Compact Multiprotocol I/O Module for Ethernet
16 Digital PNP Inputs
TBEN-LF-16DIP
Type designation TBEN-LF-16DIP
Ident-No. 100003912
■ Ford VOME IP address loaded
■ Ford VOME specific firmware
■ IP address 136.129.1.xxx
■ EtherNet/IP™ device
■ Integrated Ethernet switch
■ Supports 10 Mbps/100 Mbps
■ 2x M12, 4-pin, D-coded, Ethernet field-
bus connection
■ Glass fiber reinforced housing
■ Shock and vibration tested
■ Fully potted module electronics
■ Protection classes IP65, IP67, IP69K
■ Input diagnostics per port
Sensor/Actuator supply V
System data
Fieldbus transmission rate 10 Mbps/100 Mbps
Fieldbus connection technology 2 x M12, 4-pin, D-coded
Fieldbus address range 0 (136.129.1.254)
Protocol detection automatic
Service interface Ethernet via P1 or P2
Ethernet/IP
Addressing acc. to EtherNet/IP specification
Quick Connect (QC) < 150 ms
Device Level Ring (DLR) supported
Class 3 connections (TCP) 3
Class 1 connections (CIP) 10
Input Assembly Instance 101
Output Assembly Instance 102
Configuration Assembly Instance 106
Digital inputs
Number of channels 16
Connectivity inputs M12, 5-pin
Input type PNP
Type of input diagnostics Group diagnostics
Switching threshold EN 61131-2 Typ 3, PNP
Low level signal voltage < 5 V
High level signal voltage > 11 V
Low level signal current < 1.5 mA
High level signal current > 2 mA
Input delay 2.5 ms
Electrical isolation Galvanically isolated to the fieldbus
AUX1
supply of ports C0-C7 from V1
short-circuit proof, 120 mA per port
Voltage proof up 500 VDC
Standard/Directive conformity
Vibration test acceleration to 20 g
acc. to EN 60068-2-6
Shock test acc. to EN 60068-2-27
Drop and topple acc. to EN 60068-2-31/IEC 60068-2-32
Electromagnetic compatibility acc. to EN 61131-2
Approvals and certificates CE,
FCC,
UV-resistant in accordance with DIN EN ISO
4892-2A (2013)
UL Certificate cULus LISTED 21 W2, Encl.Type 1 IND.CONT.EQ.
Edition • 2021-04-16T19:07:05+02:00
1 / 5 TURCK Inc. ñ 3000 Campus Drive Minneapolis, MN 55441-2656 ñ Phone: 763-553-7300 ñ Application Support: 1-800-544-7769 ñ Fax 763-553-0708 ñ www.turck.com
Compact Multiprotocol I/O Module for Ethernet
16 Digital PNP Inputs
TBEN-LF-16DIP
General Information
Dimensions (W x L x H) 60.4 x 230.4 x 39mm
Operating temperature -40…+70 °C
Storage temperature -40 °C … +85 °C
Altitude max. 5000 m
Protection class IP65
IP67
IP69K
Housing material PA6-GF30
Housing color Black
Window material Lexan
Material screw 303 stainless steel
Material label Polycarbonate
Halogen-free yes
Mounting 2 mounting holes � 6.3 mm
Edition • 2021-04-16T19:07:05+02:00
2 / 5 TURCK Inc. ñ 3000 Campus Drive Minneapolis, MN 55441-2656 ñ Phone: 763-553-7300 ñ Application Support: 1-800-544-7769 ñ Fax 763-553-0708 ñ www.turck.com
Compact Multiprotocol I/O Module for Ethernet
16 Digital PNP Inputs
TBEN-LF-16DIP
Accessories
Accessories
Accessories
M12 x 1 Ethernet
M12 x 1 Input
7/8" Power Supply
Edition • 2021-04-16T19:07:05+02:00
3 / 5 TURCK Inc. ñ 3000 Campus Drive Minneapolis, MN 55441-2656 ñ Phone: 763-553-7300 ñ Application Support: 1-800-544-7769 ñ Fax 763-553-0708 ñ www.turck.com
Compact Multiprotocol I/O Module for Ethernet
16 Digital PNP Inputs
TBEN-LF-16DIP
Module Status LED
LED Color Status Description
ETH1 / ETH2 Green On Ethernet Link (100 Mbps)
Flashing Ethernet communication (100 Mbps)
Yellow
BUS Green On Active connection to a master
Red On IP-address conflict or Restore Mode or Modbus timeout
Green/Red Alternating Autonegotiation and/or waiting for DHCP/Boot-P addressing
Green On No diagnostic messageERR
Red On Diagnostic message pending
PWR ON V1 and V2 OK
LED Status I/O
LED Color Status Description
LED 0 … 15 Green ON Input active
Green
Red Flashing Power overload at the corresponding port. Both port LEDs are flashing.
