range while still maintaining high
common mode performance. This type of performance is
typically needed for motor drives and switch mode power
supplies with increased operating frequencies. The EMC
Series is ideal for applications that require a high level of
performance in a compact, cost effective package.
Electrical Schematic
Resistor location for reference only.
EMC6
EMC1
Specifications
Maximum leakage current,each line-to-ground
3,6,10 Amp
@ 120 VAC 60 Hz: .21 mA .73 mA
@ 250 VAC 50 Hz: .43 mA 1.52 mA
Hipot rating (one minute):
line-to-ground 2250 VDC
line-to-line 1450 VDC
Operating frequency: 50/60 Hz
Rated voltage (max.): 250 VAC
Minimum insertion loss in dB:
Line-to-ground in 50 ohm circuit
Current Frequency-MHz
Rating .05 .07 .11 .15 1 2 10 20 30
03A 6 6 3 16 65 66 62 60 59
06A 6 6 2 15 65 67 65 62 63
10A 5 2 13 24 72 72 56 50 48
15A 3 1 12 22 70 68 57 54 53
20A 2 2 11 21 58 57 63 55 52
30A 2 2 14 22 47 52 60 48 43
Line-to-line in 50 ohm circuit
Current
Rating .05 .07 .11 .15 1 2 10 20 30
03A 12 13 7 18 64 69 65 60 52
6A
0
10A 14 15 12 33 54 58 47 34 36
15A 16 16 13 34 61 52 36 36 23
20A 17 19 15 37 67 62 36 32 30
30A 17 18 14 40 62 53 30 28 26
12
Frequency-MHz
8
12
27
61
15,20,30 Amp
61 59 56 54
48
Catalog 1654001 Dimensions are in inches and Dimensions are shown for USA Cust. Svc.: 1-800-468-2023 www.cor.com
Revised 03-04 millimeters unless otherwise reference purposes only. CORCOM Prods: 1-847-680-7400 www.tycoelectronics.com
specified. Values in italics
are metric equivalents. to change. Germany: 49-89-6089-0
Specifications subject
1-508-992-4495
CORCOM Product Guide
D
C
E
A
B
D
A
E
B
C
D
E
A
C
B
B
D
E
A
Compact and Cost Effective Dual Stage RFI
Power Line Filters
EMC Series
Case Styles Case Dimensions
EMC1
Typical dimensions:
Terminals: .250 [
EMC3
Typical dimensions:
Wire leads: 4.0 [
Mounting Holes: .187±.008 [
EMC6
6.35]
101.6] min. 3,6,10A:18 AWG / 15A: 16 AWG
Mounting Holes: .187±.008 [
4.75±.20] Dia.(2)
4.75
±.20
] Dia.(2)
Part No.
3EMC1
6EMC1
10EMC1
15EMC1 4.97 2.25 1.78 4.063 4.46
20EMC1 126.2 57.2 45.2 103.2 113.3
3EMC3
6EMC3
10EMC3
15EMC3
10EMC6
15EMC6 5.09 2.25 1.78 4.063 4.47
20EMC6 129.3 57.2 45.2 103.2 113.5
30EMC6
ABCDE
(max) (max) (max) (max) (max)
3.35 1.81 1.16 2.375 2.78
85.1
3.85
97.8 52.6 29.5 74.6 85.1
3.85 2.07 1.53 2.938 3.35
97.8 52.6 38.91 74.6 85.1
2.07 1.81 1.16 2.375 2.78
52.6 46.0 29.5 60.3 70.6
2.56 2.07 1.16 2.938 3.35
65.0 52.6 29.5 74.6 85.1
2.56 2.07 1.53 2.938 3.35
65.0 52.6 38.9 74.6 85.1
3.69 2.25 1.78 4.063 4.47
93.7 57.2 45.2 103.2 113.5
3.94 2.07 1.53 2.938 3.35
99.9 52.6 38.9 74.6 85.1
6.05 3.12 2.18 3.50 3.96
153.7 79.2 55.4 88.9 100.6
(Continued)
RFI Power Line Filters
46.0 29.5 60.3 70.6
2.07 1.16 2.938 3.35
Part Numbers
03EMC1 10EMC30
0
6EMC1
Typical dimensions:
Terminals: 8-32 (5) Mounting Holes: .187±.008 [
4.75±.20] Dia.(2)
30EMC6
Typical dimensions:
Terminals: 10-32 (5)
Catalog 1654001 Dimensions are in inches and Dimensions are shown for USA Cust. Svc.: 1-800-468-2023 www.cor.com
Revised 03-04 millimeters unless otherwise reference purposes only. CORCOM Prods: 1-847-680-7400 www.tycoelectronics.com
specified. Values in italics
are metric equivalents. to change. Germany: 49-89-6089-0
Slots: .203 x .156 [
5.16 x 3.96] Dia.(4)
Specifications subject
10EMC1 10EMC6
15EMC1 15EMC6
20EMC1
3EMC3 30EMC6
6EMC3
1-508-992-4495
15EMC3
20EMC6
49
Loading...