TURCK TBEN-LF-16DOP Technical data

Compact Multiprotocol I/O Module for Ethernet
16 Digital PNP 2-A Outputs
TBEN-LF-16DOP

Type designation TBEN-LF-16DOP

Ident-No. 100003915

■ Ford VOME IP address loaded

■ Ford VOME specific firmware

■ IP address 136.129.1.xxx

■ EtherNet/IP™ device

■ Integrated Ethernet switch

■ Supports 10 Mbps/100 Mbps

■ 2x M12, 4-pin, D-coded, Ethernet field-

bus connection

■ Glass fiber reinforced housing

■ Shock and vibration tested

■ Fully potted module electronics

■ Protection classes IP65, IP67, IP69K

■ Max. 2 A per output

■ Output diagnostics per channel

Sensor/Actuator supply V

System data

Fieldbus transmission rate 10 Mbps/100 Mbps
Fieldbus connection technology 2 x M12, 4-pin, D-coded
Fieldbus address range 0 (136.129.1.254)
Protocol detection automatic
Service interface Ethernet via P1 or P2

Ethernet/IP

Addressing acc. to EtherNet/IP specification
Quick Connect (QC) < 150 ms
Device Level Ring (DLR) supported
Class 3 connections (TCP) 3
Class 1 connections (CIP) 10
Input Assembly Instance 101
Output Assembly Instance 102
Configuration Assembly Instance 106

Digital outputs

Number of channels 16
Connectivity outputs M12, 5-pol
Output type PNP
Type of output diagnostics Channel diagnostics
Output voltage 24 VDC from potential group
Output current per channel 2.0 A, short-circuit proof, max. 2.0 A per port
Output delay 1.3 ms
Load type EN 60947-5-1: DC-13
Short-circuit protection yes
Electrical isolation Galvanically isolated to the fieldbus

AUX2

supply of ports C0-C7 from V2
short-circuit proof, 120 mA per port

Voltage proof up 500 VDC

Standard/Directive conformity

Vibration test acceleration to 20 g

acc. to EN 60068-2-6
Shock test acc. to EN 60068-2-27
Drop and topple acc. to EN 60068-2-31/IEC 60068-2-32
Electromagnetic compatibility acc. to EN 61131-2
Approvals and certificates CE,

FCC,

UV-resistant in accordance with DIN EN ISO

4892-2A (2013)
UL Certificate cULus LISTED 21 W2, Encl.Type 1 IND.CONT.EQ.

Edition • 2021-04-16T19:07:24+02:00

1 / 5 TURCK Inc. ñ 3000 Campus Drive Minneapolis, MN 55441-2656 ñ Phone: [phone] ñ Application Support: 1-800-544-7769 ñ Fax [phone] ñ www.turck.com

Compact Multiprotocol I/O Module for Ethernet
16 Digital PNP 2-A Outputs
TBEN-LF-16DOP

General Information

Dimensions (W x L x H) 60.4 x 230.4 x 39mm
Operating temperature -40…+70 °C
Storage temperature -40 °C … +85 °C
Altitude max. 5000 m
Protection class IP65

IP67

IP69K
Housing material PA6-GF30
Housing color Black
Window material Lexan
Material screw 303 stainless steel
Material label Polycarbonate
Halogen-free yes
Mounting 2 mounting holes � 6.3 mm

Edition • 2021-04-16T19:07:24+02:00

2 / 5 TURCK Inc. ñ 3000 Campus Drive Minneapolis, MN 55441-2656 ñ Phone: [phone] ñ Application Support: 1-800-544-7769 ñ Fax [phone] ñ www.turck.com

Compact Multiprotocol I/O Module for Ethernet
16 Digital PNP 2-A Outputs
TBEN-LF-16DOP

Accessories

Accessories

Accessories

M12 x 1 Ethernet

M12 x 1 Output

7/8" Power Supply

Edition • 2021-04-16T19:07:24+02:00

3 / 5 TURCK Inc. ñ 3000 Campus Drive Minneapolis, MN 55441-2656 ñ Phone: [phone] ñ Application Support: 1-800-544-7769 ñ Fax [phone] ñ www.turck.com

Compact Multiprotocol I/O Module for Ethernet
16 Digital PNP 2-A Outputs
TBEN-LF-16DOP