On Ethernet link (10 Mbps)
Flashing Ethernet communication (10 Mbps)
Off No Ethernet link
Flashing Device ready for operation
Flashing Blink/Wink command active
Off Power off
OFF V1 power off or below defined tolerance of 18 V
Flashing V2 missing or < 18 V
OFF Input inactive
Edition • 2021-04-16T19:07:05+02:00
4 / 5 TURCK Inc. ñ 3000 Campus Drive Minneapolis, MN 55441-2656 ñ Phone: 763-553-7300 ñ Application Support: 1-800-544-7769 ñ Fax 763-553-0708 ñ www.turck.com
Compact Multiprotocol I/O Module for Ethernet
16 Digital PNP Inputs
TBEN-LF-16DIP
Process Data Mapping of the Single Protocols
For more details on the corresponding protocols see manual.
EtherNet/IP™ data mapping with activated scheduled diagnostics, default settings
Word Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit3 Bit 2 Bit 1 Bit 0
Input data (station -> scanner)
GW status 0 - FCE - - CFG COM V1 - V2 - - - - - - Diag
Warn
Inputs 1 DI15
Diag 1 2 - - Sched
Diag 2 3 SCS7 SCS6 SCS5 SCS4 SCS3 SCS2 SCS1 SCS0
EtherNet/IP™ data mapping with activated summarized diagnostics
Word Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit3 Bit 2 Bit 1 Bit 0
Input data (station -> scanner)
GW status 0 - FCE - - CFG COM V1 - V2 - - - - - - Diag
Inputs 1 DI15
Diag 1 2 - I/O
Key:
DIx Digital input channel x CFG I/O Configuration error
DOx Digital output channel x FCE I/O-ASSISTANT Force Mode active
Cx Port x I/ODiag I/O diagnostics connected
Px Pin x SchedDiag Manufacturer-specific diagnostics configured and active
DiagWarn Diagnostic at least on 1 channel SCSx Short-circuit at port x
V1 Undervoltage V1 SCG1 Short-circuit supply ports C0-C3
V2 Undervoltage V2 SCG2 Short-circuit supply ports C4-C7
COM Communication error on internal module bus SCOx Short-circuit output channel x
C7P2
C7P2
DI14
C7P4
DI14
C7P4
DI13
C6P2
Diag
DI13
C6P2
DI12
DI11
DI10
DI9
DI8
DI7
DI6
DI5
DI4
DI3
DI2
DI1
C6P4
C5P2
C5P4
C4P2
C4P4
C3P2
C3P4
C2P2
C2P4
C1P2
C1P4
C0P2
- - - - - - - - - - - - I/O
DI12
DI11
DI10
DI9
DI8
DI7
DI6
DI5
DI4
DI3
DI2
DI1
C6P4
C5P2
C5P4
C4P2
C4P4
C3P2
C3P4
C2P2
C2P4
C1P2
C1P4
C0P2
DI0
C0P4
Diag
Warn
DI0
C0P4
Diag
Edition • 2021-04-16T19:07:05+02:00
5 / 5 TURCK Inc. ñ 3000 Campus Drive Minneapolis, MN 55441-2656 ñ Phone: 763-553-7300 ñ Application Support: 1-800-544-7769 ñ Fax 763-553-0708 ñ www.turck.com
Loading...