Module Status LED

LED Color Status Description

ETH1 / ETH2 Green On Ethernet Link (100 Mbps)

Flashing Ethernet communication (100 Mbps)

Yellow

BUS Green On Active connection to a master

Red On IP-address conflict or Restore Mode or Modbus timeout

Green/Red Alternating Autonegotiation and/or waiting for DHCP/Boot-P addressing

Green On No diagnostic messageERR

Red On Diagnostic message pending

PWR ON V1 and V2 OK

LED Status I/O

LED Color Status Description

LED 0 … 15 Green ON Output active

Green

Red ON Output active with overload/short circuit

On Ethernet link (10 Mbps)

Flashing Ethernet communication (10 Mbps)

Off No Ethernet link

Flashing Device ready for operation

Flashing Blink/Wink command active

Off Power off

OFF V1 power off or below defined tolerance of 18 V

Flashing V2 missing or < 18 V

Flashing Power overload at the corresponding port. Both port LEDs are flashing.

OFF Output inactive

Edition • 2021-04-16T19:07:24+02:00

4 / 5 TURCK Inc. ñ 3000 Campus Drive Minneapolis, MN 55441-2656 ñ Phone: [phone] ñ Application Support: 1-800-544-7769 ñ Fax [phone] ñ www.turck.com

Compact Multiprotocol I/O Module for Ethernet
16 Digital PNP 2-A Outputs
TBEN-LF-16DOP

Process Data Mapping of the Single Protocols

For more details on the corresponding protocols see manual.

EtherNet/IP™ data mapping with activated scheduled diagnostics, default settings

Word Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit3 Bit 2 Bit 1 Bit 0

Input data (station -> scanner)

GW status 0 - FCE - - CFG COM V1 - V2 - - - - - - Diag

Warn

Diag 1 1 - - Sched

Diag

Diag 2 2 SCO7 SCO6 SCO5 SCO4 SCO3 SCO2 SCO1 SCO0 SCS7 SCS6 SCS5 SCS4 SCS3 SCS2 SCS1 SCS0

Diag 3 3 - - - - - - - - SCO15 SCO14 SCO13 SCO12 SCO11 SCO10 SCO9 SCO8

Output data (scanner -> station)

Control 0 Reserved

Outputs

EtherNet/IP™ data mapping with activated summarized diagnostics

Input data (station -> scanner)

GW status 0 - FCE - - CFG COM V1 - V2 - - - - - - Diag

Diag 1 2 - - - - - - - - - - - - - - - I/O

Output Data (Scanner -> Station)

Control 0 Reserved

Outputs

Key:

DIx Digital input channel x CFG I/O Configuration error

DOx Digital output channel x FCE I/O-ASSISTANT Force Mode active

Cx Port x I/ODiag I/O diagnostics connected

Px Pin x SchedDiag Manufacturer-specific diagnostics configured and active

DiagWarn Diagnostic at least on 1 channel SCSx Short-circuit at port x

V1 Undervoltage V1 SCG1 Short-circuit supply ports C0-C3

V2 Undervoltage V2 SCG2 Short-circuit supply ports C4-C7

COM Communication error on internal module bus SCOx Short-circuit output channel x

1 DO15

Word Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit3 Bit 2 Bit 1 Bit 0

1 DO15

C7P2

C7P2

DO14

C7P4

DO14

C7P4

DO13

C6P2

DO13

C6P2

- - - - - - - - - - - - I/O

DO12

DO11

DO10

DO9

DO8

DO7

DO6

DO5

DO4

DO3

DO2

DO1

C6P4

C5P2

C5P4

C4P2

C4P4

C3P2

C3P4

C2P2

C2P4

C1P2

C1P4

C0P2

DO12

DO11

DO10

DO9

DO8

DO7

DO6

DO5

DO4

DO3

DO2

DO1

C6P4

C5P2

C5P4

C4P2

C4P4

C3P2

C3P4

C2P2

C2P4

C1P2

C1P4

C0P2

Diag

DO0

C0P4

Warn

Diag

DO0

C0P4

Edition • 2021-04-16T19:07:24+02:00

5 / 5 TURCK Inc. ñ 3000 Campus Drive Minneapolis, MN 55441-2656 ñ Phone: [phone] ñ Application Support: 1-800-544-7769 ñ Fax [phone] ñ www.turck.com